a-SiNx/nc-Si/a-SiNx双势垒结构中的电荷隧穿和存储效应

在等离子体增强化学气相沉积系统中利用大氢稀释逐层淀积技术制备nc-Si量子点阵列,用硅烷和氨气混合气体淀积氮化硅层,制备了a-SiN_x/nc-Si/a-SiN_x不对称双势垒结构,其中隧穿和控制a-SiN_x层的厚度分别为3和20 nm.利用电导-电压和电容-电压测量研究结构中的载流子隧穿和存储特性.在同一样品中观测到由于电荷隧穿引起的电导峰和由于电荷存储引起的电容回滞现象.研究结果表明,合理地选择隧穿层和控制栅层的厚度,就能够实现载流子发生共振隧穿进入到nc-Si量子点中,并被保存在nc-Si量子点中. 关键词： nc-Si量子点 电导峰 存储效应     

激光干涉结晶技术制备二维有序分布纳米硅阵列

利用结合移相光栅掩模 (PSGM) 的激光结晶技术在超薄a-SiN_x/a-Si:H/ a-SiN _x三明治结构样品中制备出二维有序分布的纳米硅阵列.原始样品是用等离子体 增强化学气相淀积法生长.a-Si:H层厚为10nm，a-SiN_x 为50nm，衬底材料为SiO ₂/Si或 熔凝石英.原子力显微镜、剖面透射电子显微镜、高分辨透射电子显微镜对样品表面形貌和 微结构的观测结果表明，采用该方法可以在原始淀积的a-Si:H层中得到位置可控的晶化区域 ：每个晶化区域直径约250nm，具有同PSGM一致的2μm周期；晶化区域内形成的纳米硅 颗粒尺寸接近原始淀积的a-Si:H层厚，且晶粒的择优取向为<111>. 关键词： 纳米硅 激光结晶 定域晶化 移相光栅     

Resonant Tunnelling and Storage of Electrons in Si Nanocrystals within a-SiNx/nc-Si/a-SiNx Structures

The a-SiNx/nanocrystalline silicon （nc-Si）/a-SiNx sandwiched structures with asymmetric double-barrier are fabricated in a plasma enhanced chemical vapour deposition （PECVD） system on p-type Si substrates. The nc-Si layer in thickness 5nm is fabricated from a hydrogen-diluted silane gas by the layer-by-layer deposition technique. The thicknesses of tunnel and control SiNx layers are 3nm and 20nm, respectively. Frequency-dependent capacitance spectroscopy is used to study the electron tunnelling and the storage in the sandwiched structures. Distinct frequency-dependent capacitance peaks due to electrons tunnelling into the nc-Si dots and capacitance-voltage （C - V） hysteresis characteristic due to electrons storage in the nc-Si dots are observed with the same sample. Moreover, conductance peaks have also been observed at the same voltage region by conductance-voltage （G - V） measurements. The experimental results demonstrate that electrons can be loaded onto nc-Si dots via resonant tunnelling and can be stored in our a-SiNx/nc-Si/a-SiNx structures.     

尺寸可控的纳米硅的生长模型和实验验证

基于经典热力学理论，对a-SiN_x/a-Si:H/a-SiN_x三明治结构或a-Si:H/a-SiN_x多层膜结构中纳米硅成核，以及从球形到鼓形的生长过程进行了研究. 建立了限制性晶化理论模型：在纳米硅生长过程中，由于界面能增大将导致生长停止，给出限制性晶化条件——a-Si:H子层厚度小于34 nm. 在激光晶化和常规热退火两种方法形成的a-SiN_x/nc-Si/a-SiN_x三明治结构和nc-Si/a-SiN_x多层膜结构中验证了该理论模型. 关键词： 非晶硅 纳米硅 激光辐照 结晶     

a-Si:H/a-SiNx:H超晶格的掺杂效应

采用带有可转动掩板的沉积系统,合成出一类新的a-Si:H/掺杂a-SiN_x:H超晶格。样品中各子层厚度及a-SiN_x:H子层中N/Si比固定,仅改变掺杂浓度。结果发现:此类超晶格中的费密能级可以通过a-SiN_x:H层中的掺杂来控制,即a-Si:H/a-SiN_x:H超晶格可以从n型转变为p型,依赖于a-SiN_x:H子层中B的掺杂比。然而,a-SiN_x:H子层中P的掺杂对a-Si:H/a-SiN_x:H超晶格传输特性影响并不大。 关键词：     

