硫酸氢钠催化合成己酸异戊酯的研究

己酸异戊酯是应用最广泛的食用香料之一。通常它是在硫酸催化下由己酸和异戊醇酯化反应而得[1] ,硫酸虽然活性高 ,价廉 ,但选择性差 ,产品质量不好 ,设备腐蚀严重 ,同时产生大量废液 ,污染环境。已发现对甲苯磺酸、磺酸树脂、固体超酸、杂多酸、氯化铁以及过渡金属硫酸盐等均可作为酯化反应的优良催化剂[2～ 7] 。本文探讨了硫酸氢钠催化羧酸的酯化反应 ,结果发现它具有良好的催化性能 ,且后处理方便 ,无污染。1　实验部分在装有分水器、温度计和回流冷凝器的四颈烧瓶中 ,加入一定量分析纯的己酸、异戊醇、甲苯和催化剂硫酸氢钠 (ＮａＨＳＯ…     

十二烷基苯磺酸/异辛烷微乳液中脂肪酶催化合成异丁酸异戊酯

在十二烷基苯磺酸(DBSA)/异辛烷微乳液中进行了脂肪酶催化合成异丁酸异戊酯的反应, 考察了微乳体系的含水量w₀、溶解酶缓冲溶液的pH值、反应温度等因素对酯合成反应转化率的影响; 与前期研究的CTAB微乳体系进行比较发现, DBSA微乳体系中的酯合成反应速率明显增加, 短时间内的转化率显著提高, 在温和条件下反应9 h后, 转化率达90%以上; 通过DBSA体系中有酶与无酶条件下反应进程的比较得知, DBSA作为一种质子酸对酯合成反应具有一定的催化能力; 提出了该体系中微乳催化、酶催化和质子酸催化的三重催化机理.     

(Liquid + liquid) equilibria of (water + propionic acid + methyl isoamyl ketone or diisobutyl ketone or ethyl isoamyl keton) at T = 298.2 K

(Liquid + liquid) equilibrium (LLE) data for (water + propionic acid + solvent) were measured at T = 298.2 K and atmospheric pressure. The solvents were methyl isoamyl ketone (5-methyl-2-hexanone), ethyl isoamyl ketone (5-methyl-3-heptanone) and diisobutyl ketone. The tie-line data were correlated by means of the NRTL and UNIQUAC equation, and compared with results predicted by the UNIFAC method. A comparison of the extracting capabilities of the solvents was made with respect to distribution coefficients, separation factors, and solvent free selectivity bases.     

Green synthesis of banana flavor using different catalysts: a comparative study of different methods

ABSTRACT

Esterification of isoamyl alcohol with acetic acid was studied using different ion-exchange resins, namely Amberlyst 15 dry, Amberlyst 16 wet, Amberlite 120-IR. Esterification was carried out using different esterification methods that are quite new (ohmic, ultrasonic probe, and ultrasonic bath) and the results were compared with microwave-assisted esterification (MAE). The highest isoamyl acetate yield (99%) was obtained by MAE, using a mixture of acetic acid and isoamyl alcohol (mole ratio of 1:2) after 2?h of reaction time. In this process, 2% Amberlyst 15 dry was used. MAE had the least specific energy consumption (0.42?kWh/g isoamyl acetate) and specific CO₂ emission (34?g/g isoamyl acetate). According to the images obtained by scanning electron microscopy, lower amounts of Amberlyst 15 dry beads were destroyed by MAE method compared to other esterification methods. In conclusion, MAE proved to be an economic and environmentally-friendly method for esterification of different flavoring compounds.     

磷酸钛固载磷钨酸非均相催化合成异戊酸己酯

通过在300℃下焙烧2h制备了磷酸钛固载15%磷钨酸H3PW12O40(简记为HPW)非均相酯化催化剂HPW/Ti3(PO4)4;采用红外光谱仪分析了催化剂的结构;基于异戊酸与正己醇的酯化反应考察了催化剂用量、n(正己醇)∶n(异戊酸)、反应时间、带水剂种类和催化剂重复使用性能等因素对酯化率的影响.结果表明,该催化剂催化合成异戊酸己酯的适宜反应条件为:0.2mol异戊酸,催化剂用量0.6g,n(正己醇)∶n(异戊酸)=1.6∶1,反应时间4.5h,环己烷10mL;相应的酯化率达95.1%.与此同时,该催化剂循环利用6次后酯化率不低于84%.     

