混凝土材料声发射信号的频率特征及其与强度参量的相关性试验研究

混凝土材料声发射信号频率特征与强度指标的关系是混凝土材料声发射检测技术的重要基础。通过实验,对声发射信号频率特征与混凝土强度指标的相关关系进行了探讨。研究结果表明,在较低的应力水平上,不同强度等级混凝土声发射信号大都是低频信号。而在较高应力水平时,随着强度等级的增加,声发射信号的优势频率则逐渐升高。     

不同浓度的尾砂胶结充填体破坏过程 声发射特性试验研究*

制备了3种不同质量浓度的充填体试件，进行了单轴压缩声发射试验，分析了不同浓度的充填体力学特性，重点研究了试件破坏过程中的声发射振铃计数、声发射累计撞击数与声发射累计能量的比值(r值)、主频及其相对高频信号激增响应系数特征。研究表明：随着浓度的增加，充填体的峰值强度与弹性模量呈增大趋势，充填体中出现的声发射累计振铃计数越多；r值先升高再持续减小到一个较低值，随着外载荷的增加，进入缓慢升高阶段，峰值前均保持在该阶段。充填体破裂前兆信息在声发射信号主频分布中呈现主频段增多现象，表现为由加载初期的1~2个主频段，在临界主破裂时增多到3~5个主频段；且随着浓度的增加，声发射信号主频频段分布越宽，声发射相对高频信号(160~180 kHz)的激增响应系数呈递减趋势。以上特征可为不同浓度的尾砂胶结充填体稳定性监测、预测提供依据。     

BFRP筋混凝土粘结-滑移声发射特性研究*

为研究BFRP筋与混凝土粘结-滑移过程中的损伤特征,对BFRP筋混凝土粘结试件进行了加载速度为0.1 mm/s的拔出试验。采用声发射技术对损伤过程的特点进行了研究,并且针对破坏预警指标的有效表征进行了深入分析。结果表明,声发射能量、撞击数、振铃计数等参数能够真实反映BFRP筋混凝土粘结受载情况,并得到250 kHz～300 kHz频段的声发射事件百分比及声发射b值范围可以作为粘结应力达到峰值时的预警指标,为BFRP筋混凝土粘结-滑移破坏预警提供了依据。     

蒸养再生骨料混凝土断裂声发射特征*

为研究蒸汽养护对再生骨料混凝土断裂过程损伤特征的影响,开展了再生骨料混凝土三点弯断裂试验,并采用声发射技术对损伤过程进行了监测分析。结果表明,蒸养降低了再生骨料混凝土断裂峰值荷载,断裂过程中声发射信号强度低于标准养护试件。声发射振铃计数、撞击数、b值等参数能够准确反映再生骨料混凝土断裂过程损伤演变规律。加载上升阶段,声发射信号活动性很低,试件内以微裂纹的形成为主,加载至荷载峰值,声发射振铃计数累计值增长呈现平缓阶段,混凝土内微裂缝的聚合会持续一段时间。峰值后荷载迅速降低阶段声发射信号最活跃,为裂缝迅速发展的过程。峰后荷载缓慢降低的过程,声发射信号活跃性降低,裂缝扩展至试件顶部区域,主要是宏观裂缝的开展,不再产生新的裂缝。     

Q235钢板局部腐蚀声发射信号特性研究

为解决腐蚀声发射源特征提取和识别的难题,直接从理论上证明了腐蚀声发射监测的有效性并推导出声发射信号特征。气泡破裂声发射信号幅值近似与气泡半径平方和液位高度成正比,频率与气泡半径成反比;钢板及其腐蚀产物开裂声发射信号幅值与开裂位置局部应力强度成正比,频率与裂纹扩展速度成正比,与裂纹扩展距离成反比。用低频和高频两套声发射系统,同时长时间监测Q235钢板在10%FeCl_3·6H_2O、10%FeCl_3·6H_2O加0.01 mol/L HCl混合液、5%CuSO_4·5H_2O溶液中的腐蚀情况,辅以监测钢板及钢板腐蚀产物开裂作为验证实验。通过对声发射信号的参数及谱分析,得出不同声发射源可以通过撞击数及功率谱在频域的分布来有效区分。实验结果与理论分析相吻合,研究结果对腐蚀声发射监测技术具有重要指导意义。     

