沸石分子筛上程序升温脱附谱的Monte Carlo模拟研究 Ⅰ．模型的建立

沸石分子筛因其特殊的孔道结构而致使其ＴＰＤ谱图的分析比其它催化剂更为困难，目前尚无一种切实可行的理论分析方法。本文发展了一种较为简单的模拟分子筛上ＴＰＤ谱图的ＭｏｎｔｅＣａｒｌｏ方法，模拟结果表明，在同一组脱附动力学参数下，沸石分子筛上的峰形和峰位置与其它催化剂都有明显的差异，并且峰温的差别与脱附活化能和指前因子有关。同时表明，对于普通催化剂可以根据峰最大时的覆盖度θ＿Ｍ来判断脱附级数，而对于沸石分子筛，θ＿Ｍ却随Ｅ＿ｄ线性变化。     

沸石分子筛上程序升温脱附谱的Monte Carlo模拟研究Ⅱ．不同晶粒的沸石分子筛

沸石分子筛上程序升温脱附谱的ＭｏｎｔｅＣａｒｌｏ模拟研究＊Ⅱ．不同晶粒的沸石分子筛王建国李永旺陈诵英彭少逸（中国科学院山西煤炭化学研究所，太原０３０００１）关键词沸石分子筛，程序升温脱附，ＭｏｎｔｅＣａｒｌｏ模拟沸石分子筛被广泛用作吸附剂和催化剂的根...     

Effect of the amine type on thermal stability of modified mesoporous silica used for CO2 adsorption

In this study, the preparation by grafting of amino-functionalized SBA-15 molecular sieves was carried out. Amino-functionalized molecular sieves were synthesized using a silane coupling agent and different types of amination reagents which react with modified SBA-15. These composites were characterized by FT-IR spectroscopy, X-ray diffraction at low angles, nitrogen physisorption at 77 K, and evaluated by the adsorption of CO₂ and its temperature-programmed desorption—TPD. Thermal stability was investigated by TGA and DTA methods. In the view of a possible use of these amino-functionalized molecular sieves as sorbents for CO₂ removal, their adsorption–desorption properties towards CO₂ were also investigated by the TPD method. The mass loss of amino-functionalized molecular sieves above 215 °C was due to the oxidation and decomposition of amino propyl functional groups. This means that these composites could be used for adsorption of CO₂ at temperatures below 215 °C. The adsorption of CO₂ and its temperature programmed desorption using thermogravimetry were studied for amino-functionalized molecular sieves at 60 °C. The evolved gases during the adsorption–desorption of CO₂ on amino-functionalized molecular sieves were identified by online mass spectrometry coupled with thermogravimetry. CO₂ adsorption isotherms of functionalized samples at 60 °C showed that both the adsorption capacity (mg CO₂/g adsorbent) and the efficiency of amino groups (mol CO₂/mol NH₂) depend on the type of amination reagents and the amount of organic compound used.

     

环已胺在沸石分子筛上的吸脱附行为研究

本文以程序升温脱附(TPD)为主要实验手段,对环己胺在5种不同沸石分子筛上的吸脱附行为进行了研究。结果表明,沸石分子筛对环己胺有着较强的吸附作用,不同的沸石分子筛对环己胺的吸附能力受其结构和表面酸性特征的影响而异。有效吸附部位为与沸石分子筛表面酸性有关的弱化学吸附位;环己胺从不同沸石分子筛表面脱附的动力学与晶内扩散有关,其表观脱附活化能分别为:63.6kJ/mol(5A),68.6kJ/mol(13X),20.1kJ/mol(菱沸石),46.9kJ/mol(NaY)和47.3KJ/mol(ZSM-5)。     

13X分子筛上硫化促进剂的动态行为研究

采用TPD技术对13X分子筛的表面酸性及3种硫化促进剂在其表面上的动态行为进行了研究。结果表明,13X分子筛具有吸附能量高低不等的多种表面酸性吸附部位。对于吸附型缓释交联剂,有效的表面吸附部位为弱化学吸附位.表观脱附动力学计算结果表明,不同的硫化促进剂从13X分子筛表面有效部位脱出时,其动力学特征亦不同,但均与晶内扩散有关,表观脱附活化能(kJ/mol)分别为51.5(二乙胺)、68.6(环己胺)和78.3(乙二胺)。     

