氢稀释对纳米晶硅薄膜晶化特性的影响及薄膜生长机理

以SiH4与H2作为前驱气体,采用射频等离子增强化学气相沉积技术制备了纳米晶硅薄膜.利用Raman散射和红外吸收光谱等技术,对不同氢稀释比条件下薄膜的微观结构和键合特性进行了研究.结果表明,随着氢稀释比增加,薄膜的晶化率明显提高,而氢稀释比过高时,薄膜晶化率呈现减少趋势.红外吸收光谱分析表明,纳米晶硅薄膜中氢的键合模式与薄膜的晶化特性密切相关.随着氢稀释比增加,薄膜中整体氢含量和SiH2键合密度明显减少,而在高氢稀释比条件下,氢稀释比增加导致薄膜中SiH2键合密度和整体氢含量增加.     

纳米晶硅薄膜中氢含量及键合模式的红外分析

采用传统射频等离子体化学气相沉积技术在100—350℃的衬底温度下高速沉积氢化硅薄膜. 傅里叶变换红外光谱和Raman谱的研究表明,纳米晶硅薄膜中的氢含量和硅氢键合模式与薄膜的晶化特性有密切关系,当薄膜从非晶相向晶相转变时,氢的含量减少了一半以上,硅氢键合模式以SiH₂为主. 随着衬底温度的升高和晶化率的增加,纳米晶硅薄膜中氢的含量以及其结构因子逐渐减少. 关键词： 氢化纳米晶硅薄膜 红外透射谱 氢含量 硅氢键合模式     

高氢稀释制备微晶硅薄膜微结构的研究

采用高氢稀硅烷热丝化学气相沉积方法制备氢化微晶硅薄膜.其结构特征用Raman谱，红外透射谱，小角X射线散射等来表征.结果表明微晶硅的大小及在薄膜中的晶态比χ_c随氢稀释度的提高而增加.而从红外谱计算得到氢含量则随氢稀释度的增加而减少.小角X射线散射结果表明薄膜致密度随氢稀释度的增加而增加.结合红外谱和小角X射线散射的结果讨论与比较了不同相结构下硅网络中H的键合状态.认为随着晶化的发生和晶化程度的提高H逐渐移向晶粒表面，在硅薄膜中H的存在形式从以SiH为主向SiH₂ 关键词：     

氢稀释对高速生长纳米晶硅薄膜晶化特性的影响

以SiH₄与H₂为气源,采用射频等离子体增强化学气相沉积技术,在较高的压强(230Pa)下,研究氢稀释率对纳米晶硅薄膜的生长速率和晶化特性的影响. 实验表明,薄膜的晶化率,晶粒尺寸随着氢稀释率的提高而增加,当氢稀释率为99%,薄膜的晶化率接近70%. 而沉积速率却随着氢稀释率的减小而增加,当氢稀释率从99%减小到95%时,薄膜的沉积速率由0.3nm/s 增加至0.8nm/s. 关键词： 纳米晶硅薄膜 氢稀释 晶化率 硅烷     

氮化硅薄膜中硅纳米颗粒的形成机制研究

采用等离子体增强化学气相沉积技术,以SiH₄作为硅源, NH₃和N₂共同作为氮源,在单晶硅衬底上制备了不同的氮化硅薄膜. X射线衍射分析薄膜晶体结构,通过计算晶格尺寸大小证明了纳米硅颗粒的存在. 傅里叶变换红外光谱分析了薄膜中的键合作用的变化并结合化学反应过程对氮化硅薄膜中纳米硅颗粒的形成机制进行了研究,发现Si—Si键作为硅纳米颗粒的初始位置, 当反应朝着生成Si—Si的方向进行时,可以促进氮化硅薄膜中硅纳米颗粒的形成. X射线衍射分析和光致发光实验结果表明Si—Si键浓度增大时, 所形成的纳米硅颗粒的尺寸和浓度都随之增大.     

