溴化铵改性膨润土脱除气态单质汞的特性及机理分析

采用溴化铵对钠基膨润土进行改性制得脱汞吸附剂,在固定床实验装置上对所制备的吸附剂进行脱汞性能测试。脱汞实验结果表明,钠基膨润土较钙基膨润土在脱汞性能上提高不大,而溴化铵改性的钠基膨润土(Br-Ben/Na)脱汞性能得到明显提高,脱汞效率达到97.7%。吸附温度的升高有利于对Hg0的脱除,在140℃下,10%Br-Ben/Na吸附剂的脱汞率能长时间保持在90%以上,说明在此吸附过程中化学吸附占主导性作用。通过N2吸附/脱附、X射线衍射(XRD)、元素分析仪和傅里叶变换红外光谱(FT-IR)分析等结果表明,改性后的膨润土比表面积下降,平均孔径增大;铵根离子进入到膨润土的层间置换出层间钠离子,煅烧活化过程中层间的铵根离子并未分解,而在层间与膨润土结合为某吸附活性组分协助Br-与Hg0反应,提高了膨润土的脱汞性能。     

铝改性赤泥吸附剂的制备及其除氟效能的研究

以铝工业废矿渣为原材料,通过铝盐改性及焙烧活化处理,制备了水中除氟吸附剂。研究考察了吸附剂吸附氟能力、反应时间、pH值以及投加量对吸附效果的影响。结果表明,铝改性赤泥吸附剂具有较好的除氟效果,未焙烧铝改性赤泥吸附剂及经过200 ℃焙烧活化赤泥吸附剂的饱和吸附量分别达到68.07和91.28 mg·g^-1,远高于原状赤泥的饱和吸附量13.46 mg·g^-1。经吸附后出水氟含量低于1 mg·L^-1的国家饮用水标准。吸附规律符合Langmuir等温方程,溶液pH值显著影响除氟效果,在溶液pH值为7~8时达到最佳去除效果。     

低活化比制备天然气吸附剂： 活化助剂提高吸附剂性能

以石油焦为原料、KOH为主活化剂,在低活化比m_KOH∶m_C＝2∶1下制备吸附剂,考察了活化助剂KNO₃、NaNO₃、Mg(NO₃)₂、Ni(NO₃)₂和HJ对吸附剂储气性能的影响,对活化助剂提高吸附剂性能的机理进行了分析。结果表明,活化物料中加入适量助剂KNO₃、Mg(NO₃)₂、Ni(NO₃)₂或HJ能显著提高吸附剂性能,HJ与Mg(NO₃)₂、Ni(NO₃)₂协同活化的效果最好。其中,Mg(NO₃)₂、HJ加入量均为10 %（助剂与石油焦质量分数）下制备的吸附剂样品在25℃、3.5MPa下对甲烷质量吸附量达0.143,有效体积释放量达117.1,性能超过活化比m_KOH∶m_C=3∶1、无助剂下制备的吸附剂。     

Separation and analysis of trace volatile formaldehyde in aquatic products by a MoO3/polypyrrole intercalative sampling adsorbent with thermal desorption gas chromatography and mass spectrometry

An in situ embedded synthesis strategy was developed for the preparation of a MoO₃/polypyrrole intercalative sampling adsorbent for the separation and analysis of trace volatile formaldehyde in aquatic products. Structural and morphological characteristics of the MoO₃/polypyrrole intercalative adsorbent were investigated by a series of characterization methods. The MoO₃/polypyrrole sampling adsorbent possessed a higher sampling capacity and selectivity for polar formaldehyde than commonly used commercial adsorbent Tenax TA. Finally, the MoO₃/polypyrrole adsorbent was packed in the thermal desorption tube that was directly coupled to gas chromatography with mass spectrometry for the analysis of trace volatile formaldehyde in aquatic products. Trace volatile formaldehyde from real aquatic products could be selectively sampled and quantified to be 0.43–6.6 mg/kg. The detection limit was achieved as 0.004 μg/L by this method. Good recoveries for spiked aquatic products were achieved in range of 75.0–108% with relative standard deviations of 1.2–9.0%.     

树脂填充聚醚砜纤维吸附剂对牛血清蛋白吸附性能的研究

重点研究树脂填充聚醚砜(PES)纤维吸附剂与模型蛋白质牛血清蛋白(BSA)之间的吸附与脱附行为.结果表明,蛋白质BSA在树脂填充PES纤维吸附剂中的平衡吸附过程较好地符合朗格缪尔吸附模型,树脂Lewatit CNP80ws填充PES吸附剂的最大吸附容量约为139mg BSA/g吸附剂.表面具有开孔结构的树脂填充PES纤维吸附剂的吸附速率较快,在不同结构纤维吸附剂中BSA的扩散系数在1·82×10-14~8·7×10-14m2/s范围内变化.另外,考察了BSA溶液的pH与洗脱剂等因素对吸附剂吸附与脱附性能的影响,研究结果对蛋白质的实际分离纯化具有重要的参考价值.     

