含铜MFI分子筛的H2-TPT和O2-TPD研究

 采用H2－TPR和O2－TPD手段考察了不同金属离子交换的ZSM－5分子筛催化剂上的氢还原性能和氧脱附性能．发现Cu－ZSM－5催化剂的储氧能力及氧脱附性能优于Co－ZSM－5和Fe－ZSM－5催化剂;储氧能力强、低温下氧脱附性能好的催化剂,对NO分解反应的催化活性就高．铜离子是反应的活性中心．添加Ag和Ce可使Cu－ZSM－5催化剂上氧的脱附温度大大降低．Cu－ZSM－5／堇青石整体式催化剂上Cu的存在形式与单纯的Cu－ZSM－5有差异,整体式催化剂上的一价铜数量少,但较稳定．     

Cu-ZSM-5分子筛上[Cu-O-Cu]~(2 )物种的原位红外光谱研究

通过原位监测Cu－ZSM－5分子筛的振动红外光谱随温度及不同处理条件的变化情况，观察到［Cu－O－Cu］2＋物种的形成过程，即两个Cu（OH）＋在脱水过程中经二聚形成［Cu－O－Cu］2＋.低交换度样品开始产生［Cu－O－Cu］2＋物种所需脱水温度较高,通过观察不同处理条件对［Cu－O－Cu］2＋的影响，说明Cu2＋是通过脱出［Cu－O－Cu］2＋中的超晶格氧而被还原为Cu＋,较高温度时［Cu－O－Cu］2＋中的超晶格氧能与气相中的氧达到某种平衡.超晶格氧的脱出性能是影响Cu－ZSM－5分子筛上铜价态变化的重要因素．     

高硅ZSM-5分子筛和二次合成Ti-ZSM-5分子筛的结构

运用度角旋转（MAS）和交叉极化（CP）等核磁共振波谱和红外光谱技术，分别对采用不同模板剂制备的高硅ZSM－5分子筛和以此为母体，经气固同晶取代法得到Ti－ZSM－5分子筛的结构特性进行了研究．结果表明：在水热法合成高硅ZSM-5分子筛过程中，模板剂明显制约着所制得的分子筛的结构特性．通过选用合适的模板剂，可直接获得具有正交晶系结构的高硅ZSM－5分子筛．在随后的气固相同晶取代过程中，钛原子通过占据分子筛骨架中的缺陷位进入骨架，形成具有一定Ti／Si比例的钛硅分子筛（Ti－ZSM－5）。骨架结构中缺陷位的含量直接影响分子筛的载钛量。     

MFI沸石上对二甲苯的热脱附

MFI沸石（ZS－5型）的骨架结构内含十氧元环的二维孔道［‘］，孔容积0．18cm‘·g－‘，硅沸石（Silicallte－1）是骨架中不合铝的ZSM－5．’‘StMASNMR话可揭示沸石的结构对称性、硅铝比和局部缺陷［习．Nagy等人间提出St－OH缺陷在含铅量高时形成．Woolery等门则认为出OH完全是由于骨架内包藏的桂的存在而产生，并随铝合量降低而增大．ZSM－5、硅沸石的结构特征和对二甲苯（Px）的性质决定了Px在ZSM－5上的吸附特性·本文用’‘StMASNLDEL表征硅沸石及不同含铅量的H、Na型ZSM－5的结构，并用＊W＊＊G巾TA分析吸附于…     

环己烯水合制备环己醇的研究 I．分子筛结构及晶粒大小的影响

考察了三种不同结构的分子筛（ZSM－5，MCM－22及-β）以及不同晶粒大小的ZSM－5分子筛对环己烯水合反应的催化活性。结果表明，具有12元环孔道体系的β分子筛对环己烯的转化率（9．6％）最高，但对环己醇的选择性（35．4％）最差。MCM－22分子筛的活性很低，其环己烯转化率只有0．8％。而孔口为10元环结构的ZSM－5分子筛则具有较高的活性环己烯转化率7．5％）和产物选择性（99．2％），因此是较好的水合催化剂。ZSM－5分子筛的晶粒大小对其环己烯水合反应活性有明显的影响，分子筛晶粒越细，则水合反应活性越高，其原因大于晶粒变细增大了分子筛的外比表面积，从而增加了接近孔口处的活性中心的数量。     

