La_(2-x)(Sr,Th)_xCuO_(4±λ)系催化剂的表征及对CO+NO反应催化性能的研究

合成了x值不同的La2 -xSrxCuO4±λ( 0 .0≤x≤ 0 .1 )和La2 -xThxCuO4±λ( 0 .0≤x≤ 0 .4)两系列K2 NiF4型复合氧化物催化剂 ,用XRD和IR研究了催化剂的晶体结构 .利用化学分析和XPS等方法测定了该系列含Cu氧化物中Cu离子的平均价态、非化学计量氧 (λ)和催化剂的表面和体相组成 .通过控制B位Cu离子的价态和氧化物的非化学计量氧在一定范围内有规律的变化 ,考察对NO +CO反应的催化性能 ;利用MS TPD法研究了该系列氧化物对NO和CO +NO等小分子的吸附和活化性能 ,在此基础上探讨了含Cu的A2 BO4型复合氧化物对NO +CO反应中的催化作用本质 .发现在低温反应条件下 ,NO分子的活化是控制步骤 ,催化剂的活性与低价离子及其含量有关 .在较高反应温度下 ,NO的吸附为控制步骤 ,催化活性与氧空位有关     

用TPD研究SO2对NO催化氧化过程的影响

 针对活性氧化铝载体及过渡金属氧化物催化剂上SO2增强NO吸附并促进其氧化的实验事实，考察了反应温度对SO2发挥促进作用的影响．结果发现，在50～250℃间存在一适宜的温度范围，能使氧化铝上原本不氧化的NO在SO2气氛中发生氧化．对氧化铝预吸附不同组成的气体及在不同温度下吸附NO－O2－SO2后进行了TPD研究．结果表明，SO2的存在对NO氧化吸附生成NO2高温脱附物种有利．对Co3O4／Al2O3催化剂上吸附SO2－NO2的TPD研究结果显示，SO2先吸附或与NO2共吸附都能使NO2高温物种脱附增强，同时SO2的弱吸附物种转变成强吸附物种或表面硫酸盐物种，意味着弱吸附的SO2能与NO2形成稳定的物种；而后吸附的SO2竞争占据NO2的吸附位．推测表面上弱吸附的SO2与NO－O2或NO2之间形成了多分子的活性物种．     

CuO/Ti0.5Zr0.5 O2催化剂上NO+CO反应活性的研究

以Ti0.5Zr0.5O2复合氧化物为载体，采用浸渍法制备了不同负载量的CuO／Ti0.5Zr0.5O2(TZ)催化剂，考察了催化剂对NO的反应活性，并用TPR、TG-DTA和NO-TPD等技术对催化剂进行了表征。结果表明，CuO的负载量和焙烧温度对催化剂的活性均有影响。30％CuO／Ti0.5Zr0.5O2(500℃，2h)在反应温度为400℃时NO转化率为100％。TPR结果表明，CuO负载量≤12％时，在TPR上出现了2个还原峰(即α和β峰)；而进一步提高CuO的负载量，出现了γ还原峰，推测α峰为高度分散Cu物种的还原，β峰为孤立的Cu物种的还原，γ峰则为晶相CuO的还原峰。TG-DTA图谱显示在725℃左右的放热峰是ZrTiO4晶化过程的完成。NO-TPD结果表明NO吸附在TZ上的热脱附过程中，出现2个脱附峰；而NO吸附在12％CuO／TZ上，500℃和750℃焙烧的催化剂上出现3个脱附峰；而在850℃和950℃焙烧的催化剂上只出现2个脱附峰，且NO在上述不同焙烧温度的催化剂上的脱附峰温均低于载体，这表明NO吸附在CuO／TZ催化剂上比吸附在Ti0.5Zr0.5O2上更容易脱出和分解。     

CO和NO在CuO及Cu2O(110)表面吸附选择规律研究

采用离散变分Xα方法分别计算了CO和NO以C（或N）端顶位吸附在CuO（110）及Cu2O（110）表面上的基态势能曲线,结果表明：CO在Cu2O表面上的吸附强,而在CuO表面上的吸附弱;NO则在CuO表面上吸附强,在Cu2O表面上吸附弱．它们的吸附能的大小顺序为：CuO－NO＞Cu2O－CO＞Cu2O－NO＞CuO－CO．对于CuO－NO（或CO）吸附体系,主要是Cu的3d轨道与吸附分子的2π轨道间的相互作用;对于Cu2O－CO（或NO）吸附体系,则主要是吸附质分子的5σ及2π分子轨道与其顶位Cu1的4s及4p轨道和侧位Cu2的3d轨道相互作用．本文通过吸附势能曲线、态密度分析、成键分析及电荷转移量和方向等方面对实验现象做了合理的解释．     