Large Storage Window in a-SiNx/nc-Si/a-SiNx Sandwiched Structure for Nanocrystalline Silicon Floating Gate Memory Application

An a-SiNx/nanocrystalline silicon [（nc-Si）/a-SiNx] sandwiched structure is fabricated in a plasma enhanced chemical vapour deposition （PECVD） system at low temperature （250℃）. The nc-Si layer is fabricated from a hydrogen-diluted silane mixture gas by using a layer-by-layer deposition technique. Atom force microscopy measurement shows that the density of nc-Si is about 2 ×10^11 cm^-2. By the pretreatment of plasma nitridation, low density of interface states and high-quality interface between the Si substrate and a-SiNs insulator layer are obtained. The density of interface state at the midgap is calculated to be 1 ×10^10 cm^-2eV^-1 from the quasistatic and high frequency C - V data. The charging and discharging property of nc-Si quantum dots is studied by capacitance-voltage （C- V） measurement at room temperature. An ultra-large hysteresis is observed in the C - V characteristics, which is attributed to storage of the electrons and holes into the nc-Si dots. The long-term charge-loss process is studied and ascribed to low density of interface states at SiNx/Si substrate.     

Thermal annealing of a-Si:H/a-SiNx:H multilayers

The crystallinity of Si/SiN_x multilayers annealed by a rapid thermal process and furnace annealing is investigated by a Raman-scattering technique and transmission electron microscopy. It is found that the crystallization temperature varies from 900 °C to 1000 °C when the thickness of a-Si:H decreases from 4.0 nm to 2.0 nm. Raman measurements imply that the high crystallization temperature for the a-Si:H sublayers originates from the confinement modulated by the interfaces between a-Si:H and a-SiN_x:H. In addition to the annealing temperature, the thermal process also plays an important role in crystallization of a-Si sublayers. The a-Si:H sublayers thinner than 4.0 nm can not be crystallized by furnace annealing for 30 min, even when the annealing temperature is as high as 1000 °C. In contrast, rapid thermal annealing is advantageous for nucleation and crystallization. The origin of process-dependent crystallization in constrained a-Si:H is briefly discussed. Received: 11 April 2001 / Accepted: 20 June 2001 / Published online: 30 August 2001     

Influence of overcoat on laser-induced damage threshold of 532 and 800 nm TiO2/SiO2 high reflectors

TiO₂/SiO₂ high reflectors with and without a SiO₂ overcoat are deposited by electron-beam evaporation. The film properties are characterized by visible spectrometry measures, structure analysis, roughness and laser-induced damage threshold (LIDT) tests, surface defects and damage morphology observation. The effects of overcoats on LIDT at 532 nm, 8 ns and 800 nm, 220 ps laser pulses are investigated. The relations between film structure, roughness, surface defects, electric field and LIDT are discussed. It is found that overcoats can increase the LIDT at these two laser wavelengths. The reduction of peak temperature, the low defects density and roughness, the low intrinsic absorption of SiO₂ and its amorphous structure are the main reasons for LIDT improvement by overcoats.     

The charge storage of the nc—Si layer

Sandwiched structures (a-SiN_x/a-Si/a-SiN_x) have been fabricated by the plasma enhanced chemical vapour deposition technique. A Si nanocrystal (nc-Si) layer was formed by crystallization of an a-Si layer according to the constrained crystallization principle after quasi-static thermal annealing at 1100℃ for 30 min. Transmission electron microscopy (TEM) and Raman scattering spectroscopy clearly demonstrated that nc-Si grains were formed in the as-deposited a-Si layer after annealing. The density of nc-Si grains is about 10¹¹cm^-2 as shown by TEM photographs. Using capacitance－voltage (C－V) measurements we investigated the electrical characteristics of the sandwiched structures. The charge storage phenomenon of the nc-Si layer was observed from the shift of flat-band voltage (V_FB) in C－V curves at a high frequency (1 MHz). We estimated the density of nc-Si grains to be about 10¹¹cm^-2 from the shift value of V_FB, which is in agreement with the result of TEM photographs. At the same time, we found that the shift of V_FB increased with the increase of the applied constant dc voltage or the thickness of the nc-Si layer.     

