Design of a higher harmonic cavity for the SSRF storage ring

Higher harmonic cavity used in the third generation synchrotron light source increases the Touschek lifetime. The higher harmonic cavity of Shanghai Synchrotron Radiation Facility (SSRF) is a 1.5GHz passive superconducting cavity. Its higher order modes (HOM) are extracted by a ferrite HOM damper out of the cryostat. Multi-cell cavity is chosen concerning the voltage. The harmonic cavity dynamics, beam dynamics with passive harmonic cavity and the design of single cell cavity are included in this paper.     

铝蜂窝-铅复合阻尼器的试验研究

提出一种铝蜂窝-铅复合阻尼器,设计了2种类型的6个不同参数阻尼器试件,通过低周循环试验研究了其力学性能,揭示它的工作原理和耗能机制,分析了不同参数阻尼器的等效阻尼比、最大剪应力、存储剪切模量、骨架线等性能参数。结果表明,铝蜂窝-铅复合阻尼器具有屈服位移小、变形能力大、工作性能稳定与耗能性能好等特点,同时具有造价低廉、构造简单、安装方便的优点。相对A型阻尼器,B型阻尼器变形能力大,工作稳定,耗能性能优越。对于阻尼器的等效阻尼比、最大剪应力和存储剪切模量等参数,铝蜂窝/铅复合体的方向、高度和孔棱大小影响较大,复合体的片数影响很小。     

Hysteresis-induced bifurcation and chaos in a magneto-rheological suspension system under external excitation

The magneto-rheological damper(MRD) is a promising device used in vehicle semi-active suspension systems, for its continuous adjustable damping output. However, the innate nonlinear hysteresis characteristic of MRD may cause the nonlinear behaviors. In this work, a two-degree-of-freedom(2-DOF) MR suspension system was established first, by employing the modified Bouc–Wen force–velocity(F –v) hysteretic model. The nonlinear dynamic response of the system was investigated under the external excitation of single-frequency harmonic and bandwidth-limited stochastic road surface.The largest Lyapunov exponent(LLE) was used to detect the chaotic area of the frequency and amplitude of harmonic excitation, and the bifurcation diagrams, time histories, phase portraits, and power spectrum density(PSD) diagrams were used to reveal the dynamic evolution process in detail. Moreover, the LLE and Kolmogorov entropy(K entropy) were used to identify whether the system response was random or chaotic under stochastic road surface. The results demonstrated that the complex dynamical behaviors occur under different external excitation conditions. The oscillating mechanism of alternating periodic oscillations, quasi-periodic oscillations, and chaotic oscillations was observed in detail. The chaotic regions revealed that chaotic motions may appear in conditions of mid-low frequency and large amplitude, as well as small amplitude and all frequency. The obtained parameter regions where the chaotic motions may appear are useful for design of structural parameters of the vibration isolation, and the optimization of control strategy for MR suspension system.     

磁流变阻尼器半主动控制方法的实验研究

由于磁流变阻尼器是一种高度非线性的装置,因此建立与之相适应的控制系统是半主动控制问题的关键。本文采用改进的Bingham模型建立了磁流变阻尼器的动力学特性模型,根据天棚阻尼开关控制、天棚阻尼连续控制和模糊控制三种控制方法,确立了从系统速度响应到磁流变阻尼器励磁电流之间的关系,并开发了一套半主动控制系统。在一个两自由度的简化车辆试验平台上进行半主动控制试验,对比研究了三种控制方法的控制效果。实验结果表明,在1.3Hz~2.0Hz的低频段内,开关控制的最佳减振效果为15.1%,连续控制的最佳减振效果为14.9%,模糊控制的最佳减振效果为20.1%。可见,三种控制方法都能有效的减小车体的振动,模糊控制的减振效果最佳。     

环形调液阻尼器振动控制中拍的研究

对环形调液阻尼器减振控制中的拍现象进行研究,分析了环形调液阻尼器对结构纯扭转振动控制中的拍现象,分别考虑无阻尼结构体系、主体结构有阻尼而CTLCD无阻尼的体系及主体结构和CTLCD中均有阻尼的体系,从数学角度对拍现象发生的机理进行解释.研究结构表明,当拍现象发生时,主体结构的振动不仅不会受到抑制,有时反而会加强;当环形调液阻尼器的阻尼增大到一定程度时,拍现象会消失;对于受廹振动,发生拍现象时,由于结构反应的瞬态部分不能得到迅速衰减,结构的瞬态响应将会占结构响应的很大一部分,如果仅考虑结构的稳态响应会带来较大的误差.     

