高硅FAU沸石与甲胺吸附物的相互作用

合成高硅沸石中所用的模板剂胺类分子与沸石骨架 Si—O基团间的相互作用机理尚不清楚 .迄今为止 ,沸石与吸附胺之间的相互作用的研究还只限于测定沸石酸性质 [1,2 ]、表面羟基活性位或了解模板分子在沸石骨架中的位置和状态 [3,4 ] .甲胺、乙胺在骨架完美的高硅 FAU(Y型 )沸石上的亲和性指数 AT 值 ,即被吸附有机物脱附峰温与该有机物的沸点之差分别高达 1 60与 1 5 0℃[5] .而在高硅 MFI(Silicalite-1 )沸石上为 1 60与 1 2 7℃ [6 ] .与大多数有机物不同 ,被吸附的胺类脱附时的吸热效应十分明显 .上述现象表明胺与高硅沸石骨架 O2 -…     

甲胺与MFI、FAU 及FER型高硅沸石的相互作用

The adsorption of methylamine on highly siliceous MFI, FAU and FER-type zeolites was investigated withXRD, FT-IR, Raman, ^13C and ^29Si MAS NMR, and compared with the adsorption of methanol. As the adsorption of the amine, the relative intensity of XRD peaks of the zeolites has been changed significantly, the high-resolution ^29Si MAS NMR peaks have been broadened and shifted to low field, and the resonance of Si-OH groups has appeared. The vibration of N-H has been shifted to low frequency and C-N vibration moved to high frequency in the IR spectra, and the ^13C resonance peak broadened and shifted to high field for the adsorbed amine. The facts reveal an associating interaction between the perfect framework of the zeolites and the adsorbed methylamine with hydrogen bonds, leading to the formation of Si-OH groups and the high desorption temperature of the methylamine from the zeolites.     

FER型沸石的合成、结构与吸附性质

在TMEDA(四甲基乙基二胺)-Na2O-SiO2-Al2O3-H2O体系(I),Na2O-K2O-Al2O3-SiO2-H2O-HCO3^--CO3^2^-体系(II)及Py(吡啶)-PrNH2(正丙胺)-HF-SiO2-H2O体系(III)中, 分别合成了纯相FER沸石及FER硅沸石。用粉末XRD, FT-IR, 29Si MAS NMR及TG/DTA等表征其结构性质, 并用超微量电子真空吸附天平测定这些沸石样品对正己烷, 甲醇和水的吸附等温线。结果表明: 各体系合成的样品虽然结晶度高, 呈现出FER沸石的典型结构特征, 但由于它们的组成和晶格微结构不同, 热稳定性与吸附性质有明显的差异。在(I)体系中合成的FER沸石层错缺陷少, 晶格完美, 正己烷与甲醇的吸附量可达到理论值, 结构破坏温度为1190℃。红外精细谱及29Si MAS NMR高分辨谱证明FER硅沸石具有十分完美的骨架结构。由于晶胞收缩, 它对正己烷与甲醇吸附量略低于理论值, 并呈现出高度的疏水性。它的结构破坏温度高于1300℃。在(II)体系中合成的FER型沸石结构缺陷多, 沸石孔中的钾离子不易被质子完全交换。它的正己烷与甲醇吸附量均较低, 而水的吸附量相对较高。吸附现象表明, 正己烷和甲醇都被吸附于FER沸石的十元环主孔道中, 分压较高时, 甲醇可通过八元环进入小笼, 而水的吸附性质则主要与各样品的Si-OH缺陷及骨架中的阳离子含量有关。     

Studies on the Formation and Characteristics of Two Types of p-Xylene/Silicalite-1 Associates

