丹参酚酸B生产中去除胶体类杂质的工艺方法

胶体类杂质的去除是丹参酚酸B(salvianolic acid B, SB)纯化工艺的难点之一。实验中基于前沿色谱与置换色谱相结合的原则,改良常规大孔吸附树脂柱的操作方法,将树脂按一定的比例装入大小两支柱。小柱与大柱串联,上样至胶体类杂质在小柱上达到吸附饱和,用50%甲醇单独洗脱大柱上的SB部分,利用树脂吸附色谱法实现了SB与胶体类杂质的分离。结果表明,经过去胶体类杂质处理后,SB的加权平均纯度由59.6%提高到64.5%,收率由69.75%提高到80.0%,并且SB的洗脱条件降低。本工艺方法适合于规模化工业生产。     

Improved quality evaluation of Radix Salvia miltiorrhiza through simultaneous quantification of seven major active components by high-performance liquid chromatography and principal component analysis

A novel method, using high-performance liquid chromatography combined with principal component analysis, was developed for the quality evaluation of danshen through simultaneous determination of seven components, namely danshensu, protocatechuic acid, protocatechuic aldehyde, salvianolic acid B, tanshinone I, cryptotanshinone and tanshinone IIA. These seven components were simultaneously separated on a Zorbax SB-C(18) column. The mobile phase consisted of 0.05% phosphoric acid water and methanol:acetonitrile (1:1) with a gradient elution, and the detection wavelength was set at 280 nm. Thirty samples of danshen and its substitutes from different sources were investigated by the established method. The results showed that the content of each analyte varied considerably in different danshen samples. Among the seven components tested, salvianolic acid B, tanshinone IIA, cryptotanshinone, tanshinone I, danshensu and protocatechuic aldehyde were proved suitable and representative as chemical markers for the quality control of danshen except for protocatechuic acid. Moreover, principal component analysis was used for the similarity evaluation of different samples, and it could be straightforward and reliable to differentiate danshen samples of different origins. In conclusion, simultaneous quantification of multiple components by high-performance liquid chromatography combined with principal component analysis would be a better strategy for the quality evaluation of danshen.     

Separation and identification of water-soluble salvianolic acids from Salvia miltiorrhiza Bunge by high-speed counter-current chromatography and ESI-MS analysis

High-speed counter-current chromatography (HSCCC) technique in semi-preparative scale has been applied to separate and purify salvianolic acids from the water extract of Danshen, Salvia miltiorrhiza Bunge. High efficiency HSCCC separation was achieved on a two-phase solvent system composed of a mixture of n-hexane-ethyl acetate-water-methanol (1.5:5:5:1.5, v/v) by eluting the lower mobile phase at a flow-rate of 1.7 ml/min and a revolution of 850 rpm. A total of five well separated peaks were obtained in the HSCCC chromatogram, and their purities determined by HPLC-UV absorption. These peaks were characterized by UV-vis spectra and ESI-MS, and the data compared with the reference standards. Salvianolic acid B was positively identified as one of the major peaks. Three of the remaining four peaks were also tentatively identified as rosmarinic acid, lithospermic acid, and salvianolic acid E, an isomer of salvianolic acid B, all are members of the salvianolic acids group. In a typical run, tens of milligrams of samples can be separated with high efficiency to yield tens of milligrams of purified materials with over 98% purity. HSCCC thus provides a cost-effective alternative to preparative scale HPLC for the semi-preparative scale separation and purification of salvianolic acids in Danshen. With appropriate modifications, the technique should also be applicable to other herbs in general.     

Simultaneous determination and pharmacokinetic study of water-soluble and lipid-soluble components of danshen in rat plasma using HPLC-UV method

A sensitive and specific HPLC-UV method was developed for the simultaneous determination of major active components of danshen in rat plasma. Both water-soluble and lipid-soluble compounds were included, i.e. danshensu, salvianolic acid B and tanshinone IIA. Protocatechuic aldehyde and diazepam were used as internal standards. The chromatographic separation was achieved on a reversed-phase C(18) column by gradient elution using acetonitrile and 0.025% (v/v) phosphoric acid solution as mobile phase, at a flow rate of 1.0 mL/min. Salvianolic acid B, danshensu and internal standards were detected at 281 nm, while the detection of tanshinone IIA was carried out at 272 nm. All calibration curves showed good linearity (r(2) > 0.999) within test ranges. The limit of detection and the limit of quantification for danshensu, salvianolic acid B and tanshinone IIA in plasma were 0.065, 0.043, 0.022, 0.131, 0.085 and 0.044 microg/mL, respectively. This is the first report on the determination and pharmacokinetic study of danshensu, salvianolic acid B and tanshinone IIA in rat plasma and the results indicated that this method was reliable for the determination of the major active components of danshen in rat plasma.     

