Catalytic reduction of nitrogen monoxide with propene over Nb/TiO2 mixed mechanically with Mn2O3

Selective catalytic reduction of nitrogen monoxide (NO) over a catalyst of mechanically mixed Nb/TiO₂ and Mn₂O₃ (Mn₂O₃+Nb/TiO₂) in an oxidizing atmosphere with propene (C₃H₆) was studied. The Mn₂O₃+Nb/TiO₂ catalyst showed high activity for the reduction of NO to N₂. The maximum conversion of NO to N₂ was observed at 200∼300°C, with about 80% reduction of NO to N₂. Mn₂O₃ enhanced the formation of NO₂ from NO and the activation of propene to react with NO₂ for reduction to N₂.     

Conversion of NO in NO/N2, NO/O2/N2, NO/C2H4/N2 and NO/C2H4/O2/N2 Systems by Dielectric Barrier Discharge Plasmas

An experimental study on the conversion of NO in the NO/N₂, NO/O₂/N₂, NO/C₂H₄/N₂ and NO/C₂H₄/O₂/N₂ systems has been carried out using dielectric barrier discharge (DBD) plasmas at atmospheric pressure. In the NO/N₂ system, NO decomposition to N₂ and O₂ is the dominating reaction; NO conversion to NO₂ is less significant. O₂ produced from NO decomposition was detected by an on-line mass spectrometer. With the increase of NO initial concentration, the concentration of O₂ produced decreases at 298 K, but slightly increases at 523 K. In the NO/O₂/N₂ system, NO is mainly oxidized to NO₂, but NO conversion becomes very low at 523 K and over 1.6% of O₂. In the NO/C₂H₄/N₂ system, NO is reduced to N₂ with about the same NO conversion as that in the NO/N₂ system but without NO₂ formation. In the NO/C₂H₄/O₂/N₂ system, the oxidation of NO to NO₂ is dramatically promoted. At 523 K, with the increase of the energy density, NO conversion increases rapidly first, and then almost stabilizes at 93–91% of NO conversion with 61–55% of NO₂ selectivity in the energy density range of 317–550 J L⁻¹. It finally decreases gradually at high energy density. A negligible amount of N₂O is formed in the above four systems. Of the four systems studied, NO conversion and NO₂ selectivity of the NO/C₂H₄/O₂/N₂ system are the highest, and NO/O₂/C₂H₄/N₂ system has the lowest electrical energy consumption per NO molecule converted.     

Selective reduction of NO2 by propylene in excess oxygen over Rh/Al2O3. DRIFT spectroscopy and activity studies

A DRIFT study has shown that similar surface species are formed on Rh/Al₂O₃ during the selective catalytic reduction of NO₂ or NO by C₃H₆, indicating that the reduction of both molecules proceeds via a similar pathway. A strong correlation was observed between the –NCO and –CN infrared band intensities and NO₂ conversion.     

Reducibility of Mo species in Pt/MoO3 and PtMo/Al2O3 catalysis

Recucibility of Mo species in Pt/MoO₃ and PtMo/Al₂O₃ has been investigated by temperature-programmed reduction (TPR), temperature-programmed desorption of hydrogen (H₂-TPD) and temperature programmed electronic conductivity (TPEC) techniques. In Pt/MoO₃ at H₂ atmosphere, it was found by TPEC and TPR that, a slight amount of Pt could activate the transfer of the species and H atoms between H₂ and MoO₃, and thus accelerate the reduction of MoO₃. In PtMo/Al₂O₃, TPR and H₂-TPD revealed that the reduction of surface Mo species could also be facilitated by Pt. Two kinds of hydrogen molybdenum species were proposed on the surface of the catalyst after prereduction.     

