取代脲促进环氧树脂／双氰胺固化体系反应机理

双氰胺作为环氧树脂的固化剂，由于固化产物具有优良的机械和电性能，广泛应用在汽车、航天及电子等领域中．但由于其固化温度高达180C以上，使应用范围受到很大限制．专利文献曾报道晚衍生物作为环氧树脂／双氰胺固化体系的促进剂，可以使体系的固化温度降低到130～140oC，并且在室温下仍保持一定的潜伏性［‘，’］．在以往的研究中，认为取代脉的促进作用在于其与环氧发生反应生成环状化合物2一心竣烷酮和仲胺，仲胺与环氧基进一步反应生成的叔胺可以催化环氧发生阴离子聚合［’～’］．实验表明，环氧树脂／双氰胺／取代脉体系的固化温…     

环氧/酸酐/DMPA体系固化动力学与溶解性研究

在环氧/酸酐固化体系中引入4-二甲氨基吡啶(DMPA)作为酯交换反应催化剂和固化反应促进剂,以制备具有动态交联网络的环氧树脂。用差示扫描量热仪(DSC)对环氧/酸酐/DMPA体系的固化行为进行了研究,考察了催化剂的含量和固化剂比例对环氧/酸酐/DMPA体系固化行为的影响和固化动力学。通过乙二醇溶解实验,研究交联网络中的可交换键。结果表明反应体系中有高温和低温两种固化机理发生反应,催化剂和固化剂含量较少时,固化反应温度高,固化反应中含较多环氧自聚反应,不利于酯交换反应,溶解效果差;反之,固化反应温度向低温移动,利于酯键的形成,样品的溶解速度就越快。当环氧/酸酐为1:1.5,催化剂用量为3%时,具有较好的溶解性能。     

环氧树脂潜伏性固化促进剂的研究

对环氧树脂/桐油酸酐/乙酰丙酮钕体系的热固化反应进行了研究。用DSC、TBA和固化仪等手段测定了凝胶化时间和表观反应活化能,计算了反应动力学参数。结果表明,乙酰丙酮钕对体系的固化具有潜伏性促进作用。     

用苯乙烯-马来酸酐固化环氧树脂

通过FT-IR和DSC技术研究了甲基咪唑(MeIm)作为促进剂时,苯乙烯-马来酸酐共聚物(SMA)与环氧树脂的固化过程.用DTA-TC研究了其耐热性能.用SEM观察了固化产物的表面形态.讨论了该固化过程的机理.结果表明,SMA可以单独作为作为环氧树脂的固化剂使用,甲基咪唑(MeIm)作为促进剂时,能使固化反应的温度降低近10℃,且固化产物能耐将近400℃的高温.固化产物为两相结构:连续相为环氧树脂,分散相为SMA.     

环氧树脂潜伏性固化促进剂的研究：Ⅱ.促进剂对固化物性能的影响

对双酚A环氧树脂/桐油酸酐/乙酰丙酮钕体系的热固化及其产物性能,用热分析,介电损耗和动态力学等手段进行了研究。结果表明,乙酰丙酮钕除对固化具有潜伏性促进作用外,尚可使固化物的物理性能明显提高。     

有机脲类快速固化环氧粉末涂料的研究

有机脲类化合物一般作为一种有效固化促进剂使用。但作者经大量的实验得出,有机脲类可以单独作为一种优良的快速固化剂,其固化速度快,并且有优良的附着性能。研究结果表明,有机脲类化合物ND作为快速潜伏性环氧树脂固化剂,在环氧粉末涂料中加入4%时,固化温度为180℃,粉料55秒可以完全固化。     

白松木屑半焦与褐煤共气化过程中的协同效应

用环氧树脂E12为基体,配合酚类固化剂及其他助剂,经熔融共混制备出低温固化环氧粉末涂料。考察了固化剂、促进剂用量等对体系固化性能、附着力及耐冲击性的影响,并通过非等温差示扫描量热法及红外光谱研究了酚羟基/环氧体系的固化反应。实验结果表明:随着固化剂用量增加,涂膜耐冲击性能先提高后减小;随着促进剂用量的增加,体系固化温度降低,附着力和耐冲击性提高。固化剂、促进剂最佳用量分别为环氧树脂E-12用量的20%和2.0%。     

