煤油共处理油品的族组成研究

采用高效液相色谱法对兖州烟煤与催化裂化油浆共处理制备的油品的族组成进行了研究。结果表明 ,在实验条件下油品主要由烷烃和芳烃组成 ,杂原子化合物含量一般仅为 0 5 %～ 2 0 %。原料煤与油浆比例、反应温度、催化剂对油品族组成具有重要影响 ;随初始氢压不同 ,对油品族组成的影响不同 ;在 4MPa初始压力条件下 ,反应气氛 (氢气、氮气 )对煤油共处理和纯油浆制备油品的族组成影响不大。     

Preparation the Esters of Oleic Acid-Maleic Anhydride Copolymer and Their Evaluation as Flow Improvers for Waxy Crude Oil

Five comb-like copolymers derived from oleic acid-maleic anhydride were prepared and then esterified by long-chain fatty alcohol (POMA C_n), where n = 18, 20, 22. These polymers were characterized by FTIR and ¹H NMR analysis. The molecular weight was determined by using gel permeation chromatography (GPC). The prepared copolymers were investigated as flow improvers and pour point depressants (PPD) for crude oil. From the evaluation, it was found that, the maximum depression of PP was obtained by (POMA₂ C₂₂) with long-chain alcohol (C₂₂–OH) from 27°C to 15°C (ΔPP_3000ppm = ?12°C). On the other side, it was remarked that no depression obtained by (POMA₂ C₁₈), which esterified by alcohol (C₁₈–OH) at the same condition. The depression of pour point effectiveness was discussed on the light of polymers structure, molecular weights, and their concentrations. By analysis the results of the rheological flow properties, it was found that the POMA₂ C₂₂ enhanced the Bingham yield values (τ_β). The τ_β for crude oil without additives against 15, 27, and 39°C were 0.286, 0.131, and 0.075 Pa respectively, whereas the τβ for the treated crude oil with POMA₂ C₂₂ were 0.027, 0.022 and 0.010 Pa at 3000 ppm at the same temperatures. By using the photomicrography analysis, it was found that, the wax morphology was greatly modified to fine dispersed crystals of compact size.     

解析法确定含蜡原油热质耦合的蜡分子扩散速率

蜡分子扩散过程是在热和质的广义热力学"力"耦合驱动下产生广义热力学"流"的结果,其实质是传热和传质同时存在的复杂耦合不可逆过程.基于非平衡态热力学的基本原理,推导出含蜡原油管输过程蜡分子扩散热质传递的线性唯象方程组;依据质量和能量的守恒关系,得到蜡分子扩散的传热一传质微分方程组,利用拉普拉斯变换求解到其解析解,探讨促使蜡分子扩散的动力学原因,分析输量和季节变化的不同工况对扩散速率的影响.     

Sulfur speciation of Kuwaiti crude oils fractions using two-dimensional gas chromatography

The main objective of this study is to develop a methodology for sulfur compounds speciation using two-dimensional gas chromatography coupled with a flame ionization detector and sulfur chemiluminescence detectors. The methodology enhances the ability to detect and quantify the refractory sulfur in petroleum distillates, and it was utilized to screen the molecular differences between distillates of two Kuwaiti heavy crude oils from different reservoirs but with similar physical properties. Despite the similarity in the physical properties, the detailed comparative analysis indicated significant differences in molecular composition, which suggests substantial differences in crude oil processability based on the reactivity of the detected compounds. The distillates that have been considered in this study include heavy naphtha, kerosene, and gas oil. The compositional differences between the distillates were observed using the two-dimensional gas chromatography system with an in-house developed method. This method groups the sulfur compounds into thiols, benzothiophenes (BTs), and dibenzothiophene (DBTs), and it can handle any atmospheric distillate up 365 °C. Furthermore, the method includes the possibility of identifying and quantifying a total number of 44 sulfur species, which covers the previously mentioned sulfur groups.     

