衬底温度对MOCVD法沉积ZnO透明导电薄膜的影响

研究了衬底温度对MOCVD技术制备的ZnO薄膜的微观结构和光电特性影响. XRD和SEM的研究结果表明，衬底温度对ZnO薄膜的微观结构有显著影响，明显的形貌转变温度大约发生在175℃，低于175℃，薄膜呈镜面结构，晶粒为球状，高于177℃的较高温度范围，薄膜从“类金字塔”状的绒面结构演化为“岩石”状显微组织；随着温度增加，薄膜的晶粒尺寸明显增大.绒面结构的未掺杂ZnO薄膜具有17.96 cm²/V·s的高迁移率和3.28×10^-2 Ω·cm的低电阻率，对ZnO薄膜的进一步掺杂和结构优化有望应用于Si薄膜太阳电池的前电极. 关键词： MOCVD ZnO薄膜 透明导电氧化物 太阳电池     

提高微晶硅薄膜太阳电池效率的研究

采用甚高频等离子体增强化学气相沉积技术制备了系列微晶硅薄膜太阳电池，指出了气体总流量和背反射电极的类型对电池性能参数的影响.电池的I-V测试结果表明：随反应气体总流量的增加，对应电池的短路电流密度、开路电压和填充因子都有很大程度的提高，结果使得电池的光电转换效率得以提高.另外，ZnO/Ag/Al背反射电极能明显提高电池的短路电流密度，进而也提高了电池的光电转换效率.对气体总流量和背反射电极类型影响电池效率的原因进行了分析. 关键词： 微晶硅薄膜太阳电池 气体流量 ZnO/Ag/Al背反射电极     

Research on the boron contamination at the p/i interface of microcrystalline silicon solar cells deposited in a single PECVD chamber

This paper studies boron contamination at the interface between the p and i layers of μ c-Si:H solar cells deposited in a single-chamber PECVD system. The boron depth profile in the i layer was measured by Secondary Ion Mass Spectroscopy. It is found that the mixed-phase μ c-Si:H materials with 40% crystalline volume fraction is easy to be affected by the residual boron in the reactor. The experimental results showed that a 500-nm thick μ c-Si:H covering layer or a 30-seconds of hydrogen plasma treatment can effectively reduce the boron contamination at the p/i interface. However, from viewpoint of cost reduction, the hydrogen plasma treatment is desirable for solar cell manufacture because the substrate is not moved during the hydrogen plasma treatment.     

甚高频等离子体增强化学气相沉积法沉积μc-Si∶H薄膜中氧污染的初步研究

对不同的本底真空条件下,采用甚高频等离子体增强化学气相沉积技术沉积的氢化微晶硅（μc_Si∶H）薄膜中的氧污染问题进行了比较研究.对不同氧污染条件下制备的薄膜样品的x射线光电子能谱与傅里叶变换红外吸收光谱测量结果表明：μc_Si∶H薄膜中,氧以Si—O，O—O和O—H三种不同的键合模式存在,不同的键合模式源自不同的物理机理.μc_Si∶H薄膜的Raman光谱、电导率与激活能的测量结果进一步显示：沉积过程中氧污染程度的不同,对μc_Si∶H薄膜的结构特性与电学特性产生显著影响；而不同氧污染对μc_Si∶H薄膜电学特性的影响不同于氢化非晶硅（a_Si:H）薄膜. 关键词： 氢化微晶硅薄膜 甚高频等离子体增强化学气相沉积 氧污染     

Influence of reaction gas flows on the properties of SiGe:H thin film prepared by plasma assisted reactive thermal chemical vapour deposition

A new preparing technology, very high frequency plasma assisted reactive thermal chemical vapour deposition （VHFPA-RTCVD）, is introduced to prepare SiGe：H thin films on substrate kept at a lower temperature. In the previous work, reactive thermal chemical vapour deposition （I~TCVD） technology was successfully used to prepare SiGe：H thin films, but the temperature of the substrate needed to exceed 400℃. In this work, very high frequency plasma method is used to assist RTCVD technology in reducing the temperature of substrate by largely enhancing the temperature of reacting gases on the surface of the substrate. The growth rate, structural properties, surface morphology, photo- conductivity and dark-conductivity of SiGe：H thin films prepared by this new technology are investigated for films with different germanium concentrations, and the experimental results are discussed.     