(La0.8A0.2)MnO3 (A = Sr,K) perovskite catalysts for NO and C10H22 oxidation and selective reduction of NO by C10H22

In this work, we studied the catalytic activity of LaMnO₃ and (La_0.8A_0.2)MnO₃ (A = Sr, K) perovskite catalysts for oxidation of NO and C₁₀H₂₂ and selective reduction of NO by C₁₀H₂₂. The catalytic performances of these perovskites were compared with that of a 2 wt% Pt/SiO₂ catalyst. The La site substitution increased the catalytic properties for NO or C₁₀H₂₂ oxidation compared with the non-substituted LaMnO₃ sample. For the most efficient perovskite catalyst, (La_0.8Sr_0.2)MnO₃, the results showed the presence of two temperature domains for NO adsorption: (1) a domain corresponding to weakly adsorbed NO, desorbing at temperatures lower than 270 ℃ and (2) a second domain corresponding to NO adsorbed on the surface as nitrate species, desorbing at temperatures higher than 330 ℃. For the Sr-substituted perovskite, the maximum NO₂ yield of 80% was observed in the intermediate temperature domain (around 285 ℃). In the reactant mixture of NO/C₁₀H₂₂/O₂/H₂O/He, (La_0.8Sr_0.2)MnO₃ perovskite showed better performance than the 2 wt% Pt/SiO₂ catalyst： NO₂ yields reaching 50% and 36% at 290 and 370 ℃, respectively. This activity improvement was found to be because of atomic scale interactions between the A and B active sites, Sr²⁺ cation and Mn⁴⁺/Mn³⁺ redox couple. Thus, (La_0.8Sr_0.2)MnO₃ perovskite could be an alternative free noble metal catalyst for exhaust gas after treatment.     

合成方法对Rh/CeO2-ZrO2-La2O3催化剂的结构、表面性能及DeNOx活性的影响

用沉积沉淀法合成两种不同系列的CeO2-ZrO2-La2O3混合氧化物(ZrO2和La2O3沉积CeO2粒子(标记为A-x)以及CeO2和La2O3沉积ZrO2粒子(标记为B-x)),并用作Rh催化剂的载体。XRD、拉曼、TPR、XPS和O2脉冲等表征结果显示出不同的沉积顺序将导致不同的结构和氧化还原性能,且B-x具有更高的氧迁移性、储氧能力和表面Ce浓度。当其负载Rh后,Rh/B-x催化剂具有更高的NO和CO转化率及N2选择性,且Ce的最佳含量为50at%。这可能归因于Rh负载于富铈表面形成更多有利于NO分解的表面Ce3+活性位。     

Catalytically Promoted NOx Sorption by ZrO2-Based Oxides

Metal promoted zirconia-based oxide sorbents, such as Pt–ZrO₂/Al₂O₃ for NO _x have been investigated. To clarify the role of the catalyst component, sorption of NO and NO₂ was compared using the samples with and without Pt. The catalytic oxidation of NO to NO₂ and successively to nitrate ions is an important role for the Pt catalyst. The experimental results indicate that a high-temperature calcination is essential to remove residual Cl from Pt–ZrO₂–Al₂O₃ prepared from H₂PtCl₆ in order to provide more active NO _x sorption sites. Of M–ZrO₂–Al₂O₃ samples investigated, ruthenium as well as Pt demonstrated relatively good performance as a catalyst component in the sorbent. The FT-IR spectra after sorption of NO and NO₂ demonstrated a strong band attributed to stored nitrate ions. The Pt catalyst was more resistant to sulfur poisoning than a base metal catalyst. However, the NO _x sorptive capacities of the Pt–ZrO₂/Al₂O₃ sorbents were expected to be deteriorated in dilute SO₂ as far as observed from FT-IR spectra.     