Rapid and high-throughput purification of salvianolic acid B from Salvia miltiorrhiza Bunge by high-performance counter-current chromatography

A large-scale purification of salvianolic acid B from Salvia miltiorrhiza Bunge is presented. The method development began with selection of the solvent system, then optimization of the operating parameters and ended up with linear scale-up from an analytical to a preparative instrument. Three factors were used for method optimization and scale-up estimation: purity, process throughput and process efficiency. Preparation was achieved using a two-phase solvent system comprising hexane–ethyl acetate–methanol–acetic acid–water (1:5:1.5:0.00596:5, v/v). This preparation yielded 475 mg of salvianolic acid B with a purity of 96.1% from 1.5 g of crude extract. The process throughput of crude was 2.23 g/h while process efficiency per gram of target compound was 0.769 g/h. Two factors—process environmental risk factor and process evaluation factor were used for evaluation of the separation process.     

高效液相色谱二极管阵列检测法同时测定丹参滴注液中四种水溶性成分的含量

建立了高效液相色谱二极管阵列检测(HPLC-DAD)法同时测定丹参滴注液中丹参素、原儿茶醛、迷迭香酸和丹酚酸B四种水溶性成分的含量。采用DiamonsilTMC18色谱柱(250×4.6 mm,5μm),以甲醇和5%冰乙酸为流动相进行梯度洗脱,流速为1.0mL/min,柱温30℃,检测波长为286 nm。在此色谱条件下四种水溶性成分可完全分离。丹参素、原儿茶醛、迷迭香酸和丹酚酸B的线性范围分别为0.2192~1.934μg(r=0.9999),0.03508~0.2456μg(r=1.0000),0.2592~1.814μg(r=1.0000),0.3864~2.705μg(r=0.9999)。平均回收率丹参素为102.6%,相对标准偏差(RSD)为0.55%;原儿茶醛为103.5%,RSD为0.42%;迷迭香酸为99.8%,RSD为0.68%;丹酚酸B为102.8%,RSD为0.49%。该方法简单、快速,四组分分离良好,可用于丹参滴注液的质量控制。     

One-step purification of 3,4-dihydroxyphenyllactic acid, salvianolic acid B, and protocatechualdehyde from Salvia miltiorrhiza Bunge by isocratic stepwise hydrogen bond adsorption chromatography on cross-linked 12% agarose

Three major active components of the traditional Chinese medicinal herb Salvia miltiorrhiza Bunge, 3,4-dihydroxyphenyllactic acid, salvianolic acid B, and protocatechualdehyde, are separated and purified from a crude water extract in one step by isocratic hydrogen bond adsorption chromatography on cross-linked 12% agarose (Superose 12 HR 10/30). Separation is achieved by stepwise elution with mobile phases composed of mixtures of ethanol and acetic acid: 0-50 mL, 5% ethanol, 5% acetic acid; 50-100 mL, 20% ethanol, 20% acetic acid; and 100-200 mL, 30% ethanol, 30% acetic acid. The 3,4-dihydroxyphenyllactic acid is obtained with a purity of 97.3% and with a recovery of 88.1%. The corresponding figures for protocatechualdehyde are a purity of 99.4% with a recovery of 90.7%, and for salvianolic acid B a purity of 90.4% with a recovery of 50.3%, respectively. At a sample load of 40 mg crude extract dissolved in 0.5 mL mobile phase (corresponding to a load of 1.6 mg/mL gel), a 3,4-dihydroxyphenyllactic acid purity of approximately 94% with a recovery of 80.2% is obtained.     

The rapid assembling of oligosaccharides by the developed HASP strategy

A nona-mannoside has been assembled rapidly by using a new hydrophobic carrier based on the hydrophobically assisted switching phase strategy.     