Al2O3薄膜/纳米Ag颗粒复合结构的光吸收谱及增强Raman散射光谱研究

Al₂O₃介质薄膜与纳米Ag颗粒构成的复合结构,被应用于表面增强Raman散射探测实验中,其中Al₂O₃介质薄膜对纳米Ag颗粒的吸收谱及增强Raman散射光谱的影响被特别关注.该复合结构的光学特性表征出纳米Ag颗粒的偶极振荡特性.从光吸收谱中可以看到,其共振吸收谱随Al₂O₃介质薄膜厚度增加而在整个谱域上发生红移,表明纳米Ag颗粒的周围介电常数随Al₂O₃介质薄膜厚度的增加而增大.采用罗丹明6G作为探针原子,6个Raman特征峰的平均增益值作为表征表面增强Raman散射衬底增益程度的量度.实验结果表明,Al₂O₃介质薄膜层的引入提高了纳米Ag颗粒的衬底介电常数,并引起了散射共振的增强,从而使表面增强Raman散射强度提高.     

薄膜太阳电池的研究进展

介绍了薄膜太阳电池在光伏技术中的位置,详细叙述了非晶硅,铜铟锡,碲化镉等主要薄膜太阳电池的基本结构,制造方法,研究进展和现状,指出了存在的关键问题和解决的途径,并介绍了薄膜太阳电池的发展趋势和应用前景。     

Open-circuit voltage analysis of p-i-n type amorphous silicon solar cells deposited at low temperature

This paper identifies the contributions of p-a-SiC:H layers and i-a-Si:H layers to the open circuit voltage of p-i-n type a-Si:H solar cells deposited at a low temperature of 125 C.We find that poor quality p-a-SiC:H films under regular conditions lead to a restriction of open circuit voltage although the band gap of the i-layer varies widely.A significant improvement in open circuit voltage has been obtained by using high quality p-a-SiC:H films optimized at the "low-power regime" under low silane flow rates and high hydrogen dilution conditions.     

甚高频等离子体增强化学气相沉积制备微晶硅太阳电池的研究

采用甚高频等离子体增强化学气相沉积技术成功地制备了不同硅烷浓度和辉光功率条件下的微晶硅电池.电池的J-V测试结果表明：在实验的硅烷浓度和功率范围内，随硅烷浓度的降低和功率的加大，对应电池的开路电压逐渐变小；硅烷浓度的不同对电池的短路电流密 度有很大的影响，但功率的影响在实验研究的范围内不是很显著.对于微晶硅电池，N层最好 是非晶硅，这是因为一方面可以降低对电流的横向收集效应，另一方面也降低了电池的漏电概率，提高了电池的填充因子. 关键词： 微晶硅太阳电池 甚高频等离子体增强化学气相沉积     

薄膜厚度对MOCVD法沉积ZnO透明导电薄膜的影响

本文研究了薄膜厚度对MOCVD技术制备未掺杂ZnO薄膜的微观结构和电学特性影响.XRD和SEM的研究结果表明,随着薄膜厚度的增加,ZnO薄膜(110)峰趋于择优取向,且晶粒逐渐长大,薄膜从球状和细长棒状演变为具有类金字塔绒面结构特征的ZnO薄膜;Hall测量表明,较厚的ZnO薄膜有助于提高薄膜电学特性,可归于晶粒长大和晶体质量提高.40min沉积时间(膜厚为1250nm)制备出的ZnO薄膜具有明显绒面结构,其晶粒尺寸为300～500nm,电阻率为7.9×10-3Ω·cm,迁移率为26.8cm2/Vs.