Theoretical study on reactions of cyclic-N3 with NO, NO2 and Cl2

In this article, we report our detailed mechanistic study on the reactions of cyclic-N₃ with NO, NO₂ at the G3B3//B3LYP/6-311+G(d) and CCSD(T)/aug-cc-pVTZ//QCISD/6-311+G(d)+ZPVE levels; the reactions of cyclic-N₃ with Cl₂ was studied at the G3B3//B3LYP/6-311+G(d) and CCSD(T)/aug-cc-pVTZ//QCISD/6-31+G(d)+ZPVE levels. Both of the singlet and triplet potential-energy surfaces (PESs) of cyclic-N₃ + NO, cyclic-N₃ + NO₂ and the PES of cyclic-N₃ + Cl₂ have been depicted. The results indicate that on singlet PESs cyclic-N₃ can undergo the barrierless addition–elimination mechanism with NO and NO₂ forming the respective dominant products N₂ + ¹cyclic-NON and ¹NNO(O) + N₂. Yet the two reactions on triplet PESs are much less likely to take place under room temperature due to the high barriers. For the cyclic-N₃ + Cl₂ reaction, a Cl-abstraction mechanism was revealed that results in the product cyclic-N₃Cl + Cl with an overall barrier as high as 14.7 kcal/mol at CCSD(T)/aug-cc-pVTZ//QCISD/6-31+G(d)+ZPVE level. So the cyclic-N₃ radical could be stable against Cl₂ at low temperatures in gas phase. The present results can be useful for future experimental investigation on the title reactions.     

Synthesis and properties of pentamethylmetallocene derivatives Cp*MCp (M = Ru, Fe). Crystal structure of the salt [CpRuC5Me4CH2+OC6H2(NO2)3-]

Photolysis of a solution of Cp*RuCp (1) in CF₃CO₂H generates salt [CpRu(C₅Me₄CH₂)]-(O₂CCF₃)(2 • O₂CCF₃). The reaction of compound 1 with oleum at 20 °C through the intermediate dication [η⁵-(CH₂C₅Me₄)Ru(μ:η⁵,ν⁵-C₅H₄C₅H₅)Ru(C₅Me₄CH₂)-η⁶]²⁺ leads to the triply charged cation η⁷CH₂)₂C₅Me₃Ru(μη⁵,η⁵-C₅H₄C₅H₄)Ru(C₅Me₄CH₂)-η⁶]³⁺. Synthesis of pentamethylmetallocene derivatives CpMC₅Me₄X (M = Ru, Fe; X = CHO, CH₂OH, CH₂An) has been accomplished. The reactions of 1-hydroxymethyl-2,3,4,5-tetramethylruthenocene with acids CF₃CO₂H, HBF₄, CF₃CO₂H/NaB[C₆H₃(CF₃)₂]₄, and picric acid C₆H₂(NO₂)₃OH afforded salts 2•X (X = CF₃CO₂, BF₄, B[C₆H₃(CF₃)₂]₄), and (2,3,4,5-tetram ethylruthenocenyl)methyl picrate [CpRu(C₅Me₄CH₂)-η⁶][(C₆H₂(NO₂)₃O] (2•C₆H₂(NO₂)₃O). Structure of the latter was characterized by single crystal X-ray diffraction.     

Infrared studies of the diatomic molecules O2, N2, NO and H2 adsorbed on Fe2O3

An infrared spectroscopic study of the diatomic molecules O₂, N₂, NO and H₂ adsorbed under different conditions on Fe₂O₃ has been performed.Complex patterns of absorption on both α-Fe₂O₃ and γ-Fe₂O₃ activated in O₂ at high temperature are assigned to vibrations of two different chemisorbed O₂ species.N₂ molecules do not interact with “oxygen rich” α-Fe₂O₃ surfaces, but give N₂O^? and N₂O₂^2? species when chemisorbed on evacuated surfaces.NO molecules give complex patterns of absorption, depending on the gas pressure. Three different types of nitrate structures can be identified, as well as NO, NO^? and cis-N₂O₂ chemisorbed species. Chemisorbed water molecules are formed by contact of H₂ with Fe₂O₃ surfaces even at room temperature.     

荧光XAFS表征Pt/BaAl2O4-Al2O3催化剂中的微量铂物种

随着稀薄燃烧(lean-burn)发动机的推广使用和环保法规的日趋严格,消除稀燃尾气中的氮氧化物(N O x)已刻不容缓。N O x储存还原技术被认为是最具应用前景的方法之一[1,2]。目前,对Pt/BaA l2O4-A l2O3体系中N O x储存与还原机制的研究较多[1￣4],但对该体系中微量铂物种微观结构及其与性能的关系研究较少,这主要是由于Pt含量(0.1w t%￣0.5wt%)太低,分散度较高,使表征方法受到很大限制。本文采用共沉淀-浸渍法制得具有较高比表面积和热稳定性的N O x储存还原催化剂Pt/BaA l2O4-A l2O3,应用荧光X-射线吸收精细结构方法(Fluores-cence-…     

