Adsorption behavior of organic halides on zeolites

The adsorption behavior and the differential heat of adsorption of chloroform were measured on various types of zeolite (faujasite, ZSM-5 and mordenite) with different Si/Al ratios. The results reveal that saturated adsorption is almost proportional to the micropore volume and is independent of the micropore structure or the Si/Al ratio. However, initial heat of adsorption was the highest (90 kJ mol⁻¹) on the mordenite with low Si/Al ratio, while low on the faujasite with high Si/Al ratio or ZSM-5 (50 kJ mol⁻¹). Change in initial heat of adsorption with Si/Al ratio is small for faujasite or mordenite and large for ZSM-5. For the comparison, trichloroethylene adsorption behavior of zeolite was also investigated. Saturated adsorption of trichloroethylene was almost constant for all types of zeolite, while the faujasite with high Si/Al ratio exhibited an adsorption isotherm of type V in BDDT (Brunauer, Deming, Deming and Teller) classification. The tendencies of heat of immersion are similar to the results of the initial heat of adsorption.     

化学液相沉积法改性HY沸石及其对萘与叔丁醇择形烷基化反应的催化性能

采用化学液相沉积法,经异丁基三乙氧基硅烷修饰并用高温水蒸气处理得到了改性HY沸石.采用X射线衍射、低温N2吸附和脉冲式质量分析技术研究了改性样品骨架结构、比表面积、孔结构参数和吸附性质的变化,并考察了HY沸石及其改性后样品对萘与叔丁醇烷基化制备2,6-二叔丁基萘(2,6-DTBN)反应的催化性能.结果表明,改性后HY沸石的骨架结构基本不变,但比表面积增大,平均孔径缩小,孔口尺寸得到了一定调变.在改性后HY沸石催化剂上萘与叔丁醇烷基化反应活性下降,但催化剂择形性能明显提高,其2,6-DTBN/2,7-DTBN比可以达到6.62。     

脱铝八面沸石的催化行为——非晶格铝的影响

经水热处理和SiCl4处理得到了两个系列的脱铝Y沸石USY（W）和USY（T）。经X射线衍射分析、化学分析和ESCA研究确定USY（W）中包含有非晶格铝，通过TPD、IR研究发现，沸石中非晶格铝屏蔽了沸石中的强酸中心，同时产生部分弱酸中心，经异丙苯裂化反应和DTA实验发现非晶格铝的存在虽使反应活性降低，但却提高了抗积碳能力。     

Adsorption of normal and branched paraffins in faujasite zeolites NaY, HY, Pt/NaY and USY

The effect of chain length and branching of paraffins (from C6 to C12) on adsorption and diffusion in zeolites NaY, Pt/NaY, HY and USY has been investigated using the chromatographic method at 275–400°C. The Henry constants of the paraffins increase exponentially with the chain length (with a factor two per extra carbon group), the heats of adsorption increase with circa 7 kJ/mol per extra carbon group. Multicomponent sorption experiments reveal that longer chains are adsorbed preferentially over shorter chains, even at higher loadings. The multicomponent adsorption can be reasonably well described by an extended Langmuir adsorption isotherm, in which the stronger adsorption of the longer chains is reflected by their higher Henry constants. The molecular shape and zeolite type within this FAU group has only a small influence on the adsorption properties. Mass transfer in the pellets as used in catalytic conditions seems to be limited by macropore diffusion, rather than by micropore diffusion, which cannot be measured with the chromatographic method. Increasing the Si/Al-ratio of the zeolite reduces the adsorption capacity, but does not influence the relative adsorption properties.     

^29Si,^27AIMASNMR研究不同脱铝深度稀土 超稳Y沸石中Si、Al的分布

本文应用^29Si,^27AIMASNMR和XRD技术,测量了四种不同脱铝深度的稀土超稳Y沸石的骨架硅铝比,得到了一致的结果,并研究了稀土超稳Y沸石的脱铝过程和稀土离子和Y沸石骨架铝的机理.发现稀土离子存在时,Y沸石骨架中Si、Al的分布与相同硅铝比的ＨＹ不同,在浅、中度脱铝时,主要脱除的是Si(2Al)和Si(3Al)中的铝,深度脱铝时,主要是Si(1Al)和少量Si(2Al)中的铝,而Si(3Al)几乎不变,提出稀土离子最可能是位于方钠的Si(3Al)附近,平衡三个AlO 四面体上的负电荷,起到稳定Si(3Al)结构单元的作用.其次,稀土超稳Y沸石中总的非骨架铝(N~Al)~EF,随脱铝深度的增加而增加,仅只在REUSY-38的^27AIMAS NMR谱中观察到Al^3+非骨架铝的存在.^29Si,^27AIMASNMR     

