Influence of whey protein denaturation on κ-carrageenan gelation

Response surface methodology was applied to study the effect of different heating temperature/time treatments on whey protein denaturation and its effect on κ-carrageenan gelation in milk. The path of gel formation was followed using small deformation rheology and the extent of whey protein denaturation was determined by gel permeation chromatography. κ-Carrageenan did not influence the rate of whey protein denaturation and it was unlikely that whey protein denaturation played a significant role on κ-carrageenan gelation in milk. In skim milk serum or skim milk ultrafiltrate the path of gel formation and gel strength were not influenced by the severity of heat treatment but increasing the concentration of whey proteins enhanced the gel strength. Heat treatment became important for carrageenan gelation in skim or recombined milks (i.e. in the presence of casein micelles) by influencing the gelation temperature and gel strength. Increasing the concentration of whey proteins in the recombined milks had a beneficial effect on gel strength.     

Effect of pH and ionic strength on competitive protein adsorption to air/water interfaces in aqueous foams made with mixed milk proteins

Quantitative analysis of competitive milk protein adsorption to air/water interfaces in aqueous foam was performed by capillary electrophoresis (CE). Foams were made by whipping protein solutions, in which skim milk powder (SMP) and whey protein isolate (WPI) were mixed at 0.5% protein in different proportions at different pH values and NaCl concentrations. Preferential adsorption of beta-casein into foam phases occurred under most solution conditions, if partial dissociation of the casein micelles had occurred. Preferential adsorption of beta-casein was not observed with added Ca2+, due to the re-association of casein micelles. Enrichment of caseins into the foam phase was more apparent than that of whey proteins. The foamability of SMP demonstrated a continuous improvement due to the gradually increasing dissociation of casein micelles when the concentration of NaCl increased from 0 to 0.8 M. The foamability of WPI increased when NaCl concentration rose from 0 to 0.1 M, and decreased with further increase in NaCl concentration. NaCl at low concentration (I < or = 0.4) did not show a significant effect on the competitive adsorption among milk proteins, indicating that electrostatic interactions do not play a key role in competitive adsorption. NaCl at higher concentration, e.g., 0.6 M, caused less whey protein to be adsorbed to the air/water interfaces. The whippability of WPI was highest at pH 4.5 and lowest at pH 3, and that of SMP was the opposite. The proportions of beta-lactoglobulin and alpha-lactalbumin in the foam phase were lower at acidic pH and higher at basic pH, compared with that at natural pH of WPI.     

Analysis of bovine whey proteins in soybean dairy-like products by capillary electrophoresis

The simultaneous separation of bovine whey proteins [alpha-lactalbumin and beta-lactoglobulin (A+B)] and soybean proteins was performed, for the first time, by capillary electrophoresis. Different experimental conditions were tested. The most suitable consisted of 0.050 M phosphate buffer (pH 8) with 1 M urea and 1.2 mg/ml methylhydroxyethylcellulose, UV detection at 280 nm, 15 kV applied voltage, and 30 degrees C temperature. Quantitation of bovine whey proteins in a commercial powdered soybean milk manufactured by adding bovine whey to its formulation was performed using the calibration method of the external standard. Direct injection of a solution of the powdered soybean milk only enabled quantitation of alpha-lactalbumin in the commercial sample. Detection of beta-lactoglobulin (A+B) required acid precipitation of the solution of the sample in order to concentrate bovine whey proteins in the supernatant prior to the analysis of this protein in the whey obtained. Since alpha-lactalbumin could also be quantitated from the injection of the whey, the simultaneous determination of alpha-lactalbumin and beta-lactoglobulin (A+B) was possible upon acid precipitation of the powdered soybean milk solution. Detection limits obtained were 14 microg/g sol. for alpha-lactalbumin and 52 microg/g sol. for beta-lactoglobulin (A+B) which represent protein concentrations about 60 microg/100 g sample for alpha-lactalbumin and 100 microg/100 g sample for beta-lactoglobulin (A+B).     

