固定转捩实验中粗糙带破损对翼型气动特性的影响研究

本文以RAE2822翼型前缘7%位置3mm宽的金刚砂粗糙带为例,研究了粗糙带破损对翼型压力分布的影响。实验结果表明：粗糙带破损会引起激波位置小幅移动,而对翼型后缘压力分布影响很小。当Ma=0.5时,粗糙带破损对升力系数的影响很小;在α≥4°以后粗糙带破损对阻力系数和俯仰力矩系数的影响逐渐增大,且破损位置距翼型中心对称面越远,影响越小。当Ma=0.75时,粗糙带破损对升力系数与阻力系数的影响直到α≥4°后开始逐渐增大,并且随着破损位置远离中心对称面而减弱;俯仰力矩系数对粗糙带破损较为敏感,且粗糙带破损的位置距离中心对称面越远、尺寸越小则影响越小。     

Dynamic stall behavior from unsteady force measurements

A direct force measurement technique employing piezoelectric load cells is used to experimentally investigate a two-dimensional airfoil (NACA 0012) undergoing dynamic stall. The load cells are installed at each end of the airfoil and give the force response in two directions in the plane normal to the airfoil axis during oscillations. Experiments are carried out at a Reynolds number based on the airfoil chord equal to 7.7×10⁴, and at four reduced frequencies, k=0.005, 0.01, 0.02, and 0.04. Phase-averaged lift of the airfoil undergoing dynamic stall is presented. It is observed that hysteresis loops of the lift occur both when the airfoil is pitched to exceed its static stall limit and when it is still within its static stall limit, and they grow in size with increasing k at the same pitching mean angle of attack and pitching amplitude. Both the lift and the drag induced by the pitching motion are further analyzed using the methods of higher order correlation analysis and continuous wavelet transforms to undercover their nonlinear and nonstationary features, in addition to classical FFT-based spectral analysis. The results are quantitatively illustrated by an energy partition analysis. It is found that the unsteady lift and drag show opposite trends when the airfoil undergoes transition from the pre-stall regime to the full-stall regime. The degree of nonlinearity of the lift increases, and the lift show a nonstationary feature in the light-stall regime, while the nonlinearity of the drag decreases, and the drag shows nonstationary feature in both the light-stall and the full-stall regimes. Furthermore, the lift and the drag have significant nonlinear interactions as shown by the correlation analysis in the light-stall regime.     

飞行器纵向俯仰气动特性计算研究

应用有限体积方法求解三维可压缩雷诺平均N-S方程,计算了巡航导弹外形飞行器作小振幅俯仰运动时的动态绕流流场和空气动力特性,开展了导弹绕不同转轴、以不同频率和在不同迎角范围内进行俯仰运动的非定常气动力迟滞特性研究。计算结果表明,当导弹作快速俯仰运动时,在上仰和下俯过程中的同一迎角瞬间,绕导弹流场流动明显不同,表现出明显的非定常迟滞特性。导弹的非定常气动力迟滞特性随俯仰运动频率的增大明显增强,且气动力迟滞曲线随着俯仰轴位置的变化而变化。在同一减缩频率下,导弹在不同迎角范围内作周期俯仰运动时,相同的运动相位角所对应的升力系数对迎角的导数是一致的,而不同减缩频率下升力系数对迎角的导数随运动相位角变化曲线明显不同。     

Influence of pitching angle of incidence on the dynamic stall behavior of a symmetric airfoil

This study presents the influence of pitch angle of an airfoil on its near-field vortex structure as well as the aerodynamic loads during a dynamic stall process. Dynamic stall behavior in a sinusoidally pitching airfoil is usually analyzed at low to medium reduced frequencies and with the maximum angle of attack of the airfoil not exceeding 25°. In this work, we study dynamic stall of a symmetric airfoil at medium to high reduced frequencies even as the maximum angle of attack goes from 25° to 45°. The evolution and growth of the laminar separation bubble, also known as a dynamic stall vortex, at the leading edge and the trailing edge are studied as the pitch cycle goes from the minimum to the maximum angle of attack. The effect of reduced frequencies on the vortex structure as well as the aerodynamic load coefficients is investigated. The reduced frequency is shown to be a bifurcation parameter triggering period doubling behavior. However, the bifurcation pattern is dependent on the variation of the pitch angle of incidence of the airfoil.     