水性环氧树脂的研制及其固化性能研究

采用端甲氧基聚乙二醇、马来酸酐、E-44环氧树脂合成了反应型环氧树脂乳化剂MeO-PEG-Ma-E-44,以相反转乳化技术制备E-44水性环氧树脂,研究了工艺条件对其性能的影响。结果表明:酯化率达98.5%的MeO-PEG-Ma-E-44,用量为E-44的ω=16.5%-20%得到的水性环氧树脂乳液最稳定。DSC和TG分析结果表明:乳化前后的E-44环氧树脂都能室温条件2h内很好的固化,固化后热性能基本不变,分解温度约在380℃,热失重率89%,其玻璃转变温度有所降低,韧性有所提高,其它性能基本不受影响。     

含介晶单元的反应性增韧剂改性环氧树脂研究

合成了既含聚乙二醇醚(PEG)柔性链、又含刚性液晶结构单元的活性增韧促进剂(LCEU_PEG),对其促进环氧树脂/双氰双胺体系的固化反应活性、反应机制;增韧剂的用量与动态力学性能、冲击性能之间的关系进行了研究.结果表明:LCEU_PEG对E-51/dicy固化体系具有明显的促进作用,能有效的降低固化反应活化能及固化反应温度;改性体系的冲击强度较单纯的E-51/dicy体系提高3～7倍;模量较未增韧体系有所提高.     

含羧基/环氧树脂的丙烯酸酯共聚物乳液的制备与交联(Ⅳ)——混合乳液的制备及其中温交联

研究了含羧基丙烯酸酯乳液和含环氧树脂乳液的混合和交联反应。实验结果表明,混合乳液具有较高的机械稳定性,在室温下可以稳定贮存5个月以上,证实了在叔胺促进剂作用下,交联固化机理为单酯化反应,混合乳液可在中温(<100℃)下固化,涂膜具有优良的物理性能。     

二氧化碳和丙烯直接合成甲基丙烯酸的NiPMo/TiO2催化剂的研究

用溶胶-凝胶法以磷钼酸(MPA)的镍盐溶液水解钛酸四丁酯制备了NiPMo/TiO2催化剂.使用ICP、 XRD、 TG-DTA、 IR、 TPD-MS和微反应技术研究了催化剂的化学组成、热稳定性、化学吸附性质和催化反应性能.杂多钼酸盐与TiO2通过O2-在TiO2表面发生了键合.在623 K下,杂多阴离子仍保持原有的Keggin结构.CO2在Lewis酸位Ni(Ⅱ)和Lewis碱位Ni-O-Mo的桥氧协同作用下生成CO2卧式吸附态Ni(Ⅱ)←O-(CO)←(O--Ni).丙烯有多种吸附态在催化剂上吸附.在563 K、 1 MPa和空速1500 h-1的反应条件下,丙烯的摩尔转化率为3.2%,产物MAA选择性为95%.     

α-Amino acid derived enaminones and their application in the synthesis of N-protected methyl 5-substituted-4-hydroxypyrrole-3-carboxylates and other heterocycles

A new and simple synthesis of novel N-protected methyl 5-substituted-4-hydroxypyrrole-3-carboxylates, which exist in equilibrium with their 4-oxo tautomers, has been developed in two steps starting from N-protected α-amino acids. The key intermediates are enaminones, which can also be isolated, characterized, and used for the construction of other functionalized heterocycles, before they spontaneously decompose to pyrrole products. 4-Hydroxypyrroles are prone to partial aerial oxidation but can be efficiently alkylated or reduced to stable polysubstituted pyrrolidine derivatives.     

Specific intramolecular aromatic CH insertion of diazosulfonamides

The chemoselectivity in the intramolecular CH insertion of various diazosulfonamides has been experimentally studied. The results reveal that the aliphatic 1,4-, 1,5-, or 1,6-C(sp³)?H insertions of diazosulfonamides are not accessible, while the aromatic 1,5-C(sp²)?H insertion can be realized specifically by adjusting the diazo-adjacent group. In addition, the general chemoselectivities in the intramolecular CH insertions of diazosulfonyl compounds are summarized. Generally, diazosulfones undergo both aromatic 1,5-C(sp²)?H and aliphatic 1,5- and 1,6-C(sp³)?H insertions, while diazosulfonates undergo aliphatic 1,5- and 1,6-C(sp³)?H insertions. However, diazosulfonamides only undergo aromatic 1,5-C(sp²)?H insertion.     

