Qualitative and quantitative ATR-FTIR analysis and its application to coal char of different ranks

This paper analyzes the coal to char stages of char formation of six coals of different ranks by using Fourier transform infrared coupled w ith attenuated total reflectance(ATR-FTIR).The chars w ere obtained by coal pyrolysis carried out at temperature range of 450~700℃.The data obtained show s the pragmatic disappearance of the aliphatic hydrogen content w ith increasing char formation temperature.Numerical evaluation of the spectra enabled the determination of aromaticity,fa.The aromaticity w as found to be betw een 0.66~0.79 for lignite,0.75~0.90 for sub-bituminous,0.84~1.00 for low volatile bituminous,0.83~1.00 for high volatile bituminous,0.94~1.00 for semi-anthracite,and 0.97~1.00 for anthracite respectively.With increasing rank of coal samples,spectra exhibit rising aromaticity and enhanced condensation of aromatic rings,w hereas the aliphatic chain lengths decrease.     

The Assignment of the 1600 cm−1 Mystery Band of Carbons

Abstract

The assignment of a band near 1600 cm^?1 in IR spectra of carbons has been controversial for four decades. However, many different carbons have been studied: effectively, a single band assignment was sought for an absorption appearing with three different classes of carbon. As these differ in over-all structure, not one but three explanations are needed. These are discussed. However, undue emphasis has been placed on a single absorption; attention should also be paid to other absorptions accompanying the 1600 cm^?1 band.     

Gaseous- and Condensed-Phase Activities of Some Reactive P- and N-Containing Fire Retardants in Polystyrenes

Polystyrene (PS) was modified by covalently binding P-, P-N- and/or N- containing fire-retardant moieties through co- or ter-polymerization reactions of styrene with diethyl(acryloyloxymethyl)phosphonate (DEAMP), diethyl-p-vinylbenzyl phosphonate (DEpVBP), acrylic acid-2-[(diethoxyphosphoryl)methylamino]ethyl ester (ADEPMAE) and maleimide (MI). In the present study, the condensed-phase and the gaseous-phase activities of the abovementioned fire retardants within the prepared co- and ter-polymers were evaluated for the first time. Pyrolysis–Gas Chromatography/Mass Spectrometry was employed to identify the volatile products formed during the thermal decomposition of the modified polymers. Benzaldehyde, α-methylstyrene, acetophenone, triethyl phosphate and styrene (monomer, dimer and trimer) were detected in the gaseous phase following the thermal cracking of fire-retardant groups and through main chain scissions. In the case of PS modified with ADEPMAE, the evolution of pyrolysis gases was suppressed by possible inhibitory actions of triethyl phosphate in the gaseous phase. The reactive modification of PS by simultaneously incorporating P- (DEAMP or DEpVBP) and N- (MI) monomeric units, in the chains of ter-polymers, resulted in a predominantly condensed-phase mode of action owing to synergistic P and N interactions. The solid-state ³¹P NMR spectroscopy, Scanning Electron Microscopy/Energy Dispersive Spectroscopy, Inductively-Coupled Plasma/Optical Emission Spectroscopy and X-ray Photoelectron Spectroscopy of char residues, obtained from ter-polymers, confirmed the retention of the phosphorus species in their structures.     

循环冲击载荷作用下页岩动力学响应及能量耗散特征

采用$\varnothing $50 mm分离式霍普金森杆(split Hopkinson pressure bar,SHPB)实验系统开展页岩循环冲击实验,研究不同循环冲击载荷作用下页岩动力学响应及损伤演化特征,同时揭示了控制入射总能量不变条件下,不同气压梯度循环冲击页岩能量演化规律。随着冲击气压升高,试样破裂所需的冲击次数呈线性减少,峰值应力随循环冲击次数的增加先升高后降低,极限应变先减小后增大,试样在循环冲击下表现出先压密后损伤的力学机制。基于Weibull分布的统计损伤模型表明,升高循环冲击气压,试样损伤破坏形式由缓慢劣化逐渐转变为骤然破坏。入射总能量恒定的情况下,通过控制循环入射能量梯度能够产生不同的损伤效果,降压冲击和升压冲击下的能量吸收比均大于恒压冲击下的,且气压梯度的绝对值与能量吸收比呈现正相关性。

     

