深亚微米金属氧化物场效应晶体管及寄生双极晶体管的总剂量效应研究

为从工艺角度深入研究航空航天用互补金属氧化物半导体(CMOS)工艺混合信号集成电路总剂量辐射损伤机理, 选取国产CMOS 工艺制作的NMOS晶体管及寄生双极晶体管进行了⁶⁰Coγ射线源下的总剂量试验研究. 发现: 1) CMOS工艺中固有的寄生效应导致NMOS晶体管截止区漏电流对总剂量敏感, 随总剂量累积而增 大; 2) 寄生双极晶体管总剂量损伤与常规双极晶体管不同, 表现为对总剂量不敏感, 分析认为两者辐射损伤的差异来源于制作工艺的不同; 3)寄生双极晶体管与NMOS晶体 管的总剂量损伤没有耦合效应; 4)基于上述研究成果, 初步分析CMOS工艺混合信号集成电路中数字模块及模拟模块辐射损伤机制, 认为MOS晶体管截止漏电流增大是导致数字模块功耗增大的主因, 而Bandgap电压基准源模块对总剂量不敏感源于寄生双极晶体管抗总剂量辐射的能力. 关键词： 总剂量效应 N沟道金属氧化物场效应晶体管 寄生双极晶体管 Bandgap基准电压源     

Estimation of enhanced low dose rate sensitivity mechanisms using temperature switching irradiation on gate-controlled lateral PNP transistor

The mechanisms occurring when the switched temperature technique is applied, as an accelerated enhanced low dose rate sensitivity(ELDRS) test technique, are investigated in terms of a specially designed gate-controlled lateral PNP transistor(GLPNP) that used to extract the interface traps(Nit) and oxide trapped charges(Not). Electrical characteristics in GLPNP transistors induced by ~(60)Co gamma irradiation are measured in situ as a function of total dose, showing that generation of Nit in the oxide is the primary cause of base current variations for the GLPNP. Based on the analysis of the variations of Nit and Not, with switching the temperature, the properties of accelerated protons release and suppressed protons loss play critical roles in determining the increased Nit formation leading to the base current degradation with dose accumulation. Simultaneously the hydrogen cracking mechanisms responsible for additional protons release are related to the neutralization of Not extending enhanced Nit buildup. In this study the switched temperature irradiation has been employed to conservatively estimate the ELDRS of GLPNP, which provides us with a new insight into the test technique for ELDRS.     

An investigation of ionizing radiation damage in different SiGe processes

Different SiGe processes and device designs are the critical influences of ionizing radiation damage. Based on the different ionizing radiation damage in SiGe HBTs fabricated by Huajie and an IBM SiGe process, quantitatively numerical simulation of ionizing radiation damage was carried out to explicate the distribution of radiation-induced charges buildup in KT9041 and IBM SiGe HBTs. The sensitive areas of the EB-spacer and isolation oxide of KT9041 are much larger than those of the IBM SiGe HBT, and the distribution of charge buildup in KT9041 is several orders of magnitude greater than that of the IBM SiGe HBT. The result suggests that the simulations are consistent with the experiment, and indicates that the geometry of the EB-spacer, the area of the Si/SiO_2 interface and the isolation structure could be contributing to the different ionizing radiation damage.     

典型模拟电路低剂量率辐照损伤增强效应的研究与评估

采用变剂量率和变温两种辐照方法,对4款典型模拟电路的低剂量率辐照损伤特性及变化规律进行了研究与评估,分析了两种辐照方法下其辐照敏感参数的变化,比较了不同辐照方式下器件的退化程度,讨论了这两种实验室加速评估低剂量率辐照损伤方法的机理.结果显示,变剂量率辐照可以较快地预测实际低剂量率下的辐照损伤趋势,且在较低的总剂量下能够给出不太保守的估计,但其预测的总剂量受到器件退化速度的影响;变温辐照加速评估方法能够保守地估计其低剂量率下的辐照损伤,其评估范围不仅可达1000 Gy(Si),且可将评估时间缩短为12 h左右.研究结果表明,双极电路的低剂量率辐照损伤增强效应与感生的界面态密度和氢化的氧空位缺陷有关,辐照时剂量率和温度的改变会促进界面态的生长,抑制界面态的钝化作用,从而激发器件的辐照损伤潜能.     