利用Taguchi法以高岭土为原料制备高硅NaY分子筛

采用Taguchi试验方法优化出了以高岭土为原料制备高硅NaY分子筛的最佳合成参数,考察了硅溶胶的加入量、反应体系的碱度、加水量以及晶化时间对NaY分子筛硅铝比和结晶度的影响。结果表明,高硅NaY分子筛的最佳合成条件是：反应体系各组分的物质的量比为7.5SiO₂∶1.0Al₂O₃∶2.2Na₂O∶120H₂O,晶化时间为16 h。同时发现,对合成样品性能的影响最为显著的因素是硅溶胶的加入量和碱度。采用X射线衍射、N₂静态容量吸附法和扫描电镜对利用最佳条件所合成样品的硅铝比、比表面积、孔分布以及表观形貌进行了表征。结果显示,以高岭土原料制备的NaY分子筛比参考样品拥有更高的硅铝比和更大的比表面积。     

由酸活化高岭土制备多级纳米孔HY分子筛及其表征

由酸活化的高岭土制备了多级纳米孔HY分子筛。通过改变老化时间和晶化时间可得到最大的多级因子(HF),此时外比表面积最大而微孔孔体积变化不大。运用X射线衍射(XRD)、X射线荧光光谱、N2吸附-脱附法和NH3程序升温脱附对所得样品进行了表征。老化2 d和晶化24 h所制的纳米孔HY分子筛样品的HF值最大。样品的酸性和结晶度也随着制备条件而变化。另外,适量NaCl的嵌入对提高对所制样品的HF值、酸性和结晶度起到重要作用。通过比较样品和常规HY分子筛的XRD峰强度算得样品的结晶度。结果表明,优化合成条件可得到广泛适用于工业化的分子筛制备路线。     

HCl处理后局部有序Y沸石的二次晶化

将商品 Y 型沸石用 HCl 处理后, 运用 X 射线粉末衍射, 透射电镜和扫描电镜、红外光谱及 27Al 和 29Si 魔角旋转核磁共振对其进行了表征. 结果表明, 酸处理后 Y 沸石接近无定形, 其长程有序性遭到破坏, 但还保留部分局部结构. 以不同浓度酸处理后的 Y 沸石为前驱体, 在 150 oC, 0.3 mol/L NaOH 条件下采用蒸汽辅助干胶转化法进行二次晶化, 可以获得丝光沸石, 其相纯度与前驱体的 Si/Al 密切相关. 随 Si/Al 比不同, 所得丝光沸石形貌由纳米针状堆积逐渐向微米单块状变化, 且其比表面积可达 400 m2/g 以上, 微孔孔容在 0.19 cm3/g.     

CXN天然沸石的研究1: 离子交换与结构性质表征

采用离子交换和焙烧等方法,对我国CXN天然沸石(STI型)进行改性。应用化学分析,粉末XRD,TG/DTA,^2^7AlMASNMR,^2^9SiMASNMR,低温N~2吸附等方法表征相关的结构、离子交换等性质。CXN沸石的晶胞组成Na~0~.~2Mg~0~.~1Ca~8~.~4[Al~1~7~.~2Si~5~4~.~8O~1~4~4].65H~2O,属富钙型。经离子交换脱Ca^2^+后的沸石在焙烧过程中伴随有骨架脱铝,骨架的热稳定性已由原样的500℃以下提高到700℃以上。交换改性后的沸石,呈现反映该沸石微孔特性的I型氮吸附等温线。     

分子筛表面酸性对微波固相法制备ZnCl2/Y催化剂的影响

 采用XRD和原子吸收光谱法研究了微波作用下分子筛表面酸性对ZnCl2与Y分子筛固态相互作用的影响．结果表明，微波辐射可显著促进ZnCl2在分子筛表面分散，其分散阈值与分子筛表面酸性有关．随着分子筛表面酸量和酸强度增加，ZnCl2在分子筛表面的最大分散量减少，分散的ZnCl2与Y分子筛的固态离子交换量也减少；NaY型分子筛比HY分子筛更容易发生固态离子交换反应．考察了微波固相法制备的ZnCl2／HY催化剂在苯甲醚与乙酰氯酰化反应中的催化性能．结果表明，在分子筛表面分散的ZnCl2具有更高的催化活性及对甲氧基苯乙酮选择性．     

HY Zeolite Modified by Liquid Silane Deposition and Its Catalytic Activity in Selective tert-Butylation of Naphthalene

