Microstructure of hydrogenated silicon thin films prepared from silane diluted with hydrogen

We report results obtained from FTIR and TEM measurements carried out on silicon thin films deposited by plasma-enhanced chemical vapor deposition (PECVD) from silane diluted with hydrogen. The hydrogen content, the microstructure factor, the mass density and the volume per Si-H vibrating dipoles were determined as a function of the hydrogen dilution. Hydrogen dilution of silane results in an inhomogeneous growth during which the material evolves from amorphous hydrogenated silicon (a-Si:H) to microcrystalline hydrogenated silicon (μc-Si:H). With increasing dilution the transition from amorphous to microcrystalline phase appears faster and the average mass density of the films decreases. The μc-Si:H films are mixed-phase void-rich materials with changing triphasic volume fractions of crystalline and amorphous phases and voids. Different bonding configurations of vibrating Si-H dipoles were observed in the a-Si:H and μc-Si:H. The bonding of hydrogen to silicon in the void- and vacancy-dominated mechanisms of network formation is discussed.     

Hydrogen evolution during deposition of microcrystalline silicon by chemical transport

We exposed a freshly deposited boron-doped, hydrogenated amorphous silicon (a-Si:H) layer to hydrogen plasma under conditions of chemical transport. In situ spectroscopic ellipsometry measurements revealed that atomic hydrogen impinging on the film surface behaves differently before and after crystallization. First, the plasma exposure increases hydrogen solubility in the a-Si:H network leading to the formation of a hydrogen-rich subsurface layer. Then, once the crystallization process engages, the excess hydrogen starts to leave the sample. We have attributed this unusual evolution of the excess hydrogen to the grown hydrogenated microcrystalline (μc-Si:H) layer, which gradually prevents the atomic hydrogen from the plasma reaching the μc-Si:H/a-Si:H interface. Consequently, hydrogen solubility, initially increased by the hydrogen plasma, recovers the initial value of an untreated a-Si:H material. To support the theory that the outdiffusion is a consequence and not the cause of the μc-Si:H layer growth, we solved the combined diffusion and trapping equations, which govern hydrogen diffusion into the sample, using appropriate approximations and a specific boundary condition explaining the lack of hydrogen injection during μc-Si:H layer growth.     

Optical absorption in PECVD deposited thin hydrogenated silicon in light of ordering effects

We report results obtained from measurements of optical transmittance spectra carried out on a series of silicon thin films deposited by plasma-enhanced chemical vapour deposition (PECVD) from silane diluted with hydrogen. Hydrogen dilution of silane results in an inhomogeneous growth during which the material evolves from amorphous hydrogenated silicon (a-Si:H) to microcrystalline hydrogenated silicon (μc-Si:H). Spectral refractive indices and absorption coefficients were determined from transmittance spectra. The spectral absorption coefficients were used to determine the Tauc optical band gap energy, the B factor of the Tauc plots, E ₀₄ (energy at which the absorption coefficient is equal to 10⁴ cm⁻¹), and the Urbach energy as a function of the hydrogen dilution. The results were correlated with microstructure, namely volume fractions of the amorphous and crystalline phase with voids, and with the grain size.      

Hydrogen diffusion and electronic metastability in amorphous silicon

Hydrogen diffusion and its role in the many electronic metastability phenomena in hydrogenated amorphous silicon (a-Si:H) is reviewed. A-Si:H contains about 10 at% hydrogen, most of which is bonded to silicon. The hydrogen diffuses at relatively low temperatures by releasing hydrogen from the Si-H bonds into interstitial sites. The reactions of hydrogen with the silicon dangling bonds and the weak bonds provide a hydrogen-mediated mechanism for electron-structural interactions, which are manifested as electronic metastability. The annealing of light-induced defects, the equilibration of defects and dopants, the stretched exponential relaxation kinetics, and the atomic structure formed during growth, are all attributed to hydrogen diffusion.     