Simulation of Synergism Effect Using Temperature Switching Irradiation on Bipolar Comparator

The synergism effect of total ionizing dose(TID) on a single event transient(SET) in a bipolar comparator is investigated. Experimental results show that the shapes of the SET are considerably influenced by the TID accumulated in low dose rates. The variation tendency of SET shapes can be accurately simulated by temperature switching irradiation. The mechanism of this synergism effect is also analyzed in brief via the operating schematic of a comparator. After the accumulation of 100 krad(Si), the lower tendency of negative SET can be attributed to the degeneration of . The change tendency of a positive SET, either lower or higher, is dependent on the load condition that limits the output range of the comparator.     

电离辐射对部分耗尽绝缘体上硅器件低频噪声特性的影响

本文针对辐射前后部分耗尽结构绝缘体上硅(SOI)器件的电学特性与低频噪声特性开展试验研究. 受辐射诱生埋氧化层固定电荷与界面态的影响, 当辐射总剂量达到1 M rad(Si) (1 rad = 10^-2 Gy)条件下, SOI器件背栅阈值电压从44.72 V 减小至12.88 V、表面电子有效迁移率从473.7 cm²/V·s降低至419.8 cm²/V· s、亚阈斜率从2.47 V/dec增加至3.93 V/dec; 基于辐射前后亚阈斜率及阈值电压的变化, 可提取得到辐射诱生界面态与氧化层固定电荷密度分别为5.33×10¹¹ cm^{- 2}与2.36×10¹² cm^-2. 受辐射在埋氧化层-硅界面处诱生边界陷阱、氧化层固定电荷与界面态的影响, 辐射后埋氧化层-硅界面处电子被陷阱俘获/释放的行为加剧, 造成SOI 器件背栅平带电压噪声功率谱密度由7×10^{- 10} V²·Hz^-1增加至1.8×10^-9 V² ·Hz^-1; 基于载流子数随机涨落模型可提取得到辐射前后SOI器件埋氧化层界面附近缺陷态密度之和约为1.42×10¹⁷ cm^-3·eV^-1和3.66×10¹⁷ cm^-3·eV^-1. 考虑隧穿削弱因子、隧穿距离与时间常数之间关系, 本文计算得到辐射前后埋氧化层内陷阱电荷密度随空间分布的变化.     

栅控横向PNP双极晶体管基极电流峰值展宽效应及电荷分离研究

为了对双极器件在电离辐射环境下的损伤机理及加固技术进行深入的研究,对设计制作的不同工艺类型的栅控横向PNP双极晶体管进行了60Co-γ低剂量率辐照试验.结果表明:1)栅控双极晶体管的辐射特性具有很强的工艺相关性,钝化层的存在对于双极晶体管的辐射响应具有很大影响,有钝化层的器件在电离辐射环境中会产生更多的界面态,其抗辐射能力大大减弱;2)针对国产栅控横向PNP晶体管在低剂量率辐照时会发生峰值电流展宽效应,文中对展宽效应潜在机理进行了分析,并针对展宽效应提出了新的分离方法.这不但对设计抗辐射加固器件提供了依据,而且为进一步深入研究双极器件的低剂量率辐射损伤增强效应提供了强有力工具.     

双极器件ELDRS效应研究进展

电离总剂量是航天电子系统辐射效应研究的重要问题,其中双极器件因其特有的低剂量率损伤增强（Enhanced low Dose Rate Sensitivity,ELDRS）效应,已成为航天用双极器件抗电离总剂量效应发展重点突破的方向及难点问题。本文综述了ELDRS效应及低剂量率加速评估技术的研究进展,并结合ELDRS效应难点问题,给出了最新关于ELDRS效应的研究结果。试验结果表明,采用变温辐照方法不仅可以保守地用于双极器件在0~200 krad （Si）范围的ELDRS效应评估,将评估时间从7.7个月缩短至11 h,还可将其应用于双极模拟电路总剂量和单粒子协同效应的评估,同样可以获得保守且快速的评估效果。