PREPARATION AND ELECTROCHEMICAL CHARACTERISTICS OF POLYMER ELECTROLYTE MEMBRANES BASED ON SAN/PVDF-HFP BLENDS

A copolymer of poly(acrylonitrile-co-styrene) (SAN) was synthesized via an emulsion polymerization method. Novel polymer electrolyte membranes cast from the blends of poly(vinylidene fluoride-co-hexafluoropropylene) (PVDF-HFP), SAN and fumed silica (SiO2) are microporous and can be used in polymer lithium-ion batteries. The membrane shows excellent characteristics such as high ionic conductivity and good mechanical strength when the mass ratio between SAN and PVDF-HFP and SiO2 is 3.5/31.5/5. The ionic conductivity of the membrane soaked in a liquid electrolyte of 1 mol/L LiPF6/EC/DMC/DEC is 4.9×10-3 S cm-1 at 25℃. The membrane is electrochemical stable up to 5.5 V versus Li /Li in the liquid electrolyte. The influences of SiO2 content on the porosity and mechanical strength of the membranes were studied. Polymer lithium-ion batteries based on the membranes were assembled and their performances were also studied.     

羧基丁苯-纳米氧化硅复合粉末增韧聚苯乙烯的研究

用直接分散聚合法制备了羧基丁苯-纳米氧化硅杂化胶乳,经喷雾干燥得到的羧基丁苯-纳米氧化硅复合粉末通过本体-悬浮聚合和熔融共混法制备了高抗冲聚苯乙烯.结果表明,本体/悬浮聚合法中预聚转化率的控制与复合粉末的加入量有关,当加入的复合粉末的质量分数为0.05时,冲击强度可提高5倍,也高于熔融共混法所制备的改性聚苯乙烯.本体/悬浮聚合法制备的改性聚苯乙烯的热分解温度（Td）高于熔融共混法改性的,且Td随复合粉末加入量的增加而提高,但改性聚苯乙烯的刚性有一定程度的降低,而对材料的玻璃化转变温度影响不大.     

原位聚合法制备聚醋酸乙烯酯/纳米SiO2复合乳液

采用原位乳液聚合法制备了聚醋酸乙烯酯／纳米二氧化硅复合浮液。用红外光谱、原子力显微镜以及透射电镜等现代测试手段对复合材料进行了表征．考察了纳米二氧化硅在聚醋酸乙烯酯乳液中的分散状况及纳米二氧化硅用量对复合浮液性能的影响。结果表明：随纳米二氧化硅用量增加,复合乳液的干态,湿态粘接强度均而明显提高;乳液的粘度减小;复合乳液的胶膜耐热性提高。     

Cation identity dependence of crown ether photonic crystal Pb<Superscript>2+</Superscript> sensing

We quantitatively modeled the volume phase transition of a hydrogel containing a crystalline colloidal array with a crown ether ligand which binds Pb²⁺. The hydrogel volume response and the wavelength diffracted depend on the Pb²⁺ concentration and on both the ionic strength and the valence of the nonbinding ionic species. We successfully modeled the response of this hydrogel Pb²⁺ sensor to ionic strength and the cation valence of the added salts. Figure Cation identity dependence of crown ether photonic crystal Pb⁺ sensing     

STUDY ON THE PROPERTIES OF BLEND OF NATURAL RUBBER LATEX/METHYL METHACRYLATE GRAFTED RUBBER LATEX BY GAMMA RADIATION

Natural rubber latex(NRL)and methyl methacrylate(MMA)grafted rubber latex were blended in different ratios and irradiated at various absorbed doses by gamma rays from Co-60 source at room temperature.The tensile properties, swelling ratio and permanent set were measured.The maximum tensile strength and modulus at 500% elongation were obtained at an absorbed dose of 8 kGy.Modulus increases from 6.99 MPa to 9.87 MPa for an increase in proportion of MMA grafted rubber from 40% to 60% in the blend at similar absorbed dose.Elongation at break and swelling ratio decrease with increasing absorbed dose as well as the MMA grafted rubber content in the blends.The decreasing trend of permanent set is high up to 5 kGy absorbed dose,and beyond that dose,it becomes almost flat.     