Effect of hydrogen on hardness of amorphous silicon

A comparative study of hardness of thin films of hydrogenated amorphous silicon (a-Si:H) and hydrogen-free amorphous silicon (a-Si) was carried out to reveal the role of hydrogen in the plastic properties of amorphous silicon. In addition, the effect of hydrogen on hardness was established by changing hydrogen concentration in the material using post-deposition processing of the samples. The hydrogen concentration in a-Si:H was decreased by thermal annealing. In a-Si hydrogen was introduced by plasma hydrogenation. The values of hardness of the as-prepared a-Si and a-Si:H films were determined by nanoindentation using depth profiling. Low-depth indentation was applied to evaluate the effect of post-hydrogenation. The results obtained show that the presence of hydrogen in the amorphous silicon network leads to the increase in hardness. The conducted experiments demonstrate that plasma hydrogenation can be used as an effective tool to increase the hardness of amorphous silicon. Hardness of a-Si:H of about 12.3–12.7 GPa is as high as of crystalline silicon, suggesting a-Si:H can be a substitute for crystalline silicon in some MEMS.     

后退火增强氢化非晶硅钝化效果的研究

在本征氢化非晶硅(a-Si:H(i))/晶体硅(c-Si)/a-Si:H(i)异质结构上溅射ITO时, 发现后退火可大幅增加ITO/a-Si:H(i)/c-Si/a-Si:H(i)的少子寿命(从1.7 ms到4 ms). 这一增强效应可能的三个原因是: ITO/a-Si:H(i)界面场效应作用、退火形成的表面反应层影响以及退火对a-Si:H(i)材料本身的优化, 但本文研究结果表明少子寿命增强效应与ITO和表面反应层无关; 对不同沉积温度制备的a-Si:H(i)/c-Si/a-Si:H(i)异质结后退火的研究表明: 较低的沉积温度(<175 ℃)后退火增强效应显著, 而较高的沉积温度(>200 ℃)后退火增强效应不明显, 可以确定“低温长高温后退火”是获得高质量钝化效果的一种有效方式; 采用傅里叶红外吸收谱(FTIR)研究不同沉积温度退火前后a-Si:H(i)材料本身的化学键构造, 发现退火后异质结少子寿命大幅提升是由于a-Si:H(i)材料本身的结构优化造成的, 其深层次的本质是通过材料的生长温度和退火温度的优化匹配来控制包括H含量、H键合情况以及Si原子无序性程度等微观因素主导作用的一种竞争性平衡, 对这一平衡点的最佳控制是少子寿命大幅提升的本质原因.     

Efficient light emission from crystalline and amorphous silicon nanostructures

Optical and electronic properties of crystalline silicon (c-Si) and amorphous silicon (a-Si) nanostructures are reviewed. The photoluminescence (PL) peak energies of c-Si and a-Si nanostructures are blueshifted from those of bulk c-Si and a-Si. The temperature dependence of the PL intensity is drastically improved in c-Si and a-Si nanostructures, and efficient luminescence from c-Si and a-Si nanostructures is observed at room temperature. The quantum confinement, spatial confinement, and surface effects on luminescence properties are summarized and the PL mechanism of silicon nanostructures is discussed.     

Interface states study of intrinsic amorphous silicon for crystalline silicon surface passivation in HIT solar cell

Intrinsic hydrogenated amorphous silicon(a-Si:H) film is deposited on n-type crystalline silicon(c-Si) wafer by hotwire chemical vapor deposition(HWCVD) to analyze the amorphous/crystalline heterointerface passivation properties.The minority carrier lifetime of symmetric heterostructure is measured by using Sinton Consulting WCT-120 lifetime tester system,and a simple method of determining the interface state density(D_(it)) from lifetime measurement is proposed.The interface state density(D_(it)) measurement is also performed by using deep-level transient spectroscopy(DLTS) to prove the validity of the simple method.The microstructures and hydrogen bonding configurations of a-Si:H films with different hydrogen dilutions are investigated by using spectroscopic ellipsometry(SE) and Fourier transform infrared spectroscopy(FTIR) respectively.Lower values of interface state density(D_(it)) are obtained by using a-Si:H film with more uniform,compact microstructures and fewer bulk defects on crystalline silicon deposited by HWCVD.     