镶嵌有纳米硅的氮化硅薄膜键合特性分析

采用螺旋波等离子体化学气相沉积(HWPCVD)技术制备了非化学计量比的氢化氮化硅薄膜,对所沉积样品及氮气环境中920 ℃退火样品的微观结构及键合特性进行了分析。Raman散射结果表明,薄膜中过量硅以非晶纳米粒子形式存在,退火样品呈现纳米晶硅和氮化硅的镶嵌结构。红外吸收和可见光吸收特性比较结果显示,薄膜样品的微观结构依赖于化学计量比以及退火过程,硅含量较低样品因高的键合氢含量而表现出低的纳米硅表面缺陷态密度;退火过程将引起Si—H和N—H键合密度的减少,因晶态纳米颗粒的形成,退火样品表现出更高的结构无序度。     

SiH4/H2等离子体气相生长硅薄膜的动力学模型

在化学气相沉积微晶硅薄膜过程中,为了降低成本,必须提高生长速率,但薄膜的微观结构和光电性能则随之降低,原因是成膜先驱物在薄膜表面上的扩散长度降低了. 本文利用量子化学的反应动力学理论建立有关成膜先驱物SiH₃和H的反应平衡方程,求解薄膜生长速率和成膜先驱物的扩散长度,并找出影响生长速率与扩散长度的微观参数,发现生长速率不仅与流向衬底的SiH₃的通量密度有关,而且与H的通量密度有关;SiH₃的扩散长度与衬底温度和薄膜表面的硅氢键的形态有关,当     

激发频率对高氢稀释下纳米晶硅薄膜生长特性的影响

利用等离子体增强化学气相沉积技术,在高氢稀释条件下,研究不同激发频率对纳米晶硅薄膜生长特性的影响.剖面透射电子显微镜(TEM)分析结果显示,不同激发频率下制备的纳米晶硅薄膜晶化区均呈锥状结构生长,但13.56 MHz激发频率下制备的纳米晶硅薄膜最初生长阶段存在非晶态孵化层,即纳米晶硅薄膜的形成经历了由非晶态孵化层到晶态结构层的转变.而高激发频率(40.68 MHz)下硅纳米晶则能直接在非晶态衬底上生长形成.Raman谱和红外吸收谱测量结果表明高激发频率(40.68 MHz)下制备的纳米晶硅薄膜不但具有较高     

氢化纳米硅薄膜中氢的键合特征及其能带结构分析

对氢化纳米硅薄膜中氢的键合特征和薄膜能带结构之间的关系进行了研究.所用样品采用螺 旋波等离子体化学气相沉积技术制备，利用Raman散射、红外吸收和光学吸收技术对薄膜的 微观结构、氢的键合特征以及能带结构特性进行了分析.Raman结果显示不同衬底温度下所生 长薄膜的微观结构存在显著差异，从非晶硅到纳米晶硅转化的衬底温度阈值为200℃.薄膜中 氢的键合特征与薄膜的能带结构密切相关.氢化非晶硅薄膜具有较高的氢含量，因键合氢引 起的价带化学位移和低衬底温度决定的结构无序性，使薄膜呈现较大的光学带隙和带尾宽度 .升 关键词： 氢化纳米硅 螺旋波等离子体 能带结构     

4H-SiC纳米薄膜的微结构及其光电性质研究

采用新设计的电极结构的等离子体增强化学气相沉积(PECVD)技术,在高功率密度、高氢稀释比、低温、偏压及低反应气压的条件下,在衬底表面形成双等离子流,增加了衬底表面SiC的成核概率,增强成核作用,形成纳米晶.采用高H2等离子体刻蚀弱的、扭曲的、非晶Si—C及Si—Si和Si—H等键时,由于H等离子体对纳米SiC晶粒与非晶态键的差异刻蚀作用,产生自组织生长,发生晶化.Raman光谱和透射电子衍射(TEM)的测试结果表明,纳米晶SiC是4HSiC多型结构.电子显微照片表明平均粒径为16nm,形状为微柱体.实验结果指出,SiC纳米晶的形成必须经过偏压预处理成核,并且其晶化存在一个功率密度阈值;当低于这一功率密度阈值时,晶化消失;当超过这一阈值时,纳米晶含量随功率密度的提高而增加.随着晶化作用的加强,电导率增加. 关键词： 4H-SiC PECVD 纳米结构 多型薄膜 纳米电子学     