One-step separation and purification of 3,4-dihydroxyphenyllactic acid, salvianolic acid B and protocatechualdehyde from Salvia miltiorrhiza Bunge by high-speed counter-current chromatography

Three kinds of polyphenols of Salvia miltiorrhiza Bunge, 3,4-dihydroxyphenyllactic acid, salvianolic acid B and protocatechualdehyde, were separated and purified in one step with solvent system n-hexane-ethyl acetate-methanol-acetic acid-water (1:6:1.5:1.5:8) by high-speed counter-current chromatography. Acetic acid was successfully used to increase the partition of high polar target compounds in organic phase to modify partition coefficient value. 3,4-Dihydroxyphenyllactic acid, salvianolic acid B and protocatechualdehyde were purified from 100mg water extracted crude sample of Salvia miltiorrhiza Bunge at purity of 97.6%, 94.2% and 98.2% and at yield of 98.6%, 73.6% and 90.2%. High-speed counter-current chromatography together with organic/aqueous solvent system supplied an efficient method to purify water-soluble compounds directly from crude samples of traditional Chinese medicines.     

Determination of methanol in o,o-dimethyldithiophosphoric acid (DMDTPA) of technical grade by UV/vis spectrophotometry and by HPLC

Two procedures are proposed in this work for the determination of methanol impurities in o,o-dimethyldithiophosphoric acid (DMDTPA). To avoid possible interferences from the main component, DMDTPA was precipitated in the form of insoluble lead complex. Free Pb(II) ions were eliminated with sulfuric acid and methanol was oxidized to formaldehyde with potassium permanganate in methanesulfonic acid medium. Finally, the excess of oxidizing agent was neutralized with saturated sodium oxalate. The above pretreatment procedure was identical for spectrophotometric assay and for chromatographic determination. In the first case, the solution obtained was treated with Nash reagent to form 3,5-diacetyl-1,4-dihydrolutidine (λ_max = 415 nm). In the calibration range 0.1-1.0% (methanol in DMDTPA), the analytical figures of merit were: R² = 0.9993, quantification limit 0.02% methanol in DMDTPA coefficient of variance (n = 5) for 0.1% and 0.4% methanol respectively 6.7% and 2.4%. Recoveries obtained in the sample fortified with 0.1, 0.2, 0.4% of methanol (in DMDTPA) were in the range 99-105%. For chromatographic procedure, formaldehyde was derivatized with 2,4-dinitrophenylhydrazine and separation was achieved on Luna C18(2) column using the isocratic elution with acetonitrile-water (70:30, v/v) and spectrophotometric detection at 360 nm. In the calibration range 0.05-0.25% (methanol in DMDTPA), R² was always higher than 0.999, the quantification limit was 0.004% and the recoveries in these same fortified samples in the range 98-101%. No statistically significant differences were observed between the results obtained in the analysis of technical grade DMDTPA by the two procedures (ANOVA, p < 0.05)     

Preparative isolation and purification of salvianolic acid B from the Chinese medicinal plant Salvia miltiorrhiza by high-speed counter-current chromatography

High-speed counter-current chromatography was applied to the isolation and purification of salvianolic acid B from the Chinese medicinal plant Salvia miltiorrhiza Bunge. The crude salvianolic acid B was obtained by extraction with ethanol-water from S. miltiorrhiza Bunge. Preparative high-speed counter-current chromatography with a two-phase solvent system composed of n-hexane-ethyl acetate-ethanol-water (3:7:1:9, v/v) was successfully performed yielding 342 mg salvianolic acid B at 98% purity from 500 mg of the crude extract in a one-step separation.     

高效液相色谱中用于梯度洗脱的有机溶剂的纯度测试

在反相高效液相色谱中,空白梯度基线的漂移和杂质峰,可能由含水溶剂和有机溶剂中杂质所引起的。当含水溶剂通过预柱在线净化后,根据空白梯度色谱图可测试有机溶剂的纯度。按照此法,对国产不同等级的乙腈和甲醇进行了测试,指明这些试剂用于梯度洗脱的可能性。     

Use of expanded bed adsorption to purify flavonoids from Ginkgo biloba L.