氧化钙对胜利褐煤焦水蒸气气化反应性能及微结构的影响

研究了CaO对胜利褐煤焦水蒸气气化反应性能及微结构的影响。脱除矿物质的胜利褐煤混合不同含量的CaO后在1 100 ℃下进行热解得到相应的煤焦,采用BET、XRD和Raman技术对其进行表征,同时在微型固定床反应器上对所制得煤焦进行水蒸气气化实验。比较添加CaO不同含量煤焦的反应性表明,添加2%(质量分数)的CaO对煤焦水蒸气气化的催化作用很小,而CaO添加量增大到5%时,煤焦的气化反应性能明显提高。煤焦比表面积随CaO添加量的提高而增大。XRD结果表明,在热解过程中,CaO能有效地抑制煤焦向石墨化方向发展趋势。煤焦002和100峰的峰强度随CaO添加量的增加而降低,且煤焦芳香度从66.8%降至39.9%。Raman光谱结果表明,随着CaO添加量的增加,I_D/I_G由1.363增加至1.541,I_G/I_all由0.423减少到0.394。意味着由于Ca的催化作用,煤中大芳香环结构的裂解速率明显增加,且随CaO添加量的增多,煤焦的无序化程度和晶格缺陷均增大。     

Evaluation of Oil Yield of Oil Shale by Infrared Spectrometry Coupled with Ultrasound-assisted Extraction

The oil yield of oil shale was evaluated by Fourier transform infrared(FTIR) spectrometry coupled with ultrasound-assisted extraction. The extraction conditions, including the amount of sample, extraction time and extraction temperature, were examined and optimized. Twenty-four oil shale samples were collected and divided into calibration set and prediction set randomly with a ratio of 2:1. The oil yields of all the samples were determined by the routine method(low-temperature retorting) for reference. The linear regression(LR) equations of oil yield vs. the total area of the spectrum peaks in a wavenumber range of 3100-2800 cm^-1 as well as the sum of absorbance of three absorption peaks(2855, 2927 and 2955 cm^-1), and the multiple linear regression(MLR) model of oil yield vs. the absorbances of the three absorption peaks were constructed with the samples in calibration set and applied to the evaluation of the oil yields of the samples in prediction set, respectively. The results show that the MLR model provides more accurate predictions than the other LR two equations. The determination coefficient(R_p²), the root-mean-square error of prediction(RMSEP) and the residual prediction deviation(RPD) of the MLR model are 0.9616, 0.6458 and 3.6, respectively. The present method is a rapid and effective alternative to the routine low-temperature retorting method.     

加压下中国典型煤二氧化碳气化反应的热重研究

用TG-151加压热天平，测定了三种典型中国煤在二氧化碳气氛下的气化反应活性。结果表明，反应速率与温度的关系符合Arrhenius定律，同时反应速率随着压力的增加而增加，但是随着压力的增加，压力对反应速率的影响越来越小。用下式dx/dt=k0 Pco2/1 αPco2 exp(-Eα/(RT)(1-X)^n模拟实验曲线的结果表明，n值随着温度的升高而降低，随压力的增加而增大。     

玉米芯水解残渣热解焦气化反应性研究

利用热重分析仪研究了玉米芯及其酸水解残渣热解焦的气化反应性,重点考察了热解温度、升温速率、气化温度和气化介质(CO₂、H₂O)对残渣热解焦气化反应性的影响,并借助SEM观测了热解焦的表观形貌。结果表明,残渣热解焦的气化反应性较玉米芯热解焦有所下降;在热解温度550~850 ℃,残渣热解焦的气化反应性随热解温度提高而降低,在热解升温速率0.1 K/s下制取的热解焦,其气化反应性低于15.0 K/s下的热解焦;在气化温度850~950 ℃,提高气化反应温度和使用水蒸气作为气化介质能显著提高残渣热解焦的气化反应性;采用混合反应模型计算了残渣热解焦的气化反应动力学参数。     

中国无烟煤焦气化活性的研究--水蒸气与二氧化碳气化活性的比较

在常压和920℃~1050℃下,采用热重方法,进行了六种中国典型无烟煤焦水蒸气与二氧化碳气化活性比较的研究。结果表明,无烟煤焦与水蒸气气化反应的活性与无烟煤的煤化程度相对应,无烟煤煤化程度越高,水蒸气气化反应活性越小。无烟煤焦与二氧化碳气化反应的活性与煤中矿物质的催化作用有密切关系,煤中矿物质的催化作用越大,二氧化碳气化反应活性越大。无烟煤焦与二氧化碳气化反应活性明显小于与水蒸气气化反应活性,后者比前者大10倍左右。初步探讨了无烟煤焦与水蒸气和二氧化碳的气化机理。     

抚顺页岩油的高分辨核磁共振研究

用高分辨液体核磁共振氢谱、碳谱、二维碳氢相关谱和DEPT谱(无畸变极化转移增强法)对我国抚顺页岩油的不同组分进行了详细研究,得出了一些结构信息和变化规律。