Interfacial properties of acidified skim milk

The purpose of this study is to investigate the tension properties and dilatational viscoelastic modulus of various skim milk proteins (whole milk, EDTA-treated milk, beta-casein, and beta-lactoglobulin) at an oil/water interface at 20 degrees C. Measurements are performed using a dynamic drop tensiometer for 15,000 s. The aqueous bulk phase is a skim milk simulated ultrafiltrate containing 11 x 10(-3) g L(-1) milk protein. At pH 6.7, beta-casein appears as the best to decrease the interfacial tension, whereas beta-lactoglobulin leads to the highest interfacial viscoelastic modulus value. Whole milk was almost as surface-active as individual beta-casein in terms of the final (steady-state) lowering of the interfacial tension, but the rate of tension lowering was smaller. EDTA treatment improved the rate of tension lowering of whole milk. The acidification of milk, from previous measurements, would lead to the enhancement of surface activity. At t=15,000 s, the order of effectiveness is pH 4.3 > pH 5.3 = pH 5.6 > pH 6.7 whole milk, suggesting that pH 4.3 whole milk is the best surface active. As compared to pH 6.7 whole milk, the use of pH 5.3 and pH 5.6 milk as surface active would result in the use of milk containing more free beta-casein born of pH-dissociated casein micelles.     

Inhibition of heat-induced aggregation of a beta-lactoglobulin-stabilized emulsion by very small additions of casein

Heat stability has been studied in model systems of oil-in-water emulsions (3 wt.% total protein, 45 vol.% n-tetradecane, pH 6.8, ionic strength 30-50 mM) with pure beta-lactoglobulin (beta-lg) as the main emulsifier. The effect of small additions of sodium caseinate, beta-casein or alpha s1-casein prior to emulsion preparation has been investigated. Samples heated for 3 min at 90 degrees C were monitored with respect to changes in viscosity and particle-size distribution. As expected, the pure beta-lg-stabilized emulsions were susceptible to heat-induced changes. But the replacement of just 1% of the beta-lg by sodium caseinate (0.03 wt.% caseinate in the total emulsion) led to complete elimination of any heat-induced viscosity or particle size increase. These findings show that a very small proportion of casein can inhibit the susceptibility of a beta-lg-based emulsion to heat-induced destabilization. The magnitude of the effect is dependent on the type of casein, with the order of effectiveness being beta-casein>sodium caseinate>alpha s1-casein. This work has potential implications for the development of milk protein-stabilized emulsions of improved shelf life.     

The impact of the concentration of casein micelles and whey protein-stabilized fat globules on the rennet-induced gelation of milk

The rennet-induced aggregation of skim milk recombined with whey protein-stabilized emulsion droplets was studied using diffusing wave spectroscopy (DSW) and small deformation rheology. The effect of different volume fractions of casein micelles and fat globules was investigated by observing changes in turbidity (1/l*), apparent radius, elastic modulus and mean square displacement (MSD), in addition to confocal imaging of the gels.Skim milk containing different concentration of casein micelles showed comparable light-scattering profiles; a higher volume fraction of caseins led to the development of more elastic gels.By following the development of 1/l* in recombined milks, it was possible to describe the behaviour of the fat globules during the initial stages of rennet coagulation. Increasing the volume fraction of fat globules showed a significant increase in gel elasticity, caused by flocculation of the oil droplets. The presence of flocculated oil globules within the gel structure was confirmed by confocal microscopy observations. Moreover, a lower degree of κ-casein hydrolysis was needed to initiate casein micelles aggregation in milk containing whey protein-stabilized oil droplets compared to skim milk.This study for the first time clearly describes the impact of a mixture of casein micelles and whey protein-stabilized fat globules on the pre-gelation stages of rennet coagulation, and further highlights the importance of the flocculation state of the emulsion droplets in affecting the structure formation of the gel.     

Influence of chemical agents on interactions in dairy products: Effect of SDS on casein micelles

The addition of SDS during skim milk reconstitution is an original approach to study the effect of an ionic amphiphilic molecule on the milk system and particularly on the casein micelle component. SDS-induced changes in casein micelles were investigated by turbidimetry, rheology, scanning electron microscopy (SEM) and biochemical measurements (including soluble proteins analysis). This study shows that casein micelles were able to interact together to form micellar aggregates or milk gel without coagulating agents addition, when milk was reconstituted in the presence of SDS. This micellar aggregation, depending on the SDS concentration, is confirmed by SEM observations showing that the general aspect of casein micelles was affected by SDS treatment. Biochemical analysis indicated that SDS induced micellar casein dissociation. SDS-induced milk gel formation required a defined level of casein dissociation which could be also related to a particular micellar state.     