Effect of hydrogen dilution on the optical properties of hydrogenated amorphous silicon-nitrogen films prepared by plasma deposition

The effect of the dilution of silane and nitrogen with hydrogen on the optical properties of hydrogenated amorphous silicon-nitrogen films prepared by plasma deposition has been investigated as functions of the gas-volume ratio γ (= ([SiH₄] + [N₂])/([SiH₄] + [N₂] + [H₂]) and the substrate temperature. The prepared films are characterized by the values of the deposition rate, the optical gap, the Urbach energy, the defect density, the integrated infrared absorption intensity and the refractive index, and by correlations between these parameters and the type of hydrogen- and nitrogen-bonding configurations estimated from infrared absorption spectra. The hydrogen dilution effect is discussed in terms of the above and compared with that in hydrogenated amorphous silicon reported in a previous paper by the present authors. It is pointed out that nitrogen atoms incorporated into the silicon network cause more disorder than incorporated hydrogen atoms, from the γ dependence of the Urbach energy and the integrated infrared intensities associated with the hydrogen and nitrogen bondings.     

Effects of high hydrogen dilution ratio on optical properties of hydrogenated nanocrystalline silicon thin films

Hydrogenated nanocrystalline silicon thin films were prepared by plasma enhanced vapor deposition technique. In our experiment, hydrogen dilution ratio R_H was changed mainly, while the other parameters, such as the radio frequency power, the direct current bias value, the chamber pressure, the total gas flow and the substrate temperature were kept constant. The film's surface topography was gained by AFM. The chemical bond was confirmed by Fourier transform infrared spectra. The optical properties were characterized by transmission spectra. To consider absorption peak of stretching vibration mode of SiH₃ at 2140 cm⁻¹ and to reduce the calculation error, a hydrogen content calculation method was proposed. Effects of hydrogen dilution ratio on the deposition rate v and hydrogen content C_H were investigated. The bonding mode and the force constants k of chemical bond, the structural factor f in films were changed by high hydrogen dilution ratio, which gave rise to the shift of absorption peak of infrared stretching mode and the decrease of optical band gap E_g.     

Growth characteristics of amorphous-layer-free nanocrystalline silicon films fabricated by very high frequency PECVD at 250 ℃

Amorphous-layer-free nanocrystalline silicon films were prepared by a very high frequency plasma enhanced chemical vapor deposition(PECVD) technique using hydrogen-diluted SiH4 at 250 C.The dependence of the crystallinity of the film on the hydrogen dilution ratio and the film thickness was investigated.Raman spectra show that the thickness of the initial amorphous incubation layer on silicon oxide gradually decreases with increasing hydrogen dilution ratio.High-resolution transmission electron microscopy reveals that the initial amorphous incubation layer can be completely eliminated at a hydrogen dilution ratio of 98%,which is lower than that needed for the growth of amorphous-layer-free nanocrystalline silicon using an excitation frequency of 13.56 MHz.More studies on the microstructure evolution of the initial amorphous incubation layer with hydrogen dilution ratios were performed using Fourier-transform infrared spectroscopy.It is suggested that the high hydrogen dilution,as well as the higher plasma excitation frequency,plays an important role in the formation of amorphous-layer-free nanocrystalline silicon films.     

