Comparison of the kinetic behavior of crystalline cane and beet sucrose thermal decomposition

Journal of Thermal Analysis and Calorimetry - In this work, an experimental investigation on the effects of temperature and concentration of nanoparticles on the viscosity of...     

General remarks on the thermal decomposition of some drugs

The thermal decomposition of antituberculous, local anaesthetic and calcium salts of organic acids used as the drugs has been studied by differential thermal and thermogravimetric techniques. General characteristics of their thermal decomposition has been made. The effect of sample size over the range 20–200 mg and heating rate over the range 3–15 deg·min^?1 on the thermal degradation has been investigated. The values of the kinetic parameters has been also determined.     

Non-isothermal kinetic studies on thermal decomposition of energetic materials

Thermal stability and decomposition kinetics for two energetic materials, potassium nitroform (KNF) and 5-Nitro-2,4-dihydro-3H-1,2,4-triazol-3-one (NTO), were investigated to obtain information on their safety for handling, storage, and use. Differential scanning calorimetry (DSC) and simultaneous thermogravimetry-differential thermal analysis (TG-DTA) techniques have been used to study thermal behavior of these energetic compounds. The results of TG analysis revealed that the main thermal degradation for the KNF occurs during two temperature ranges of 270?C330 and 360?C430?°C. Meanwhile, NTO decomposes completely in temperature range of 250?C300 °C. TG-DTA analysis of KNF indicates that this energetic compound dehydrated (at about 108?°C) before its decomposition. However, NTO is thermally stable until its decomposition. The decomposition kinetic of energetic materials was studied by non-isothermal DSC under various heating rates. Kinetic parameters such as activation energy and frequency factor for thermal decomposition of energetic compounds were obtained via the methods proposed by ASTM E696 and Starink. Also, thermodynamic parameters correspond to the activation of thermal decomposition and critical ignition temperatures of the compounds were obtained.     

硫酸铵的热分解

目前 ,关于各种无机酸铵盐的热分解情况都研究得比较清楚 ,但关于硫酸铵热分解情况的报道结果则不一致[1 - 7] 。本文对硫酸铵在各种温度下的常量热分解进行了研究 ,探讨其热分解机理 ,以利于对磷石膏 (主要成分为ＣａＳＯ4)的开发利用提供新的思路和方法[8] 。1　实验坩锅炉中热分解　约 1 0ｇ(ＮＨ4) 2 ＳＯ4置于恒重坩埚中 ,再放入坩埚炉中升温至设定温度 ,恒温0 5ｈ ,取出冷却 ,称重。并将坩埚中残余物用水溶解 ,测定水溶液中的Ｈ+、ＮＨ+4、ＳＯ2 -4 等离子的含量。其中ＮＨ+4含量采用甲醛法测定 ,ＳＯ2 -4 含量采用硫酸钡重量法测定…     

A gas-phase kinetic study on the thermal decomposition of 2-chloropropene

The gas-phase thermal decomposition of 2-chloropropene in the presence of a radical inhibitor was studied in the temperature range of 668.2–747.2 K and pressure between 11–76 Torr using the conventional static system. The dehydrochlorination to propyne and HCl was the only reaction channel and accounted for >98% of the reaction. The formation of propyne was found to be homogeneous and unimolecular and follows a first-order rate law. The observed rate coefficient is expressed by the following Arrhenius equation: $$ k_{total} = 10^{13.05 \pm 0.46} (s^{ - 1} )\exp ^{ - 242.6 \pm 6.2({{kJ} \mathord{\left/ {\vphantom {{kJ} {mol}}} \right. \kern-\nulldelimiterspace} {mol}})/RT} . $$ The hydrogen halide elimination is believed to proceed through a semipolar four-membered cyclic transition state. The presence of a methyl group on the α-carbon atom lowered the activation energy by 47 kJ mol^?1. The experimentally observed pressure dependence of the rate constant is compared with the theoretically predicted values that are obtained by RRKM calculations.     