High resolution 29Si MAS NMR, 13C CPMAS NMR, and TG/DTG/DTA were used to study the interaction between theframework of siliceous MFI type zeolite (silicalite) and the adsorbedp-xylene. The zeolite sample used in this study possesses a perfectframework. A series of high resolution 29Si MAS NMR and 13CCP MAS NMR spectra of the samples with various loadings of p-xylene weremeasured. Experimental results of XRD, NMR and thermal analysis confirm theformation of two types of p-xylene/silicalite associate. The properties ofthe two types of associates are given in terms of their XRD patterns,NMR spectra and TG/DTG/DTA curves. When the p-xylene loading is lessthan four molecules per unit cell, the adsorbed molecules disperse inthe sinusoidal channels and interact with the framework O2-forming associate-I (p-xylene/silicalite), and inducing themonoclinic/orthorhombic(I) transition. When the p-xylene loadingis more than 5.2 molecules/u.c., the adsorbed p-xylene moleculesare located in the channel intersections and combined into ap-xylene/p-xylene complex via hydrogen bonding, formingassociate-II (p-xylene/p-xylene/silicalite) and inducingthe orthorhombic(I)/orthorhombic(II) transition. The desorptionof p-xylene from associate-II occurs at about 90 °Cwith an evident endothermic effect, whereas the desorption fromassociate-I occurs at about 140 °C without any visibleheat effect, implying that two types of sorption and desorptionprocesses exist in this host/guest system.     

硅沸石完美骨架上的吸附1: 乙胺/FAU型沸石相互 作用

采用核磁、红外、XRD研究了FAU硅沸石与吸附的乙胺之间的相互作用,XRD谱显示乙胺的吸入导致沸石晶胞收缩、对称性改变,立方变四方。^2^9SiMASNMR上,FAU硅沸石的单峰分裂成四重峰,同时骨架的红外吸收峰移向低频。这些结果表明,FAU骨架与吸附的乙胺之间存在着强烈的相互作用。     

全硅FER沸石上有机吸附物脱附行为的研究

运用热分析技术,研究吸附在体相和表面结构完美的单晶状疏水全硅FER沸石孔道中的有机化合物的脱附行为,测定亲和性指数AT值和负载量。所研究的吸附质为直链烷烃、直链烷基醇、直链烷基胺等,结果显示醇有较低的AT值,而直链烷烃有较高的AT值,胺类有最高的AT值。证明全硅FER沸石骨架对烷基、胺基呈现出强的"亲和性",而对羟基呈现出“憎性”。同时还发现吸附质的链长对脱附性质、AT值也有较大影响。     

Contribution of Silica Gels to Superimposed 29Si MAS NMR Spectra of Y Zeolites Dealuminated by Steaming

The ²⁹Si MAS NMR spectra of in situ formed amorphous aluminosilicates and silica gels superimpose the spectra of steamed and chemically modified DAY‐T, DAY‐T_acid, DAY‐T_alkaline and DAY‐T_{alkaline+acid} zeolites. In comparison with XRD data, the Si/Al_NMR ratios of the zeolite framework are determined to high or to low.     

A solid-state NMR method for solution of zeolite crystal structures

Since zeolites are notoriously difficult to prepare as large single crystals, structure determination usually relies on powder X-ray diffraction (XRD). However, structure solution (i.e., deriving an initial structural model) directly from powder XRD data is often very difficult due to the diffraction phase problem and the high degree of overlap between the individual reflections, particularly for materials with the structural complexity of most zeolites. Here, we report a method for structure determination of zeolite crystal structures that combines powder XRD and nuclear magnetic resonance (NMR) spectroscopy in which the crucial step of structure solution is achieved using solid-state (29)Si double-quantum dipolar recoupling NMR, which probes the distance-dependent dipolar interactions between naturally abundant (29)Si nuclei in the zeolite framework. For two purely siliceous zeolite blind test samples, we demonstrate that the NMR data can be combined with the unit cell parameters and space group to solve structural models that refine successfully against the powder XRD data.     