Flow field characteristics study of a flapping airfoil using computational fluid dynamics

The flow field of a flapping airfoil in Low Reynolds Number (LRN) flow regime is associated with complex nonlinear vortex shedding and viscous phenomena. The respective fluid dynamics of such a flow is investigated here through Computational Fluid Dynamics (CFD) based on the Finite Volume Method (FVM). The governing equations are the unsteady, incompressible two-dimensional Navier-Stokes (N-S) equations. The airfoil is a thin ellipsoidal geometry performing a modified figure-of-eight-like flapping pattern. The flow field and vortical patterns around the airfoil are examined in detail, and the effects of several unsteady flow and system parameters on the flow characteristics are explored. The investigated parameters are the amplitude of pitching oscillations, phase angle between pitching and plunging motions, mean angle of attack, Reynolds number (Re), Strouhal number (St) based on the translational amplitudes of oscillations, and the pitching axis location (x/c). It is shown that these parameters change the instantaneous force coefficients quantitatively and qualitatively. It is also observed that the strength, interaction, and convection of the vortical structures surrounding the airfoil are significantly affected by the variations of these parameters.     

Assessment of 2D/3D numerical modeling for deep dynamic stall experiments

The results of computational fluid dynamics (CFD) simulations in two and three spatial dimensions are compared to pressure measurements and particle image velocimetry (PIV) flow surveys to assess the suitability of numerical models for the simulation of deep dynamic stall experiments carried out on a pitching NACA 23012 airfoil. A sinusoidal pitching motion with a 10° amplitude and a reduced frequency of 0.1 is imposed around two different mean angles of attack of 10° and 15°. The comparison of the airloads curves and of the pressure distribution over the airfoil surface shows that a three-dimensional numerical model can better reproduce the flow structures and the airfoil performance for the deep dynamic stall regime. Also, the vortical structures observed by PIV in the flow field are better captured by the three-dimensional model. This feature highlighted the relevance of three-dimensional effects on the flow field in deep dynamic stall.     

Aerodynamics of laminar separation flutter at a transitional Reynolds number

Experimental observations of self-sustained pitch oscillations of a NACA 0012 airfoil at transitional Reynolds numbers were recently reported. The aeroelastic limit cycle oscillations, herein labelled as laminar separation flutter, occur in the range 5.0×10⁴≤Re_c≤1.3×10⁵. They are well behaved, have a small amplitude and oscillate about θ=0°. It has been speculated that laminar separation leading to the formation of a laminar separation bubble, occurring at these Reynolds numbers, plays an essential role in these oscillations. This paper focuses on the Re_c=7.7×10⁴ case, with the elastic axis located at 18.6% chord. Considering that the experimental rig acts as a dynamic balance, the aerodynamic moment is derived and is empirically modelled as a generalized Duffing–van-der-Pol nonlinearity. As expected, it behaves nonlinearly with pitch displacement and rate. It also indicates a dynamically unstable equilibrium point, i.e. negative aerodynamic damping. In addition, large eddy simulations of the flow around the airfoil undergoing prescribed simple harmonic motion, using the same amplitude and frequency as the aeroelastic oscillations, are performed. The comparison between the experiment and simulations is conclusive. Both approaches show that the work done by the airflow on the airfoil is positive and both have the same magnitude. The large eddy simulation (LES) computations indicate that at θ=0°, the pitching motion induces a lag in the separation point on both surfaces of the airfoil resulting in negative pitching moment when pitching down, and positive moment when pitching up, thus feeding the LCO.     

带涡襟翼翼型流场的数值模拟

以数值计算为手段,分析了带涡襟翼的翼型的流场特性,分别对迎角及扰流板偏角对翼型气动性能的影响做了分析。结果表明,在小迎角来流情况下,保持迎角不变,涡襟翼偏转角度越大,升力越小,阻力越大,呈现较好的线性关系。在大迎角情况下,绕翼型的流动发生分离,通过适当控制涡襟翼的偏转角度,能够有效的改善翼型的失速特性,从而达到流动控制的目的,迎角越大,涡襟翼所需偏转的角度越大。     

Transonic limit cycle oscillation behavior of an aeroelastic airfoil with free-play