固体磺酸促进亚硝酸异戊酯催化氧化苯甲醇反应

 以亚硝酸异戊酯为催化剂, 通过固体磺酸的促进作用原位产生亚硝酰正离子, 实现了催化氧气氧化苯甲醇制备苯甲醛. 300 oC 处理的 Amberlyst 15 表现出较高的促进效果, 在 0.5 MPa O2, 80 oC 反应 2 h, 苯甲醇转化率和苯甲醛选择性可分别达到 90% 和 97%. 通过红外、热分析及酸碱滴定研究了不同方法制得的固体酸的差别及其对反应促进效果的影响, 并利用紫外-可见光谱和衍生化方法检测了亚硝酰正离子.     

Structural studies on banana oil,isoamyl acetate,by means of microwave spectroscopy and quantum chemical calculations

The rotational spectrum of isoamyl acetate, H₃C–COO–(CH₂)₂–CH(CH₃)₂, has been recorded and assigned using a molecular beam Fourier transform microwave (MB-FTMW) spectrometer in the frequency range of 3–26.5?GHz. One conformer has been observed. By comparing the spectroscopic data with the quantum chemical data, it was found that the conformer observed does not have C_s symmetry. The rotational and centrifugal distortion constants were determined. The barrier to internal rotation of the acetate methyl group was found to be 93.98?cm^?1. Due to the high number of the conformers, a systematic nomenclature will be presented.     

Enantiomeric analysis of drugs in water samples by using liquid–liquid microextraction and nano-liquid chromatography

The nano-LC technique is increasingly used for both fast studies on enantiomeric analysis and test beds of novel stationary phases due to the small volumes involved and the short conditioning and analysis times. In this study, the enantioseparation of 10 drugs from different families was carried out by nano-LC, utilizing silica with immobilized amylose tris(3-chloro-5-methylphenylcarbamate) column. The effect on chiral separation caused by the addition of different salts to the mobile phase was evaluated. To simultaneously separate as many enantiomers as possible, the effect of buffer concentration in the mobile phase was studied, and, to increase the sensitivity, a liquid–liquid microextraction based on the use of isoamyl acetate as sustainable extraction solvent was applied to pre-concentrate four chiral drugs from tap and environmental waters, achieving satisfactory recoveries (>70%).     

Fe2O3-ZnO/SiO2催化氧化异戊醇一步合成异戊酸异戊酯

采用浸渍法制备了系列不同Fe2O3、ZnO负载量的Fe2O3-ZnO/SiO2催化剂,并用XRD、BET、SEM等对催化剂进行了表征;考察了以分子氧为氧化剂时,该系列催化剂对异戊醇一步合成异戊酸异戊酯的催化性能,并初步探讨了其反应机理。结果表明,在Fe2O3/SiO2催化剂上引入适量ZnO后,提高了Fe2O3在SiO2上的分散度,减小了Fe2O3的粒径,所制得的Fe2O3-ZnO/SiO2催化剂有较大的比表面积、孔体积、孔径,催化性能优于Fe2O3/SiO2。其中,在Fe2O3与ZnO的协同作用下,6%Fe2O3-4%ZnO/SiO2催化性能最佳,常压下当催化剂用量为0.9 g(占反应物质量的3.5%),反应温度120℃,反应时间9 h,异戊醇一步合成异戊酸异戊酯的选择性达54.5%,收率达31.4%。对该合成机理的初步探讨表明,只有催化剂与分子氧的共同作用下,异戊醇才能高效的合成异戊酸异戊酯。     

稀土固体超强酸SO42-/TiO2/La3+催化合成丁酸异戊酯

The synthesis of isoamyl butyrate with isoamyl alcohol and butyric acid as reactants and rare-earth solid superacid SO₄^2-/TiO₂/La³⁺ as catalyst had been studied.The influent actors of reaction were investigated.The results showed that the appropriate conditions should be: Weight of catalyst was 0.5g (weight of butyric acid if 0.2mol); molar ratio of isoamyl alcohol to butyric acid was 1.8: 1; reaction time was 2.0 h; the taking water reagent (Toluene) was 15mL.The yield of isoamyl butyrate was about 99.0%.