汽轮机叶片材料抗固粒冲蚀磨损能力的试验研究

利用多种测试技术和试验方法解决了模拟超常气固两相流动过程中的一些特殊问题,较系统地进行了常温到610℃、粒子冲击速度从220 m/s到450 m/s及冲击角从15°到90°条件下氧化铁粒子对两种汽轮机叶片材料抗固粒冲蚀磨损能力的对比性试验研究.研究发现两种叶片材料都呈现出塑性材料的冲蚀特性,最大冲蚀率发生在冲击角约25°和20°处;两种叶片材料冲蚀率的速度指数为2.8～3.0和2.25～2.55,且随温度的变化特性相反.     

双路离心式喷嘴雾化特性研究

在常温常压条件下,使用激光相位多普勒分析仪PDA(Phase Dopplor Analyzer)对某型双路离心式喷嘴的雾化 特性进行了试验研究。测量了不同工况下的喷雾特性参数,通过喷雾液滴粒子的索太尔平均直径SMD、通量及粒子速度 等量的变化规律分析了喷嘴的喷雾特性。     

围压条件下空化磨料射流的冲蚀特性与机制分析

 磨料射流在水利水电、石油工程和海洋资源开发等领域有着广泛的应用,研究射流的冲蚀特性和破坏物料机制对提高水射流利用效率具有重要意义。利用自行研制的实验装置,研究了围压条件下自振空化、文丘里和锥形3种喷嘴形成的磨料射流冲蚀特性,分析了空化磨料射流冲蚀物料的机制。结果表明：自振空化喷嘴和文丘里喷嘴的冲蚀效果优于锥形喷嘴,空化作用有助于提高磨料射流的冲蚀效果;磨料射流的冲蚀效率随围压的增大而降低,主要原因是围压对纯水射流和空化磨料射流的压力脉动和冲击力具有抑制作用。分析认为,空化磨料射流冲蚀破碎物料的机制主要包括冲蚀、气蚀和共混磨蚀3 种作用。     

气固两相对撞流颗粒运动特性分析

本文采用PIV两相同时测量方法,对低载荷气固两相双喷嘴对置撞击射流中的颗粒运动特性进行了研究。实验中轴向射流出口雷诺数为Re=14500,喷嘴内径为d=10 mm,喷嘴间距为L/d=12;颗粒相采用平均直径为dp=100μm的实心玻璃微珠,圆管加速段中的颗粒质量载荷控制为1%~4%。研究结果表明,低载荷下撞击射流中的颗粒间碰撞可忽略,颗粒浓度在喷嘴附近达到峰值;惯性使得颗粒轴向速度在穿入到反向射流前缓慢衰减,之后迅速减小;颗粒在撞击区形成高湍动区域,进而强化了颗粒相的混合效应。     

旋转离心风机叶轮内两相流动的高速摄影研究

固体颗粒与叶栅的磨擦与碰撞，危及叶轮的可靠性和整体装置的稳定性。为研究风机内气固两相流动，利用自制的图象消转装置，拍摄了旋转风机内部固体颗粒相对于叶轮流道的相对运动轨迹的高速摄影照片，对旋转离心风机内颗粒运动特性、颗粒与叶片的碰撞过程及碰撞恢复特性进行了研究，分析了颗粒对叶片的冲蚀机理并指出改进设计思路。     

平面撞击流偏斜振荡的实验研究与大涡模拟

采用实验和大涡模拟对喷嘴出口雷诺数(Re= U₀ hρ/μ, 其中 U₀为出口平均速度, h为平面喷嘴出口狭缝高度, ρ和 μ分别为流体的密度与动力黏度)为25–10000, 喷嘴间距 L为4h–40h范围内的平面撞击流偏斜振荡特性进行了研究. 通过对平面撞击流模拟和实验的结果进行比较, 验证了数值模拟的可靠性, 并对平面撞击流发生偏斜振荡的无因次参数(喷嘴间距 L/h与出口雷诺数 Re)范围进行划分, 重点考察了湍流平面撞击流的偏斜振荡周期及速度-压力变化特征. 研究结果表明大涡模拟能对平面撞击流的偏斜振荡进行有效预报; 当平面撞击流发生周期性偏斜振荡时, 特定点的压力与速度也发生周期性变化, 且变化周期与偏斜振荡周期一致, 偏斜振荡本质上是由速度-压力的周期性变化和转换引起的. 关键词： 平面撞击流 偏斜振荡 大涡模拟     

金属Bi的卸载熔化实验研究

在火炮上利用金属铋(Bi)直接撞击单晶LiF窗口, 开展了金属Bi反向碰撞的冲击加载-卸载实验研究, 实验采用激光位移干涉测试系统, 获得了金属Bi在11—16 GPa压力范围内完整的卸载粒子速度剖面. 实验结果结合特征线方法计算表明, 金属Bi经冲击加载进入体心立方相, 并在11—16 GPa冲击压力作用下发生了卸载熔化, 界面粒子速度剖面的卸载拐点, 对应着金属Bi经冲击加载后发生的卸载熔化, 而这一结论同Cox的理论计算及一维流体力学程序计算结果基本一致. 本文报道的金属Bi卸载波剖面解读技术, 对于认识冲击加载下其他相似材料相变具有实用价值.     