含铜MFI分子筛的H2-TPT和O2-TPD研究

 采用H2－TPR和O2－TPD手段考察了不同金属离子交换的ZSM－5分子筛催化剂上的氢还原性能和氧脱附性能．发现Cu－ZSM－5催化剂的储氧能力及氧脱附性能优于Co－ZSM－5和Fe－ZSM－5催化剂;储氧能力强、低温下氧脱附性能好的催化剂,对NO分解反应的催化活性就高．铜离子是反应的活性中心．添加Ag和Ce可使Cu－ZSM－5催化剂上氧的脱附温度大大降低．Cu－ZSM－5／堇青石整体式催化剂上Cu的存在形式与单纯的Cu－ZSM－5有差异,整体式催化剂上的一价铜数量少,但较稳定．     

γ-Mo2N催化剂上H2及NO吸附性质的TPD-MS研究

采用TPD-MS方法研究了H2及NO在γ-Mo2N上的吸附状况．单独的H2-TPD结果表明,当H2在673K吸附时,在443K、573K及723K得到了三个H2脱附峰,表明γ-Mo2N上有三种不同能量的H2吸附位．NO－TPD结果表明,NO吸附后亦有三个脱附峰（383K、493K、543K）,对应着γ-Mo2N上三种不同能量的NO吸附位：低、中、高能吸附位．NO既可以以解离状态,又可以以一种NO三聚态（dimerordinitrosyl）的形式吸附在γ－Mo2N上,这些吸附物种在脱附过程中产生大量的N2及少量的N2O.对比NO吸附在不同处理条件的γ-Mo2N上的TPD结果可知,NO是吸附在γ-Mo2N上的MO的配位不饱和中心上,这些吸附中心既可通过还原催化剂,又可通过在773K抽空钝化态的γ－Mo2N而产生,H2和NO共吸附的结果表明,预吸附H2再吸附NO后,H2和NO的脱附量均大大减少,且只有两个脱附峰出现.NO只在363K及493K出现两个脱附峰,表明预吸附氢占据了NO的强吸附位,且NO很难取代它,从而使NO只能吸附在能量较低的吸附位上;而H2只在523K及723K出现两个脱附峰,且伴随着H2的脱出有N2和H2O的产生,表明在γ－Mo2N上NO可能与预吸附氢形成了一种复合相MoHx（NO）y,它在脱附时分解为H2、N2及H2O.     

铁助剂对Rh-Mn-Li/SiO2催化剂表面上的CO脱附和CO加氢行为的影响

 采用一氧化碳程序升温脱附（CO－TPD）和吸附的一氧化碳加氢程序升温表面反应（TPSR）考察了Fe助剂对Rh基催化剂上CO的脱附行为及吸附CO的加氢行为的影响．CO－TPD实验表明，在Rh／SiO2催化剂上CO有三个脱附峰．在Rh－Mn－Li／SiO2中加入0．05％Fe后，高温脱附CO比Rh／SiO2催化剂上相应的CO量大．增加Fe的负载量，CO的脱附量减少．TPSR实验中，CO加氢反应的主要产物是甲烷．不同组分的催化剂上甲烷的生成温度有如下顺序：Rh／SiO2（482K）＜Rh－Mn－Li／SiO2（489K）＜Rh－Fe／SiO2（494K）＜Rh－Mn－Li－Fe／SiO2（501K）．甲烷峰的产生伴随着CO（s）高温脱附峰的消失，说明甲烷是由强吸附的CO加氢生成的．     