Adsorption of organic pollutants over microporous solids investigated by microcalorimetry techniques

This work is focused on the gas and liquid-phase adsorption of pollutants: propanol, 2-butanone, phenol and nicotine onto zeolites (H-BETA, H-ZSM-5, H-MCM-22, and clinoptilolite). Textural properties and origin of zeolites were taken into account as criteria of adsorbents selection. The aldehyde and the ketone were adsorbed in the gas phase using microcalorimetry linked to a volumetric line to evaluate adsorption. Adsorptions in water were carried out for phenol and nicotine and the evolved heats during adsorption were measured by a differential heat flow reaction calorimeter with stirring. Results are discussed in relation with the pore sizes and various interactions which could occur between the adsorbent and the adsorbate.     

Characterization and removal of extra lattice species in faujasites

The acidic properties of dealuminated Y-type zeolites were characterized by infrared (IR) spectroscopy, microcalorimetry, ²⁹Si magic-angle spinning nuclear magnetic resonance (MAS NMR) spectroscopy and temperature-programmed desorption (TPD). Microcalorimetric measurements exhibited a uniform heat of adsorption (140 kJ/mol) of ammonia on the strong Brönsted acid sites. The differences in the acid site concentrations measured by adsorption of ammonia from the gas phase and by decomposition of ammonium-exchanged zeolites are discussed. The results indicate that parts of the extra lattice material consisting of cationic aluminium oxide species or silica alumina species are removed by ion exchange with aqueous solutions of ammonium hydroxide. Based on this, a method for the controlled removal of extra lattice material was developed.     

不同吸附剂上动态吸附-脱附挥发性有机气体性能研究

采用气相色谱法和热重分析(TG)研究了活性炭以及5A、NaY、13X、ZSM-5(Si0_2/Al_2O_3=27、300)、Hβ和MCM-41分子筛对正己烷、甲苯和乙酸乙酯的动态吸附-脱附性能,系统考察了挥发性有机气体(VOCs)浓度与种类及体积空速对吸附容量的影响。结果表明,增加体积空速和VOCs浓度,一定程度上能够提升吸附容量;活性炭吸附剂对三种VOCs具有较高的单位质量吸附量,而13X与NaY对三种VOCs具有更大的单位体积吸附量。     

掺Ag对氧化锰八面体分子筛催化CO氧化性能的影响

采用回流法在酸性介质中合成了掺杂贵金属Ag的氧化锰八面体分子筛(OMS-2).利用X射线衍射、低温N2吸附、透射电子显微镜及程序升温脱附(TPD)等技术对固体材料的结构进行了表征,考察了材料对CO氧化反应的催化性能,以及Ag的掺杂对该反应的影响.结果表明,合成的OMS-2材料属于cryptomelane一维隧道结构,适量Ag的掺杂使分子筛的有序性得到改善,孔径更均一.Ag的加入还能明显提高催化剂的反应活性.O2-TPD和CO-TPD实验表明,Ag的引入使材料对CO的吸附性能及晶格氧的扩散能力得到显著增强,这是提高催化剂对CO氧化催化能力的主要原因.     

Exceptional framework flexibility and sorption behavior of a multifunctional porous cuprous triazolate framework

