锌锅中低Pr流体混合对流的自维持振荡

本文对以带钢连续热镀锌为背景抽象出的锌锅中低Pr流体的流动和传热进行了数值模拟.数值结果显示,对Re=0的纯自然对流,Ra在104和105间时数值解由稳态解分岔为振荡解;对于Ra=0的纯强制对流,Re在4×103和5x1003之间时,数值解从稳态解分岔为振荡解;当Ra和Re均小于自然对流和强制对流单一机制作用时发生振荡的临界值时,混合对流的流动和传热为稳态;当Ra和Re中的一个参数大于单一机制作用发生振荡的临界值时,另一个参数由小于增加到大于单一机制作用发生振荡的临界值时,数值解由振荡解变为稳态解.     

具有隔板的平行通道内空气混合对流换热数值模拟

本文以锅炉干排渣装置为背景,对抽象的理论模型具有隔板的平行通道内空气混合对流换热进行了数值模拟.数值计算表明,在Re＞1000时应采用非稳态数学模型进行数值模拟;在Re＞500时,自然对流机制对流动和换热的影响基本可以忽略.数值计算给出了不同Re时的进出口无量纲压差、局部的Nux和平均Nu以及流线图.这些结果可为深入研究干排渣装置中流动和换热特性提供参考.     

底部加热长方体腔内自然对流的非线性特性

采用SIMPLE算法,QUICK差分格式,对底部加热三维长方体腔内空气的自然对流进行了数值模拟。根据模拟结果,探讨了方腔内流体流动与换热的静态分岔与振荡等非线性现象。数值结果显示,在固定的几何尺寸和不同Ra的情况下,当初始场不同时,会出现若干不同的解,即存在解的静态分岔;在固定的几何尺寸和相同的初始场情况下,低Ra时流动和换热处于稳态,当Ra超过某一临界值时,流动和换热就会随时间振荡,并通过倍周期分岔过渡到混沌;当方腔的几何尺寸不同时,分岔点的特征值Ra也发生变化。     

封闭圆内开缝圆自然对流换热的振荡特性

本文通过数值计算探讨了封闭圆内开缝圆自然对流换热的振荡特性。数值计算以整个圆为计算区域,采用了非稳态的数学模型和具有QUICK差分格式的SIMPLE算法。在相同条件下计算结果和实验结果符合很好。数值结果显示, 当几何结构一定时,Rayleigh数Ra小于某个临界值时,流动和换热处于稳态,并且关于垂直中心线对称;Ra大于这个临界值时,流动和换热是振荡的,非对称的。数值实验还表明,流动和换热出现振荡时的临界Rayleigh数Rac与开缝圆的开缝度有关,且流动和换热的振荡会出现对称振荡和非对称振荡两种情形。     

方腔内竖直板混合对流换热的数值模拟

对方腔内竖直板的层流混合对流换热进行了数值模拟.结果表明,竖直板处于水平方向两个不同位置时,竖直板背风面的混合对流换热量大于纯自然对流换热量.送风口高度比取0.667、0.767时,竖直板背风面的混合对流换热量大于纯自然对流换热量.当送风口高度比为0.167～0.467、0.767～0.867区间内,流动与换热得到定常解.在送风口高度比大于0.467小于0.767范围内,流动与换热为非定常解.     

水平空气层自然对流换热的分岔和振荡

本文用SIMPLE算法对底部加热的水平空气层的自然对流换热进行了数值计算,研究了这种空气层的流动与换热数值解的振荡和分岔问题。结果表明,对流与换热存在分岔情况。分岔存在一个临界Ra。分岔的临界值与Pr相关,随着Pr的增大,其相应的临界Ra也增大。但当Ra取到5×10~6,这种空气层的对流和换热没有发生振荡。     

水平板自然对流换热的非线性特性

采用SIMPLE算法,QUICK差分方案,对封闭方腔内水平板自然对流换热进行了数值模拟.数值结果显示,低Ra数时流动和换热处于稳态,当Rayleigh数超过某一临界值时,流动和换热就会发生非稳态振荡,此时流动和换热表现出非对称性.对不同Rayleigh数,流动和换热通过单周期分岔从稳态过渡到非稳态,并通过倍周期分岔过渡到混沌.在混沌区,仍然会出现周期性窗口,并且数值结果与初始条件有关.     

槽内热磁耦合流动换热数值模拟

数值模拟研究了矩形槽内导电流体由于焦耳热作用和电磁力共同作用引起的流动换热现象.数值结果表明,在给定流体性质情况下,焦耳热作用引起对流为两涡,电磁力作用时获得四涡流动,随Ha数的增加,电磁力驱动对流作用增大,热、磁共同作用时,流场温度场与Ha2Pr/Ra大小有关,从而影响到对流换热的强弱,在临界Ha2Pr/Ra以下,焦耳热引起的对流为主,Ha数增加,减弱换热;在临界日Ha2Pr/Ra以上,电磁力驱动的对流为主,Ha数增加,换热强化.     