疏水硅沸石Silicalite-I)结构性质的表征

用粉末XRD, FT-IR, 29^Si MAS NMR, 对高硅HZSM-5沸石及疏水硅沸石Silicalite I进行结构性质表征。在室温下, 疏水硅沸石具有ZSM-5的单斜对称性。它的红外骨架振动谱及高分辨29^Si固体核磁共振谱均显示出高的分辨率。在红外光谱中, 3700和3500cm^-1左右的表面Si-OH基振动消失。表明疏水硅沸石晶格中的[SiO~4]四面体排列完美。由-Si-O-Si-构成的微也表面, 具有优良的疏水性。     

Characterisation of Siliceous Extra‐Framework Species in DAY Zeolites by 29Si MAS NMR and IR Spectroscopic Measurements

Dealuminated Y zeolites (DAY) were obtained by steaming of NH₄NaY at temperatures between 450 °C and 700 °C. They were characterised by means of ²⁷Al and ²⁹Si MAS NMR, IR spectroscopic and XRD measurements. The Si/Al framework ratios of samples were calculated using the ²⁹Si MAS NMR signal intensities, the wave numbers of the double‐ring vibration band w_DR and the asymmetrical TOT valence vibration w_TOT of IR spectra as well as the XRD lattice constant a₀. In contrast to actual Si/Al ratio obtained from w_DR and a₀, the NMR spectroscopic and w_TOT values were determined to be too high because of the superposition of the signals coming from dealuminated zeolite framework and silica gel which forms in the zeolite as a result of steaming. The differently determined Si/Al ratios characterise the siliceous extra‐framework species.     

Effect of molecular oxygen on the variable-temperature 29Si MAS NMR spectra of zeolite-sorbate complexes

Structure determinations of siliceous zeolite-sorbate host-guest complexes by solid-state NMR require highly resolved 29Si MAS NMR spectra. As the temperature is lowered, the 29Si MAS NMR spectra of many zeolite-sorbate complexes become broadened such that the resolution of the individual 29Si peaks is lost, limiting the application of solid-state NMR for structure determination. It is shown that the 29Si peak widths are related to the 29Si T2 relaxation times and that the source of the 29Si relaxation and the line broadening is paramagnetic molecular oxygen in the channels of the zeolite. Removal of the oxygen by purging the sample with nitrogen gas leads to a dramatic increase in the resolution of the 29Si MAS NMR spectrum of the p-dibromobenzene/ZSM-5 complex. An analysis of the individual 29Si T1 relaxation times reveals that the oxygen molecules are localized mainly in the zigzag channels of ZSM-5, suggesting that the p-dibromobenzene molecules are located in the channel intersections.     

Optimization, standardization, and testing of a new NMR method for the determination of zeolite host-organic guest crystal structures

An optimized and automated protocol for determining the location of guest sorbate molecules in highly siliceous zeolites from (29)Si INADEQUATE and (1)H/(29)Si cross polarization (CP) magic-angle spinning (MAS) NMR experiments is described. With the peaks in the (29)Si MAS NMR spectrum assigned to the unique Si sites in the zeolite framework by a 2D (29)Si INADEQUATE experiment, the location of the sorbate molecule is found by systematically searching for sorbate locations for which the measured rates of (1)H/(29)Si cross polarization of the different Si sites correlate linearly with (1)H/(29)Si second moments calculated from H-Si distances. Due to the (1)H/(29)Si cross polarization being in the "slow CP regime" for many zeolite-sorbate complexes, it is proposed that the CP rate constants are best measured by (1)H/(29)Si cross polarization drain experiments, if possible, to avoid complications that may arise from fast (1)H and (29)Si T(1)rho relaxations. An algorithm for determining the sorbate molecule location is described in detail. A number of ways to effectively summarize and display the large number of solutions which typically result from a prediction of the structure from the CP MAS NMR data are presented, including estimates of the errors involved in the structure determinations. As a working example throughout this paper, the structure of the low loaded p-dichlorobenzene/ZSM-5 complex is determined under different conditions from solid-state (1)H/(29)Si CP MAS NMR data, and the solutions are shown to be in excellent agreement with the known single-crystal X-ray diffraction structure. This structure determination approach is shown to be quite insensitive to the use of relative rate constants rather than absolute values, to the detailed structure of the zeolite framework, and relatively insensitive to temperature and motions.     