The porous metal azolate framework [Cu(etz)]infinity (MAF-2, Hetz = 3,5-diethyl-1,2,4-triazole) processes an NbO type cuprous triazolate scaffold and a CsCl type hydrophobic channel system, in which the large cavities are interconnected by small apertures with pendant ethyl groups. Since the ethyl-blocked apertures behave as thermoactivated IRIS stops for the guest molecules, the gas sorption behavior of MAF-2 can be controlled by temperature, in which N2 adsorption was observed at 195 K rather than 77 K. Single-crystal X-ray structural analysis revealed that the [Cu(etz)]infinity host framework is not altered upon N2 inclusion, confirming the occurrence of the so-called " kinetically controlled flexibility". By virtue of the kinetically controlled flexibility and hydrophobic pore surface, MAF-2 can adsorb large amounts of small organic molecules but excludes H2O. As demonstrated by single-crystal X-ray structural analyses, MAF-2 shrinks, expands, or distorts its framework to accommodate the hydrogen-bonded hexamers of MeOH, EtOH, or MeCN, respectively. Moreover, MAF-2 can also separate benzene and cyclohexane efficiently, as its flexible scaffold can distort to a certain degree so that benzene can diffuse through the distorted apertures but cyclohexane cannot. Moreover, the adsorption/desorption of these organic vapors induces reversible, multimode structural transformations.     

Temperature-programmed desorption of n-hexane from hydrated HZSM-5 and NH4ZSM-5 zeolites

Temperature-programmed desorption coupled with mass spectrometer as a detector (TPD), IR and ¹³C NMR measurements are used to study the adsorption of n-hexane on hydrated HZSM-5 and NH₄ZSM-5 zeolites. The ¹³C NMR measurements show that n-hexane can access the pore structure of ZSM-5 zeolites previously saturated with water. TPD spectra of n-hexane are monitored in the temperature region 50–300°C, in the case of fully or partially hydrated samples; two-stage desorption of n-hexane is found. Simultaneous desorption of water and n-hexane in the same temperature region are found, in all investigated samples.     

Adsorption, desorption, and diffusion of nitrogen in a model nanoporous material. I. Surface limited desorption kinetics in amorphous solid water

The adsorption and desorption kinetics of N2 on porous amorphous solid water (ASW) films were studied using molecular beam techniques, temperature programed desorption (TPD), and reflection-absorption infrared spectroscopy. The ASW films were grown on Pt(111) at 23 K by ballistic deposition from a collimated H2O beam at various incident angles to control the film porosity. The experimental results show that the N2 condensation coefficient is essentially unity until near saturation, independent of the ASW film thickness indicating that N2 transport within the porous films is rapid. The TPD results show that the desorption of a fixed dose of N2 shifts to higher temperature with ASW film thickness. Kinetic analysis of the TPD spectra shows that a film thickness rescaling of the coverage-dependent activation energy curve results in a single master curve. Simulation of the TPD spectra using this master curve results in a quantitative fit to the experiments over a wide range of ASW thicknesses (up to 1000 layers, approximately 0.5 microm). The success of the rescaling model indicates that N2 transport within the porous film is rapid enough to maintain a uniform distribution throughout the film on a time scale faster than desorption.     

氢同位素吸附容量与吸附剂比表面积的关系

采用容积法测量了77 K下氢气与氘气在不同微孔与介孔分子筛吸附剂上的吸附容量与比表面积. 结果表明, 同类吸附剂上氢同位素的吸附容量与其比表面积之间存在较好的线性关系, 这有力地证明了超临界温度下氢同位素吸附遵循单分子层吸附机理. 在相同的温度、压力和比表面积条件下, 氢同位素气体在微孔分子筛上的吸附容量比介孔分子筛上的大, 这是由于在吸附剂微孔内吸附势场叠加所致, 并通过构建的吸附势模型, 较好地解释了该实验结果.     

Characterization of short-time dealumined HZSM-5 zeolites

Temperature-programmed desorption (TPD) of water was applied to characterize short-time dealuminated HZSM-5 zeolites. Using a regularization method, distribution functions of the effective desorption energy of water were calculated. The results clearly show that during dealumination a new adsorption site is formed which can be attributed to non-framework or transient aluminium species. The highest concentration of these sites was observed for a dealumination time of 25-30 min. NO adsorption studies support this result. Furthermore, it could be concluded that the heterogeneity and the average acid strength of the remaining Si-OH-Al groups of the dealuminated samples do not change compared to the Si-OH-Al groups of the parent HZSM-5 zeolite. This revised version was published online in July 2006 with corrections to the Cover Date.     