降压地面模拟技术中的临界压力研究

利用降压地面模拟技术,可以抑制自然对流的影响,从而通过地面试验结果还原空间密封舱内的流动换热情况.降压法的关键在于确定临界压力,使得自然对流对流动换热的影响刚好得到忽略.本文使用数值模拟方法确定临界压力比,以方腔密封舱内的流动换热情况为例,计算了不同 Gr/Re2 数和压力比下密封舱内的流动换热情况.得到了舱内气体温度分布和对流换热系数.通过比较空间情况和地面情况的计算结果,分析了自然对流给流动换热带来的影响,给出了判断临界压力的准则式,并给出了临界 Gr/Re2 数.     

周期性矩形槽通道内对流换热的振荡

采用非稳态数学模型,通过数值模拟对周期性矩型槽通道内流动和换热的振荡特性进行了研究。结果表明:随着Re的增大,对流换热从入口后某一个几何周期开始振荡,振幅沿着通道逐渐增加,并经过若干周期后振幅基本不变;对于不同的Re开始振荡的几何周期数不同;当振幅基本不变时,各几何周期的平均Nu及相应点的速度按时间的平均值基本相等,表明振荡的流动和换热特征参数的时均值仍然具有周期性充分发展的特征;通道中突出物高度对振荡有显著影响,突出部分越高,开始振荡的几何周期数越小。     

非稳态横掠管束周期性充分发展对流换热的数值模拟

本文采用非稳态数学模型对横掠管束的周期性充分发展流动与换热进行了数值模拟。结果显示,在所考虑的参数条件下,Re≥100以后流场和温度场随时间发生振荡,并且振幅随Re增加而增大;进一步增加Re到一定值后,在管束间会有交替出现的涡。计算得到的平均Nusselt数与现有文献中的实验关联式基本是吻合的。平均Nusselt数的计算值随流动方向管间距的增加而增加。     

Experimental Investigation of Mixed Convection in a Channel With an Open Cavity

Mixed convection in an open cavity with a heated wall bounded by a horizontally unheated plate is investigated experimentally. The cavity has the heated wall on the inflow side. Mixed convection fluid flow and heat transfer within the cavity is governed by the buoyancy parameter, Richardson number (Ri), and Reynolds number (Re). The results are reported in terms of wall temperature profiles of the heated wall and flow visualization for Re = 100 and 1000, Ri in the range 30–110 (for Re = 1000) and 2800–8700 (for Re = 100), the ratio of the length to the height of cavity (L/D) is in the range 0.5–1.5, and the ratio of the channel height to cavity height (H/D) is in the range of 0.5 and 1.0. The present results show that the maximum dimensional temperature rise values decrease as the Reynolds and the Richardson numbers decrease. The flow visualization points out that for Re = 1000 there are two nearly distinct fluid motions: a parallel forced flow in the channel and a recirculation flow inside the cavity. For Re = 100 the effect of a stronger buoyancy determines a penetration of thermal plume from the heated plate wall into the upper channel. Nusselt numbers increase when L/D increase in the considered range of Richardson numbers.     

Laminar free convection heat transfer between vertical isothermal plates

The paper represents results on numerical investigation of flow and heat transfer between two isothermal vertical plates under laminar natural convection. A system of complete Navier–Stokes equations is solved for a two-dimensional gas flow between the plates along with additional rectangular regions (connected to inlet and outlet sections), whose characteristic sizes are much greater than the spacing between the plates. The calculations were performed over very wide ranges of Rayleigh number Ra = 10 ÷ 10⁵ and a relative channel length AR = L/w = 1 ÷ 500. The influence of the input parameters on the gas-dynamic and thermal structure of thermogravitational convection, the local and mean heat transfer, and also the gas flow rate between the plates (convective draft. We determined sizes of the regions and regime parameters when the local heat flux on the walls tends to zero due to the gas temperature approach to the surface temperature. It is shown that the mean heat transfer decreases as the relative channel length AR grows, whereas the integral gas flow rate (convective draft) and Reynolds number in the channel Re = 2wUm/ν increase. The use of a modified Rayleigh number Ra* = Ra · (w/L) (Elenbaas number) leads to generalization of calculation data on mean heat transfer. These data are in good agreement with the correlations for heat transfer [1, 2] and gas flow rate [3]. The reasons of variation of the data in the range of low Rayleigh numbers are discussed in detail.     