ZrO2酸碱性质的TPD表征 III.苯酚和CO2或NH3共吸附

用TPD－MS技术对ZrO2上PhOH和CO2或NH3双组分共吸附效应进行了研究．当有CO2或NH3预先吸附时，PhOH的吸附状态和脱附温度并不发生改变．PhOH一方面可以取代与表面酸－碱对中心有关的强吸附CO2或NH3物种而吸附，另一方面表面剩余的CO2或NH3吸附物种又能通过表面键诱导极化使一些“潜在的酸碱中心”得到活化，组成能够吸附PhOH的酸－碱对中心．后一种作用可导致PhOH吸附量增加一倍，表明ZrO2表面具有很高的可极化度．     

NO在Au／Al2O3催化剂上还原反应的TPD-MS研究

 考察了沉积－沉淀法制备的Au／Al2O3催化剂在O2存在下催化C3H6还原NO的反应，并用程序升温脱附－质谱（TPD－MS）手段研究了吸附于催化剂上的NO或NO－O2的脱附性能．结果表明：在O2存在的条件下，对于C3H6还原NO的反应，1％Au／Al2O3的催化活性最高，可于375℃左右使NO生成N2，转化率达60％．这与催化剂对所吸附NO的脱附性能密切相关，N2O可能是C3H6还原NO反应过程中产生的比较稳定的中间体．     

ZrO_2酸碱性质的TPD表征Ⅰ.单组分吸附研究

以NH3、吡啶、Et3N、CO2和苯酚为探针，用TPD－MS方法对ZrO2催化剂的酸碱性质进行了表征．ZrO2上碱性探针（NH3、吡啶和Et3N）的脱附温度远低于在强酸性SiO2－Al2O3上；而酸性探针CO2的脱附温度远低于在强碱性MgO上的结果．为ZrO2的弱酸弱碱性质提供了证明．NH3吸附IR结果表明ZrO2表面配位不饱合Zr4＋为酸（Lewis酸）中心．NH3、吡啶和Et3N与这些酸中心作用的方式和能量分布相似．NH3和CO2的TPD谱图均存在三个脱附峰，且相应脱附峰的温度范围相近．表明ZrO2的酸中心和碱中心具有匹配相当的酸、碱强度，ZrO2为典型的酸－碱双功能催化剂，在苯酚的TPD过程中，ZrO2的特征表现为对苯酚的强吸附和对苯酚分解的高活性．文中结合IR结果，对与NH3和CO2的脱附相联系的表面吸附物种分别进行了讨论．     

Characterization and catalytic behavior of La2 - x (Sr, Th)xCuO4 ± λ in reaction NO+CO

Two mixed oxide systems La₂-_xSr_xCuO_{4± λ} (0.0⩽x⩽1. 0) and La_2-xTh_xCuO_{4± λ} (O. O⩽x⩽ 0.4) with K₂NiF₄ structure were prepared by varyingx values. Their crystal structures were studied by means of XRD and IR spectra. The average valence of Cu ion at B site, nonstoichiometric oxygen (λ) and the chemical composition in the bulk and on the surface of the catalysts were measured by means of chemical analysis and XPS. The catalytic behavior in reaction CO+NO was investigated under the regular change of average valence of Cu ion at B site and nonstoichiometric oxygen (λ). Meanwhile, the adsorption and activation of the small molecules NO and the mixture of NO+CO over the mixed oxide catalysts were studied by means of MS-TPD. The catalytic mechanism of reaction NO+CO over these oxide catalysts were proposed; and it has been found that, at lower temperatures the activation of NO is the rate determining step and the catalytic activity is related to the lower valent metallic ion and its concentration, while at higher temperatures the adsorption of NO is the rate determining step and the catalytic activity is related to the oxygen vacancy and its concentration. Project supported by the National Natural Science Foundation of China.     

CuO/Al_2O_3催化剂中毒与氧吸附

燃煤烟气属于贫燃燃烧 (燃烧时通入过量空气 )尾气 ,其中除含 NOx、SO2 外还含有 O2 等 ,与非贫燃系统尾气中 NOx 的催化还原脱除相比有着很大的不同 .目前这一领域的研究工作虽然取得一些进展 ,但仍有许多问题尚待解决 [1] .无论是 NOx 的催化还原还是催化分解 ,气相中存在的SO2 对非贵金属及其氧化物催化剂构成了严重威胁 ,原因是非贵金属氧化物很容易吸收 SO2 生成稳定的硫酸盐而使催化剂中毒失活 .为脱除烟气中的 NOx,有报道先将气相中的 NO催化氧化为NO2 ,然后将 NO2 和 SO2 同时液相吸收 .研究表明 ,作为 NO催化氧化的非贵…     