Vibrational emission of NO2 from the reaction of NO with O3

Vibrational chemiluminescence in the Δν₁ = Δν₃ = ?1 band of NO₂ is observed both in the O + NO and O₃ + NO reactions and shown to be emitted by molecules with up to 11 000 cm^?1 of vibrational energy. Quenching rate constants of NO₂³ are estimated ranging from about 6 × 10^?14 for Ar to about 3 × 10^?12 cm³ s^?1 for NO₂. The ratio of vibrational to electronic emission is 0.06 ± 0.03 for O + NO and 5.3 ± 1.0 for O₃ + NO. It is suggested that vibrationally excited NO₂ is a major product of that channel of the O₃ + NO reaction which forms ground-state NO₂(²A₁) directly.     

1-Allyl derivatives: Synthesis and crystal structures for [(NH2C5H4N(C3H5))2Cu3Cl3(NO3)2] and [C9H7N(C3H5)Cu(NO3)2]

1-Allyl-4-aminopyridinium chloride reacts with Cu(NO₃)₂ · 3H₂O in an ethanolic solution under the conditions of ac electrochemical synthesis at copper electrodes to form crystals of compound [(NH₂C₅H₄N(C₃H₅))₂Cu₃Cl₃(NO₃)₂] (I). The crystals of compound I are monoclinic: space group P2₁/c, Z = 4, a = 25.770(7), b = 7.230(4), c = 12.505(5) ?, β = 92.58(3)°, V = 2328(2) ?³. The direct interaction of 1-allylquinolinium nitrate with Cu(NO₃)₂ · 3H₂O in a methanolic solution in the presence of metallic copper yields crystals of compound [C₉H₇N(C₃H₅)Cu(NO₃)₂] (II). The crystals of compound II are triclinic: space group P , a = 6.756(3), b = 8.391(4), c = 12.489(5) ?, α = 77.18(3)°, β = 89.48(4)°, γ = 73.32(3)°, V = 662.0(5) ?³. The structure of compound I is built of infinite linear anions: polymeric fragments {(NH₂C₅H₄N(C₃H₅))₂Cu₃Cl₃(NO₃)₂} _n . Each of two copper atoms (Cu(1) and Cu(2)) π-coordinates the C=C bonds of the allyl groups of the 1-allyl-4-aminopyridinium cations, the oxygen atom of the nitrate ions, and two chlorine atoms. The third copper atom Cu(3) is linearly linked with two chlorine atoms. Particular polymeric fragments are additionally joined by the N-H…O, C-H…O, C-H…Cl hydrogen bonds. The crystal structure of compound II is built-up of the isolated L₂Cu₂(NO₃)₄ fragments (L is the 1-allylquinolinium cation). The metal atom is localized in the trigonal pyramidal coordination environment of three oxygen atoms of the nitrate ions and of the C=C bond of the allyl group of the cation. The particular L₂Cu₂(NO₃)₄ fragments are additionally joined by the C-H…O hydrogen bonds. Original Russian Text ? A.V. Pavlyuk, T. Lis, M.G. Mys’kiv, 2009, published in Koordinatsionnaya Khimiya, 2009, Vol. 35, No. 6, pp. 458–462.     

Vapour-liquid equilibrium data for the systems C2H6 + N2, C2H4 + N2, C3H8 + N2, and C3H6 + N2

High pressure vapour-liquid equilibrium data for the C₂H₆ + N₂, C₂H₄ + N₂, C₃H₈ + N₂, and C₃H₆ + N₂ systems are presented. The data are obtained isothermally in the range from 200 K to 290 K. For each point of data, temperature, pressure and liquid and vapour phase mole fractions are measured.Values for the vapour phase mole fractions are calculated from the obtained pressure, temperature and liquid phase mole fractions. The calculated values are compared with the experimental results, and it is found that the average mean deviation between calculated and experimental mole fractions is less than 0.009 for the systems considered in this work.     