The limit cycle oscillation (LCO) behaviors of an aeroelastic airfoil with free-play for different Mach numbers are studied. Euler equations are adopted to obtain the unsteady aerodynamic forces. Aerodynamic and structural describing functions are employed to deal with aerodynamic and structural nonlinearities, respectively. Then the flutter speed and flutter frequency are obtained by V-g method. The LCO solutions for the aeroelastic airfoil obtained by using dynamically linear aerodynamics agree well with those obtained directly by using nonlinear aerodynamics. Subsequently, the dynamically linear aerodynamics is assumed, and results show that the LCOs behave variously in different Mach number ranges. A subcritical bifurcation, consisting of both stable and unstable branches, is firstly observed in subsonic and high subsonic regime. Then in a narrow Mach number range, the unstable LCOs with small amplitudes turn to be stable ones dominated by the single degree of freedom flutter. Meanwhile, these LCOs can persist down to very low flutter speeds. When the Mach number is increased further, the stable branch turns back to be unstable. To address the reason of the stability variation for different Mach numbers at small amplitude LCOs, we find that the Mach number freeze phenomenon provides a physics-based explanation and the phase reversal of the aerodynamic forces will trigger the single degree of freedom flutter in the narrow Mach number range between the low and high Mach numbers of the chimney region. The high Mach number can be predicted by the freeze Mach number, and the low one can be estimated by the Mach number at which the aerodynamic center of the airfoil lies near its elastic axis. Influence of angle of attack and viscous effects on the LCO behavior is also discussed.     

Numerical investigation of transonic flow over deformable airfoil with plunging motion

In this article, the transonic inviscid flow over a deformable airfoil with plunging motion is studied numerically. A finite volume method based on the Roe scheme developed in a generalized coordinate is used along with an arbitrary Lagrangian-Eulerian method and a dynamic mesh algorithm to track the instantaneous position of the airfoil.The effects of different governing parameters such as the phase angle, the deformation amplitude, the initial angle of attack, the flapping frequency, and the Mach number on the unsteady flow field and aerodynamic coefficients are investigated in detail. The results show that maneuverability of the airfoil under various flow conditions is improved by the deformation. In addition, as the oscillation frequency of the airfoil increases, its aerodynamic performance is significantly improved.     

Effect of one-sided unsteady energy supply on aerodynamic characteristics of airfoils in a transonic flow

The possibility of controlling the aerodynamic characteristics of airfoils in transonic flight regimes by means of one-sided pulsed-periodic energy supply is studied. Based on the numerical solution of two-dimensional unsteady gas-dynamic equations, the change in the flow structure in the vicinity of a symmetric airfoil at different angles of attack and the aerodynamic characteristics of the airfoil as functions of the amount of energy supplied asymmetrically (with respect to the airfoil) are determined. The results obtained are compared with the data calculated for the flow past the airfoil at different angles of attack without energy supply. It is found that a given lift force can be obtained with the use of energy supply at a much better lift-to-drag ratio of the airfoil, as compared to the case of the flow past the airfoil at an angle of attack. The moment characteristics of the airfoil are found. __________ Translated from Prikladnaya Mekhanika i Tekhnicheskaya Fizika, Vol. 49, No. 6, pp. 82–87, November–December, 2008.     

Experimental analysis of passive bio-inspired covert feathers for stall and post-stall performance enhancement

Technologies inspired by the functioning and behavior of biological beings are commonly developed for aircraft flight. Among the bio-inspired approaches that have grown in interest, particularly for unmanned aerial vehicle flight, is based on the behavior of bird’s cover feathers under higher angles of attack. The covert feathers, when activated by separated flows, promote lift increment that helps in certain maneuvers. This work investigates the benefit in the stall and post-stall performance of employing bio-inspired covert feathers devices attached to an airfoil’s upper surface. To fill the gaps in the recent technical literature, experimental analysis of an SD7003 airfoil was executed in a wind tunnel with the application of bio-inspired covert feathers of different shapes and tapes in three chordwise positions. The bio-inspired devices were conceived to resemble the feathers’ lightness and discrete-distribution along with the wing model. Experiments were carried out measuring the aerodynamic forces and moment at Reynolds number around 170,000 for static and dynamic ramp-up and hold pitching motion. It has been confirmed that the use of bio-inspired covert feathers brought benefits to the stall and post-stall behavior of the airfoil. The maximum lift has increased, and the transition from attached to stalled flow around the airfoil tends to be smoother when the devices were used. Four shapes for the bio-inspired devices and three positions in chordwise direction were considered. The best performance among the case was encountered for a jagged bio-inspired device taped at a quarter-chord position. Indeed, the most forward position for all the devices resulted in higher maximum lift and increment to the respective angle of attack. Ramp-up and hold wind tunnel tests also confirmed the best performance of jagged bio-inspired devices nearer the leading edge. The aerodynamic response to the pitching motion showed that the stall and post-stall regime occur much smoother, indicating that the approach presents good potential for dynamic stall or gust response passive control.