Three techniques (liquid–liquid extraction, packed bed adsorption and expanded bed adsorption) have been compared for the purification of flavonoids from the leaves of Ginkgo biloba L. A crude Ginkgo extract was obtained by refluxing with ethanol for 3 h. The yield of flavonoids achieved by this crude extraction was about 19% (w/w) and the purity of flavonoids in the concentrated extract was between 1.9 and 2.3% (w/w). The crude extract was then dissolved in deionized water and centrifuged where necessary to prepare clarified feedstock for further purification. For the method using liquid–liquid extraction with ethyl acetate, the purity, concentration ratio and yield of flavonoids were 25.4–31.0%, 16–18 and >98%, respectively. For the method using packed bed adsorption, Amberlite XAD7HP was selected as the adsorbent and clarified extract was used as the feedstock. The dynamic adsorption breakthrough curves and elution profiles were measured. For a feedstock containing flavonoids at a concentration of 0.25 mg/mL, the appropriate loading volume to reach a 5% breakthrough point during the adsorption stage was estimated to be 550–600 mL for a packed bed of volume 53 mL and a flow rate of 183 cm/h. The results from the elution stage indicated that the majority of impurities were eluted by ethanol concentrations of 40% (v/v) or below and efficient separation of flavonoids from the impurities could be achieved by elution of the flavonoids with 50–80% ethanol reaching an average purity of ∼25%. The recovery yield of flavonoids using the packed bed purification method was about 60% of the flavonoids present in the clarified feedstock (corresponding to around 30% for the total flavonoids in the unclarified crude extract). For the method using expanded bed adsorption also conducted with Amberlite XAD7HP as the adsorbent, the optimal operation conditions scouted during the packed bed experiments were used but unclarified crude extract could be loaded directly into the column. For an expanded bed with a settled bed height of 30 cm, the loss of flavonoids in the column flow-through was about 30%. The two-step elution protocol again proved to be effective in separating the adsorbed impurities and flavonoids. More than 96% of the bound impurities were completely removed by 40% ethanol in the first elution stage and less than 4% remained in the final product eluted by 90% ethanol in the second elution stage. Also, ∼74% of the adsorbed flavonoids on column (corresponding to 51% of the total flavonoids in the unclarified feedstock) were recovered in the product. In addition to higher recovery yield, the average process time to obtain the same amount of product was decreased in the expanded bed adsorption (EBA) process. The results suggest that the adoption of EBA procedures can greatly simplify the process flow sheet and in addition reduce the cost and time to purify flavonoids from Ginkgo biloba. These results clearly demonstrate the potential for the use of EBA to purify pharmaceuticals from plant sources.     

Purification of folic acid candidate reference material by preparative high-performance liquid chromatography

An effective process for the purification of folic acid candidate reference material with preparative high-performance liquid chromatography (Pre-HPLC) was developed in this study. During the process of experimental operation, parameters including the influences of mobile phase, flow rate, and injection volume on the purity and yield were investigated, and the optimized conditions were as follows: the mobile phase was acetonitrile and water in a gradient mode with flow rate of 16?mL/min and injection volume of 2.0?mL at concentration of 10?mg/mL. Under the conditions, the purity and yield of folic acid product were up to 99.4% and 21.0%, respectively, whereas the purity of folic acid raw material was 95.2%. The purified folic acid product was characterized by LC–MS, HPLC, Karl Fischer coulometer, and quantitative nuclear magnetic resonance (qNMR). Results proved that the main component of the product was folic acid and the purities determined by HPLC and qNMR were consistent. Two impurities including N-(4-aminobenzoyl)-L-glutamic acid and pteroic acid were further quantified by LC–MS. Compared with the recrystallization approach, the purity of folic acid obtained by Pre-HPLC increased from 98.2% to 99.4%.     

Large-scale separation of salvianolic acid B from the Chinese medicinal plant Salvia miltiorrhiza by pH-zone-refining countercurrent chromatography

pH-Zone-refining countercurrent chromatography was successfully applied to the separation of salvianolic acid B from the Chinese medicinal plant, Salvia miltiorrhiza Bunge, using a multilayer coil planet centrifuge. A 2.0 g quantity of sample was separated using the following two-phase solvent system: methyl tert-butyl ether (MtBE)-water, 10 mM TFA in organic stationary phase and 10 mM ammonia in aqueous mobile phase. The obtained fractions were analyzed by HPLC and ESI-MS. The separation yielded 572 mg of the main component of salvianolic acid B with a purity of 94.1%.     