不同喷嘴组合超高压射流破岩钻进特性分析

本文对不同喷嘴组合方式时超高压射流井底流场特性进行数值模拟.根据得出的井底流场的速度矢量图和井底压力分布图,分析超高压钻头喷嘴组合形式对流场结构及钻进效果的影响.结果表明,三个垂直的边喷嘴组合破岩效率较高,但清洗井底效果不佳,冲蚀井壁严重;中心加-个喷嘴可解决清洗井底及冲蚀井壁的问题,但要求高压流体排量增加;两个垂直边喷嘴与-个中心倾斜喷嘴的组合及-个垂直边喷嘴和-个中心倾斜喷嘴的组合流场结构对钻进较为有利.     

二次压缩条件下JOB-9003炸药特性研究

采用火炮加载技术对HMX基JOB-9003炸药进行一维平面冲击实验。实验使用的飞片由蓝宝石和Kel-F黏合而成,撞击炸药后,先后传入两道不同压力的冲击波。通过组合式电磁粒子速度计测量撞击界面和炸药内部不同深度处的粒子速度,得到粒子速度-时间图。根据粒子速度-时间图,计算出撞击界面粒子速度和冲击波传播速度,进一步获得炸药雨贡纽关系。根据炸药雨贡纽关系,并对比已有实验数据,通过Pop图说明炸药在二次压缩下的"钝化"特性。     

带凹槽的微通道中液滴运动数值模拟

运用改进的耗散粒子动力学方法模拟了液滴在由凹槽所构成的粗糙表面微通道内的运动行为.改进的耗散粒子动力学方法采用新近提出的一种短程排斥、长程吸引相互作用势能函数,从而可以模拟带有自由面的流体,如液滴等.模拟了新势能函数下液滴与固体壁面的静态接触角,并用2次多项式拟合了"接触角-a_wf/a_f"变化曲线.研究了液滴在带凹槽的微通道中运动时,微通道壁面浸润性、外场力、液滴温度对液滴流动特性的影响.研究表明壁面浸润性和外场力对液滴流动特性的影响较大,液滴温度对液滴流动特性的影响较小.研究结果对运用耗散粒子动力学方法模拟并分析微流体在复杂微通道的流动有一定的参考价值.     

Theoretical analysis and simulation of conjugate heights for dual-conjugate AO system in lidar

A multi-conjugate adaptive optics （MCAO） can offer a possibility of widening field of view （FOV） characterized by the isoplanatic angle, and the choose of conjugate height becomes a basic problem for MCAO, which influences the size of iosplanatic angle. Considering the application of lidar, the isoplanatic angle＇s expressions of two deformable mirrors （DMs） MCAO for uplink and downlink are deduced. The effects of conjugate heights for dual-conjugate AO are thoughtfully discussed, and the isoplanatic angles are further analyzed. The results show that the isopanatic angle varies with the conjugate height and reaches the maximum as the conjugate height is at the optimal altitude. Moreover, the optimal conjugate height changes with the propagation distance.     

Quick single-photon detector with many avalanche photo diodes working on the time division

Due to the limit of response speed of the present single-photon detector, the code rate is still too low to come into practical use for the present quantum key distribution (QKD) system.A new idea is put up to design a quick single-photon detector.This quick single-photon detector is composed of a multi-port optic-fiber splitter and many avalanche photo diodes (APDs).Au of the ports with APDs work on the time division and cooperate with a logic discriminating and deciding unit driven by the clock signal.The operation frequency lies on the number N of ports, and can reach N times of the conventional single-photon detector.The single-photon prompt detection can come true for high repetition-rate pulses.The applying of this detector will largely raise the code rate of the QKD, and boost the commercial use.     