非晶态异质结构a-Si:H/a-SiNx:H和a-Si:H,a-SiNx:H薄膜的应力研究

实验发现在一定Si—H键浓度下,相对于平坦的硅衬底而言,在其上沉积的a-Si:H薄膜具有压缩应力,a-SiN_x:H薄膜具有伸张应力。当a-Si:H和a-SiN_x:H层厚度比近似于1:2时,硅衬底上生长的a-Si:H/a-SiN_x:H/c-Si样品,弯曲最小,并能保持很长时间。文中还给出了应力随退火变化的情况,并对实验结果进行了讨论。 关键词：     

Preparation of five-layered Si/SixGe1−x nano-films by RF helicon magnetron sputtering

Five-layered Si/Si_xGe_1−x films on Si(1 0 0) substrate with single-layer thickness of 30 nm, 10 nm and 5 nm, respectively were prepared by RF helicon magnetron sputtering with dual targets of Si and Ge to investigate the feasibility of an industrial fabrication method on multi-stacked superlattice structure for thin-film thermoelectric applications. The fine periodic structure is confirmed in the samples except for the case of 5 nm in single-layer thickness. Fine crystalline Si_xGe_1−x layer is obtained from 700 °C in substrate temperature, while higher than 700 °C is required for Si good layer. The composition ratio (x) in Si_xGe_1−x is varied depending on the applied power to Si and Ge targets. Typical power ratio to obtain x = 0.83 was 7:3, Hall coefficient, p-type carrier concentration, sheet carrier concentration and mobility measured for the sample composed of five layers of Si (10 nm)/Si_0.82Ge_0.18 (10 nm) are 2.55 × 10⁶ /°C, 2.56 × 10¹² cm⁻³, 1.28 × 10⁷ cm⁻², and 15.8 cm⁻²/(V s), respectively.     

a-Si:H/a-SiNx:H超晶格薄膜的光学性质

本文介绍,当a-SiN_x:H层的厚度一定,a-Si:H层的厚度不同时,a-Si:H/a-SiN_x:H超晶格薄膜的光吸收系数、光学禁带宽度以及折射率随之变化的规律。 关键词：     

氮化硅介质中双层纳米硅薄膜的两级电荷存储

研究镶嵌在超薄非晶氮化硅(a-SiN_x)层之间的双层纳米硅(nc-Si)的电荷存储现象.利用等离子体增强化学气相淀积(PECVD)技术在硅衬底上制备a-SiN_x/a-Si/a-SiN_x/a-Si/a-SiN_x多层薄膜结构.采用常规热退火方法使非晶硅(a-Si)层晶化，形成包含双层nc-Si的金属-氮化物-半导体(MIS)结构.通过电容电压(C-V)特性测量，观测到该结构中由于电荷存储引起的C-V回滞现象，并在室温下成功观察到载流子基于Fowler-Nordheim(F-N)隧穿注入到第一层、第二层nc-Si的两级电荷存储状态.结合电流电压(I-V)特性的测量，对电荷存储的机理进行了深入分析. 关键词： 纳米硅 氮化硅 电容电压法 电流电压法     

Microstructures of patterned nc-Si superlattices made by pulsed laser interference crystallization

We employed atomic force microscopy, cross-section transmission electron microscopy and high-resolution electron microscopy to investigate the microstructures and surface morphology of laser interference crystallized a-Si : H/a-SiN_x : H superlattices. The experimental results show that Si nanocrystallites (nc-Si) are formed within the initial a-Si : H sublayers and are patterned in certain regions with the same periodicity of 2.0 μ m as the phase-shifting mask grating. The size of nc-Si is limited by adjacent a-SiN _x: H sublayers due to the constrained crystallization effect so it is possible to use this crystallization method to get a three-dimensional ordered nc-Si array.     

a-Si:H/a-SiNx:H超晶格中空间电势分布和光电导的理论计算

本文从a-Si:H体材料的缺陷态模型出发,考虑在a-Si:H/a-SiN_x:H超晶格中由于空间电荷转移掺杂效应,以及界面不对称引起的a-Si:H阱层的能带下降和弯曲,严格求解空间电势分布和电荷分布,发现a-Si:H阱层中能带的下降值远大于由界面电荷不对称所引起的两端电势能差,且随转移到阱层中的电荷总量的变化非常敏感。空间电荷分布比较平缓,当不对称参数K=0.9时,空间电荷浓度的最大差值不到两倍。在此基础上,计算了超晶格中光电导的温度曲线,发现引起超晶格中暗电导和光电导相对于单层膜增大的主要原因是转移电荷量的多少,而界面电荷不对称的影响则小得多。计算中对带尾态采用Simmons-Taylor理论,考虑a-Si:H中悬挂键的相关性,并用巨正则分布讨论其在复合过程中的行为。 关键词：     

