高速沉积微晶硅薄膜光发射谱的研究

采用PR650光谱光度计对高速沉积微晶硅薄膜的生长过程进行了在线监测研究,并对所对应的材料进行了Raman谱和红外吸收谱(FTIR)的测试.结果表明：能反映材料晶化程度的I_［SiH^*］/I_［Hβ^*］比值在沉积时间为100 s之内有下降的趋势,且反应气体总流量T_fl越小下降趋势越明显,这与拉曼散射光谱对材料的结构测试结果一致;沉积5 min时I 关键词： 高速沉积 微晶硅薄膜 电子温度     

纳米Ag材料表面等离子体激元引起的表面增强拉曼散射光谱研究

用热蒸发的方法制备了纳米Ag材料,并用扫描电子显微镜对纳米粒子进行了形貌的表征,通过紫外—可见分光光度计得到Ag纳米粒子的透过谱,得到了Ag纳米粒子的表面等离子体共振的峰值位置.以罗丹明6G为探针分子测定Ag纳米粒子衬底的表面增强拉曼散射效应,通过拉曼散射光谱与透过谱研究了由表面等离子体激元的强极化场引起的表面增强拉曼散射效应,结合透过谱与拉曼增益因子提出了一种描述表面等离子体光学和电学特性的方法,并结合扫描电镜的结果给出了不同结构的纳米Ag材料对表面等离子体激元强度的影响. 关键词： 热蒸发 纳米Ag材料 表面等离子体 表面增强拉曼散射     

微晶硅太阳电池

采用VHF-PECVD技术制备了系列微晶硅太阳电池．综合测试结果表明：硅烷浓度、热阱温度和前电极都对微晶硅太阳电池的性能有影响．在湿法腐蚀的ZnO衬底上制备的电池的效率比在ZnO/SnO2复合膜上制备的电池的效率高1.5%．在优化了沉积条件后,制备出效率达6.7%的微晶硅太阳电池（Jsc=18.8mA/cm2,Voc=0.526V,FF=0.68）,电池的结构是glass/ZnO/p(μc-Si∶H)/i(μc-Si∶H)/(a-Si∶H)/Al,没有ZnO背反射电极．     

气压对VHF-PECVD制备的μc-Si:H 薄膜特性影响的研究

本文主要研究了用VHF-PECVD方法制备的不同工作气压的微晶硅薄膜样品.结果表明:沉积速率随反应气压的增大而逐渐增大;光敏性(光电导/暗电导)和激活能测试结果给出了相同的变化规律;傅立叶红外测试、X射线衍射和室温微区喇曼谱的结果都表明了样品的晶化特性;通过工艺的具体优化得出了器件级的微晶硅材料.     

从P-a-SiC:H到P-μc-Si:H过程中材料特性的变化

采用RF-PECVD方法,在P-a-SiC:H薄膜沉积技术基础上,通过逐步减小碳、硼的掺杂浓度,增大氢稀释率,使材料从非晶态向微晶态转变,在获得本征微晶材料之后,再逐步增大硼掺杂浓度,得到P型微晶硅薄膜材料(暗电导率为5.22×10-3S/cm,光学带隙大于2.0eV).在这个过程中可以明显观察到碳、硼抑制材料晶化的作用.     

SiO2阻挡层对电子束沉积法生长高迁移率IWO薄膜性能的影响

利用电子束沉积技术在玻璃衬底上制备了IWO( In2O3∶WO3)薄膜和SiO2缓冲层,并将SiO2缓冲层对IWO薄膜性能的影响作了探究.SiO2缓冲层在室温生长.SIMS测试表明:SiO2缓冲层能有效阻挡浮法玻璃中的杂质进入到IWO薄膜.实验获得的具有SiO2阻挡层的IWO薄膜的电子迁移率μ～54.5 cm2·V-1·s-1,电阻率p ～5.86×10-4Ω,cm,电子载流子浓度n～ 1.95×1020 cm-3,400～1600nm砌光谱区域内的平均透过率～76;.     

退火温度和β-FeSi2薄膜厚度对n-β-FeSi2/p-Si异质结太阳电池的影响

本文采用室温直流磁控溅射Fe-Si组合靶的方法,并通过后续退火温度的优化得到了单一相高质量的β-FeSi2薄膜.结果表明,在本实验条件下得到的未掺杂的β-FeSi2薄膜在室温下是n型导电的,其电学特性存在一个退火温度的最优点:800 ℃.而且在这个最佳温度点上,在Si(111)衬底上外延得到的薄膜载流子迁移率比在Si(100)上高出了一倍多.在上述研究的基础上,采用p-Si(111)单晶片作为外延生长β-FeSi2薄膜的衬底,并通过退火温度和薄膜厚度的优化制备出了国内第一个n-β-FeSi2/p-Si异质结太阳电池,其Jsc=7.90 mA/cm2 ,Voc=0.21 V,FF=0.23,η=0.38;.     

Effect of substrate temperature and pressure on properties of microcrystalline silicon films

In this paper intrinsic microcrystalline silicon films have been prepared by very high frequency plasma enhanced chemical vapour deposition (VHF-PECVD) with different substrate temperature and pressure. The film properties were investigated by using Raman spectra, x-ray diffraction, scanning electron microscope (SEM), and optical transmittance measurements, as well as dark conductivity. Raman results indicate that increase of substrate temperature improves the microcrystallinity of the film. The crystallinity is improved when the pressure increases from 50Pa to 80Pa and the structure transits from microcrystalline to amorphous silicon for pressure higher than 80Pa. SEM reveals the effect of substrate temperature and pressure on surface morphology.     

Microstructure and lateral conductivity control of hydrogenated nanocrystalline silicon oxide and its application in a-Si:H/a-SiGe:H tandem solar cells

Phosphorous-doped hydrogenated nanocrystalline silicon oxide(n-nc-SiO_x:H) films are prepared via radio frequency plasma enhanced chemical vapor deposition(RF-PECVD). Increasing deposition power during n-nc-SiO_x:H film growth process can enhance the formation of nanocrystalline and obtain a uniform microstructure of n-nc-SiO_x:H film. In addition,in 20 s interval before increasing the deposition power, high density small grains are formed in amorphous SiO_x matrix with higher crystalline volume fraction(I_c) and have a lower lateral conductivity. This uniform microstructure indicates that the higher Ic can leads to better vertical conductivity, lower refractive index, wider optical band-gap. It improves the back reflection in a-Si:H/a-SiGe:H tandem solar cells acting as an n-nc-SiO_x:H back reflector prepared by the gradient power during deposition. Compared with the sample with SiO_x back reflector, with a constant power used in deposition process,the sample with gradient power SiO_x back reflector can enhance the total short-circuit current density(Jsc) and the initial efficiency of a-Si:H/a-SiGe:H tandem solar cells by 8.3% and 15.5%, respectively.     

L12／3Ca1／3MnOz薄膜中的巨磁阻效应

采用直流磁控溅射法在ＺｒＯ２衬底上首次成功地制备了Ｌａ２／３Ｃａ１／３ＭｎＯｚ薄膜，Ｘ－射线衍射结果表明该膜具有良好的择优取向，并首次观察到十分明显的巨磁阻效应，在６个特斯拉磁场下，室温时的磁阻比为６％，而７８度Ｋ时竟高达２５００％，中还对磁阻比的磁场关系作了简单的讨论