Characterization of PolyA and PolyC mismatches by Raman spectroscopy

A.C mismatches are studied by Raman spectral characterization of PolyA, PolyC, and their equimolar complex in solution of 0.14 mol/L Na ,pH7.0.Experimental results show that A·C mismatches occur to be A/B (mainly A) conformers, and unlike Watson-Crick base pairing, this kind of mismatches is stabilized by only one hydrogen bond involving cytosine N4H2 and adenine N7.The formation of A·C complex makes the base stacking interactions much stronger, and conformation of the backbone more ordered, which leads to obvious Raman hypochromic effect with some shifts in corresponding bands.     

Improvement of four-wave mixing-based wavelength conversion efficiency in dispersion shifted fiber by 40-GHz clock pumping

40-GHz clock modulated signal as a pump to improve the efficiency of four-wave mixing (FWM)-based wavelength conversion in a 26.5-km dispersion shifted fiber (DSF) is investigated. The experimental results demonstrate that the conjugated FWM component has higher intensity with the clock pumping than that with the continuous-wave (CW) light pumping. The improvement of FWM-based wavelength conversion efficiency is negligible when the pump power is less than Brillouin threshold. But when the pump power is greater than Brillouin threshold, the improvement becomes significant and increases with the increment of pump power. The improvement can increase up to 9 dB if pump power reaches 17 dBm.     

Multi-pulse operation of a Kerr-lens mode-locked femtosecond laser

Our experimental results show that the presence of a proper amount of negative group velocity dispersion is essential to multi-pulse operation of a Kerr-lens mode-locked femtosecond laser. We demonstrate that the pulse separations and the number of pulses contained within a cavity round trip are strongly dependent on the initial perturbations. The results allow us to get a better understanding on the influences of the convoluted self-phase modulation and intra-cavity dispersions on the stable multi-pulse oscillation in a Kerr-lens mode-locked femtosecond laser.     

Propagation of Helmholtz-Gauss beams in weak turbulent atmosphere

Based on the Rytov approximation of light propagation in weak turbulent atmosphere,the closed-form expressions of field and average irradiance of each one of the four fundamental families of Helmholtz-Gauss (HzG)beams:cosine-Gauss beams,stationary Mathieu-Gauss beams,stationary parabolic-Gauss beams,and Bessel-Gauss beams,which are propagating in weak turbulent atmosphere,are obtained.The results show that the field and average irradiance can be written as the product of four factors:complex amplitude depending on the z-coordinate only,a Ganssian beam.a factor of complex phase perturbation induced by atmospheric turbulence,and a complex scaled version of the transverse shape of the non-diffracting beam.The effect of weak atmospheric turbulence on irradiance distribution of the HzG beam can be ignored.     

An effective method for reducing speckle noise in digital holography

An effective method for reducing the speckle noise in digital holography is proposed in this paper.Different from the methods based on classical filtering technique,it utilizes the multiple holograms which are generated by rotating the illuminating light continuously.The intensity images reconstructed by a series of holograms generated by rotating the illuminating light possess different speckle patterns.Hence by properly averaging the reconstructed intensity fields,the speckle noises can be reduced greatly.Experimental results show that the proposed method is simple and effective to reduce speckle noise in digital holography.     

Influence of purity of HfO2 on reflectance of ultraviolet multilayer

The impurities in two kinds of HfO2 materials and in their corresponding single layer thin films were determined through glow discharge mass spectrum technology and secondary ion mass spectrometry(SIMS) equipment respectively.It was found that ZrO2 was the main impurity in the two kinds of HfO2 either in the original HfO2 materials or in the electron beam deposited films.In addition,the difference of Zr content in the two kinds of HfO2 single laver films was much laxger than that of the other impurities such as Ti and Fe.which showed that it was just ZrO2 that made the difference between the optical performance of the film products including the two kinds of HfO2.With these two kinds of HfO2 and the same kind of SiO2.we deposited HfO2/SiO2 multilayer reflective coatings at the wavelength of 266 nm.Experimental results showed that the reflectances of these two mirrors were about 99.85% and 99.15% respectively,which agreed well with the designed results what were based on the optical constants obtained from the corresponding single layer thin films.     

Speech enhancement by array crosstalk resistant ANC and spectrum subtraction

Microphone array-based speech enhancement has great importance for speech communications and speech recognition. To reduce the aperture of the microphone array and to increase the effect of the speech enhancement will greatly broaden the application areas of the microphone array. An array crosstalk resistant adaptive noise cancellation method is therefore presented. And then an improved spectral subtraction algorithm is further cascaded to obtain better enhancement results. Theoretic analysis and experiments indicate that the proposed scheme needs only a very small microphone array while it simultaneously achieves a higher SNR improvement. Besides, the proposed scheme can be used in many noisy environments and is easy for real-time implementation.