     

Reynolds number, thickness and camber effects on flapping airfoil propulsion

The effect of varying airfoil thickness and camber on plunging and combined pitching and plunging airfoil propulsion at Reynolds number Re=200, 2000, 20 000 and 2×10⁶ was studied by numerical simulations for fully laminar and fully turbulent flow regimes. The thickness study was performed on 2-D NACA symmetric airfoils with 6-50% thick sections undergoing pure plunging motion at reduced frequency k=2 and amplitudes h=0.25 and 0.5, and for combined pitching and plunging motion at k=2, h=0.5, phase ?=90°, pitch angle θ_o=15° and 30° and the pitch axis was located at 1/3 of chord from leading edge. At Re=200 for motions where positive thrust is generated, thin airfoils outperform thick airfoils. At higher Re significant gains could be achieved both in thrust generation and propulsive efficiency by using a thicker airfoil section for plunging and combined motion with low pitch amplitude. The camber study was performed on 2-D NACA airfoils with varying camber locations undergoing pure plunging motion at k=2, h=0.5 and Re=20 000. Little variation in thrust performance was found with camber. The underlying physics behind the alteration in propulsive performance between low and high Reynolds numbers has been explored by comparing viscous Navier-Stokes and inviscid panel method results. The role of leading edge vortices was found to be key to the observed performance variation.     

Experimental study of wings undergoing active root flapping and pitching

This paper presents the results of experiments carried out on mechanical wings undergoing active root flapping and pitching in the wind tunnel. The objective of the work is to investigate the effect of the pitch angle oscillations and wing profile on the aerodynamic forces generated by the wings. The experiments were repeated for a different reduced frequency, airspeed, flapping and pitching kinematics, geometric angle of attack and wing sections (one symmetric and two cambered airfoils). A specially designed mechanical flapper was used, modelled on large migrating birds. It is shown that, under pitch leading conditions, good thrust generation can be obtained at a wide range of Strouhal numbers if the pitch angle oscillation is adjusted accordingly. Consequently, high thrust was measured at both the lowest and highest tested Strouhal numbers. Furthermore, the work demonstrates that the aerodynamic forces can be sensitive to the Reynolds number, depending on the camber of the wings. Under pitch lagging conditions, where the effective angle of attack amplitude is highest, the symmetric wing was affected by the Reynolds number, generating less thrust at the lowest tested Reynolds value. In contrast, under pure flapping conditions, where the effective angle of attack amplitude was lower but still significant, it was the cambered wings that demonstrated Reynolds sensitivity.     

横摆振荡翼型动态气动掠效应试验研究

大型风力机设计对获取翼型更加全面、准确的动态载荷提出更高要求, 研究翼型横摆振荡动态气动特性具有重要意义. 借助"电子凸轮"技术和动态数据同步采集手段, 针对翼型动态“掠效应”首次开展了横摆振荡风洞试验研究, 研究表明: 横摆振荡翼型的气动曲线存在明显迟滞效应, 吸力面压力周期性波动是主要诱因, 且随着振荡频率、初始迎角和振幅的增大, 气动迟滞特性均增强; 升力和压差阻力随横摆角变化的迟滞回线呈"W"形, 俯仰力矩迟滞回线呈"M"形, 升力差量迟滞回线呈"$\infty$"形; 负行程下翼型气动力相对于正行程下的更高, 且负行程下翼型气动力随振荡频率的增大而略有增大, 正行程下则明显减小; 升力系数功率谱密度分布在振荡频率倍频处的能量集中的幅值随着振荡频率增大有增大趋势; 吸力面1.2%和40%弦长处压力的滞回特性较强, 是由于翼面剪切层涡和动态分离涡周期性发展、运动、破裂和重建; 振幅为$10^{\circ}$时, 升力迟滞曲线呈"$^{\wedge}$"形, 振幅为$30^{\circ}$ 时, 升力迟滞曲线呈"$^{\wedge\wedge\wedge}$"形.      

Numerical investigations into the asymmetric effects on the aerodynamic response of a pitching airfoil

The effects of asymmetric sinusoidal motion on pitching airfoil aerodynamics were studied by numerical simulations for 2-D flow around a NACA0012 airfoil at Re=1.35×10⁵. Various unsteady parameters (amplitude of oscillation, d; reduced frequency, k) were applied to investigate the effect of asymmetry parameter S on the instantaneous force coefficients and flow patterns. The results reveal that S has a noticeable effect on the aerodynamic performance, as it affects the instantaneous force coefficient, maximum lift and drag coefficient, hysteresis loops and the flow structures.     