The relationship between hydrogen and paramagnetic defects in thin film silicon irradiated with 2 MeV electrons

After irradiation of hydrogenated amorphous and microcrystalline silicon (a-Si:H and μc-Si:H) with 2 MeV electrons at 100 K, we observe satellite-like components close to the dominating electron spin resonance (ESR) signal of these materials. The satellites overlap with the commonly observed dangling bond resonance and are proposed to originate from a hyperfine interaction with the nuclear magnetic moment of hydrogen atoms in a-Si:H and μc-Si:H. Our present study is focused on the verification of this hypothesis. Equivalent hydrogenated and deuterated a-/μc-Si:H/D materials have been investigated with ESR before and after 2 MeV electron bombardment. From the difference between ESR spectra of hydrogenated and deuterated samples we identify the doublet structure in the ESR spectra as a hyperfine pattern of hydrogen-related paramagnetic centers. The observations of H-related paramagnetic centers in a-/μc-Si:H are of particular interest in view of metastability models of a-Si:H, which include H-related complexes as precursors for the stabilization of the metastable Si dangling bonds. The nature of the observed center is discussed in the light of known H-related complexes in crystalline Si and suggested H-related dangling bonds in a-Si:H.     

The influence of Fermi energy on structural and electrical properties of laser crystallized P-doped amorphous silicon

A series of phosphorous-doped hydrogenated amorphous silicon films (a-Si:H) were crystallized using step-by-step laser crystallization process. The structural changes during the sequential crystallization process were detected by Raman measurements. The dehydrogenation was monitored by measuring the Si-H local vibrational modes using Raman spectroscopy and hydrogen effusion measurements. Interestingly, hydrogen bonding is affected by doping of the amorphous material. The influence of doping concentrations, thus the Fermi energy on electronic properties has been investigated employing secondary ion mass spectroscopy (SIMS), dark-conductivity- and Hall-effect measurements. The results from hydrogen effusion are consistent with the results obtained from Raman spectroscopy, Hall-effect- and dark-conductivity measurements.     

Effect of hydrogen on surface texturing and crystallization of a-Si:H thin film irradiated by excimer laser

Hydrogenated amorphous silicon (a-Si:H) thin films have been considered for use in solar cell applications because of their significantly reduced cost compared to crystalline bulk silicon. However, their overall efficiency and stability are lower than that of their bulk crystalline counterpart. Limited work has been performed on simultaneously solving the efficiency and stability issues of a-Si:H. Previous work has shown that surface texturing and crystallization on a-Si:H thin film can be achieved through a single-step laser processing, which can potentially alleviate the disadvantages of a-Si:H in solar cell applications. In this study, hydrogenated and dehydrogenated amorphous silicon thin films deposited on glass substrates were irradiated by KrF excimer laser pulses and the effect of hydrogen on surface morphologies and microstructures is discussed. Sharp spikes are focused only on hydrogenated films, and the large-grained and fine-grained regions caused by two crystallization processes are also induced by presence of hydrogen. Enhanced light absorptance is observed due to light trapping based on surface geometry changes of a-Si:H films, while the formation of a mixture of nanocrystalline silicon and original amorphous silicon after crystallization suggests that the overall material stability can potentially improve. The relationship between crystallinity, fluence and number of pulses is also investigated. Furthermore, a step-by-step crystallization process is introduced to prevent the hydrogen from diffusing out in order to reduce the defect density, and the relationship between residue hydrogen concentration, fluence and step width is discussed. Finally, the combined effects show that the single-step process of surface texturing and step-by-step crystallization induced by excimer laser processing are promising for a-Si:H thin-film solar cell applications.     