Lattice Boltzmann simulation of 3-dimensional natural convection heat transfer of CuO/water nanofluids

The present study investigated fluid flow and natural convection heat transfer in an enclosure embedded with isothermal cylinder. The purpose was to simulate the three-dimensional natural convection by thermal lattice Boltzmann method based on the D3Q19 model. The effects of suspended nanoparticles on the fluid flow and heat transfer analysis have been investigated for different parameters such as particle volume fraction, particle diameters, and geometry aspect ratio. It is seen that flow behaviors and the average rate of heat transfer in terms of the Nusselt number (Nu) are effectively changed with different controlling parameters such as particle volume fraction (5 % ≤ φ ≤ 10 %), particle diameter (d _p = 10 nm to 30 nm) and aspect ratio (0.5 ≤ AR ≤ 2) with fixed Rayleigh number, Ra = 10⁵. The present results give a good approximation for choosing an effective parameter to design a thermal system.     

竖直圆管中超临界压力CO2对流换热实验研究

本文对超临界压力CO2在竖直加热圆管内的对流换热进行了实验研究,比较了不同流向、不同热流密度等对流动和换热的影响。实验结果表明,管内径为2mm时,在低进口Re条件下,由于浮升力影响导致层流向湍流提前转变, 对流换热增强;与向上流动相比,向下流动更易由层流转变为湍流;向下流动的换热要强于向上流动,表明浮升力对换热有很大影响。对于管内径为0．27 mm的微细圆管,当进口Re高于104时,浮升力的影响可以忽略,对流换热系数的变化完全由物性的变化尤其是cp的变化导致。     

Transient mixed convection in a channel with two facing discretely heated semicircular cavities: Buoyancy,inclination angle,and channel aspect ratio effects

Space-averaged surface temperature distributions and overall Nusselt number measurements have been carried out to study the transient mixed convection heat transfer in a channel with two facing and symmetrically heated semicircular cavities. Effects of buoyancy, channel orientation, and channel aspect ratio on thermal behavior have been investigated from Re 500 to 1,500. Depending on the parametric set, steady, oscillatory, and irregular thermal regimes have been identified. The natural frequencies and time scales of the oscillatory regimes have been obtained using spectral analysis. Results show that with increase in channel aspect ratio, the heat transfer performance reduces for all inclination angles.     

方形通道内非牛顿流体的强化传热

对非牛顿流体在小尺寸方形通道内的低雷诺数受迫对流传热进行了实验研究。实验用介质为１５００ｗｐｐｍＣａｒｂｏｐｏｌ－９３４中性水溶液。通道顶壁受到等热流加热。结果表明，流体粘弹性与传热的相互作用取决于雷诺数的大小。当表观雷诺数Ｒｅ＞１１．５时，非牛顿流体开始强化对流传热。Ｒｅ数越高，传热强化的程度越大。流体的阻力系数则几乎不受粘弹性的影响。     

Heat transfer and fluid flow of benard-cell convection in rectangular container with free surface sensed by infrared thermography

The natural convection flow phenomena that occur inside an enclosed space are very interesting examples of complex fluid systems that may yield to analytical, empirical and numerical solutions, and many reports have looked into this basic problem. In the present study, heat transfer and fluid flow for natural convection in a horizontal rectangular container with a free surface are investigated using infrared thermography. The temperature field was measured and visualized at a gas-liquid (air — silicon oil) interface using infrared thermography. The heat transfer phenomena were also investigated by statistically analyzing the temperature data. The applicability of the infrared thermography to quantitative heat transfer measurement at the gas-liquid interface was evaluated. It is revealed that infrared thermography is effective not only in visualization of a gas-liquid interface but also in heat transfer measurement. A new heat transfer correlation is proposed for the gas-liquid interface of this flow system. The coefficient of heat transfer can be summarized by a specific heat transfer correlation formula regardless of several conditions, including container aspect ratio, fluid viscosity and fluid layer depth.     

b／a＝0．5的椭圆形通道内非牛顿流体的强化传热

对非牛顿流体在小尺寸椭圆形通道内的层流受迫对流传热进行了实验研究。实验介质为１５００Ｗｐｐｍ的Ｃａｒｂｏｐｏｌ－９３４中性水溶液。采用直接通电的方法对管壁四周等热流加热。结果表明，椭圆通道内，非牛顿流体Ｃａｒｂｏｐｏｌ水溶液的换热强于牛顿流体水，约高出水５０％左右，说明粘弹性流体在椭圆形通道内也产生二次流并能强化换热；与同种浓度的Ｃａｒｂｏｐｏｌ水溶液在方形通道内的换热结果相比，椭圆通道内的换热高于方形通道。流体的压力降则不受粘弹性的影响，仍符合幂律流体的阻力系数关系式（ｆ＝１６／Ｒｅ＊）。