循环流化床(CFB)煤/焦气化反应的研究 Ⅰ.操作气速、固体循环速率对循环流化床气化反应的影响

报道了山西西山焦煤飞灰，在小型循环流化床气化反应器上，以二氧化碳为气化介质，在不同操作条件下（气速、固体循环速率）的气化反应。研究结果表明，ＣＯ出口浓度及碳转化率随着ＣＦＢ操作气速减小、固体颗粒循环速率的增加而增加。即在ＣＦＢ床中，提高气体、固体停留时间（床内固体颗粒浓度）有利于ＣＦＢ气化的进行。ＣＯ浓度及碳转化率沿床高的变化趋势与床内颗粒浓度分布一致。     

旋流煤粉燃烧的一维综合数值模拟

发展了综合考虑气－固两相旋流流动，气相燃烧，颗粒相变与燃烧及两相辐射传热的旋流煤粉燃烧－维数学模型，给出了气－固两相能量方程中颗粒相就源项的计算表达式，应用这一模型对涡旋燃烧炉环形通道内多组工况的旋流气体燃烧和煤粉燃烧进行了数值模拟，计算得到的炉内温度分布和燃烧效率与实验数据基本相符，表明本文建立的模型可用于旋流煤粉燃烧的一维综合数值模拟。     

Temperature-controlled combustion and kinetics of different rank coal samples

Differential scanning calorimetry (DSC) and thermogravimetry (TG/DTG) has been used to obtain information on the temperature-controlled combustion characteristics of seventeen coals of different origin from Thrace basin of Turkey. Experiments were performed in air atmosphere up to 600°C at a heating rate of 10°C min^-1. The DSC/TG curves clearly demonstrate distinct transitional stages in the entire coal samples studied. Reaction intervals, peak and burn-out temperatures of the coal samples are also determined. Two different kinetic methods known as, Arrhenius and Coats-Redfern, were used to analyze the kinetic data and the results are discussed.     

热处理及与KOH共炭化对深度脱除煤中无机矿物质的促进作用

研究了煤经热处理（炭化）以及煤与ＫＯＨ共炭化对酸洗脱灰的影响。结果表明，煤经炭化再用盐酸洗涤，可以在缓和的条件下大幅度提高酸洗脱灰率；煤与ＫＯＨ共炭化后再酸洗，不仅对煤中的粘土、黄铁矿等无机矿物质有很好的效果，还特别适于脱除在一般情况下都难以除去的石英矿物。     

几种烟煤及其热处理后的溶胀性能研究

研究了四种不同变质程度烟煤及其二硫化碳/N-甲基-2-吡咯烷酮（CS2/NMP）混合溶剂(1∶1,vol)的抽提物在不同溶剂中的溶胀性能，同时考察了四种煤样不同温度热处理后其溶胀性能的变化。结果表明，煤的溶胀率随煤化度增加而有所降低;变质程度较低的烟煤在极性溶剂中的溶胀率大于非极性溶剂，随着煤化度的增加，两者溶胀度差距减小;四种烟煤经混合溶剂抽提后，其抽余煤的交联密度降低，溶胀率增加。四种煤样150℃热处理后在CS2中的溶胀率均有所增加，表明热处理可以降低煤的交联密度。随着热处理温度提高至240℃，除气煤外，其余三种煤样在NMP和CS2中溶胀率均进一步增大，说明其交联密度进一步降低。这一结果与热处理煤样在混合溶剂中抽提率的变化趋势一致，如240℃热处理后瘦煤的抽提率由原煤的6.9%提高到17.3%。红外光谱研究表明，经过适当温度的热处理，可以脱除煤分子中的羰基和羟基等含氧官能团，破坏煤结构中的氢键，从而降低煤的交联密度，提高煤的溶胀率及其在混合溶剂中的抽提率。     