Characteristics of the thermal decomposition of antituberculous drugs

The thermal decomposition of antituberculous drugs-ethambutol (base and dihydrochloride), isoniazid, ethionamid and pyrazinamid has been studied by DTA, TG and DTG techniques. General remarks have been made on their thermal destruction. The effect of sample size over the range 20–200 mg and heating rate over the range 3–15 deg·min^?1 on the thermal degradation has also been investigated. Moreover, based on the Kissinger’s equation, the values of the kinetic parameters were determined.     

A thermochemistry and kinetic study on the thermal decomposition of ethoxyquinoline and ethoxyisoquinoline

Quantum chemical calculations were used to study the production of ethylene and keto/enol tautomers from ethoxyquinoline (2‐EQ) and ethoxyisoquinoline (1‐EisoQ and 3‐EisoQ) in the gas phase and ethanol at the MP2/6‐311++G(2d,2p)//BMK/6‐31+G(d,p) level. The obtained data indicate that the elimination of ethylene from 1‐EisoQ and 2‐EQ is slightly more favorable than from 3‐EisoQ. Formation of quinolone and isoquinolone (2‐EQO, 1‐EisoQO, and 3‐EisoQO) is kinetically favored compared to their enols. Decomposition of 2‐EQ and 1‐EisoQ to ethylene and keto forms is thermodynamically and kinetically preferable more stable than the corresponding enols. However, the hydroxy form of 3‐EisoQ is more stable than its keto tautomer in the gas phase and ethanol. The enol tautomers cost less energy when formed from their keto forms rather than from the parent ethoxyquinolone and ethoxyisoquinoline.     

Theoretical kinetic investigation of thermal decomposition of nitropropane

The thermal decomposition of nitropropane (CH₃CH₂CH₂NO₂) has been investigated at the CBS-QB3 level of theory. The pyrolysis of CH₃CH₂CH₂NO₂ mainly includes the simple bond ruptures mechanism, hydrogen abstraction processes, isomerization and secondary reactions. As a result, for the simple bond ruptures mechanism, the formation of \({\text{CH}}_{3} {\text{CH}}_{2} {\text{CH}}_{2}^{\cdot} +\,^{\cdot}{\text{NO}}_{2}\) products is dominant with the energy barrier of 49.77 kcal mol^?1. The process of H atom on the β–CH₂ abstracted by one O atom of NO₂ moiety in CH₃CH₂CH₂NO₂(CH₃CH₂CH₂NO₂ → CH₃CH=CH₂ + HONO) needs to overcome lower energy barrier than that of the rate-determining step (one of H atom on the α-CH₂ and γ-CH₃ abstracted of reaction) of the other hydrogen abstraction reactions. Therefore, we predict that the corresponding alkenes and HONO are the main products in the hydrogen abstraction reaction of nitroparaffin. Besides, the channel of the CH₃CH₂CHO + HNO formations (CH₃CH₂C(α)H₂NO₂ → CH₃CH₂C(α)H₂ONO → CH₃CH₂CHO + HNO), occurring through the H atom of C(α) abstracted by the N atom of NO₂ moiety after the isomerization reaction from CH₃CH₂CH₂NO₂ to CH₃CH₂CH₂ONO, is favorable in the isomerization secondary reactions. Rate constants and branching ratios are estimated by means of the conventional transition state theory with zero curvature tunneling over the temperature range of 400–1500 K. The calculation shows that the overall rate constant in the temperature of 400–1500 K is mainly dependent on the competitive channels of formations of CH₃CH=CH₂ + HONO and \({\text{CH}}_{3} {\text{CH}}_{2} {\text{CH}}_{2}^{\cdot} +\,^{\cdot}{\text{NO}}_{2}\) The three-parameter expression for the total rate constant is fitted to be k _total = 1.74 × 10^?13 T ^8.20exp(17038.7/T) (s^?1) between 400 and 1500 K.     