ZSM－5（核）／AlPO4－5（壳）双结构分子筛的合成与催化裂化性能

 采用X射线衍射、扫描电镜、X射线能量散射谱、红外光谱和核磁共振等多种物化方法对合成的ZSM－5（核）／AlPO4－5（壳）双结构分子筛进行了表征，证明这种材料具有以ZSM－5为核层、以AlPO4－5为壳层的双结构特征．考察了合成条件对ZSM－5（核）／AlPO4－5（壳）分子筛形貌的影响，发现ZSM－5分子筛的加入方式对产物的形貌有较大影响．重油裂化反应结果表明，ZSM－5（核）／AlPO4－5（壳）双结构分子筛的催化性能比ZSM－5和ZSM－5／AlPO4－5机械混合分子筛样品好，表现为原油转化率和低碳烯烃、汽油及柴油收率提高．     

MMM分子筛的制备与表征

 以碱溶液处理ZSM－5分子筛，得到了含微孔及介孔的MFI结构分子筛（简称MMM），并采用XRD，XRF，SEM，XPS和低温氮吸附等技术对分子筛进行了表征．结果表明，通过改变处理碱的浓度可以得到具有不同物化性能的MMM分子筛，其化学组成、介孔及微孔的大小和多少，及分子筛晶体上n（Al）／n（Si）均随碱浓度的变化而变化，随着碱浓度的增加，分子筛部分微孔结构遭到破坏，介孔的数量增加，孔径增大，n（Al）／n（Si）增大．碱处理脱硅的过程包括脱除晶粒间的无定形物质，脱除分子筛表面的硅及脱除分子筛体相硅等步骤，硅脱除以后形成了介孔．     

铜离子交换分子筛上NO吸附的IR光谱及TPD研究

采用原位IR光谱及TPD技术研究了NO在铜离子交换分子筛上各种表面物种的生成及脱附,并与NO在Cu-ZSM-5上的分解反应性能相关联,考察了Cu-ZSM-5反应活性高的原因及O₂的生成机理。NO的吸附状态随分子筛母体种类及铜离子交换度的不同而变化,交换度较高的ZSM-5催化剂上容易形成NO-3物种,该物种对NO分解及O₂的生成具有重要作用。     

不同硅铝比的Cu-ZSM-5/堇青石整体式催化剂的NO分解反应性能

 考察了原位合成的不同硅铝比的Cu－ZSM－5／堇青石整体式催化剂上的NO分解反应．结果表明,在573～773K的温度范围内,硅铝比分别为60,55和40的催化剂在723K下NO的转化率最高,而硅铝比小于25的催化剂上的NO转化率很低．低温有利于N2O的生成．整体式催化剂上的NO转化率低于单纯的分子筛催化剂Cu－ZSM－5,但其催化转换频率高于后者．     

N2和Ar在改性的NaA分子筛上的吸附分离

采用水溶液离子交换法分别制备了不同Li^ 和Ca^2^ 交换度的A型分子筛，并在25℃下测定了各分子筛吸附剂的氮和氩的吸附等温线及穿透曲线．研究发现，锂交换和钙交换的两种分子筛的氮吸附量和氮氩分离选择性都随分子筛中阳离子交换度的增加而增大；在阳离子交换度较高时，锂离子和钙离子交换的A型分子筛的氮氩分离能力均优于NaA分子筛．穿透曲线的结果显示，所研究的各种吸附剂都存在一个最优的吸附分离压力，大约在0．6MPa．在0．6MPaT，接近100％阳离子交换度的CaNaA分子筛的动态氮氩分离性能优于相同交换度的LiNaA分子筛。     

Critical assessment of electron spin resonance studies on Cu(I)-NO complexes in Cu-ZSM-5 zeolites prepared by solid- and liquid-state ion exchange

