| 两种润滑介质下关节软骨摩擦行为的对比研究 |
| |
| 引用本文： | 钱善华,刘利国,倪自丰,葛世荣.两种润滑介质下关节软骨摩擦行为的对比研究[J].摩擦学学报,2013,33(5):488-494. |
| |
| 作者姓名： | 钱善华 刘利国 倪自丰 葛世荣 |
| |
| 作者单位： | 江南大学 机械工程学院, 江苏 无锡 214122;江南大学 机械工程学院, 江苏 无锡 214122;江南大学 机械工程学院, 江苏 无锡 214122;中国矿业大学 摩擦学与可靠性工程研究所, 江苏 徐州 221116 |
| |
| 基金项目： | 国家自然科学基金重点项目(50535050)和清华大学摩擦学国家重点实验室开放基金项目(SKLTKF12B09)资助. |
| |
| 摘 要： | 通过对两种润滑介质下关节软骨摩擦行为的对比研究,探讨软骨摩擦行为的影响因素.以牛膝关节软骨为摩擦副,以生理盐水和50%小牛血清溶液为润滑介质,在UMT-2试验机上分别测定软骨摩擦副的接触变形和摩擦系数,以及两种润滑介质在软骨表面的接触角.结果表明:滑动时接触变形是由软骨变形量和波动变形组成,软骨变形量与时间呈非线性增加,波动变形与时间呈周期非线性变化;软骨表面轮廓对波动变形和摩擦系数有着显著的影响;生理盐水的接触角低于小牛血清溶液的接触角,生理盐水的软骨变形量和摩擦系数均略高于小牛血清溶液的变形量和摩擦系数,其差异可能是边界润滑的效果.
|
| 关 键 词： | 关节软骨 表面轮廓 波动变形 摩擦系数 边界润滑 |
| 修稿时间： | 7/9/2013 12:00:00 AM |
Comparative Investigation of the Friction Behaviour of Natural Articular Cartilage Based on Two Lubricants |
| |
| QIAN Shan-hu,LIU Li-guo,NI Zi-feng and GE Shi-rong.Comparative Investigation of the Friction Behaviour of Natural Articular Cartilage Based on Two Lubricants[J].Tribology,2013,33(5):488-494. |
| |
| Authors: | QIAN Shan-hu LIU Li-guo NI Zi-feng and GE Shi-rong |
| |
| Institution: | School of Mechanical Engineer, Jiangnan University, Wuxi 214122, China;School of Mechanical Engineer, Jiangnan University, Wuxi 214122, China;School of Mechanical Engineer, Jiangnan University, Wuxi 214122, China;Institute of Tribology and Reliability Engineering, China University of Mining and Technology, Xuzhou 221116, China |
| |
| Abstract: | Base on the comparative investigation of the friction behavior of nature articular cartilage using two lubricants, the effect factors on the cartilage friction were discussed. Contact deformation and coefficient of friction between bovine knee cartilage pairs were measured on two kinds of saline solution and 50% bovine serum using UMT-2 Multi2 specimen test system. Contact angles of two lubricants on the cartilage surface were also obtained. These results show that contact deformation was made up of cartilage deformation and wavy deformation. Cartilage deformation functioned as a nonlinear relation with time while wavy deformation as a nonlinearly periodic relation with time. Surface profiles of the cartilage samples played an obvious role on the wavy deformation and coefficient of friction. Contact angle of saline solution was lower than that of bovine serum while cartilage deformation and coefficient of friction based on the lubricant of the saline solution were higher than those of bovine serum. These differences between tow lubricants may be caused by boundary lubrication. |
| |
| Keywords: | articular cartilage surface profile wave deformation coefficient of friction boundary lubrication |
|
| 点击此处可从《摩擦学学报》浏览原始摘要信息 |
| 点击此处可从《摩擦学学报》下载免费的PDF全文 |
|
