晶粒易轴取向度对纳米晶永磁Pr2Fe14B磁性的影响

构造了立方和不规则形状晶粒的各向异性纳米晶单相Pr₂Fe₁₄B磁体 .利用微磁学的有限元法，模拟计算了样品的磁滞回线.计算结果表明，随着磁体晶粒易轴取向度的变差， 磁体的剩磁、矫顽力均随之下降.不同晶粒尺寸的纳米晶单相Pr₂Fe_{14B磁体，其磁 性能随取向度的变化快慢不同，原因在于磁体中的晶间交换作用 (IGEC) 的强弱不同.随着 晶粒取向度的提高，纳米晶单相磁体的矫顽力逐渐增加，这完全不同于烧结磁体. 关键词： 纳米晶磁体 矫顽力 剩磁}     

晶粒大小分布对纳米晶磁体Pr2Fe14B剩磁和矫顽力的影响

用微磁学有限元法计算了纳米晶磁体Pr2Fe14B的退磁曲线，文中模拟了三种具有不同晶粒大小分布的样品。计算结果表明，剩磁增强与磁体的晶粒尺寸分布情况无关而依赖于平均晶粒直径。晶粒尺寸分布对矫顽力的影响与磁体中的晶间交换耦合作用密切相关。     

晶粒易轴取向度对纳米晶永磁Pr2Fe14B磁性的影响

构造了立方和不规则形状晶粒的各向异性纳米晶单相r2Fe14B磁体.利用微磁学的有限元法,模拟计算了样品的磁滞回线.计算结果表明,随着磁体晶粒易轴取向度的变差,磁体的剩磁、矫顽力均随之下降.不同晶粒尺寸的纳米晶单相Pr2Fe14B磁体,其磁性能随取向度的变化快慢不同,原因在于磁体中的晶间交换作用(IGEC)的强弱不同.随着晶粒取向度的提高,纳米晶单相磁体的矫顽力逐渐增加,这完全不同于烧结磁体.     

FePt薄膜中磁相互作用

采用磁控溅射方法在自然氧化的单晶Si(100)衬底上制备了纳米结构的Fe₅₃Pt₄₇薄膜，并研究热处理后薄膜中的磁相互作用、晶粒尺寸与热处理温度的关系.经400℃热处理后，FePt薄膜中有明显的面心四方相形成，薄膜表现出硬磁性，晶粒尺度在20 nm，薄膜内部存在软硬磁交换耦合作用；随着热处理温度升高，硬磁相含量增加.同时由于FePt薄膜的晶粒长大，部分软硬磁晶粒之间的交换耦合作用失效；600℃热处理后，FePt的面心立方相已经完全转变为面心四方相，薄膜矫顽力由硬磁相之间的静磁作用贡献. 关键词： 磁性薄膜 纳米晶 磁性能 热处理     

纳米晶复合永磁材料的交换耦合相互作用和磁性能

本文介绍了纳米磁性材料晶粒交换耦合相互作用的有关理论。采用不同模型讨论了晶粒交换耦合相互作用对纳米单相软磁材料、永磁材料及双相复合永磁材料磁性能的影响。简述了用δM(H)曲线和不可逆磁导率的变化研究晶粒交换耦合相互作用及反磁化过程的方法。讨论了合金成分配比、添加元素、制备及热处理工艺对磁体硬磁性能的影响。从理论和实验两方面分析、研究了纳米复合永磁材料的反磁化过程和矫顽力机制。     

纳米晶复合永磁材料的交换耦合相互作用和磁性能

本介绍了纳米磁性材料晶粒交换耦合相互作用的有关理论。采用不同模型讨论了晶粒交换耦合相互作用对纳米单相软磁材料、永磁材料及双相复合永磁材料磁性能的影响。简述了用δM（H）曲线和不可逆磁导率的变化研究晶粒交换耦合相互作用及反磁化过程的方法。讨论了合金分配比、添加元素、制备及热处理工艺对磁体硬磁性能的影响。从理论和实验两方面分析、研究了纳米复合永磁材料的反磁化过程和矫顽力机制。     