Cu(I)-NO adsorption complexes were formed over Cu-ZSM-5 zeolites prepared by (i) solid-state ion exchange of NH(4)-ZSM-5 with CuCl and (ii) liquid-state ion exchange of ZSM-5 with Cu(CH(3)COO)(2). Electron spin resonance spectroscopy revealed the formation of two different Cu(I)-NO species A and B in both systems, whose spin Hamiltonian parameters are comparable with those already reported for the Cu(I)-NO species formed over 66% Cu(II) liquid-state ion-exchanged Cu-ZSM-5 materials. The population of the species A and B differs for the two systems studied. Formation of species B is more favored in the solid-state ion-exchanged Cu-ZSM-5 when compared to the liquid-state exchanged zeolite. The X-, Q- and W-band electron spin resonance spectra recorded at 6 and 77 K reveal the presence of a rigid geometry of the adsorption complexes at 6 K and a dynamic complex structure at higher temperatures such as 77 K. This is indicated by the change in the spin Hamiltonian parameters of the formed Cu(I)-NO species in both the liquid- and solid-state ion-exchanged Cu-ZSM-5 zeolites from 6 to 77 K. Possible models for the motional effects found at elevated temperatures are discussed. The temperature dependence of the electron spin phase memory time measured by two-pulse electron spin-echo experiments indicates, likewise, the onset of a motional process of the adsorbed NO molecules at temperatures above 10 K. The studies support previous assignments where the NO complexes are formed at two different Cu(I) cationic sites in the ZSM-5 framework and highlight that multifrequency electron spin resonance experiments at low temperatures are essential for reliable determination of the spin Hamiltonian parameters of the formed adsorption complexes for further comparison with Cu(I)-NO complex structures predicted by quantum chemical calculations.     

On the nature of gallium species in gallium-modified mordenite and MFI zeolites. A comparative DRIFT study of carbon monoxide adsorption and hydrogen dissociation

The results of a DRIFT study of carbon monoxide molecular adsorption and hydrogen dissociative adsorption on gallium-modified mordenite and MFI (ZSM-5) zeolites are presented. It was found that in the reduced gallium-modified mordenite (Ga-MOR) both Ga(3+) and Ga(+) exchanged cations are present and can be detected by CO adsorption. Ga(3+) cations in Ga-MOR dissociatively adsorb molecular hydrogen at elevated temperatures, resulting in the formation of gallium hydride species and acidic hydroxyl groups. In the reduced Ga-MFI evacuated at 823 K under medium vacuum conditions only Ga(+) exchanged intrazeolite cations were detected. It was found, however, that Ga(3+) intrazeolite exchanged cations which form upon high-temperature disproportionation of Ga(+) cations in the reduced Ga-MFI and Ga-MOR can be stabilized by high-temperature oxidation of these zeolites.     

不同分子筛的氮氩分离性能

采用水溶液离子交换法制备了不同离子交换的13X和4A分子筛,并在25℃下测 定了它们的静态吸附等温线和动态穿透曲线。研究发现,Ca~(2+)离子和Li~+离子 交换的13X和4A分子筛对氮的吸附性能都明显优于其相应的钠型分子筛,而它们对 氩的吸附量变化不大,说明这两种离子交换的分子筛是较好的氮氩分离吸附剂。从 动态吸附的结果来看,所研究的各种分子筛都有一个最优的吸附分离压力,在本论 文研究的压力范围内,这个最优压力在0.6MPa附近。通过穿透曲线推算出的混合气 体吸附量和纯气体吸附量的对比可以得出,对于氮氩吸附选择性较高的分子筛,氮 的存在对氩的吸附量有较大的影响。     

Ca2＋交换的几种分子筛的氮氩分离性能

采用水溶液离子交换法制备了Ca2＋交换的4A、13X和LSX分子筛，并在25 ℃下测定了它们的静态吸附等温线和动态穿透曲线.研究发现， Ca2＋交换的4A、13X和LSX分子筛对氮的吸附性能都明显优于其相应的钠型分子筛，而它们对氩的吸附量变化不大，说明Ca2＋交换的这三种分子筛是较好的氮氩分离吸附剂.从动态吸附的结果来看，所研究的各种分子筛都有一个最优的吸附分离压力，在本论文研究的压力范围内，这个最优压力在0.6 MPa附近.由穿透曲线可推算出混合气体的吸附量，通过氮和氩在混合气体中的吸附量和相应纯气体吸附量的对比可以得出，对于氮氩吸附选择性较高的分子筛，氮的存在对氩的吸附量有较大的影响.     