Control of epitaxial growth at a-Si:H/c-Si heterointerface by the working pressure in PECVD

The epitaxial-Si(epi-Si) growth on the crystalline Si(c-Si) wafer could be tailored by the working pressure in plasmaenhanced chemical vapor deposition(PECVD).It has been systematically confirmed that the epitaxial growth at the hydrogenated amorphous silicon(a-Si:H)/c-Si interface is suppressed at high pressure(hp) and occurs at low pressure(1p).The hp a-Si:H,as a purely amorphous layer,is incorporated in the 1p-epi-Si/c-Si interface.We find that:(i) the epitaxial growth can also occur at a-Si:H coated c-Si wafer as long as this amorphous layer is thin enough;(ii) with the increase of the inserted hp layer thickness,lp epi-Si at the interface is suppressed,and the fraction of a-Si:H in the thin films increases and that of c-Si decreases,corresponding to the increasing minority carrier lifetime of the sample.Not only the epitaxial results,but also the quality of the thin films at hp also surpasses that at lp,leading to the longer minority carrier lifetime of the hp sample than the lp one although they have the same amorphous phase.     

椭圆偏振光谱表征单晶硅衬底上生长的非晶硅和外延硅薄膜

本文采用射频等离子体增强化学气相沉积(rf-PECVD)技术在单晶硅衬底上沉积了两个系列的硅薄膜. 通过对样品进行固定角度椭圆偏振测试, 结果表明第一个系列硅薄膜为非晶硅, 形成了突变的a-Si:H/c-Si异质结构, 此结构在HIT电池中有利于形成好的界面特性, 对于非晶硅薄膜采用通常的Tauc-Lorentz摇摆模型(Genosc)拟合结果很好; 第二个系列硅薄膜为外延硅, 对于外延硅薄膜, 随着膜厚增加晶化率降低, 当外延硅薄膜厚度为46 nm时开始非晶硅生长. 对于外延硅通常采用EMA模型(即将硅薄膜体层看成由非晶硅和c-Si构成的混合层)拟合结果较好, 当硅薄膜中出现非晶硅生长时, 将体层分成混合层和非晶硅两层, 采用三层模型拟合结果很好. 本文证实了椭偏光谱分析采用不同的模型可对单晶硅衬底上不同结构的硅薄膜进行有效表征.     

Noise in boron doped amorphous/microcrystallization silicon films

Hydrogenated silicon (Si:H) film was grown by radio frequency plasma enhanced chemical vapor deposition (PECVD) method. The transition between hydrogenated amorphous silicon (a-Si:H) and hydrogenated microcrystalline silicon (μc-Si:H) was characterized by X-ray diffraction analysis. A semiconductor system was used to measure low frequency noise (1/f noise) and random telegraph switching noise of Si:H films. The results show that the 1/f noise of μc-Si:H is 4 orders of magnitude lower than that of a-Si:H and no RTS noise was found in both films. It also shows that using μc-Si:H instead of a-Si:H film as a sensing layer will enable the development of high performance uncooled microbolometer.     

Dynamics of hydrogen in hydrogenated amorphous silicon

The problem of hydrogen diffusion in hydrogenated amorphous silicon (a-Si:H) is studied semiclassically. It is found that the local hydrogen concentration fluctuations-induced extra potential wells, if intense enough, lead to the localized electronic states in a-Si:H. These localized states are metastable. The trapping of electrons and holes in these states leads to the electrical degradation of the material. These states also act as recombination centers for photo-generated carriers (electrons and holes) which in turn may excite a hydrogen atom from a nearby Si-H bond and breaks the weak (strained) Si-Si bond thereby apparently enhancing the hydrogen diffusion and increasing the light-induced dangling bonds.     