聚对苯乙烯磺酸钠添加剂的分子量对水煤浆浆体性质的影响

选用了变质程度不同的八种煤和三种不同分子量的聚对苯乙烯磺酸钠（PSS）添加剂，详细考查了该添加剂的分子量对水煤浆浆体性质的影响。结果发现，在考查PSS相对分子量的范围内（质均分子量为5.34×104～33.39×104），八种煤的水煤浆成浆性随着分子量的增大而增加，水煤浆成浆性与PSS添加剂的平均分子量的关系可归因于添加剂在煤粒上的吸附，分子量小的PSS在煤粒上的吸附量大于分子量大的PSS；PSS分子量的增加有利于水煤浆的流变性由胀性向假塑性转变；PSS分子量的增加使水煤浆的静态稳定性得到显著的改善。     

Investigation of pyrolysis of chinese coals using thermal analysis/mass spectrometry

TA/MS (thermal analysis coupled with mass spectrometry) was applied to the pyrolysis of Chinese coals with different ranks. A total of 13 Chinese coals were investigated. The samples were deliberately chosen to represent the 13 types of Chinese coals according to the Chinese coal classification system. The experiments were carried out in an argon atmosphere with a flow rate of 150 ml min^-1. The samples were heated from 40 up to 1200°C with a constant heating rate of 10 k min^-1. The main evolved pyrolysis products were identified through the on-line recorded mass spectra. The thermal and evolution behavior was compared between the coals. The results showed a strong thermal and evaluation behavior dependence on the coal rank. Different aliphatic fragments and also some aromatic substances, which are of environmental concern (BTX, PAHs), were found to be released depending on the different types of coal. This revised version was published online in July 2006 with corrections to the Cover Date.     

铁岭煤中重金属元素的赋存形态及其在热解过程中的挥发行为研究

采用密度分离、脱灰处理和逐级化学提取等间接方法,考察了铁岭煤中Pb, Cr, Co, Ni, V五个重金属元素的宏观结合形态,并在Φ25mm小型石英流化床反应装置上考察了上述五个重金属元素在热解过程中的挥发行为。研究发现,铁岭煤中Pb, Cr, Co, Ni, V均主要与非黄铁矿类矿物质相伴生, 且高达40%～60%赋存在硅酸盐类矿物质中。Pb的碳酸盐结合态和有机束缚的离子可交换态600℃前即可分解转化,而其硫化物和硫酸盐结合态在较高的热解温度下才能分解挥发；Co、Ni的硫化物和硫酸盐结合态在高温下可部分转换为有机结合的离子可交换态；而Cr、V的硫化物和硫酸盐结合态在高温下部分转化生成了新的热稳定相。在500℃～900℃范围内,Pb属半挥发性元素,Cr, Co, Ni, V属难挥发性元素。微量元素的挥发性极大地受其伴生环境、共存活泼元素等的影响,硅铝酸盐类矿物质对重金属元素的挥发有一定的抑制作用。     

反应条件对煤加氢热解产物分布的影响

本文以内蒙古红庙煤为研究对象，在温度４５０－６５０℃和氢氯压力２－５ＭＰＡ的范围内，在加压固定床反应器上考察了各种因素包括传质作用对煤加氢热解产物分布的影响。研究表明，转化率和焦油收率随最终反应温度，氢气压力和流速的升高而升高，随加速速率的增大而降低。     

Dissipative structures formed in the course of drying the colloidal crystals of silica spheres on a cover glass

Macroscopic and microscopic dissipative structural patterns formed in the course of drying the deionized aqueous colloidal crystal suspensions of silica spheres (diameter: 103 nm) on a cover glass have been observed. Spoke-like and ring-like patterns are formed in the macroscopic scale; the former is the crack in the sphere film and the latter is the hill accumulated with spheres formed around the outside edge. The neighbored inter-spoke angle, thickness of the film, and other morphological parameters have been discussed as a function of sphere concentration, concentration of sodium chloride, and the inclined angle of the cover glass. Fractal patterns of the mud cracks are observed in the microscopic scale. Capillary forces between spheres at the air-liquid surface and the relative rates between the water flow at the drying front and the convection flow of spheres are important for the pattern formation. Electronic Publication