On influence of kinematics to equivalent linear damping of helicopter blade hydraulic damper

ＩｎｔｒｏｄｕｃｔｉｏｎＴｈｅｐｒｏｂｌｅｍｗａｓｆｉｒｓｔｅｎｃｏｕｎｔｅｒｅｄｄｕｒｉｎｇｆｌｉｇｈｔｔｅｓｔｏｆａＣＨ＿53ＥｄｅｖｅｌｏｐｅｄｂｙＳｉｋｏｒｓｋｙ[1].Ａｓｔｈｅａｉｒｃｒａｆｔｗａｓｉｎｃｒｅａｓｉｎｇｉｔｓａｉｒｓｐｅｅｄｆｒｏｍ 2 77ｋｍ·ｈ- 1,ａｐｈｅｎｏｍｅｎｏｎｏｆｅｘｃｅｓｓｉｖｅｏｓｃｉｌｌａｔｉｏｎｓｗａｓｏｂｓｅｒｖｅｄ .Ｉｔｗａｓｒｅａｌｉｚｅｄｔｈａｔｔｈｅｒｅｗａｓａｓｅｌｆ＿ｅｘｃｉｔｅｄｏｓｃｉｌｌａｔｉｏｎｏｆｃｏｕｐｌｅｄｆｉｒｓｔｃｏｌｌｅ…     

DEPENDENCE OF DAMPING CHARACTERISTICS OF A BEAM WITH DAMPING RUBBER MAGNETIC POWDER ON RUBBER PROPERTY

A cantilever beam with Damping Material Applying Rubber Magnetic Powder （DRM） has been investigated. Two methods are selected to hold DRM to a vibrating steel beam, one is to attach DRM by the magnetic attractive force （called DRM beam） and the other by adhesive bonding （called AB-DRM beam）. Different from the damping property of AB-DRM beam caused by shear deformation of damping material, the damping property of DRM beam is characterized by the sliding frictional loss together with the internal loss of damping material. The authors established a formulation to predict the damping characteristics of DRM beam, which was validated experimentally. It is found that rubber material loss factor β has a decisive influence on damping improvement of DRM beam versus AB-DRM beam. If β is smaller than the critical value around 0.8255, a valid range of vibratory amplitude always exists in which DRM beam can achieve better damping than AB-DRM beam; conversely, if β is bigger than the critical value, the valid range does not exist when slide occurs. Such results are used to determine the merits and limitations of DRM and develop design guidelines.     

采用半主动斜拉索控制柔性梁的横向振动

提出采用磁流变阻尼器构成的半主动斜拉索实现柔性梁横向振动的半主动控制,讨论了其可行性、具体控制方案和控制算法。同时给出了在五种不同情况下的控制仿真结果,表明采用磁流变阻尼器实现结构半主动控制能避免“模态截断”而引起的“溢出”问题,具有能耗小、鲁棒性强的特点。     

双盘悬臂柔性转子--同心型挤压油膜阻尼器系统关于稳态圆响应的参数优选

获得了双盘悬臂柔性转子－同心型挤压油膜阻尼器（ＳＦＤ）系统在ＳＦＤ轴承处的稳态响应的频响特性曲线、盘的频响曲线及传递率曲线。通过求解各方程和分析响应曲线图优选出可以避免出现双稳态和不稳态的参数组合。在给定的参数范围内分析了参数对于各项系统特性的影响,保证了所选能较好地满足各项性能要求,使系统具有优良的稳定性和动态特性。     

三种电流变阻尼器阻尼特性的对比分析

首先简要地介绍了电流变体材料以及电流变阻尼器的基本概念,进而阐明了剪切模式电流变阻尼器、流动模式电流变阻尼器和复合模式电流变阻尼器的工作原理。最后,应用非牛顿流体力学理论给出了它们的阻尼力模型,并对其各自的阻尼特性进行了一些理论分析和探讨。