Effect of strontium substitution on the activity of La_(2-x)Sr_xNiO_4(x=0.0-1.2)in NO decomposition

The aim of this work is to study the effect of Sr substitution on the redox properties and catalytic ac- tivity of La2-xSrxNiO4(x=0.0-1.2)for NO decomposition.Results suggest that the x=0.6 sample shows the highest activity.The characterization(TPD,TPR,etc.)of samples indicates that the x=0.6 sample possesses suitable abilities in both oxidation and reduction,which facilitates the proceeding of oxygen desorption and NO adsorption.At temperature below 700℃,the oxygen desorption is difficult, and is the rate-determining step of NO decomposition.With the increase of reaction temperature(T> 700℃),the oxygen desorption is favorable and,the active adsorption of NO on the active site(NO Vo Ni2 →NO~--Ni3 )turns out to be the rate-determining step.The existence of oxygen vacancy is the prerequisite condition for NO decomposition,but its quantity does not relate much to the activity.     

CO2加氢合成甲醇催化反应中CO的作用

研究了铜基催化剂上CO₂加氢合成甲醇反应中掺人CO的作用,结果表明,在原料中添加少量CO,甲醇的选择性提高38%,收率提高25%;TPD-MS和TPSR-MS结果表明,CO能抑制催化剂表面起逆水汽变换作用的活性位对CO₂的吸附,从而提高了CO₂加氢合成甲醇的选抒性.     

掺杂ZrO＿2的Pt／Al＿2O＿3表面氧性质及一氧化碳氧化性能研究

用ＴＰＤ－ＭＳ、ＴＰＳＲ－ＭＳ及ＣＯ氧化活性测定等方法研究了Ｐｔ／Ａｌ２Ｏ３和掺杂超细ＺｒＯ２的样品的表面氧脱出－恢复性能、ＣＯ表面氧化性能及催化氧化性能．结果表明，在Ｐｔ／Ａｌ２Ｏ３中掺杂ＺｒＯ２后，样品表面上的氧物种脱出和氧化恢复性能明显提高，脱氧量也明显增大；并发现在ＣＯ－ＴＰＳＲ过程中程脱物ＣＯ２的脱附量大小及峰顶温度次序与对ＣＯ的催化氧化活性也有一致的关系     

La-Ba-Cu复合氧化物在催化消除NO反应中催化性能的研究

合成了具有钙钛石结构的复合氧化物YBa₂Cu₃O₇、LaBa₂Cu₃O₇、LaBaCu₂O₅、La₂BaCu₃O₇和La₄BaCu₅O₁₂.考察了它们对NO分解和NO+CO反应的催化性能.结合化学分析、XRD、TPD和TPR对催化剂的表征结果,探讨了该系列复合氧化物对NO分解和NO+CO反应的催化机理.     

钛铝载体的合成及负载CuO对NO催化性能研究

以TiCl4为原料合成了TiO2/[[alpha]]-Al2O3载体. 在色谱-微反流动法反应装置上考察了CuO/15%(w, 下同)TiO2/[alpha]-Al2O3系列催化剂对NO+CO 的反应性能. 结果表明上述催化剂对NO+CO 反应表现出较好的活性, 其中12%CuO/15%TiO2/[alpha]-Al2O3反应活性最佳. 空气和H2 预处理后, NO 完全转化的温度分别为300C[[deg]]和275C[deg].通过H2-TPR、XRD 和FT-IR 等技术表征, 发现适量TiO2能促进CuO 在钛铝载体上的分散. TPR 结果显示12%CuO/15%TiO2/[alpha]-Al2O3在整个TPR 过程中出现四个还原峰, 琢和酌还原峰分别是钛铝载体表面裸露的TiO2上高度分散的CuO 和晶相CuO 的还原；茁和啄还原峰为钛铝载体上高度分散的CuO 和晶相CuO 的还原. FT-IR实验表明NO和CO 在经H2气氛预处理的催化剂表面上吸附较强, 且生成了N2O 和NO2等物种；NO+CO混合气在经空气和H2预处理的催化剂表面吸附时, 出现了N2O吸收峰, 峰温分别为200C[deg]和150C[deg].     