HY zeolites were modified by chemical liquid deposition with i-C₄H₉Si(OC₂H₅)₃, followed by hydrothermal treatment. The samples were characterized by X-ray diffraction, N₂ adsorption and pulse mass analysis to investigate the influence on framework structure, specific surface area, pore diameter and adsorption behaviors. The catalytic performances of HY zeolite and the modified samples in the alkylation of naphthalene with tert-butyl alcohol were also evaluated. The results showed the modification of HY zeolite did not change framework structure but increased specific surface area, decreased average pore diameter, and reduced the size of pore opening. Catalytic activity of the modified HY zeolite catalyst for tert-butylation of naphthalene was decreased compared with that of HY zeolite catalyst while shape-selectivity of 2,6-di-tert-butylnaphthalene (2,6-DTBN) was increased obviously, the highest 2,6-DTBN/2,7-DTBN ratio of 6.62 obtained.     

17O magic angle spinning NMR studies of Brønsted acid sites in zeolites HY and HZSM-5

High-resolution 17O/1H double resonance NMR spectra were obtained for two zeolites, one with a low Si/Al ratio (zeolite HY) and one with a high Si/Al ratio (HZSM-5), to investigate their local structure and Br?nsted acidity. Two different oxygen signals, corresponding to Br?nsted acid sites in supercages and sodalite cages of zeolite HY were readily resolved in the two-dimensional (2-D) 1H-17O heteronuclear correlation (HETCOR) NMR spectra allowing the 17O isotropic chemical shift (deltaCS) and quadrupolar coupling parameters (quadrupolar coupling constant, QCC, and asymmetry parameter, eta) for the two oxygen atoms to be extracted. Similar experiments for HZSM-5 showed that the sites in this system are associated with a much larger distribution in NMR parameters than found in HY. 17O-1H rotational echo double resonance (REDOR) NMR was applied to probe the O-H distances in zeolites HY and HZSM-5. Weaker 17O-1H dephasing was observed for zeolite HZSM-5 in comparison to that of HY, consistent with longer O-H bonds and/or increased proton mobility.     

Ce离子对苯在Y分子筛上吸附扩散行为的影响

采用液相离子交换法制备了不同稀土含量的Y型分子筛(HY、USY和NaY),研究了稀土铈(Ce)阳离子在Y型分子筛上吸附-脱附烃类分子(苯)过程中的作用机理与影响。通过X射线荧光光谱仪(XRF)、智能质量分析仪(IGA)、脱附指数的计算和巨正则蒙特卡罗模拟计算等多种表征计算方法,对引入稀土物种后,Y型分子筛对苯的饱和吸附量、吸附作用力、脱附热力学参数、苯在Y分子筛上的吸附势能分布及扩散行为等方面进行了研究。结果表明,Ce离子对苯在Y分子筛上脱附活化能的降低、吸附作用力的减弱以及吸附态由团聚态向分散态转变等方面具有显著影响,该作用构成了CeY分子筛催化剂在流化催化裂化(FCC)过程中能够优化轻质产品选择性的重要因素。     

The effect of acidity behaviour of Y zeolites on the catalytic degradation of polyethylene

Thermogravimetric (TGA) and differential scanning calorimetric (DSC) analyses were used to investigate the effect of the acidity behaviour of Y zeolites on the catalytic degradation of polyethylene (PE). The acidity behaviour of these zeolites was modified by ion exchange treatments. Two Y zeolites with similar Si/Al atomic ratios were subjected to an ion exchange treatment using NaNO₃ for H-form (HY) and NH₄NO₃ for Na-form (NaY). The activity and the deactivation behaviour of the Y zeolites were determined in the samples by TGA measurements, using a polymer/catalyst ratio of 9:1. The sample residues obtained after an isothermic TGA, were analysed by DSC, in order to evaluate the crystallinity of each mixture. The HY zeolite, which has the strongest acidity, reduced the onset temperature resulting in more rapid degradation of the polymer. It is shown that the ion exchange treatment over Y zeolites enhances the selective catalytic degradation of polymer in detriment of the rapid deactivation.     