NiO/ZnO-Al2O3吸附剂吸附脱除焦炉气中COS

采用浸渍法制备了NiO/ZnO-Al₂O₃吸附剂,在固定床装置上对模拟焦炉气中的COS进行吸附脱除,并采用XRD和压汞仪对吸附剂进行了表征。实验结果表明,吸附反应适宜的工艺条件为350 ℃、0.40 MPa、空速500~1 000 h^-1,在此条件下吸附剂可将焦炉气中的COS从320~450 mg/m³降低至0.5 mg/m³,烯烃的体积分数从2.3%~4.5%降为0,其他组分含量不变,吸附剂穿透硫容为17.18%。吸附剂的再生实验表明,吸附剂再生前后晶形、孔结构及硫容变化不大,吸附剂具有较好的再生性能。通过实验总结出脱硫过程为COS首先吸附在还原态Ni原子上,在Ni作用下COS中S-C断裂生成NiS,然后生成H₂S,H₂S与ZnO反应生成ZnS。     

B2O3对Ag/TiO2-Al2O3吸附剂的柴油吸附脱硫性能影响

采用浸渍法制备了不同B₂O₃负载量(e.g. 5%~20% (w))的Ag/TiO₂-B₂O₃-Al₂O₃吸附剂。以含硫量为245.36mg(S)/L 的商业柴油作为考察对象,常温常压下采用静态评价进行吸附脱硫性能研究。结果表明,B₂O₃改性后的Ag/TiO₂-Al₂O₃吸附剂的柴油吸附脱硫活性有了较大提高,当B₂O₃的负载量为15%时,吸附剂的吸附脱硫活性最高,2%Ag/4%TiO₂-15%B₂O₃-Al₂O₃ (w)的饱和吸附硫容达到2.36mg(S)/g 吸附剂。这对于未经预处理的商业柴油而言,吸附脱硫活性已经达到较高水平。采用N₂物理吸附、O₂化学吸附、X射线衍射(XRD)、NH₃程序升温脱附(NH₃-TPD)、傅里叶红外光谱(FT-IR spectra)、¹¹B核磁共振(¹¹B-NMR)等表征手段对不同负载量B₂O₃改性Ag/TiO₂-Al₂O₃吸附剂的织构性质、晶相结构和表面酸性的影响进行研究。关联活性测试和表征结果发现,吸附剂的吸附脱硫活性主要与吸附剂的表面弱酸性有关,而B₂O₃改性在吸附剂表面引入了较多的四配位的BO₄物种,能显著增加吸附剂表面弱酸性位点数量,提高吸附剂的吸附脱硫活性。     

Separation properties of saccharides on a hydrophilic stationary phase having hydration layer formed zwitterionic copolymer

A novel water-holding adsorbent bonded with a zwitterionic polymer, diallylamine–maleic acid copolymer, was developed. With this adsorbent, hydrophilic solutes are partitioned by a hydration layer that forms on the zwitterions, as a main separating force. When the adsorbent was used to separate saccharides by normal-phase partition chromatography, the saccharides eluted in the order, mono-, di- and trisaccharide. The elution profile for mono- and di-saccharides was similar but not identical to that on anion exchange columns. This indicated that the adsorbent exhibited a complex retention behavior by the existence of both anion and cation exchange moieties in the functional polymer. Selecting Na⁺ as a counter-ion of the maleate moiety enhanced the retention of saccharide. When used in an high performance liquid chromatography (HPLC) system with gradient elution, the adsorbent enabled the simultaneous analysis of mono-, di- and oligosaccharides.     

Preparation and adsorption mechanism of rare earth-doped adsorbent for arsenic(V) removal from groundwater

Human poisoning and death from arsenic(As) have occurred as a result of drinking water contaminated with As in some regions and countries, such as Taiwan, Chile, Bangladesh, and In-dia[1]. Chronic arsenism poses a serious health problem in China also[2]. If China lowers its current drinking water standard of As from 0.05 to 0.01 mg/L[3], a level adopted by WHO[4] and some industrialized countries[5], the population affected will increase significantly. It is of great impor-tance to develo…     

Gd~(3+)掺杂锰锌铁氧体的高分子吸附燃烧法制备及电磁性能

采用固态高分子吸附燃烧法合成了Gd3+掺杂锰锌铁氧体Mn0.3Zn0.7Fe2-xGdxO4(x=0,0.01,0.02,0.03,0.04)。借助XRD、SEM和网络分析仪等研究了样品的物相结构和掺杂浓度与电磁特性的关系。结果表明:当x≤0.02时,制得的粉体为单一的锰锌铁氧体,样品的晶格常数随着Gd3+掺杂量的增加先增后减。少量Gd3+掺杂能有效调整锰锌铁氧体的电磁参数,当x=0.02时,微波电磁损耗(RL)最大值达到-18.7dB。