钙钛矿/硅叠层太阳电池中平面a-Si:H/c-Si异质结底电池的钝化优化及性能提高

最近,旋涂法制备的钙钛矿/平面硅异质结高效叠层太阳电池引起人们广泛关注,主要原因是相比于绒面硅衬底制备的钙钛矿/硅叠层太阳电池,其制备工艺简单、制备成本低且效率高.对于平面a-Si:H/c-Si异质结电池, a-Si:H/c-Si界面的良好钝化是获得高转换效率的关键,进而决定了钙钛矿/硅异质结叠层太阳电池的性能.本文主要从硅片表面处理、a-Si:H钝化层和P型发射极等方面展开研究,通过对硅片表面的氢氟酸(HF)浸泡时间和氢等离子体预处理气体流量、a-Si:H钝化层沉积参数、钝化层与P型发射极(I/P)界面富氢等离子体处理的综合调控,获得了相应的优化工艺参数.对比研究了p-a-Si:H和p-nc-Si:H两种缓冲层材料对I/P界面的影响,其中高电导、宽带隙的p-nc-Si:H缓冲层既能够降低I/P界面的缺陷态,又可以增强P型发射层的暗电导率,提高了前表面场效应钝化效果.通过上述优化,制备出最佳的P-type emitter layer/aSi:H(i)/c-Si/a-Si:H(i)/N-type layer (inip)结构样品的少子寿命与implied-Voc分别达到2855μs和709 mV,表现出良好的钝化效果.应用于平面a-Si:H/c-Si异质结太阳电池,转换效率达到18.76%,其中开路电压达到681.5 mV,相对于未优化的电池提升了34.3 mV.将上述平面a-Si:H/c-Si异质结太阳电池作为底电池,对应的钙钛矿/硅异质结叠层太阳电池的开路电压达到1780 mV,转换效率达到21.24%,证明了上述工艺优化能够有效地改善叠层太阳电池中的硅异质结底电池的钝化及电池性能.     

Hydrogen pile-up at interfaces between differently doped layers of amorphous silicon

Hydrogen profiles for layered a-Si:H structures are presented. Substantial accumulation of hydrogen at the p-i interface is found. Additional incorporation of hydrogen in p-layers is also observed for intermediate boron doping levels compared to intrinsic layers. Hydrogen profiles in single pin and in pinpin amorphous silicon structures enable determination of individual layer thickness.     

高压射频等离子体增强化学气相沉积制备高效率硅薄膜电池的若干关键问题研究

报道了采用高压射频等离子体增强化学气相沉积(RF-PECVD) 制备高效率单结微晶硅电池和非晶硅/微晶硅叠层电池时几个关键问题的研究结果, 主要包括: 1)器件质量级本征微晶硅材料工艺窗口的确定及其结构和光电性能表征; 2)孵化层的形成机理以及减小孵化层的有效方法; 3)氢稀释调制技术对本征层晶化率分布及其对提高电池性能的作用; 4)高电导、高晶化率的微晶硅p型窗口层材料的获得, 及其对减小微晶硅电池p/i界面孵化层厚度和提高电池性能的作用等. 在解决上述问题的基础上, 采用高压RF-PECVD制备的单结微晶硅电池效率达8.16%, 非晶硅/微晶硅叠层电池效率11.61%.     

Nuclear magnetic resonance investigation of H, H2 and dopants in hydrogenated amorphous silicon and related materials

Nuclear magnetic resonance has been successfully applied to the study of the microstructure of hydrogenated amorphous silicon and related materials. It has been used to determine the local bonding and structural environment of the host atoms, the hydrogen, and the dopants. First, we review some of these NMR experimental results on the hydrogen microstructure in hydrogentaed amorphous semiconductors and compare the results on plasma deposited hydrogenated amorphous silicon (a-Si:H), remote hydrogen plasma deposited a-Si:H, thermally annealed a-Si:H, doped a-Si:H, microcrystalline Si and amorphous (Si, Ge):H alloys. A common feature is that these materials exhibit a heterogeneous distribution of hydrogen bonded to the semiconductor lattice in dilute and clustered phases. In addition, the lattice contains voids of varying number and size that contain non-bonded molecular hydrogen whose quantity is altered by deposition conditions and thermal treatment. Second, we review some aspects of the local bonding structure of dopants in a-Si:H. A significant fraction of the dopants are found to be in dopant-hydrogen clusters similar to those proposed to explain hydrogen passivation in crystalline silicon. Implications of the determined local structure on the doping efficiency are discussed.