聚乙烯醇硫酸钾水凝胶电机械化学行为研究

通过将交联聚乙烯醇硫酸酯化的方法制备了一种新型电刺激响应性聚乙烯醇硫酸钾(PVSK)智能水凝胶,并探讨了溶液离子强度和pH对PVSK水凝胶的溶胀吸水率、机械性能以及电机械化学行为的影响.结果表明,制备的PVSK水凝胶的平衡溶胀比随NaCl溶液离子强度的增大而减小,在pH2.39～10.83范围内基本不受溶液pH的影响;经不同离子强度和pH的NaCl溶液充分溶胀的PVSK水凝胶具有良好的机械性能,在非接触的直流电场作用下,该水凝胶向电场负极弯曲,凝胶的弯曲速度和弯曲偏转量随外加电场强度的增加而增大,随NaCl溶液离子强度的增大出现临界最大值,但不随溶液pH(2.08～10.53)的改变而改变;在循环电场作用下,PVSK水凝胶的电机械化学行为具有良好的可逆性.     

SYNTHESIS, CHARACTERIZATION AND PROPERTIES OF ORGANOCLAY-MODIFIED POLYSULFONE/EPOXY INTERPENETRATING POLYMER NETWORK NANOCOMPOSITES

Organoclay-modified hydroxylterminated polysulfone (PSF)/epoxy interpenetrating network nanocomposites (oM-PSF/EP nanocomposites) were prepared by adding organophilic montmorillonite (oMMT) to interpenetrating polymer networks (IPNs) of polysulfone and epoxy resin (PSF/EP) using diaminodiphenylmethane (DDM) as curing agent.The mechanical properties like tensile strength,tensile modulus,flexural strength,flexural modulus and impact properties of the nanocomposites were studied as per ASTM standards.Differ...     

取代基对N—H…O＝C氢键三聚体中氢键强度的影响

使用MP2方法研究了氢键三聚体中N-H…O=C氢键强度,探讨了氢键受体分子中不同取代基对N-H…O=C氢键强度的影响.研究表明,不同取代基对氢键三聚体中N-H…O=C氢键强度的影响是不同的:取代基为供电子基团,氢键键长r(H…O)缩短,氢键强度增强;取代基为吸电子基团,氢键键长r(H…O)伸长,氢键强度减弱.自然键轨道(NBO)分析表明,N-H…O=C氢键强度越强,氢键中氢原子的正电荷越多,氧原子的负电荷越多,质子供体和受体分子间的电荷转移越多.供电子基团使N-H…O=C氢键中氧原子的孤对电子n(O)对N-H的反键轨道σ~*(N-H)的二阶相互作用稳定化能增加,吸电子基团使这种二阶相互作用稳定化能减小.取代基对与其相近的N-H…O=C氢键影响更大.     

含磷有机硅杂化环氧树脂固化体系性能研究

通过磷酸与γ-环氧丙氧基三甲氧基硅烷反应得到含磷有机硅氧烷,并加入到环氧树脂/4,4'-二氨基二苯基甲烷体系中混合,通过溶胶-凝胶的方法制备了含磷有机硅杂化环氧树脂固化物.对固化体系进行了玻璃化转变温度、热失重、阻燃、拉伸强度、冲击强度测试分析.结果表明,该固化体系的阻燃性得到提高,极限氧指数在25.8～29.3,玻璃化转变温度得到提高,在161～179℃;虽然初始分解温度比纯环氧树脂固化物低,但800℃残炭率可以达到26.5%,提高了36%;拉伸强度得到提高,在71～94 MPa,冲击强度可以达到14.36 kJ/m2,提高了14%.该固化体系具有较好的阻燃性能和热性能,同时具有较好的力学性能.     

防覆冰涂层构建机理及制备

航空、通信、电力和运输设备的覆冰现象给人们的生产、生活带来许多不便,甚至引起重大经济损失,防覆冰涂层主要通过材料表面特殊物理化学性能与微相形貌来实现抗冰目的,这类材料需要兼具防结冰性和疏冰性,从延长结冰时间和降低冰的附着力两方面来减轻甚至消除冰雪积聚,是目前研究的热点。本文从防覆冰机理入手,深入探讨了防结冰性和疏冰性的影响因素,阐述了防覆冰涂层材料的设计与制备方面的最新进展,并对防覆冰涂层目前存在的问题与发展方向进行了分析和展望。