稀土永磁体及复合磁体反磁化过程和矫顽力

稀土永磁体即使内秉性质相同,但矫顽力可能相差很大.本文以Pr-Fe-B磁体为例,从热激活反磁化即反磁化临界过程探讨决定矫顽力的关键因素.Pr-Fe-B晶粒表层缺陷区与晶粒内部耦合推动反磁化畴形核从而去钉扎,晶粒表层缺陷区的各向异性对克服晶粒内部势垒具有贡献,因此反磁化形核场和矫顽力大大降低.由于晶粒表层缺陷区与晶粒内部耦合,在反磁化临界过程磁畴壁尺寸稍大于理论尺寸.具有软、硬磁相结构的Pr-Fe-B复合磁体,软、硬磁相晶粒之间交换耦合作用也会增大反磁化畴壁尺寸.软、硬磁交换耦合的能量对克服硬磁相晶粒内部各向异性势垒也会有贡献,这将进一步降低磁体矫顽力.添加Ti,Nb高熔点金属,复合磁体矫顽力显著提高.分析认为,这不仅仅是磁体晶粒尺寸减小的缘故.热激活尺寸减小说明磁畴壁中包含的硬磁相晶粒表层缺陷区尺寸减小,硬磁相表面和两相界面各向异性对克服硬磁相晶粒内部势垒的贡献减小,反磁化所需外磁场增大.     

Ti掺杂Nd2Fe14B/α-Fe纳米双相复合永磁体晶化动力学

纳米双相复合稀土永磁材料,利用硬磁相高磁晶各向异性和软磁相高饱和磁化强度的优点,通过铁磁交换耦合作用获得优异的磁性能.但是如何解决软硬磁双相纳米微结构不匹配的问题,控制软硬磁相同时达到理想的纳米尺度复合是关键.本文研究了掺杂合金元素Ti对熔体快淬法制备的Nd₂Fe₁₄B/α-Fe快淬薄带晶化过程的影响.结果表明,掺杂合金元素Ti能影响Nd₂Fe₁₄B/α-Fe交换耦合磁体整个晶化动力学过程,使α-Fe相的晶化激活能升高,抑制其从非晶相中析出.同时,降低1∶7亚稳相的晶化激活能,起到稳定亚稳相的作用.而且随着晶化温度的进一步提高, α-Fe和Nd₂Fe₁₄B两相由1∶7亚稳相分解产生,从而有效避免了α-Fe相的优先析出.显微组织观察表明,掺杂Ti的样品晶粒细小、分布均匀,平均晶粒尺寸在20 nm左右,没有特别大的α-Fe粒子出现.当Ti的掺杂量原子百分数为1.0%时,获得了最佳磁性能(BH)_max=12 MG·Oe(1 G=10     

SmCo7纳米晶合金晶粒组织热稳定性的热力学分析与计算机模拟

推导出了单相纳米晶合金的晶界过剩体积与晶粒尺寸之间的定量关系, 建立了纳米晶合金的晶界热力学性质随温度和晶粒尺寸发生变化的确定性函数. 针对SmCo₇纳米晶合金, 通过纳米晶界热力学函数计算和分析, 研究了单相纳米晶合金的晶粒组织热稳定性. 研究表明, 当纳米晶合金的晶粒尺寸小于对应于体系中晶界自由能最大值的临界晶粒尺寸时, 纳米晶组织处于相对稳定的热力学状态; 当纳米晶粒尺寸达到和超过临界尺寸时, 纳米晶组织将发生热力学失稳, 导致不连续的快速晶粒长大. 利用纳米晶合金热力学理论与元胞自动机算法相耦合的模型对SmCo₇纳米晶合金在升温过程中的晶粒长大行为进行了计算机模拟, 模拟结果与纳米晶合金热力学模型的计算预测结果一致, 由此证实了关于纳米晶合金晶粒组织热稳定性的研究结论. 关键词： 纳米晶合金热力学 7纳米晶合金')" href="#">SmCo₇纳米晶合金 热稳定性 计算机模拟     

纳米晶Nd—Fe—B基稀土永磁体的磁性能的微磁量子理论计算

从微磁学理论出发，利用铁磁体总自由能极小的变分法，导出了取向各向异性磁体的磁化强度满足的Ｂｒｏｗｎ方程，对取向的纳米晶双相交换耦合磁体，该方程类似于量子力学中的定态Ｓｃｈｒｄｉｎｇｅｒ方程，利用中心场问题的求解方法推导了Ｎｄ－Ｆｅ－Ｂ基稀土永磁体的成核场同时随两相晶粒尺寸的变化关系。数值计算结果表明，当两相晶粒尺寸小于某一临界尺寸时，可以获得磁性能优异的纳米晶稀土永磁体。所得结果可用于定性解释实验结果和指导巨磁能积纳米晶永磁体的制备。     

Studies on the magnetic properties for single-phase nanocrystalline FePt magnets with different orientation degrees

The single-phase nanocrystalline FePt magnets composed of 343 irregular-shaped grains are built. The demagnetization curves are simulated by micromagnetic finite element method. The remanence, coercivity and maximum energy product of the magnets decrease with deteriorating grain alignment. The characteristics of variation of magnetic properties with the degree of orientation are closely related to the average grain size of nanocrystalline magnets. The contribution of intergrain exchange coupling (IGEC) to remanence enhancement is associated to the degree of orientation, and decreases with improved grain alignment. With decreasing grain size, coercivity increases for anisotropic nanocrystalline magnets, which is completely different from that of isotropic nanocrystalline magnets.     