氢在A、X及ZSM-5型沸石上的高压物理吸附

The hydrogen adsorption properties and uptake capacities of the A, X and ZSM-5 types of zeolites were investigated at temperatures of 77, 195 and 293 K and pressures up to 7MPa, using a conventional volumetric adsorption apparatus. All hydrogen adsorption isotherms were basically type I, but the maximum in isotherm,a unique feature of supercritical adsorption, was observed at high pressures of 2-5 MPa at 77 K. The isosteric heats of adsorption were determined from the isotherms and the factors that influence their variations were discussed. Different types of zeolites exhibited remarkably different hydrogen uptake, based on both the framework structure and the nature of the cations present. The highest gravimetric storage capacity of 2.55wt% was obtained for NaX-type zeolite at 4 MPa and 77 K. In CaA, NaX and ZSM-5 types of zeolites,hydrogen uptakes were proportional to the specific surface areas, which were associated with the available void volumes of the zeolites. A threshold in hydrogen adsorption observed in NaA and KA was attributed to a pore blocking effect by large cations in KA. A ratio of the kinetic diameter of adsorbate to the effective opening diameter of zeolite was used to judge the blocking effect for physisorption.     

Coverage-dependent sticking probability and desorption kinetics of water molecules on Rh(111)

The adsorption and desorption kinetics of water molecules on Rh(111) were investigated using temperature programed desorption (TPD). Water molecules on Rh(111) show coverage-dependent sticking probability; the initial sticking probability is estimated to be 0.46. In the desorption process, a dilute gaslike phase and two-dimensional islands of water coexist on the surface. Based on the model proposed by Kreuzer and Payne [Surf. Sci.200, L433 (1988)], the apparent fractional-order TPD spectra can be interpreted as first-order desorption from the coexistence of two phases on which the sticking probabilities are different. Based on this, the previous estimation of pre-exponential factors assuming half-order desorption [A. Beniya et al., J. Chem. Phys.125, 054717 (2006)] should be revised.     

改性Y分子筛的酸碱性能及吸附性能的研究

吡啶、吡咯、苯、甲苯、乙苯作为探针分子，在Li＋, Na＋, K＋, Cs＋改性的Y型分子筛上进行吸附，用TPD及IR方法系统地研究了不同碱金属离子改性的Y型分子筛的酸碱性能和吸附性能的变化. 结果表明，按Li、Na、K、Cs的顺序, 随着碱金属离子半径的增大, 其L酸酸强度依次减弱，L碱的强度逐渐增强.由于改性Y型分子筛所含碱金属离子的不同，其对芳烃的吸附的强弱及吸附量的大小亦不同.随着骨架外的阳离子的半径逐渐增大，碱的强度逐渐增强，与芳烃的作用愈强烈，导致TPD脱附峰温增高及芳烃和侧链上的C－H伸缩振动谱带向低波数位移愈多.由于位阻的原因，对含同一种碱金属离子的分子筛来说，随着芳烃侧链C数的增加，芳烃的吸附量逐渐减小.     

Cavitation and pore blocking in nanoporous glasses

In gas adsorption studies, porous glasses are frequently referred to as model materials for highly disordered mesopore systems. Numerous works suggest that an accurate interpretation of physisorption isotherms requires a complete understanding of network effects upon adsorption and desorption, respectively. The present article deals with nitrogen and argon adsorption at different temperatures (77 and 87 K) performed on a series of novel nanoporous glasses (NPG) with different mean pore widths. NPG samples contain smaller mesopores and significantly higher microporosity than porous Vycor glass or controlled pore glass. Since the mean pore width of NPG can be tuned sensitively, the evolution of adsorption characteristics with respect to a broadening pore network can be investigated starting from the narrowest nanopore width. With an increasing mean pore width, a H2-type hysteresis develops gradually which finally transforms into a H1-type. In this connection, a transition from a cavitation-induced desorption toward desorption controlled by pore blocking can be observed. Furthermore, we find concrete hints for a pore size dependence of the relative pressure of cavitation in highly disordered pore systems. By comparing nitrogen and argon adsorption, a comprehensive insight into adsorption mechanisms in novel disordered materials is provided.