Adsorption Characteristics of Ion-Exchanged ZSM-5 Zeolites for CO(2)/N(2) Mixtures

Adsorption characteristics of alkali metal ion-exchanged ZSM-5 zeolites, M-ZSM-5 (M=Li, Na, K, Rb, and Cs), for CO(2)/N(2) mixtures were investigated by a column method and IR study. It was shown that CO(2) was adsorbed from CO(2)/N(2) mixtures on M-ZSM-5 zeolites by two types of adsorbtion at temperatures below 333 K. One was a weak adsorption due to interaction with the wall of ZSM-5, and the other was a strong adsorption caused by interactions with the cation of ZSM-5. IR-spectra of gases adsorbed at various temperatures revealed that the CO(2) were strongly adsorbed on M-ZSM-5 in several ways, which seemed to be caused by different adsorption sites. At temperatures above 373 K, almost all CO(2) adsorbed were on cation sites, while N(2) coadsorbed with CO(2) was shown to interact with the wall of ZSM-5 under all experimental conditions. Copyright 2000 Academic Press.     

Li＋交换的几种分子筛的氮氩分离性能

采用水溶液离子交换法制备了高Li＋交换度的4A、13X和LSX分子筛,并在25 ℃下测定了它们的静态吸附等温线和动态穿透曲线.研究发现,高Li＋离子交换度的4A、13X和LSX分子筛都具有较大的氮吸附容量和较高的氮氩分离选择性,说明高Li＋离子交换度的4A、13X和LSX分子筛是较好的氮氩分离吸附剂.从动态穿透曲线结果来看,所研究的三种分子筛都有一个最优的吸附分离压力,在本文研究的压力范围内,这个最优压力在0.6 MPa附近.对比高锂交换度的三种分子筛,以高锂交换度的LSX分子筛的氮氩吸附分离性能最好.     

Comparative study of the deactivation of Cr-BEA, Cr-MOR and Cr-ZSM-5 in catalytic decomposition of VOC

The catalytic activity and stability studies of chromium exchanged beta, mordenite and ZSM-5 zeolites for VOCs decomposition are reported. Difference in deactivation behavior by the zeolites was observed. Cr-ZSM-5 (Si/Al=240) was the most stable catalyst due to its high Si/Al ratio. It also has less coking tendency due to its uniform sized intersecting channel system. This revised version was published online in June 2006 with corrections to the Cover Date.     

Enthalpy–entropy compensation for n-hexane adsorption on HZSM-5 containing transition metal ions

In this work, the values of entropy changes related to n-hexane adsorption onto ion-exchanged ZSM-5 zeolites were calculated from differential heats, obtained from microcalorimetric experiments. The existence of enthalpy–entropy compensation effect, evidenced by the linearity of −ΔH vs. −ΔS plots and characteristic for all investigated ZSM-5 zeolites, was found. In the case of ZSM-5 structure, modifying the zeolite structure by ion-exchange gives rise to changes in the heats of adsorption and adsorption entropy in the same manner. The factors that can influence the appearance of entropy–enthalpy compensation were discussed. It was found that compensation effect is governed by ion-induced dipole interaction between highly polarising cationic centres in zeolite and nonopolar n-hexane molecules, and hence, depends on the size, charge and electron configuration of the cation. It was found also that the compensation temperature is in correlation with the number of zeolites’ strong acid centres. Contrary to the adsorption of n-hexane on ZSM-5 zeolites, compensation effect was not found for the adsorption of the same gas on faujasite-type zeolites.     

Selective Catalytic Reduction of Nitric Oxide by Ammonia over Ag and Zn‐Exchanged Cuban Natural Zeolites

The catalytic selective reduction of NO over metal‐exchanged (Zn^II, Ag^I) natural zeolites (mordenite and clinoptilolite) from Cuba using NH₃ as a reducing agent in the presence of excess oxygen was studied. Both transition metals slightly improve the catalytic performance for the NO reduction. Zn^II‐exchanged zeolites exhibit a moderate catalytic activity, with conversions of NO of ≈58 % and high selectivity to N₂ at high temperatures.     

FTIR Studies on NO Adsorption on [Co+Mg(Sr)]/ZSM-5

IntroductionThe FTIR spectroscopy of NO adsorption on[Co +Mg(Sr) ]/ZSM- 5 has not been fullyelucidated yet.Previous researchers working onNO adsorption over Co/ZSM- 5 stated that thebands at 1 81 0 and 1 890 cm-1are due to dinitrosylspecies adsorbed on Co2 +[1] ,while the band at193 5 cm-1is attributable to mononitrosyl species.Aband near1 85 8cm-1(w) may be attributable tothe species of Co3O4 —NO[2 ] .Further,Zhu etal.[2 ]reported the bands at1 81 3 ,1 896 and1 93 9cm-1assigned to …