大孔吸附树脂对熊果酸吸附性能的研究

研究了从山楂叶中纯化熊果酸的柱层析工艺。静态吸附结果表明,X-5、NKA和AB-8树脂的吸附率分别为91.32%,72.28%和41.19%;以90%乙醇为洗脱剂,X-5、NKA和AB-8树脂的洗脱率分别为83%,70%,87%。静态实验表明X-5树脂具有较好的吸附解吸性能。动态实验优化了在X-5树脂中的流速、上样液的熊果酸浓度和上样体积。结果表明,流速为3BV/h(BV为倍量体积),上样液的熊果酸浓度为0.304mg/mL,上样体积为3BV为最优上样条件。动态洗脱中采用梯度洗脱方式,结果表明在90%的乙醇洗脱下,熊果酸纯度达93.21%。对层析工艺制备的熊果酸进行结晶处理,所获得的熊果酸纯度为98.61%,与熊果酸标准品的红外光谱一致。     

Purification of salvianolic acid B from the crude extract of Salvia miltiorrhiza with hydrophilic organic/salt-containing aqueous two-phase system by counter-current chromatography

Establishment of hydrophilic organic/salt-containing aqueous two-phase system and purification of salvianolic acid B from crude extract of S. miltiorrhiza by counter-current chromatography with said system were studied. Ethanol and n-propanol were selected to constitute biphasic systems with ammonia sulphate, sodium chloride and phosphate separately, and related system characteristics including phase diagrams, phase ratio, separation time were tested. The partition coefficient of crude salvianolic acid B was also tested in above systems and further finely adjusted by altering the constitution of phosphate in n-propanol/phosphate system. Salvianolic acid B was purified to 95.5% purity by counter-current chromatography in 36% (w/w) n-propanol/8% (w/w) phosphate system with the ratio between dipotassium hydrogen phosphate and sodium dihydrogen phosphate of 94:6. One hundred and eight milligrams of salvianolic acid B was purified from 285 mg crude extract with the recovery of 89%.     

Efficient synthesis of trisubstituted alkenes in an aqueous-organic system using a versatile and recyclable Rh/m-TPPTC catalyst

We have found that the use of [Rh(cod)OH]₂ associated with the water-soluble ligand m-TPPTC was highly efficient for the Rh-catalyzed arylation of alkynes. Aryl and alkyl alkynes were transformed to alkenes using 3 mol % rhodium catalyst and 2.5 equiv of boronic acid at 100 °C in a biphasic water/toluene system in 80-99% yield. The reaction was found to be totally regioselective for alkyl arylalkynes and alkyl silylated alkynes. The Rh/m-TPPTC system was for the first time recycled with no loss of the activity and with excellent purity of the desired alkene.     

Biotransformation of salvianolic acid B by Fusarium oxysporum f. sp. Cucumerinum and its two degradation routes

Resting cells of Fusarium oxysporum f. sp. Cucumerinum (F. oxsporum) were used for the biotransformation of salvianolic acid B (Sal B). Three transformed products, isolithospermic acid, prolithospermic acid and danshensu, were identified on the basis of chemical and spectroscopic data. The stability of the two ester bonds of Sal B was studied and two degradation routes were found. In the biotransformation system, Sal B was transformed into isolithospermic acid first which was then converted into prolithospermic acid. In alkaline solutions, Sal B was transformed into lithospermic acid first which was then converted into prolithospermic acid. This is the first reports of the NMR spectra of isolithospermic acid and this result may indicate the metabolic pathways of Sal B in vivo.     

Preparative isolation of terpene trilactones from Ginkgo biloba leaves

This study investigated and compared some techniques for the preparative isolation of terpene trilactones, including ginkgolides (GA and GB, etc.) and bilobalide (BB), from Ginkgo biloba leaves. The crude Ginkgo biloba L. extracts (GBE) were prepared using an extractor with solvent refluxing operated under an optimal extraction condition. The extraction yield was 20-23% and the purity of terpene trilactones was about 1.0-1.4 wt%. Before the isolation operations, the extracts were dissolved in de-ionized water. The isolation procedures included the method of liquid-liquid extraction and the method of column chromatography. For the method of liquid-liquid extraction using ethyl acetate as the organic solvent operated under the optimal extraction conditions, the purity, concentration ratio, and yield of terpene trilactones were 13.5-18.0%, 15-16, and >99%. For the method of column chromatography, XAD-7HP, XAD-4, and C-18 adsorbents with different polarities were used as the packing materials. Only for the XAD-7HP column, a part of more polar impurities was efficiently separated with the majority of terpene trilactones by a proper step-gradient elution, which resulted in an efficient isolation: the purity, concentration ratio, and yield of terpene trilactones were approximately 20, approximately 15, and approximately 80%. In comparison, the XAD-7HP column achieved the highest purity, but at the expense of the yield of terpene trilactones; on the contrary, the liquid-liquid extraction method, achieving the highest yield but with a slightly lower purity, was proved to be superior to the method of column chromatography in the current isolation stage.