SURFACE METALLIZATION OF CENOSPHERES AND PRECIPITATORS BY ELECTROLESS PLATING

This paper reports the use of a colloidal Pd^0 catalysis system to metallize the surface of precipitators separated from coal fly-ash, and metals such as Cu, Ni etc. are deposited on the precipitators surface. Alternatively, according to the characteristic surface of cenospheres, an Ag coating catalysis system is adopted to first deposit Ag on the cenospheres surface, followed, if necessary, by the deposition of other metals such as Cu, Ni, etc. on the Ag coating to produce monolayer and multilayer metal-coated cenospheres. The surface characteristics and the morphologies of the metal coatings are examined in detail with scanning electron microscopy (SEM), energy dispersive spectroscopy (EDX) and X-ray photoelectron spectroscopy (XPS) techniques. It can be shown that the quality of metal coatings derived from the Aa coatina catalysis system, is better than that of the colloidal Pd^0 catalysis system.     

粉煤灰填充聚氯乙烯复合材料的摩擦学特性研究

用热压方法制备了不同粉煤灰粒度及含量的聚氯乙烯(PVC)复合材料，在MM—200型环—块摩擦磨损试验机上评价了复合材料同淬火45^#钢在干摩擦条件下对摩时的摩擦磨损性能，用扫描电子显微镜及光学显微镜观察分析磨损表面．结果表明：当粉煤灰质量分数为40％时，填充PVC复合材料的硬度最高，相应的磨损率最低，比纯PVC的磨损率低2个数量级以上；粉煤灰粒度越小，复合材料的硬度越高，耐磨性越好．     

微波消解植物灰分与环境土壤中微量元素的ICP-AES方法研究

应用MDS-2002A犁压力自控密闭微波消解样品制备系统,针对研究样品的特性和共性,进行植物灰分和土壤样品相同微波消解条件的研究实验,并采用电感耦合等离子体原子发射光谱法测定其元素的含量.讨论了混合酸体系、混酸配比、固液比和微波消解时间对于样品制备结果的影响.最终的优选方案为A281C2,即微波程序为工步2,混酸配比为6:2:1:1,混合酸体系为HNO3-HCl-HF-HClO4,最高功率消解时间为10 min的条件下,消解结果最佳.在微波消解最佳条件下,进行了方法准确度实验和测量结果重现性实验,该方法经土壤(GBW07401)和植物(GBW07603)国家标准物质验证,所得测试结果的相对误差均在0.00%～7.14%之间,相对标准偏差均在0.87%～5.25%之间.结果表明,微波消解法处理植物灰分和土壤样品,具有快速、简便、节省试剂、消解完全等特点,测定结果的准确度和精密度令人满意.     

燃煤飞灰物理化学特性及其润湿机理研究

以小龙潭电厂燃煤飞灰及其不同粒径范围的分级灰为对象,采用X射线荧光光谱、X射线衍射、离子色谱、Zeta电位、扫描电镜等实验方法研究了飞灰的物理化学特征.同时采用沉降实验、表面张力实验研究了三种不同润湿剂对飞灰的润湿性能.研究发现,溶液对飞灰的润湿能力不仅取决于其气液界面张力,还与飞灰的组成、表面电位以及形貌特征密切相关.亲水性物质含量的增加,颗粒表面电荷与润湿剂分子间的静电吸引,颗粒表面的棱角孔隙等均可以促进其润湿;温度越高飞灰润湿性能越好,且温度对飞灰润湿过程影响较大,温度较高(60℃)时润湿剂种类及浓度对飞灰润湿过程的影响不明显.     