Studies on multistep thermal decomposition behavior of polytriazole polyethylene oxide‐tetrahydrofuran elastomer

Polytriazole polyethylene oxide‐tetrahydrofuran (PTPET) is an energetic propellant elastomer that is prepared using glycidyl azide polymer and trifunctional alkynyl‐terminated polyethylene oxide‐tetrahydrofuran. Its thermal decomposition, determined using thermogravimetic analysis, showed two mass‐loss peaks largely related to the decomposition of azide groups and the main chain. Flynn‐Wall‐Ozawa and Kissinger‐Akahira‐Sunose methods were deployed to obtain kinetic triplet parameters of PTPET thermal decomposition by the traditional model‐free method; the Coats‐Redfern approach was used as the model‐fitting method. Kinetics analysis indicated that the mechanism of the two‐step reactions were the primary‐reaction of first order and the power‐law phase reaction of the 2/3 order. The first decomposition stage of PTPET had an activation energy (E_a) of 113 to 116 kJ/mol while the second was 196 to 210 kJ/mol. The thermal decomposition of PTPET with different heating rates and mechanisms showed good kinetic compensation effects, the gas products being further studied with TG‐FTIR.     

Non-isothermal kinetic study of the thermal decomposition of diaminoglyoxime and diaminofurazan

Data on the thermal stability of organic materials such as diaminofurazan (DAF) and diaminoglyoxime (DAG) was required in order to obtain safety information for handling, storage and use. These compounds have been shown to be a useful intermediate for the preparation of energetic compounds. In the present study, the thermal stability of the DAF and DAG was determined by differential scanning calorimetery (DSC) and simultaneous thermogravimetery-differential thermal analysis (TG-DTA) techniques. The results of TG analysis revealed that the main thermal degradation for the DAF and DAG occurs in the temperature ranges of 230–275°C and 180–230°C, respectively. On the other hand, the TG-DTA analysis of compounds indicates that DAF melts (at about 182°C) before it decomposes. However, the thermal decomposition of the DAG started simultaneously with its melting. The influence of the heating rate (5, 10, 15 and 20°C min⁻¹) on the DSC behaviour of the compounds was verified. The results showed that, as the heating rate was increased, decomposition temperatures of the compounds were increased. Also, the kinetic parameters such as activation energy and frequency factor for the compounds were obtained from the DSC data by non-isothermal methods proposed by ASTM E698 and Ozawa. Based on the values of activation energy obtained by ASTM and Ozawa methods, the following order in the thermal stability was noticed: DAF>DAG.     

Studies on the thermal decomposition of thermosetting aniline-formaldehyde resins

The thermal decomposition of different aniline-formaldehyde (A-F) resins (1:1, 1:2. 1:3, 1:4 and 1:5) is studied in nitrogen and oxygen atmospheres. Values for the apparent reaction order, activation energy, pre-exponential factor are evaluated for different stages of decomposition. The validity of the linear kinetic compensation law is observed. The apparent activation energy values are higher in a nitrogen atmosphere than in an oxygen atmosphere and the higher value of the activation energy for the 1:5 A-F resin compared with the other A-F resins may be attributed to its larger cross-link density.     

Structural kinetic rules governing the thermal decomposition of pyridine N-oxides

The Arrhenius parameters of the thermal composition of pyridine N-oxides in the liquid phase have been determined. The conclusion has been reached that the formation of an oxaziridine activated complex can be considered as the initial act of the thermolysis. A correlation has been found to exist between the rate constants of the thermal decomposition and the calculated values of the fractional electron charge at the oxygen of the N-oxide, and the length of the N- O bonds.Kazan' State Technological University, Kazan' 420015. Biisk Liceum of the Altai Region, Biisk 659322. Translated from Khimiya Geterotsiklicheskikh Soedinenii, No. 5, pp. 644–646, May, 1994. Original article submitted April 4, 1994.     