^29Si,^27AIMASNMR研究不同脱铝深度稀土 超稳Y沸石中Si、Al的分布

本文应用^29Si,^27AIMASNMR和XRD技术,测量了四种不同脱铝深度的稀土超稳Y沸石的骨架硅铝比,得到了一致的结果,并研究了稀土超稳Y沸石的脱铝过程和稀土离子和Y沸石骨架铝的机理.发现稀土离子存在时,Y沸石骨架中Si、Al的分布与相同硅铝比的ＨＹ不同,在浅、中度脱铝时,主要脱除的是Si(2Al)和Si(3Al)中的铝,深度脱铝时,主要是Si(1Al)和少量Si(2Al)中的铝,而Si(3Al)几乎不变,提出稀土离子最可能是位于方钠的Si(3Al)附近,平衡三个AlO 四面体上的负电荷,起到稳定Si(3Al)结构单元的作用.其次,稀土超稳Y沸石中总的非骨架铝(N~Al)~EF,随脱铝深度的增加而增加,仅只在REUSY-38的^27AIMAS NMR谱中观察到Al^3+非骨架铝的存在.^29Si,^27AIMASNMR     

TS-1分子筛骨架钛原子引入过程的研究

采用廉价的四丙基溴化铵（ＴＰＡＢｒ）为模板剂合成了ＴＳ１分子筛．在晶化过程中,运用ＸＲＤ,ＩＣＰ,ＩＲ,２９ＳｉＭＡＳＮＭＲ和ＵＶＶｉｓ光谱等表征手段,系统地研究了钛原子引入分子筛骨架的机制,观察到钛原子随分子筛的形成同步进入骨架的规律．另外,尽管在晶化初期固相中没有ＴｉＯ２结晶出现,但存在分散态的ＴｉＯｘ物种．随晶化时间的延长,液相中钛物种之间聚合的几率增加,使固相中ＴｉＯ２晶体不断形成．     

Studies on Natural CXN Zeolite： Modification, Framework De-alumination and Ion-exchange

A natural CXN zeolite (stilbite, type code-STI) discovered in China was modified with NH4^ exchange by using ammonium salt and calcinations (procedure Ⅰ), or with NH4 exchange followed by treatment with acid (procedure Ⅱ). The coordination state of Si and A1 atoms in the framework, the property of ion exchange, and the adsorption of the H-STI zeolite samples prepared by different modification procedure were investigated with XRD,EDX,^29Si and ^27Al MAS NMR, Ag^ ion exchange and Ne adsorption. The results of the investigations indicate that different procedure of the modification made variety on the distribution of the framework Si atoms and A1 atoms,the content of non-framework aluminum, and the blocking channels and the shielding effect to the positions of the exchangeable cations. The H-STI zeolite prepared by the procedure Ⅱ possesses high ion exchange capacity, open and perfect pore system, and high thermal stability.     