Investigation on magnetic properties of orientated nanocomposite Pr2Fe14B/α-Fe permanent magnets by micromagnetic finite-element method

Demagnetization curves for nanocomposite Pr₂Fe₁₄B/α-Fe permanent magnets with different hard grain alignment are calculated by a micromagnetic finite-element method. The results show that both remanence and coercivity increase with improving hard grains alignment. The demagnetization curves show a single-phase demagnetization behavior for the samples with grain size d of 10 nm and two-phase behavior for the samples with d of 20 and 30 nm. H_ex (reflecting the magnetic hardening of α-Fe) and H_irr (expressing the irreversible reversal of hard phase) are both enhanced with improving the hard grain alignment. The magnetic reversal in orientated nanocomposite permanent magnets is mainly controlled by inhomogeneous pinning of the nucleated type.     

纳米晶永磁Pr8Fe87B5反磁化机理研究

用熔体快淬法制备了Pr2Fe14B/α-Fe纳米复合永磁样品.测量了样品的起始磁化、反磁化过程、矫顽力和剩磁与外场的关系，以及样品的磁粘滞性.经分析认为材料的矫顽力主要由非均匀的钉扎机理决定，但由于交换硬化的软磁相的可逆转动使得这种反磁化机理不同于单相永磁材料的钉扎行为.磁粘滞性表明热激活主要源于硬磁相的不可逆磁化行为. 关键词： 纳米复合永磁 矫顽力 剩磁 磁粘滞     

Thermal activation of magnetization in Pr_2Fe_(14)B ribbons

The aftereffect field of thermal activation,which corresponds to the fluctuation field of a domain wall,is investigated via specific measurements of the magnetization behavior in Pr2Fe14B nanocrystalline magnets.The thermal activation is a magnetization reversal arising from thermal fluctuation over an energy barrier to an equilibrate state.According to the magnetic viscosity and the field sweep rate dependence of the coercivity,the calculated values of the fluctuation field are lower than the aftereffect field and in a range between those of domain walls and individual grains.Based on these results,we propose that the magnetization reversal occurs in multiple ways involving grain activation and domain wall activation in thermal activation,and the thermal activation decreases the coercivity by~0.2 kOe in the Pr2Fe14B ribbons.     

CALCULATION OF DEMAGNETIZATION CURVES OF NANOCOMPOSITE Pr2Fe14B/α－Fe MAGNETS USING A ONE-DIMENSIONAL MODEL

The demagnetization curves of nanocomposite magnets have been calculated using a one-dimensional model. The results are in agreement with experimental results. The shoulders of the demagnetization curve have also been explained based on the model.     

The magnetization reversal behaviour for SmCo6.8Zr0.2 and SmCo6.8Zr0.2/α-（Fe,Co） nanocrystalline magnets at low temperature

This paper reports that the SmCo 6.8 Zr 0.2 nanocrystalline permanent magnets and SmCo 6.8 Zr 0.2 /α-(Fe,Co) nanocomposite permanent magnets are successfully produced by mechanical alloying and subsequently annealing at 700 C for 10 minutes.The x-ray diffraction results show that the phase structure of SmCo 6.8 Zr 0.2 nanocrystalline permanent magnets is composed of SmCo 7 phase and SmCo 6.8 Zr 0.2 /α-(Fe,Co) nanocomposite permanent magnets is composed of SmCo 7 and α-(Fe,Co) phases.The mechanism of magnetization reversal is mainly controlled by inhomogeneous domain wall pinning in SmCo 6.8 Zr 0.2 and SmCo 6.8 Zr 0.2 /α-(Fe,Co) magnets.The inter-grain exchange interaction at low temperature is investigated,which shows that the inter-grain exchange interaction of SmCo 6.8 Zr 0.2 /α-(Fe,Co) magnets increases greatly by the decrease of the measured temperature.According to Δm irr-H/H cj,Δm rev-H/H cj and χ irr-H/H cj curves at room temperature and 100 K,the changes of irreversible and reversible magnetization behaviours of SmCo 6.8 Zr 0.2 and SmCo 6.8 Zr 0.2 /α-(Fe,Co) magnets with the decreasing temperature are analysed in detail.The magnetic viscosity and the activation volume of SmCo 6.8 Zr 0.2 and SmCo 6.8 Zr 0.2 /α-(Fe,Co) magnets at different temperatures are also studied.