新型高能炸药热分解研究进展

炸药的热分解对其安定性和库存可靠性等研究是很重要的。本文总结了国内外有关TNAZ(1,3,3-三硝基氮杂环丁烷)、NTO(3-硝基-1,2,4-三唑-5-酮)、LLM-105(1-氧-2,6-二氨基-3,5-二硝基吡嗪)、FOX-7(1,1-二氨基-2,2-二硝基乙烯)等几种新型高能炸药的热分解研究。分别从理论上、实验上阐述了它们的热分解研究现状,指出了以前研究中存在的问题,预测了钝感高能炸药热分解的发展前景。参考文献32篇。     

The kinetic parameters of thermal decomposition hydrated iron sulphate

The thermal decomposition of iron sulphate hexahydrate was studied by thermogravimetry at a heating rate of 5°C min^?1 in static air. The kinetic parameters were evaluated using the integral method by applying the Coats and Redfern approximation. The thermal stabilities of the hydrates were found to vary in the order. Fe₂(SO₄)₃·6H₂O → Fe₂(SO₄)₃·4.5H₂O → Fe₂(SO₄)₃·0.5H₂O The dehydration process of hydrated iron sulphate was found to conform to random nucleation mass loss kinetics, and the activation energies of the respective hydrates were 89.82, 105.04 and 172.62 kJ mol^?1, respectively. The decomposition process of anhydrous iron sulphate occurs in the temperature region between 810 and 960 K with activation energies 526.52 kJ mol^?1 for the D3 model or 256.05 kJ mol^?1 for the R3 model.     

Studies on the thermal decomposition of N-2,4,6 tetranitro-N-methyl aniline

The kinetics of the initial stage of thermal decomposition of N-2,4,6 tetranitro-N-methyl aniline (tetryl) in condensed state has been investigated by high temperature infrared spectroscopy (IR) in conjunction with pyrolysis gas analysis and thermogravimetry (TG). The decomposition in KBr matrix in the temperature range of 131 to 145 °C shows rapid decrease in the N-NO₂ band intensity as compared to the C-NO₂ band. Decomposition products in the initial stage show mainly NO₂ gas and picric acid. The studies show that the initial stage of decomposition of tetryl occurs by the rupture of the N-NO₂ bond and the energy of activation for this process is 177 kJ/mol.

---

Zusammenfassung Mittels Hochtemperatur-IR-Spektroskopie wurde in Verbindung mit Pyrolysengasanalyse und Thermogravimetrie (TG) die Kinetik des einleitenden Schrittes der thermischen Zersetzung von N-2,4,6-Tetranitro-N-Methylanilin (Tetryl) im kondensierten Zustand untersucht. Die Zersetzung in einer KBr-Matrix im Temperaturbereich von 131–145 °C äußert sich in einem schnellen Abnehmen der Intensität der N-NO₂ Bande bezogen auf die der C-NO₂ Bande. Zersetzungsprodukte des einleitenden Schrittes sind hauptsächlich NO₂ Gas und Pikrinsäure. Die Untersuchungen zeigten, daß der einleitende Schritt der Zersetzung von Tetryl die Spaltung der N-NO₂ Bindung ist. Die Aktivierungsenergie für diesen Prozess beträgt 177 kJ/mol.

---

N-2,4,6-N- () , . 131–145 °C N-NO₂ C-NO₂. . , N-NO₂, 177 /.

     

An experimental study on thermal decomposition behavior of magnesite

Thermal decomposition of magnesite is investigated by using a TG–MS. Different kinetic methods including Coats–Redfern, Flynn–Wall–Ozawa, and Kissinger–Akahira–Sunose are used to investigate the thermal decomposition kinetics of magnesite. It was observed that the activation energy values obtained by these methods are similar. The average apparent activation energy is found to be about 203 kJ mol^?1. The raw magnesite and its decomposition products obtained at different temperatures are analyzed by Fourier transform infrared spectroscopy (FTIR), X-ray diffraction (XRD), and scanning electron microscope (SEM). The concentration of functional groups, crystal structure and composition, and apparent morphology of decomposition products were studied in detail. The FTIR, XRD, and SEM analyses showed that magnesite was completely decomposed at 973 K to form MgO.