不同模板剂含量MCM-49分子筛的CTAB修饰及在苯甲醚酰基化反应中的应用

芳香族化合物的Friedel-Crafts酰基化反应是制备芳香酮的一类重要反应,传统的Lewis酸(如AlCl3)和质子酸(如H2SO4)催化剂易制备,价格便宜,但存在对环境污染严重、与产物难分离等问题.因此,近年来研究者一直致力于环境友好催化剂的研发,其中分子筛因选择性好、与产物易分离、可再生和无污染等优点而日益受到人们的重视,尤其是MWW分子筛,由于具有较多的外表面酸性位,而在酰基化反应中表现出良好的抗积碳性能.本课题组曾讨论了对一系列不同模板剂(六亚甲基亚胺, HMI)含量的MCM-49分子筛进行NaOH与十六烷基三甲基溴化铵(CTAB)共处理的情况,而本文重点考察的是只用CTAB处理不同HMI含量的MCM-49分子筛时,其结构与酸性会如何变化,改性前后样品的结构与酸性借助XRD, N2吸脱附等温线测试,29Si与27Al MAS NMR, NH3-TPD, Py-IR与漫反射傅里叶变换红外光谱(DRIFTS)等技术进行表征.另外,将一系列样品用于催化苯甲醚(AN)与乙酸酐(AA)的酰基化反应,考察CTAB处理对MCM-49分子筛催化性能的影响.将含模板剂HMI的MCM-49分子筛原粉在不同温度(250,350,450或550°C)下焙烧,得到一系列不同孔道系统内保留HMI的样品,随后采用CTAB溶液(0.27 mol/L)对其在70°C下进行后处理1 h.结构表征的结果表明,在脱除模板剂HMI及CTAB处理的过程中,分子筛骨架结构基本未被破坏,同时, CTAB处理不能向分子筛中引入任何形式的介孔,无论是晶内介孔还是晶间介孔.在CTAB处理时,可以清除分子筛中部分无定形物种,尤其是无定形Al物种,同时也可能发生部分非骨架Al原子重新进入分子筛骨架的情况,造成骨架铝的比例相对提高.根据29Si与27Al MAS NMR结果可以推断,进入分子筛骨架的Al原子可能会取代T3位置上的Si原子,亦或直接进入T2或T3位置缺陷位.酸性表征的结果表明, CTAB修饰后样品Br?nsted酸量比HMCM-49明显提高,并随HMI含量的逐渐降低呈现先增加后降低的趋势,而Lewis酸量则相对于HMCM-49有所降低.将一系列CTAB修饰前后的MCM-49样品用于催化AN与AA的酰基化反应,反应条件为：压力1.0 MPa、温度110°C、总质量空速WHSV(AN+AA)为10.2 h?1及原料中AN与AA的摩尔比为5：1.反应数据表明,相对于HMCM-49样品, CTAB修饰后样品对应的AA转化率显著提高(初始转化率由51.4%最高增加至85.0%),并随CTAB处理过程中HMI含量的逐渐降低呈现先增加后降低的趋势,而产物选择性则基本没有变化.各样品的AA初始转化率与其Br?nsted酸量基本呈现正向关联.通过间二甲苯歧化反应预积碳堵塞超笼及碱性探针分子2,4-二甲基喹啉吸附覆盖表面半超笼的方法,研究CTAB修饰前后各样品的不同孔道系统对酰基化反应的催化贡献.结果表明,酰基化反应主要发生在MCM-49分子筛的表面半超笼,其次为超笼,正弦孔道的贡献很小.另外, CTAB修饰后样品催化活性的提高主要来自于不含HMI的孔道系统的贡献,进一步验证在CTAB处理过程中,改性作用主要发生在MCM-49分子筛中不含HMI的区域.结合表征和反应评价结果,提高酰基化反应活性需尽可能提高催化剂的Br?nsted酸量,这是分子筛催化剂今后改进的一个主要方向.     

不同方法处理的脱铝Y沸石的结构特征研究

用~(29)Si MAS NMR、~(27)Al MAS NMR、XRD及IR等方法对4种不同脱铝方法处理的USY、SSY、US-SSY和DAY的微观结构进行了研究,结合脱铝方法讨论了骨架硅铝的分布以及非骨架硅铝和羟基空穴等的形成和含量不同的原因.发现不同脱铝方法可导致骨架上不同Si(nAl)单元的脱除.XRD结果表明,SSY经进一步高温水蒸汽处理得到的US-SSY的相对结晶度可高达97％.脱铝后,微孔保留愈多,二次孔越少,相对结晶度愈高.最后对~(29)Si MAS NMR、XRD和IR3种测定骨架单胞铝(N_(Al))_F的结果进行了比较.     