Toward new camptothecins. Part 6: Synthesis of crucial ketones and their use in Friedländer reaction

In the context of the preparation of camptothecin and luotonin A analogs, the synthesis of some key keto-precursors and their use in Friedländer condensation are described. This paper also focuses on the stability of these keto intermediates and emphasizes the major differences between indolizinones and pyrroloquinazolinones series. Noteworthy is also the report of some original structures isolated as by-products of some experiments.     

N-Heterocyclic carbene-palladacyclic complexes: synthesis,characterization and their applications in the C-N coupling and α-arylation of ketones using aryl chlorides

N-Heterocyclic carbene-palladacyclic complexes 3 were successfully achieved in a one-pot procedure under mild conditions. The structure of 3a was unambiguously confirmed by X-ray single crystal diffraction and it was an active catalyst in the Buchwald-Hartwig amination and α-arylation of ketones even at very low catalyst loadings (0.01?mol%).     

Iodine-mediated oxidative Pictet-Spengler reaction using terminal alkyne as the 2-oxoaldehyde surrogate for the synthesis of 1-aroyl-β-carbolines and fused-nitrogen heterocycles

An efficient iodine-mediated oxidative Pictet-Spengler reaction in dimethyl sulphoxide (DMSO) using terminal alkynes as the 2-oxoaldehyde surrogate for the synthesis of aryl (9H-pyrido[3,4-b]indol-1-yl)methanones is described. The scope of the protocol includes the total synthesis of Fascaplysin, Eudistomins Y₁ and Y₂. The methodology is extended for preparing pyrrolo[1,2-a]-quinoxaline and indolo[1,5-a]quinoxaline derivatives. The utility of 1-aroyl-β-carbolines was demonstrated by performing palladium-catalyzed β-carboline directed ortho-C(sp2)-H functionalization of the phenyl ring with thiomethyl (SMe) group using DMSO as source and for accessing 4-aryl-canthin-6-ones.     

Facile synthesis of bicyclic 1-arylpyrazol-5-ones

In this Letter, we described a facile method for constructing fused bicyclic 1-arylpyrazol-5-one ring system. We employed various methylene-containing carboxylic acids as the substrates and proved that the pyrazolone ring closure requires activated methylene group in intermediate II. Accordingly, a series of structurally diversified, fused bicyclic 1-arylpyrazol-5-ones was prepared in moderate to high yields using the requisite substrates.     

CoFe2O4自形成磁性液体场致结构化对磁化的影响

The Langevin paramagnetic theory can’t describe the relation between magnetization of ferrofluids and applied magnetic field. The structuralization of ferrofluids, which is considered the main influence factor of the magnetization, is regarded. The part of magnetization works is deposited when the structure is forming. This action influences the magnetization of ferrofluids directly or indirectly. On the base of the “compressing” model, the Langevin function that usually describes the magnetization of ferrofluid is modified, and a well-fitted curve is obtained. An equation of the relation between the equivalent volume fraction after being “compressed” and the intensity of magnetic field is discovered, which approximately describes the process of magnetization. The relation between the approximate initial susceptibility and the volume fraction can be obtained from modified formula.     

KMnO4-mediated oxidative CN bond cleavage of tertiary amines: Synthesis of amides and sulfonamides

KMnO₄-mediated oxidative CN bond cleavage of tertiary amines producing secondary amine was introduced, which was trapped by electrophiles (acyl chloride and sulfonyl chloride) to form amides and sulfonamides. The reaction could take place at mild condition, tolerating a wide range of function groups and affording products in moderate to excellent yields.     

Chemistry of heterocyclic compounds at the A. E. Favorsky Irkutsk Institute of Chemistry, Siberian Branch of the Russian Academy of Sciences, over 50 years (Review)

The review contains a concise historical account and information on the most significant researches undertaken by the staff at the A. E. Favorsky Irkutsk Institute of Chemistry, Siberian Branch of the Russian Academy of Sciences on the Chemistry of Heterocyclic Compounds. Dedicated to Academician of the Russian Academy of Sciences B. A. Trofimov on his 70th jubilee. Translated from Khimiya Geterotsiklicheskikh Soedinenii, No. 10, pp. 1443–1502, October, 2008.