Effect of uncertainty on the bifurcation behavior of pitching airfoil stall flutter

In this paper the effect of system parametric uncertainty on the stall flutter bifurcation behavior of a pitching airfoil is studied. The aerodynamic moment on the two-dimensional rigid airfoil with nonlinear torsional stiffness is computed using the ONERA dynamic stall model. The pitch natural frequency, a cubic structural nonlinearity parameter, and the structural equilibrium angle are assumed to be uncertain. The effect on the amplitude of the response, the bifurcation of the probability distribution, and the flutter boundary is considered. It is demonstrated that the system parametric uncertainty results already in 5% probability of pitching stall flutter at a 12.5% earlier position than the point where a deterministic analysis would predict unstable behavior. Probabilistic collocation is found to be more efficient than the Galerkin polynomial chaos method and Monte Carlo simulation for modeling uncertainty in the post-bifurcation domain.     

Delayed detached eddy simulations of fighter aircraft at high angle of attack

The massively separated flows over a realistic aircraft configuration at 40?, 50?, and 60?angles of attack are studied using the delayed detached eddy simulation(DDES).The calculations are carried out at experimental conditions corresponding to a mean aerodynamic chord-based Reynolds number of 8.93 × 10~5 and Mach number of 0.088. The influence of the grid size is investigated using two grids, 20.0×10~6cells and 31.0 × 10~6 cells. At the selected conditions, the lift,drag, and pitching moment from DDES predictions agree with the experimental data better than that from the Reynoldsaveraged Navier–Stokes. The effect of angle of attack on the flow structure over the general aircraft is also studied, and it is found that the dominated frequency associated with the vortex shedding process decreases with increasing angle of attack.     

An experimental study on boundary layer transition detection over a pitching supercritical airfoil using hot-film sensors

In the present work, experimental tests are conducted to study boundary layer transition over a supercritical airfoil undergoing pitch oscillations using hot-film sensors. Tests have been undertaken at an incompressible flow. Three reduced frequencies of oscillations and two mean angles of attack are studied and the influences of those parameters on transition location are discussed. Different algorithms are examined on the hot-film signals to detect the transition point. Results show the formation of a laminar separation bubble near the leading edge and at relatively higher angles of attack which leads to the transition of the boundary layer. However, at lower angles of attack, the amplification of the peaks in voltage signal indicate the emergence of the vortical structures within the boundary layer, introducing a different transition mechanism. Moreover, an increase in reduced frequency leads to a delay in transition onset, postponing it to a higher angle of attack, which widens the hysteresis between the upstroke and downstroke motions. Rising the reduced frequency yields in weakening or omission of vortical disturbances ensuing the removal of spikes in the signals. Of the other important results observed, is faster movement of the relaminarization point in the higher mean angle of attack. Finally, a time–frequency analysis of the hot-film signals is performed to investigate evolution of spectral features of the transition due to the pitching motion. An asymmetry is clearly observed in frequency pattern of the signals far from the bubble zone towards the trailing edge; this may reflect the difference between the transition and relaminarization physics. Also, various ranges of frequency were obtained for different transition mechanisms.     

低雷诺数俯仰振荡翼型等离子体流动控制

针对低雷诺数翼型气动性能差的特点, 通过介质阻挡放电(dielectric barrier discharge, DBD)等离子体激励控制的方法, 提高翼型低雷诺数下的气动特性,改善其流场结构. 采用二维准直接数值模拟方法求解非定常不可压Navier-Stokes方程,对具有俯仰运动的NACA0012翼型的低雷诺数流动展开数值模拟.同时将介质阻挡放电激励对流动的作用以彻体力源项的形式加入Navier-Stokes方程,通过数值模拟探究稳态DBD等离子体激励对俯仰振荡NACA0012翼型气动特性和流场特性的影响.为了进行流动控制, 分别在上下表面的前缘和后缘处安装DBD等离子体激励器,并提出四种激励器的开环控制策略,通过对比研究了这些控制策略在不同雷诺数、不同减缩频率以及激励位置下的控制效果.通过流场结构和动态压强分析了等离子体进行流场控制的机理. 结果表明,前缘DBD控制中控制策略B(负攻角时开启上表面激励器,正攻角时开启下表面激励器)效果最好,后缘DBD控制中控制策略C(逆时针旋转时开启上表面激励器,顺时针旋转时开启下表面激励器)效果最好,前缘DBD控制效果会随着减缩频率的增大而下降, 同时会导致阻力增大.而后缘DBD控制可以减小压差阻力, 优于前缘DBD控制,对于计算的所有减缩频率(5.01~11.82)都有较好的增升减阻效果.在不同雷诺数下, DBD控制的增升效果较为稳定, 而减阻效果随着雷诺数的降低而变差,这是由流体黏性效应增强导致的.