Y沸石的酸性

用^29Si MAS NMR(MAS为Magie Angle Spinning), 统计计算,NH3-TPD 等方法对(NH4)2·SiF6去铝补硅得到的高硅Y型沸石的酸位分布情况进行了研究, 并与典型酸催化反应数据相关联, 证实了Y型沸石的酸位强度取决于A1原子的周围环境, 即与次邻位A1原子数目n-NNN(NNN为Next Nearst Neighbor)有关, 沸石的强酸性来自次邻位无A1原子的AIO^-4四面体。 NH3-TPD法测量的沸石酸量和酸强度数据与^29Si MAS NMR 实验结果和统计计算得到的不同n-NNN A1位的分布是一致的。 随着A1含量减少, Y型沸石表面的总酸量是单调下降的。但强酸量却是先增加后下降, 在A1/(A1+Si)为0.15左右出现极大值。不同硅铝比的Y型沸石对典型的强酸性和弱酸性催化反应的活性变化规律亦与酸性相吻合。     

Reactivity of Extra‐framework Species of USY Zeolites in Alkaline Medium

Zeolites of type USY (ultra‐stable Y) were obtained by steaming of NH₄NaY modification. Samples were modified by subsequent alkaline treatment in KOH solution. USY and USY‐KOH were characterised by chemical element analysis, XRD, IR, ²⁹Al and ²⁹Si MAS NMR spectroscopic measurements. Correct silicon to aluminium ratios (Si/Al) were determined by XRD and IR (double ring vibration w_DR) data whereas values calculated according to data of ²⁹Si MAS NMR and IR spectroscopy (asymmetrical TOT valence vibration w_TOT) appeared to be too high., In the latter case, the signals of the zeolite framework were strongly superimposed by that of extra‐framework silica gel (EFSi) formed during steaming. It was found that alkaline leaching induces desilication of silicon‐rich area of the zeolite framework and partial dissolution of EFSi. Silicate ions of both react with likewise dissolved extra‐framework aluminium (EFAl) to form X‐ray amorphous aluminosilicate. Consequently, the superposition of the ²⁹Si MAS NMR signals of the zeolite framework by silica gel was reduced for Q⁴(0Al) but increased for Q⁴ (2Al) and Q⁴(3Al) structure units. A reinsertion of EFAl into the zeolite framework has not been observed.     

Distribution of aluminum and boron in the periodical building units of boron-containing Beta zeolites

Various boron only ([B]-BEA) as well as aluminum- and boron-containing beta zeolites ([Al,B]-BEA) have been prepared and modified by ion exchange of ammonium, sodium, and nickel ions. The zeolite samples have been characterized by 11B, 27Al, and 29Si MAS as well as three of them by 11B and 27Al 3Q-MAS NMR spectroscopy. The quantitative contributions of defect-free Si(nX) (n = 2, 1, 0; X = Al, B) and Si(OH)x (x = 2, 1) sites to the NMR signal intensities were calculated from the various Si/(Al + B) ratios and relative 11B, 27Al, and 29Si NMR signal intensities using the special distribution of aluminum and boron in different periodical building units of the zeolite framework. The boron atoms are sitting exclusively in diagonal positions in the four-membered rings of [B]-BEA zeolites, while the aluminum atoms are situated both in diagonal and lone positions in the four-membered rings of [Al,B]-BEA zeolites. A higher part of boron atoms are positioned in framework-related deformed tetrahedral boron species than in lattice positions in the [B]-BEA than in the [Al,B]-BEA zeolites. All extraframework octahedral aluminum species are transformed back to lattice positions due to ion exchange from the protonated form to ammonium-, sodium-, or nickel-ions containing zeolites. Oppositely, trigonal boron leaves the zeolite structure completely during ion exchange.