A PREDICTIVE APPROACH TO THE IN-PLANE MECHANICAL PROPERTIES OF STITCHED COMPOSITE LAMINATES

This contribution attempts to model the alteration of the in-plane elastic properties in laminates caused by stitching,and to predict the in-plane effective tensile strength of the stitched composite laminates.The distortion of in-plane fibers is considered to be the main cause that affects the in-plane mechanical properties.A fiber distortion model is proposed to characterize the fiber misalignment and the fiber content concentration due to stitching.The undistorted region,the fiber distortion region,the resin-rich pocket and the through-thickness reinforcement section are taken into account.The fiber misalignment and inhomogeneous fiber content due to stitching have been formulated by introducing two parameters,the distortion width and maximum misalignment.It has been found that the ply stress concentration in stitched laminates is influenced by the two concurrent factors,the stitch hole and inhomogeneous fiber content.The stitch hole brings about the stress concentration whereas the higher fiber content at the local region induced by stitching restrains the local deformation of the composite.The model is used to predict the tensile strength of the [0/45/0/-45/90/45/0/-45]_(2s) T300/QY9512 composite laminate stitched by Kevlar 29 yarn with different stitching configurations,showing an acceptable agreement with experimental data.     

未熔透尺寸对十字焊接接头疲劳性能影响规律试验研究

针对某厂一压力机架的焊接结构，采用极大似然方法，进行了部分熔透焊接十字接头的拉—拉疲劳试验，得到了该类结构的Ｐ－Ｓ－Ｎ对数曲线。研究了未熔透尺寸对接头的应力集中系数、疲劳强度和试件疲劳破坏形式的影响规律，结果表明，在焊缝与母材等强的情况下，当未熔透尺寸２ａ／Ｔ＜０．５时，其疲劳性能无明显减弱；而当未熔透尺寸２ａ／Ｔ＞０．５时，则接头的抗疲劳性能有显著的改变。     

Modeling the effect of diffusion of the ambient medium on the long-term strength of a hollow cylinder under uniaxial tension

The problem of the long-term strength of an extended thick-walled tube containing a corrosive medium in the internal cavity is solved. The diffusion of this medium into the tube material is analyzed. The diffusion equation is solved approximately by introducing the diffusion front, and the error of the solution is estimated. The dependence of the time of fracture of the tube on the variable tensile stress and the concentration of the medium filling the cavity is obtained. __________ Translated from Prikladnaya Mekhanika i Tekhnicheskaya Fizika, Vol. 48, No. 4, pp. 88–93, July–August, 2007.     

拉压性能不同材料的几种结构的极限分析

给出了拉压性能不同材料（简称具有Ｓ－Ｄ效应的材料）的几种结构的极限载荷公式。揭示出材料的拉压性能不同对几种结构承载能力的影响规律。所给出的极限载荷公式可供工程设计人员参考。     

基于吸力量测确定膨胀土活动带和裂隙深度

采用M itchell公式和裂隙扩展深度方程两种吸力法确定安康地区膨胀土大气影响深度和裂隙开展深度。其一通过对安康地区两处天然边坡开挖观测井,利用张力计进行不同深度处吸力值的现场量测,根据M itchell提出公式计算大气影响深度;其二根据非饱和土抗拉强度公式,建立膨胀土裂隙扩展深度方程,利用基质吸力量测结果求其理论解。结果表明,安康地区膨胀土吸力变化曲线随深度增加变幅减小,呈“波浪式”推移。M itchell公式确定安康地区膨胀土的大气影响深度为3.35m以内,裂隙深度方程确定裂隙开展深度为3.06³.14m。利用M itchell公式计算大气影响深度与膨胀土断裂理论公式确定的裂隙开展深度结果接近。     

天然盐渍土冻融循环时水盐迁移规律及强度变化试验研究

通过对新疆喀什地区12处天然盐渍土室内基本性质试验分析,选取典型天然盐渍土,在开放系统中进行反复冻融循环条件下的试验研究。研究了天然盐渍土在多次冻融循环时的水分和盐分迁移规律及强度变化特征。试验结果表明:经多次冻融循环,低液限粘土试样水分重分布与盐分重分布有很大的一致性,水分和盐分自下而上迁移;试样粘聚力自下而上线形减小,内摩擦角呈s形分布。含砂低液限粘土试样冻融循环过程中,易溶盐均随水分向冷端面迁移,离子剖面呈现中间大两端小的趋势;试样粘聚力呈反s形分布,内摩擦角均呈s形分布。     

高速公路工程中水泥搅拌桩桩身合理设计强度研究

在公路工程的搅拌桩地基设计中,一般假设加固区桩土变形协调,从而采用复合地基理论进行设计。但是目前许多的工程实践表明在路堤荷载作用下,搅拌桩地基桩土之间存在差异沉降,桩身强度不能够完全发挥,为此需要对复合模量的表达式进行改进。本文采用有限元分析了路堤荷载作用下搅拌桩地基的变形响应情况,分析了加固区桩间土变形与桩身模量之间关系,得到了水泥土搅拌桩强度的合理范围。     

树枝状界面相开裂对纤维强度的影响

碳纤维增强铝的复合材料在制造过程中，由于发生化学反应而在界面上形成新相。该相并非均匀附着在纤维表面，而是以纤维为主杆形成树枝状。本文利用剪切滞后理论，同时考虑到界面相亦有承受轴向外载的能力，分析了界面相开裂对纤维强度的影响。结果表明界面相与纤维间界面强度以及该界面脱粘后的摩擦应力的增加都能使纤维在给定外载下破坏的概率减小；另外界面相的厚度、沿纤维方向的弹性模量、剪切模量的增加却使上述概率增加。     

Cavity nucleation, growth and stress field in elastic-plastic medium

A finite element method is used to study the cavity nucleation and growth in an elastic-plastic medium. The critical cohesion strength, _c at IPM (interface between second phase particle and matrix) is employed as the criterion of cavity formation. Three different values of _c are taken to examine their influence on the overall mechanical behaviour and process of cavity formation.     

改性膨胀土路堤填筑含水量优化试验研究

在控制含水量的前提下,对分别掺入不同量石灰、不同量水泥改性膨胀土试件进行强度和膨胀量试验,得到不同含 水量及不同石灰(水泥)掺量对改性膨胀土强度和膨胀性的影响,通过对实验所得数据的分析,找出含水量和掺石灰(水泥)剂 量的最佳融合点,并据此对膨胀土路堤填料的改性施工提出了一些有益的建议。