The rennet coagulation mechanism of skim milk as observed by transmission diffusing wave spectroscopy

The technique of forward-scattering diffusing wave spectroscopy has been used to study the rennet-induced gelation of skim milk. The results allow the comparison of a colloidal suspension at a realistic concentration (Phi approximately 10%) compared with well-established measurements made on highly-diluted milk samples. It is shown that the partially renneted casein micelles do not begin to approach one another until the extent of breakdown of kappa-casein has reached about 70%; above this point, they interact increasingly strongly with the extent of proteolysis. This interaction initially restricts the diffusive motion of the particles rather than causing true aggregation. Only after more extensive removal of the protective kappa-casein does true aggregation occur, with the appearance of a space-filling gel (defined by rheology as having a value of tandelta<1). The results show in greater detail than hitherto the progress of interactions between the particles in a system where the steric stabilization is progressively destroyed, and suggest that the renneting of milk at its normal concentration cannot be described simply by reactions between freely-diffusing particles.     

Fermentation of a skim milk concentrate with Streptococcus thermophilus and chymosin: structure, viscoelasticity and syneresis of gels

Fermentation of a reconstituted skim milk concentrate (8% protein) was investigated to elucidate the effects of various fermentation parameters on the structural, rheological and visual (wheying-off) properties of the resulting gels (pH 4.60). Fermentation trials were performed with non-exocellular polysaccharide-producing strains of Streptococcus thermophilus at various fermentation temperatures and at various chymosin levels. Oscillatory vane rheometry carried out on the intact gels (at 4 °C) showed that the level of chymosin had a significant impact on the gel strength (storage modulus G′). This can be explained by the arrangement of casein micelles into more compact aggregates and the enhanced fusion of aggregated casein micelles as revealed by transmission electron microscopy for the gels fermented with chymosin. Wheying-off of the stirred gels as measured by a centrifugation test (at 4 °C) and pore size of the intact gel structures investigated by scanning electron microscopy both increased with increasing level of chymosin and increasing fermentation temperature (resulting in an increase in acidification rate). A higher level of syneresis (wheying-off) is explained by the larger pore size, since larger pores present a lower resistance to the outflow of whey from the gel.     

Electrostatic effects on the yield stress of whey protein isolate foams

The mechanisms responsible for foam structure are of practical interest within the food industry. The yield stress (tau) of whey protein isolate (WPI) foams as affected by electrostatic forces was investigated by whipping 10% (w/v) protein solutions prepared over a range of pH levels and salt concentrations. Measurements of foam overrun and model WPI interfaces, i.e. adsorption kinetics as determined via dynamic surface tension and dilatational rheological characterization, aided data interpretation. Interfacial measurements were also made with the primary whey proteins, beta-lactoglobulin (beta-lg) and alpha-lactalbumin (alpha-la). Yield stress of WPI foams was dependent on pH, salt type and salt concentration. In the absence of salt, tau was highest at pH 5.0 and lowest at pH 3.0. The addition of NaCl and CaCl2 up to 400 mM significantly increased tau at pH 7.0 but not at pH 3.0. Furthermore, at pH 7.0, equivalent molar concentrations of CaCl2 as compared to NaCl increased tau to greater extents. Salts had minimal effects on tau at pH 5.0. Comparisons with interfacial rheological data suggested the protein's capacity to contribute towards tau was related to the protein's potential at forming strong, elastic interfaces throughout the structure. The dynamic surface tension data for beta-lg and alpha-la were similar to WPI, while the interfacial rheological data displayed several noticeable differences.     

Interactions between denatured milk serum proteins and casein micelles studied by diffusing wave spectroscopy

The acid-induced aggregation of casein micelles from milk, in the presence of different whey protein preparations from heated and unheated milk, has been studied using diffusing wave spectroscopy (DWS). In particular, the study focused on the turbidity (or l*) parameter obtainable from DWS, which can give information on the interactions between particles in aggregating systems. The experiments provided evidence that the presence of small, soluble, whey protein/kappa-casein aggregates derived from heated milk gave rise to interactions with both heated and unheated casein micelles over a pH range of 5.6 down to 5.2. Comparison of heated and unheated milks, together with milks whose sera had been exchanged, showed that direct interactions were indeed occurring, even between untreated casein micelles and soluble whey protein complexes. Comparison of the behavior of the whey protein aggregates in emulsion preparations where they could not interact with the large particles confirmed that the effect was specific to the presence of casein micelles and could not arise simply from the aggregation of the whey proteins themselves.     