燃煤锅炉粉煤灰中痕量元素赋存形态研究

本文运用改进的Tessier法对某燃煤电厂静电除尘器收集的三个电场的粉煤灰进行分级提取(SEE)实验研究.SEE实验将粉煤灰中的重金属分为五个存在形态进行分级提取:水溶态(pH=7),酸溶态(pH=5),氧化物结合态,难还原态及残渣态.试验结果表明,残渣态在ESP除尘器所收集的飞灰中含量占据绝大部分;在容易迁移的离子可交换态和酸溶态中,所研究的痕量重金属元素均呈现出FA1相似文献   

Spectral analysis of rare-earth elements in ash of sapropel and its fractions

Quantitative atomic emission spectral analysis was used to study the rare-earth content in sapropel and the rare-earth distribution over the isolated fractions. The conditions for determination of Ce, Y, and La (analytical lines, arc discharge current, exposure time) were selected empirically. We calculated the metrological characteristics of the proposed technique. We have shown that in Tyurin fractionation, the nonhydrolyzable residue fraction has the highest concentrations of these elements. Translated from Zhurnal Prikladnoi Spektroskopii, Vol. 76, No. 2, pp. 273–276, March–April, 2009.     

Mg2+和Na+对高熔点煤灰熔融性的影响

以山西阳泉固庄高熔点煤灰为研究对象,通过向煤灰中添加不同量的MgO与Na₂CO₃,研究了Mg²⁺与Na⁺在高温下对煤灰熔融性的影响。研究结果表明,煤灰熔融温度随氧化镁的添加(5%~25%)单调下降;而随氧化钠添加(5%~25%)出现先降后升现象,在氧化钠添加量为15% 时,灰熔点达到最低。XRD分析表明,阳泉固庄煤灰熔融温度高(大于1 750℃)的原因是高温条件下耐熔矿物莫来石、方英石的存在。添加外加剂后,高温时外加剂与硅酸盐矿物反应,生成了更多的低共熔矿物霞石、堇青石等。同时,Mg²⁺和Na⁺的加入会使得非桥氧数量增多,高温煤灰低聚物增多,降低了煤灰的熔融温度。通过三元相图以及SEM分析,高温条件下煤灰中部分元素的富集以及团聚现象是导致Mg²⁺和Na⁺对煤灰熔融温度影响不同的原因。     

Size-based analysis of incinerator fly ash using gravitational SPLITT fractionation, sedimentation field-flow fractionation, and inductively coupled plasma-atomic emission spectroscopy

Fly ash has been regarded as hazardous because of its high adsorption of toxic organic and/or inorganic pollutants. Fly ash is also known to have broad distributions of different chemical and physical properties, such as size and density. In this study, fly ash emitted from a solid waste incinerator was pre-fractionated into six sub-populations by use of gravitational SPLITT fractionation (GSF). The GSF fractions were then analyzed by sedimentation field-flow fractionation (SdFFF) and ICP–AES. SdFFF analysis showed the fly ash has a broad size distribution ranging from a few nanometers up to about 50 µm. SdFFF results were confirmed by electron microscopy. Inductively coupled plasma–atomic emission spectroscopy (ICP–AES) analysis of the GSF fractions showed the fly-ash particles contain a variety of inorganic elements including Ca, Si, Mg, Fe, and Pb. The most abundant in fly ash was Ca, followed by Si then Mg. No correlations were found between trace element concentration and particle size.     

配煤燃烧过程中煤灰熔融性研究

采用灰熔点较低的神华煤和较高的准格尔煤以及这两种煤组成的混煤在沉降炉内进行实验,模拟实际电站锅炉内结渣的形成过程。采用SEM、XRD技术对煤粉和灰渣的微观形貌和晶相成分进行分析。结果表明,准格尔煤粉中包含的大量高岭石和勃姆石为莫来石的大量生成提供了条件,神华煤中不含勃姆石,高岭石的含量也不多,莫来石的生成量很少。莫来石在高温下遇到石灰石的分解产物CaO,要与之反应生成钙长石,这是神华煤灰渣中没有检测到莫来石衍射峰的主要原因。莫来石是一种高熔点矿物（1850℃）,能显著改善煤灰的熔融温度,神华煤灰渣中不含莫来石,灰渣中缺少大量能在其熔融过程中发挥“骨架”作用的成分,这是导致神华煤灰熔融温度较低的一个重要原因。