聚丙烯酸十八酯-乙酸乙烯酯梳状二元共聚物降凝剂对含蜡原油结晶特性与流变性的影响

在合成聚丙烯酸十八酯(POA)梳状均聚物和聚丙烯酸十八酯-乙酸乙烯酯(POA-VA)系列梳状二元共聚物的基础上,通过凝点测量、流变实验、差示扫描量热(DSC)分析及偏光显微镜观察等手段研究了POA与POA-VA对长庆含蜡原油结晶特性与流变性的影响.实验结果表明VA基团的引入调控了POA降凝剂对含蜡原油的作用效果.当OA与VA单体摩尔比为3∶1时,POA-VA对含蜡原油的流变改善效果最好,在降凝剂400 mg/kg剂量下可以降低凝点22℃,平均降黏率为51.45%;而单体摩尔比升高或降低均会使POA-VA对含蜡原油的流变改善效果变差.另外,从POA-VA分子的结晶放热特性和蜡晶微观形貌分析角度,探讨了VA含量对POA-VA作用性能的影响规律和机理.     

Evaluation of gas chromatography-tandem quadrupole mass spectrometry for the determination of organochlorine pesticides in fats and oils

A gas chromatography-tandem quadrupole mass spectrometry multi-residue method for the analysis of 19 organochlorine pesticides in fats and oils has been developed. Gel permeation chromatography was employed to remove lipid material prior to GC-MS/MS analysis. Average recoveries of the pesticides spiked at 10 and 50 microg kg(-1) into fish oil, pork fat, olive oil and hydrogenated vegetable oil were typically in the range 70-110% with relative standard deviations generally less than 10%. Calculated limits of detection are between 0.1 and 2.0 microg kg(-1) and results obtained for the analysis of proficiency test materials are in good agreement with assigned values. The higher selectivity of the GC-MS/MS compared to electron capture detection and GC-MS in selective ion monitoring mode allowed unambiguous identification and confirmation of all the target pesticides at low microg kg(-1) levels in fats and oils in a single analysis.     

Laminar Flow Emulsification Process to Control the Viscosity Reduction of Heavy Crude Oils

The formation of heavy crude oil in water (O/W) emulsion by a low energy laminar controlled flow has been investigated. The emulsion was prepared in an eccentric cylinder mixer. Its geometry allows the existence of chaotic flows that are able to mix well highly viscous fluids. This new mixer design is used to produce high internal phase ratio emulsions for three oils: castor oil and two heavy crude oils of different initial viscosity (Zuata and Athabasca crude oils). The influence of the stirring conditions, geometrical parameters, and water volume fraction on the rheological properties of the resulting O/W emulsion is studied.     

绿色润滑油的发展概况

概述了绿色润滑油的发展状况,阐述了绿色润滑油的含义,阐述了绿色润滑油的含义,介绍了生物降解试验方法,通过对绿色润滑油基础油及基适用的添加剂的综述,提出了绿色润滑油发展过程中存在的主要问题,并对将来的发展趋势进行了展望。     

Oscillatory measurements of silicone oils —Loss and storage modulus master curves

The work describes a way to obtain loss modulus and storage modulus master curves from oscillatory measurements of silicone oils.The loss modulus master curve represents the dependence of the viscous flow behavior on · ₀ ^* and the storage modulus master curve — the dependence of the elastic flow behavior on · ₀ ^* .The relation between the values of the loss modulus and storage modulus master curves (at a certain frequency) is a measurement of the viscoelastic behavior of a system. The G/G-ratio depends on · ₀ ^* which leads to a viscoelastic master curve. The viscoelastic master curve represents the relation between the elastic and viscous oscillatory flow behavior.     

DSC and Rheometry Investigations of Crude Oils

Thermal characteristics and rheological behaviour of eight crude oils covered a wide range of fluid composition and properties were studied by differential scanning calorimeter (DSC) and viscometry. Wax appearance temperatures (WAT) of crude oils were determined by DSC and viscometry. Good agreement is obtained between the results. The dynamic viscosity in the Newtonian temperature range of the crude oils (above 30°C) generally obeyed a simple first-order Arrhenius type of temperature dependence. Activation energies of flow in the non-Newtonian range are not uniquely defined. This revised version was published online in August 2006 with corrections to the Cover Date.