304不锈钢点蚀声发射监测研究

为研究304不锈钢在高于常温条件下的点蚀声发射特性,对70℃下6%氯化铁溶液中304不锈钢点蚀过程进行了声发射监测。采用参数和波形分析相结合的方法处理信号,并通过点蚀形貌观察进行验证。结果表明声发射撞击和能量随时间逐渐增加,在某一时段达到峰值,随后下降并维持平稳状态。信号波形主要由幅度、能量较大的低频段(<100kHz)弯曲波和幅度、能量较小的高频段(>100 kHz)扩展波构成。研究结果对304不锈钢高于常温条件下声发射点蚀监测具有一定意义。      

Q235钢板局部腐蚀声发射信号特性研究

为解决腐蚀声发射源特征提取和识别的难题,直接从理论上证明了腐蚀声发射监测的有效性并推导出声发射信号特征。气泡破裂声发射信号幅值近似与气泡半径平方和液位高度成正比,频率与气泡半径成反比;钢板及其腐蚀产物开裂声发射信号幅值与开裂位置局部应力强度成正比,频率与裂纹扩展速度成正比,与裂纹扩展距离成反比。用低频和高频两套声发射系统,同时长时间监测Q235钢板在10%FeCl₃·6H₂O、10%FeCl₃·6H₂O加0.01 mol/L HCl混合液、5%CuSO₄·5H₂O溶液中的腐蚀情况,辅以监测钢板及钢板腐蚀产物开裂作为验证实验。通过对声发射信号的参数及谱分析,得出不同声发射源可以通过撞击数及功率谱在频域的分布来有效区分。实验结果与理论分析相吻合,研究结果对腐蚀声发射监测技术具有重要指导意义。      

三点弯曲试验 条件下花岗岩声发射横纵波特征及损伤演化*

开展花岗岩三点弯曲试验,利用横纵波两种传感器接收花岗岩破坏过程的声发射信号,对比分析声发射横纵波信号的时频特征,在此基础上,基于声发射横纵波建立损伤变量,探讨花岗岩三点弯曲条件下损伤演化规律。研究结果表明：花岗岩破坏过程声发射横纵波事件率变化趋势较为相似,临近峰值载荷时均加速上升,破坏时达到峰值,但纵波事件率加速点早于横波事件率;声发射横纵波能率变化趋势一致,呈现峰前低水平稳定变化、峰后陡升到峰值的特征。声发射横纵波主频在临近峰值载荷逐渐形成主频条带,但其频率存在差异,纵波主频分布在0~10 kHz、30~50 kHz和100~110 kHz,而横波主频集中分布在0~10 kHz。相比纵波损伤变量,横波损伤变量能够刻画峰后损伤急速发展的过程,能较好地表征花岗岩三点弯曲作用下损伤变化规律。     

金属点蚀过程声发射源机制研究

研究了腐蚀特别是点蚀过程产生应力波,即声发射(ＡＥ)的源机制,估算了单个钝化膜破裂所产生的薄板表面位移量级,并用实验进行了论证。作者提出,利用板波声发射理论加上参数识别方法,可将腐蚀过程产生的声发射信号同背景噪声相区别。     

长骨中振动声激发超声导波的方法

为了实现一定频段内任意低频下在长骨中激励导波信号,本文提出一种采用聚焦高频(5 MHz)超声换能器在长骨皮质骨中激发低频(150 kHz)超声导波的振动声方法.首先介绍了板状超声导波理论和双声束共聚焦法与单声束调幅法激发振动声的基本原理;进而采用三维有限元仿真方法分析振动声激发低频超声导波的基本现象,然后结合牛胫骨板离体实验,验证振动声激发低频超声导波的可行性.结果均表明,双声束共焦与单声束振动超声均可在骨板中激发低频超声导波.相关研究方法有助于提高空间域长骨中超声导波测量精度,以及在一定频段内实现任意频率激励等,对发展低频超声导波在体测量长骨皮质骨的新技术具有一定的指导意义.     

Echolocation signals of wild Atlantic spotted dolphin (Stenella frontalis)

An array of four hydrophones arranged in a symmetrical star configuration was used to measure the echolocation signals of the Atlantic spotted dolphin (Stenella frontalis) in the Bahamas. The spacing between the center hydrophone and the other hydrophones was 45.7 cm. A video camera was attached to the array and a video tape recorder was time synchronized with the computer used to digitize the acoustic signals. The echolocation signals had bi-modal frequency spectra with a low-frequency peak between 40 and 50 kHz and a high-frequency peak between 110 and 130 kHz. The low-frequency peak was dominant when the signal the source level was low and the high-frequency peak dominated when the source level was high. Peak-to-peak source levels as high as 210 dB re 1 microPa were measured. The source level varied in amplitude approximately as a function of the one-way transmission loss for signals traveling from the animals to the array. The characteristics of the signals were similar to those of captive Tursiops truncatus, Delphinapterus leucas and Pseudorca crassidens measured in open waters under controlled conditions.     