氮化硅薄膜中纳米非晶硅颗粒的键合结构及光致发光

采用螺旋波等离子体化学气相沉积技术以N₂/SiH₄/H₂为反应气体制备了镶嵌有纳米非晶硅颗粒的氢化氮化硅薄膜,通过改变N₂流量实现了薄膜从红到蓝绿的可调谐光致发光.傅里叶红外透射和紫外-可见光吸收特性分析表明,所生长薄膜具有较高的氢含量,N₂流量增加使氢的键合结构发生变化,非晶硅颗粒尺寸减小,所对应的薄膜的光学带隙逐渐增加和微观结构有序度减小.可调光致发光(PL)主要来源于纳米硅颗粒的量子限制效应发光,随N₂流量增加,PL的谱线展宽并逐渐增强. 关键词： 傅里叶红外透射谱 光吸收谱 纳米硅粒子镶嵌薄膜 光致发光     

Preparation of hydrogenated microcrystalline silicon films with hot-wire-assisted MWECR-CVD system

Intrinsic hydrogenated microcrystalline silicon (\muc-Si:H) films have been prepared by hot-wire-assisted microwave electron-cyclotron-resonance chemical vapour deposition (HW-MWECR-CVD) under different deposition conditions. Fourier-transform infrared spectra and Raman spectra were measured. Optical band gap was determined by Tauc plots, and experiments of photo-induced degradation were performed. It was observed that hydrogen dilution plays a more essential role than substrate temperature in microcrystalline transformation at low temperatures. Crystalline volume fraction and mean grain size in the films increase with the dilution ratio (R=H₂/(H₂+SiH₄)). With the rise of crystallinity in the films, the optical band gap tends to become narrower while the hydrogen content and photo-induced degradation decrease dramatically. The samples, were identified as \mu c-Si:H films, by calculating the optical band gap. It is considered that hydrogen dilution has an effect on reducing the crystallization activation energy of the material, which promotes the heterogeneous solid-state phase transition characterized by the Johnson--Mehl--Avrami (JMA) equation. The films with the needed structure can be prepared by balancing deposition and crystallization through controlling process parameters.     

Effect of Ar in the source gas on the microstructure and optoelectronic properties of microcrystalline silicon films deposited by plasma-enhanced CVD

Hydrogenated microcrystalline silicon films have been prepared by plasma-enhanced chemical vapor deposition technique using silane diluted in H₂ or H₂ + Ar. The microstructures for silicon films have been evaluated by Raman scattering spectroscopy, X-ray diffraction and Fourier-transform infrared spectroscopy. Optical characterization has been done by UV-vis spectroscopy. It is found that the addition of Ar in diluent gases efficiently improves the deposition rate and crystallinity due to an enhanced dissociation of the source gas and the energy of deexcitation of Ar* released within the growth zone. Meanwhile, the enhanced crystallinity and the reducing of hydrogen ion bombardment with increasing Ar dilution lead to the polymerization and also a bad passivation of the hydrogen which cause the widening of the optical gap and increase of defect states in the μc-Si films. The absorption coefficient and dark conductivity are found to decrease basically with increasing Ar dilution corresponding to the widening optical gap and more defects. That the activation energy increases with increasing Ar dilution or decreasing hydrogen dilution is due to the fact that more defect states lead to a pulling down of the Fermi level.     

氢稀释对FTS沉积a-Si:H薄膜结构特性的影响

采用对靶磁控反应溅射技术,以氢气作为反应气体在不同的氢稀释比条件下制备了氢化非晶硅薄膜.利用台阶仪、傅里叶红外透射光谱、Raman谱和紫外-可见光透射谱测量研究了不同氢稀释比对氢化非晶硅薄膜生长速率和结构特性的影响.分析结果发现,利用对靶磁控溅射技术能够实现低温快速沉积高质量氢化非晶硅薄膜的制备.随着氢稀释比不断增加,薄膜沉积速率呈现先减小后增大的趋势.傅里叶红外透射光谱表明,氢化非晶硅薄膜中氢含量先增大后变小.而Raman谱和紫外-可见光透射谱分析发现,氢稀释比的增加使氢化非晶硅薄膜有序度和光学带隙均先增大后减小.可见,此技术通过改变氢稀释比R能够实现氢化非晶硅薄膜结构的有效控制.