Ellipsometry studies of Si/Ge superlattices with embedded Ge dots

In this paper, we present an analysis for treating the spectroscopic ellipsometry response of Si/Ge superlattices (SLs) with embedded Ge dots. Spectroscopic ellipsometry (SE) measurement at room temperature was used to investigate optical and electronic properties of Si/Ge SLs which were grown on silicon (Si) wafers having 〈111〉 crystallographic orientation. The results of the SE analysis between 200 nm and 1000 nm indicate that the SL system can effectively be described using an interdiffusion/intermixing model by assuming multicrystalline Si and Si_1?x Ge _x intermixing layers. The electronic transitions deduced from the analysis reveal Si-, Ge- and alloying-related critical energy points.     

Au/(SiO2/Si/SiO2)纳米双势垒/n+-Si结构的电致发光研究

利用射频磁控溅射方法,在n⁺-Si衬底上淀积SiO₂/Si/SiO_{2纳米双势垒单势阱结构,其中Si层厚度为2至4nm,间隔为0.2nm,邻近n⁺-S i衬底的SiO2层厚度固定为1.5nm,另一SiO2层厚度固定为3nm.为了 对比研究,还制备了Si层厚度为零的结构,即SiO2(4.5nm)/n⁺-Si 结构.在经过600℃氮气下退火30min,正面蒸上半透明Au膜,背面也蒸Au作欧姆接触后,所 有样品都在反向偏置(n^＋-Si的电压高于Au电极的电压)下发光,而在正向偏压 下不发光.在一定的反向偏置下,电流和电致发光强度都随Si层厚度的增加而同步振荡,位 相相同.所有样品的电致发光谱都可分解为相对高度不等的中心位于2.26eV(550nm)和1.85eV (670nm)两个高斯型发光峰.分析指出该结构电致发光的机制是：反向偏压下的强电场使Au/( SiO2/Si/SiO2)纳米双势垒/n⁺-Si结构发生了雪崩击穿 ,产生大量的电子-空穴对,它们在纳米SiO2层中的发光中心(缺陷或杂质)上复 合而发光. 关键词： 电致发光 纳米双势垒 高斯型发光峰 雪崩击穿}     

Formation of W/HfO2/Si gate structures using in situ magnetron sputtering and rapid thermal annealing

The W(150 nm)/HfO₂(5 nm)/Si(100) structures prepared in a single vacuum cycle by rf magnetron sputtering were subjected to rapid thermal annealing in argon. It is found that at an annealing temperature of 950°C, the tungsten oxide WO _x phase and the hafnium silicate HfSi _x O _y phase grow at the W/HfO₂ and HfO₂/Si(100) interfaces, respectively. Herewith, the total thickness of the oxide layeris 30% larger than that of the initial HfO₂ film. In addition, a decrease in the specific capacitance in accumulation C _max and in the dielectric constant k (from 27 to 23) is observed. At an annealing temperature of 980°C, intensive interaction between tungsten and HfO₂ takes place, causing the formation of a compositionally inhomogeneous Hf _x Si _y W _z O oxide layer and further decrease in C _max. It is shown that a considerable reduction in the leakage currents occurs in the W/HfO₂/X/Si(100) structures, where X is a nitride barrier layer.     

多层纳米硅复合膜的共振光学非线性

本文采用简并四波混频技术在室温下研究晶化a-Si:H/a-SiN_x:H多层纳米硅复合膜三阶非线性光学性质,首次观察到这种多层膜的相位共轭信号,在共振光波波长λ=589nm处实验所用样品的三阶非线性极化率为χ⁽³⁾=1.4×10^-6esu,分析表明其非线性光学响应增强的原因是纳米硅的强量子限域作用.     

Strong Green Light Emission from Low-Temperature Grown a-SiNx:H Film after Different Oxidation Routes

Room-temperature deposited amorphous silicon nitride （a-SiNx ：H） films exhibit intense green light emission after post-treated by plasma oxidation, thermal oxidation and natural oxidation, respectively. All the photoluminescence （PL） spectra are peaked at around 500nm, independent of oxidation method and excitation wavelength. Compared with the PL results from oxidized a-Si：H and as-deposited a-SiNx：H samples, it is indicated that not only oxygen but also nitrogen is of an important role in enhancing light emission from the oxidized a-SiNx：H. Combining the PL results with the analyses of the bonding configurations as well as chemical compositions of the films, the strong green light emission is suggested to be from radiative recombination in luminescent centres related to N Si-O bonds.