Enhancing interaural-delay-based extents of laterality at high frequencies by using "transposed stimuli"

An acoustic pointing task was used to determine whether interaural temporal disparities (ITDs) conveyed by high-frequency "transposed" stimuli would produce larger extents of laterality than ITDs conveyed by bands of high-frequency Gaussian noise. The envelopes of transposed stimuli are designed to provide high-frequency channels with information similar to that conveyed by the waveforms of low-frequency stimuli. Lateralization was measured for low-frequency Gaussian noises, the same noises transposed to 4 kHz, and high-frequency Gaussian bands of noise centered at 4 kHz. Extents of laterality obtained with the transposed stimuli were greater than those obtained with bands of Gaussian noise centered at 4 kHz and, in some cases, were equivalent to those obtained with low-frequency stimuli. In a second experiment, the general effects on lateral position produced by imposed combinations of bandwidth, ITD, and interaural phase disparities (IPDs) on low-frequency stimuli remained when those stimuli were transposed to 4 kHz. Overall, the data were fairly well accounted for by a model that computes the cross-correlation subsequent to known stages of peripheral auditory processing augmented by low-pass filtering of the envelopes within the high-frequency channels of each ear.     

钢筋混凝土动态粘结滑移声发射特性试验

为研究不同加载速率下钢筋混凝土粘结-滑移损伤破坏过程中的损伤特征,对钢筋混凝土粘结试件进行了0.01 mm/s～10 mm/s四种不同速度的拔出试验。采用实时动态的声发射监测技术对整个试验过程进行监测,对试验过程中的声发射信号进行声发射振幅-振铃计数特性及功率谱峰值频率特性分析。结果表明,随着滑移速率的增加,声发射振幅-振铃计数拟合曲线变缓,在0～50 k Hz和100～150 k Hz频率范围内的声发射事件比重分别减小和增加。损伤过程的声发射特性对钢筋混凝土粘结滑移损伤演化规律的研究具有重要的价值。     

Effect of the ultrasound action on the acoustic emission and mechanical properties of zirconium-based bulk metallic glasses

The effect of preliminary ultrasound action on the mechanical properties and features of the structure of zirconium-based bulk metallic glasses has been studied by the method of acoustic emission under uniaxial compression. Results of studies have been interpreted using the polycluster model of the structure of amorphous metallic alloys. Analysis of the obtained data has allowed us to substantiate the mechanism of the change in the structure and strength of metallic glasses as a result of alternating-sign mechanical loading with an ultrasound frequency of 20 kHz.     

Lateralization of bands of noise and sinusoidally amplitude-modulated tones: effects of spectral locus and bandwidth

Lateralization of narrow bands of noise was investigated while varying interaural temporal disparity (ITD), center frequency, and bandwidth, utilizing an acoustic pointing task. Stimuli were narrow bands of noise centered at octave intervals between 500 Hz and 4 kHz with bandwidths ranging from 50-400 Hz. In a second experiment, lateralization for bands of noise and sinusoidally amplitude-modulated (SAM) tones, whose spectral content was constrained to be no lower than 3.8 kHz, was assessed. Overall, relatively large extents of laterality were obtained from all four listeners for ITDs of low-frequency bands of noise. Increasing the bandwidth of these noises did not yield consistent changes in the extent of laterality across ITDs and listeners. Most targets centered at high frequencies were lateralized near the midline. However, three of the four listeners did exhibit rather large displacements of the intracranial image when the bandwidth of the high-frequency noises was 400 Hz or greater. Interestingly, ITDs within high-frequency SAM tones were relatively ineffective. Thus, it appears that ITDs of relatively wide-band, high-frequency stimuli can mediate rather substantial extents of laterality. However, these effects are highly listener-dependent.     

声发射特性与材料断裂韧性相关性研究

以高强度铝合金的断裂过程为研究对象，利用先进的声发射试验系统，考察了拉伸试样和带有预制疲劳裂纹的DCB试样在断裂时的声发射事件特性，揭示了材料断裂韧性和声发射特性 间的关系.试验结果表明，材料稳态裂纹扩展起始于K_1C并发射出许多幅值超过 阈值35 dB的信号，材料裂纹失稳扩展时爆发出强烈的声发射信号，材料断裂的累积声发射能与宏 观断裂能呈线性关系. 关键词： 声发射 断裂韧性 铝合金