Foaming and interfacial properties of hydrolyzed beta-lactoglobulin

beta-lactoglobulin (beta-lg) was hydrolyzed with three different proteases and subsequently evaluated for its foaming potential. Foam yield stress (tau0) was the primary variable of interest. Two heat treatments designed to inactivate the enzymes, 75 degrees C/30 min and 90 degrees C/15 min, were also investigated for their effects on foam tau0. Adsorption rates and dilatational rheological tests at a model air/water interface aided data interpretation. All unheated hydrolysates improved foam tau0 as compared to unhydrolyzed beta-lg, with those of pepsin and Alcalase 2.4L(R) being superior to trypsin. Heat inactivation negatively impacted foam tau0, although heating at 75 degrees C/30 min better preserved this parameter than heating at 90 degrees C/15 min. All hydrolysates adsorbed more rapidly at the air/water interface than unhydrolyzed beta-lg, as evidenced by their capacity to lower the interfacial tension. A previously observed relationship between interfacial dilatational elasticity (E') and tau0 was generally confirmed for these hydrolysates. Additionally, the three hydrolysates imparting the highest tau0 not only had high values of E' (approximately twice that of unhydrolyzed beta-lg), they also had very low phase angles (essentially zero). This highly elastic interfacial state is presumed to improve foam tau0 indirectly by improving foam stability and directly by imparting resistance to interfacial deformation.     

Antioxidant activity of whey protein fractions isolated by gel exclusion chromatography and protease treatment

Whey proteins were isolated from whey powder by a combination of gel exclusion chromatography and protease (pepsin or trypsin) treatment. Whey solution (6g/dl) was applied to Sephadex G-200 column chromatography and three fractions were obtained. Gel electrophoresis (SDS-PAGE) was used to identify the fractions; the first one contained immunoglobulins and bovine serum albumin, the second contained beta-lactoglobulin and alpha-lactalbumin whereas the third fraction contained small peptides. We have also subjected the whey filtrate to proteases (pepsin and trypsin). Treatment with proteases showed that beta-lactoglobulin can be obtained after hydrolysis of the second fraction with pepsin. When the whey filtrate was treated with pepsin and then applied to Sephadex G-200 column chromatography three fractions were obtained; the first one was bovine serum albumin, the second was beta-lactoglobulin and the third fraction contained small peptides. After trypsin treatment only two fractions were obtained; the first one was serum albumin and the second fraction was an alpha-lactalbumin rich fraction. We have determined the antioxidant activity of the fractions using an assay based on the measurement of superoxide radical scavenging activity. Our results showed that among the three fractions, the first fraction had the highest superoxide radical scavenging activity. Also, protease treatment of the second fraction resulted in an increase in the antioxidant activity.     

Monte Carlo simulations of flexible polyanions complexing with whey proteins at their isoelectric point

Electrostatic complexation of flexible polyanions with the whey proteins alpha-lactalbumin and beta-lactoglobulin is studied using Monte Carlo simulations. The proteins are considered at their respective isoelectric points. Discrete charges on the model polyelectrolytes and proteins interact through Debye-Huckel potentials. Protein excluded volume is taken into account through a coarse-grained model of the protein shape. Consistent with experimental results, it is found that alpha-lactalbumin complexes much more strongly than beta-lactoglobulin. For alpha-lactalbumin, strong complexation is due to localized binding to a single large positive "charge patch," whereas for beta-lactoglobulin, weak complexation is due to diffuse binding to multiple smaller charge patches.     

High resolution two-dimensional electrophoresis and sodium dodecyl sulphate-polyacrylamide gel electrophoresis of cheese proteins after rapid solubilisation

The proteins of cheese are rapidly solubilised by heating to 95 degrees C in buffered 2% sodium dodecyl sulfate, 5% 2-mercaptoethanol. Electrophoretic analysis of the solubilised proteins by either one-dimensional sodium dodecyl sulphate-polyacrylamide gel electrophoresis or high resolution two-dimensional electrophoresis yields reproducible patterns characteristic of an individual cheese and its extent of ripening. The patterns reveal (i) the residual amounts of milk casein and whey proteins, and (ii) the appearance of casein degradation products, including pink-violet components as detected by Coomassie Blue staining.     