超稳丫沸石制备技术对沸石铝分布的影响 Ⅰ.两种典型超稳Y沸石表面-体相组成的XPS研究

用XPS考察了USY和FSY超稳Y型沸石及其起始原料NH_4Y沸石的表面组成,并结合Ar~+刻蚀技术与其体相组成进行了比较。结果表明,NH_4Y沸石的铝分布基本均匀一致,经超稳化处理后,沸石表面组成发生了很大的变化。用(NH_4)_2SiF_6液相脱铝补硅法制备的FSY表面呈缺铝特征,其表面铝原子浓度比体相低8～10％;而用传统水热法制备的USY具有典型的富铝表面,其表面铝原子浓度比体相高30％左右。USY表面富铝主要是由于USY“次表面”(Subsurface)附近的非骨架铝类迁移到表面所致。内层的非骨架铝类在常规水热超稳处理条件下一般则很难迁移,仍然留有在USY晶体内部。     

氯硅烷改性对Y沸石结构的影响

用２９Ｓｉ，２７ＡｌＭＡＳＮＭＲ，ＸＲＤ及化学分析法研究了氯硅烷改性Ｙ沸石的结构及组成变化，结果表明改性过程伴有脱铝和补硅作用，并同时有大量非骨架铝碎片形成．非骨架铝有两类，一类是２７ＡｌＭＡＳＮＭＲ可测的，另一类是不可测的．改性沸石的酸性可能来源于非骨架铝碎片．对各催化剂上甲苯歧化反应的考察表明，由于改性沸石酸度适中，是较ＨＹ沸石优良的催化剂．     

乙炔、丙烯在多种分子筛上的吸附和脱附性质

在80℃下研究了ZSM5、13X、Y、MOR、5A、SAPO34等多种分子筛和常见载体上乙炔和丙烯的吸附和脱附性能。结果表明，乙炔和丙烯在SiO2、γ-Al2O3上不吸附，而与分子筛存在较强的相互作用。对于同类型的分子筛，两者的饱和吸附量均随分子筛硅铝比的增大而减小。在同一种分子筛上，以摩尔计的丙烯吸附量均明显高于乙炔。在80℃改性β分子筛上乙炔和丙烯饱和吸附量可分别达到0.11mmol/g和4.89mmol/g，该结果明显高于文献报道的结果。     

Selective adsorption of biopolymers on zeolites

Zeolites adsorb biopolymers on their surface and may be suitable as a new type of chromatographic carrier material for proteins, nucleic acids, and their conjugates. We report here various parameters that influence the adsorption of biopolymers on synthesized zeolites with regard to the Si/Al2 ratio and three-dimensional structure. There are three physicochemical principles that may underly the adsorption: 1) below the isoelectric point (pI), mainly Coulombic attraction similar to ion-exchange chromatography; 2) at pI, hydrophobic interactions (a kind of van der Waals attraction) plus the three-dimensional mesopore structure; and 3) above pI, the sum of the Coulombic repulsion and attraction forces, such as the hydrophobic interaction, and also substitution reaction of water on the Al molecule with a protein amino-base. At high Si/Al2 ratio in the presence of a small amount of Al and with mesopores between the zeolite particles, maximal adsorption was seen at pI and was suggested to be dependent on the number of hydrophobic interaction points on the mesopores, and their morphology. The application of zeolites to biochemistry and biotechnology is also discussed.     

Studies on Natural CXN Zeolite： Modification, Framework De-alumination and Ion-exchange

A natural CXN zeolite (stilbite, type code-STI) discovered in China was modified with NH4^ exchange by using ammonium salt and calcinations (procedure Ⅰ), or with NH4 exchange followed by treatment with acid (procedure Ⅱ). The coordination state of Si and A1 atoms in the framework, the property of ion exchange, and the adsorption of the H-STI zeolite samples prepared by different modification procedure were investigated with XRD,EDX,^29Si and ^27Al MAS NMR, Ag^ ion exchange and Ne adsorption. The results of the investigations indicate that different procedure of the modification made variety on the distribution of the framework Si atoms and A1 atoms,the content of non-framework aluminum, and the blocking channels and the shielding effect to the positions of the exchangeable cations. The H-STI zeolite prepared by the procedure Ⅱ possesses high ion exchange capacity, open and perfect pore system, and high thermal stability.     

Phenylalanine and arginine adsorption in zeolites X, Y, and Beta

This paper documents a continuation of work published in Langmuir 2005, 21, 8743-8750. We report new aspects of this amino acid adsorption study, including the effect of changing zeolite framework type and results from adsorption of mixed amino acids. In single-amino-acid adsorption experiments, zeolite Y (Si/Al=2.5) was found to adsorb no phenylalanine while admitting arginine to a similar extent as observed with zeolite beta. Using this zeolite Y, we measured mixed-amino-acid separation selectivities for arginine/phenylalanine as large as 25,000 or 2 orders of magnitude larger than the corresponding selectivities measured with zeolite beta.