Fe—Silicalite—2催化剂表面CO2加氢反应性能的研究

研究了Ｆｅ／Ｓｉｌｉｃａｌｉｔｅ－２催化剂ＣＯ２加氢低碳烯烃反应性能，利用ＣＯ２－ＴＰＤ，ＣＯ２／Ｈ２－ＴＰＳＲ和ＣＯ／Ｈ２－ＴＰＳＲ表征手段，考察了铁含量及ＭｎＯ助剂对Ｆｅ／Ｓｉｌｉｃａｌｉｔｅ－２催化剂ＣＯ２吸附脱附及加氢反应性能的影响，表明随铁含量增加可提高催化剂对ＣＯ２的吸附能力，有利于提高ＣＯ２加氢反应的转化率。     

Effects of Carrier on CuO／TiO2 and CuO／Ti0.5Zr0.5O2 Catalysts in the NO＋CO Reaction

Using TiO2 and Ti0.5Zr0.5O2 as carriers, the CuO/TiO2 and CuO/Ti0.5Zr0.5O2 catalysts were prepared by the impregnation method with Cu(NO3)2 as active component. The catalytic activities in NO CO reaction were investigated using a microreactor-GC system, and structure and reducibility of catalysts were characterized by means of physical adsorption, TPR, XRD, NO-TPD technologies. It was found that the activity of CuO/Ti0.5Zr0.5O2 catalyst was higher than that of CuO/TiO2, probably due to the large specific surface area of Ti0.5Zr0.5O2 that played an important role in NO CO reaction.     

The remarkable enhancement of CO-pretreated CuO-Mn2O3/γ-Al2O3 supported catalyst for the reduction of NO with CO: the formation of surface synergetic oxygen vacancy

NO reduction by CO was investigated over CuO/γ-Al2O3, Mn2O3/γ-Al2O3, and CuOMn2O3/γ-Al2O3 model catalysts before and after CO pretreatment at 300 °C. The CO-pretreated CuO-Mn2O3/γ-Al2O3 catalyst exhibited higher catalytic activity than did the other catalysts. Based on X-ray diffraction (XRD), X-ray photoelectron spectroscopy (XPS), UV/Vis diffuse reflectance spectroscopy (DRS), Raman, and H2-temperature-programmed reduction (TPR) results, as well as our previous studies, the possible interaction model between dispersed copper and manganese oxide species as well as γ-Al2O3 surface has been proposed. In this model, Cu and Mn ions occupied the octahedral vacant sites of γ-Al2O3, with the capping oxygen on top of the metal ions to keep the charge conservation. For the fresh CuO/γ-Al2O3 and Mn2O3/γ-Al2O3 catalysts, the -Cu-O-Cu- and -Mn-O-Mn- species were formed on the surface of γ-Al2O3, respectively; but for the fresh CuO-Mn2O3/γ-Al2O3 catalyst, -Cu-O-Mn- species existed on the surface of -Al2O3. After CO pretreatment, -Cu-□-Cu- and -Mn-□-Mn- (□ represents surface oxygen vacancy (SOV)) species would be formed in CO-pretreated CuO/γ-Al2O3 and CO-pretreated Mn2O3/γ-Al2O3 catalysts, respectively; whereas -Cu-□-Mn- species existed in CO-pretreated CuO-Mn2O3/γ-Al2O3. Herein, a new concept, surface synergetic oxygen vacancy (SSOV), which describes the oxygen vacancy formed between the individual Mn and Cu ions, is proposed for CO-pretreated CuO-Mn2O3/γ-Al2O3 catalyst. In addition, the role of SSOV has also been approached by NO temperature-programmed desorption (TPD) and in situ FTIR experiments. The FTIR results of competitive adsorption between NO and CO on all the CO-pretreated CuO/γ-Al2O3, Mn2O3/γ-Al2O3, and CuO-Mn2O3/γ-Al2O3 samples demonstrated that NO molecules mainly were adsorbed on Mn2+ and CO mainly on Cu+ sites. The current study suggests that the properties of the SSOVs in CO-pretreated CuO-Mn2O3/γ-Al2O3 catalyst were significantly different to SOVs formed in CO-pretreated CuO/γ-Al2O3 and Mn2O3/γ-Al2O3 catalysts, and the SSOVs played an important role in NO reduction by CO.