Structure, dynamics, and optical properties of concentrated milk suspensions: an analogy to hard-sphere liquids

A systematic study of the effects of volume fraction increment on the optical properties, the structure, and the dynamics of the casein micelles and fat droplets in milk was performed using diffusing wave spectroscopy. Four types of milk were investigated, NIDO full fat milk, fat-free milk, whey and fat-free milk, and finally lactose and fat-free milk. Independent measurements to calculate the dependence of the viscosity and the index of refraction of the milk serum and casein micelles as a function of the volume fraction were also performed. We compare the experimentally determined quantities photon transport mean free path (l*) and self-diffusion coefficient D(s) with the predictions from theoretical calculations using classical colloidal models such as a hard-sphere fluid. We demonstrate that all types of milk with and without fat content behave, structurally, like colloidal hard-sphere systems up to volume fractions well over 45%. In the case of dynamic measurements, both lactose- and fat-free and whey- and fat-free milk behave also like hard-sphere systems whereas fat-free milk and fat-containing NIDO milk deviate slightly at volume fractions over 35%. Finally, a comparative measurement and theoretical calculation of the casein micelle's size was performed.     

Migration behavior and separation of active components in Glycyrrhiza uralensis Fisch and its commercial extract by micellar electrokinetic capillary chromatography

1-Anilinonaphthalene-8-sulfonic acid (1,8-ANS), 4,4'-dianilino-1,1'-binaphthyl-5,5'-disulfonic acid (bis-ANS) and 2-(p-toluidino)naphthalene-6-sulfonic acid (2,6-TNS) were evaluated as additives in different buffers for the detection of bovine whey proteins using laser-induced fluorescence (LIF) monitoring in capillary electrophoresis (CE). These N-arylaminonaphthalene sulfonates furnish a large fluorescence emission when associated to some proteins whereas their emission in aqueous buffers, such as those used in CE separations, is very small. To select the best detection conditions, the fluorescence of these probes was first compared using experiments carried out in a fluorescence spectrophotometer. Using bovine serum albumin (BSA) as a model protein, it was demonstrated that 2-(N-cyclohexylamino)ethanesulfonic acid (CHES) buffer (pH 8 and pH 10.2) and the fluorescent probe 2,6-TNS gave rise to the highest increase in fluorescence for BSA. When the composition of these separation buffers was optimized for the electrophoretic separations, CHES buffer, pH 10.2 was chosen as the most suitable buffer to detect bovine whey proteins. The limit of detection obtained for some whey proteins in CE separations was about 6.10(-8) M for BSA, 3.10(-7) M for beta-lactoglobulin A (beta-LGA), 3.10(-7) M for beta-lactoglobulin B (beta-LGB), and 3.10(-6) M for alpha-lactalbumin (alpha-LA). These detection limits were compared to those achieved using UV detection under the same separation conditions. The results showed that the detection limits of BSA, beta-LGA and beta-LGB were twice as good using LIF than with UV detection. However, the limit of detection for alpha-LA was better when UV was used. The applicability of LIF detection to CE separation of whey proteins in bovine milk samples was also demonstrated.     

Distribution of strontium in milk component

The distribution of strontium between the milk components, i.e., serum, casein micelles, whey and hydroxyapatite was determined. The sorption on hydroxyapatite was investigated using batch method and radiotracer technique. The aqueous phase comprised of either milk or whey. The sorption of strontium on hydroxyapatite depended on the method of its preparation and on the composition of the aqueous phase. The sorption of strontium was increased with an increase of pH. The presence of citrate species resulted in decrease of the sorption of strontium on hydroxyapatite. The sorption of ⁸⁵Sr on hydroxyapatite decreased with the increasing concentration of Ca²⁺ ions. Addition of Ca²⁺ ions to milk resulted in milk pH decrease. The decrease in pH value after calcium addition to milk is related to exchanges between added calcium and micellar H⁺. The average value of strontium sorption on casein micelles in milk with presence of hydroxyapatite was (47.3 ± 5.6) %. The average value of sorption of ⁸⁵Sr on casein micelles in milk without the addition of hydroxyapatite was (68.9 ± 2.2) %.