Nox Reduction Characteristics for Different Composition Ratios of Pt/Al2O3, Rh/Al2O3 Catalyst Mixtures Using Model Gas as Reformates

This study investigated the selective catalytic reduction (SCR) of nitrogen oxides (NO_x) with hydrocarbon in the presence of excess oxygen using various composition ratios of Pt/Al₂O₃, Rh/Al₂O₃ catalyst mixtures. The composition ratios were 1:1, 1:2, 2:1, 1:3 and 3:1 of 1 wt% Pt/Al₂O₃ and Rh/Al₂O₃, which are known to exhibit efficient NO_x reduction at low and high temperatures among the noble metal catalysts. Experiments conducted on a single reductant revealed that more efficient NO_x conversion could be obtained when Pt/Al₂O₃ and Rh/Al₂O₃ were mixed at a ratio of 3:1, rather than 1:1 or 1:3. In a single reductant condition, C₃H₆ 800 ppm (2400 ppmC₁) and 400 ppm (1200 ppmC₁) exhibited 50% and 38% NO_x conversion efficiency at 200°C, respectively. However, NO_x conversion efficiency gradually decreased when temperatures were increased above 250°C. With regard to Pt/Al₂O₃ and Rh/Al₂O₃ ratio, higher ratios of Rh/Al₂O₃ activated this Pt+Rh/Al₂O₃ catalyst in the high temperature range.     

NO2对Cu/SAPO-34分子筛催化剂上NH3选择性催化还原NO性能的影响

主要考察了NO₂对Cu/SAPO-34 分子筛催化剂在整个温度范围内（100-500 ℃）NH₃选择性催化还原（SCR）NO性能的影响. 研究所使用样品为新鲜Cu/SAPO-34 催化剂在750 ℃下水热处理4 h 的稳定期样品.通过X射线衍射（XRD）和扫描电子显微镜（SEM）对样品的结构以及形貌进行表征,采用SCR活性评价、动力学实验以及原位漫反射傅里叶变换红外光谱（in situ-DRIFTS）表征催化剂的性能以及催化剂表面物种的变化. 活性评价实验结果表明,NO₂会抑制催化剂的低温（100-280 ℃）活性,但其存在会提高催化剂的高温（280 ℃以上）活性. 与此同时,随着反应物中NO/NO₂的摩尔比例减少,由于NH₄NO₃物种的分解,副产物（N₂2O）的浓度增大. 动力学结果表明,Cu/SAPO-34 催化剂上快速SCR反应的表观活化能（E_a=64.02 kJ·mol^-1）比标准SCR反应的表观活化能（E_a=48.00 kJ·mol^-1）更大. In situ-DRIFTS实验结果表明NO比NO₂更容易在催化剂表面形成硝酸盐,并且NO₂更容易与吸附在Brønsted 酸性位上的NH₃物种反应生成NH₄NO₃. 低温下,催化剂表面的NH₄NO₃物种会覆盖SCR反应的活性位,造成活性降低,但在高温时,形成的NH₄NO₃物种一部分会被NO还原为N2,而另一部分会直接热分解为N₂O,造成催化剂的选择性降低.     

Selective Catalytic Reduction of NO with Propene over Au/Fe2O3/Al2O3 Catalysts

A series of Au/Fe₂O₃/Al₂O₃ catalysts were prepared by the homogeneous deposition-precipitation method. The catalytic activity of the catalyst samples for selective catalytic reduction of NO by propene under oxygen-rich atmosphere was evaluated. The results showed that 2%Au/10%Fe₂O₃/Al₂O₃ exhibited good low-temperature activity. The maximum of NO conversion reached 43% at 300 °C, while it was only 21% over the 2%Au/Al₂O₃ catalyst at the same temperature. The addition of 2% steam to the feed gas had little effect on the catalytic activity. X-ray diffraction results indicated that both Au and Fe₂O₃ particles were highly dispersed over Al₂O₃. H₂-temperature-programmed reduction results indicated that there was strong interaction between Au and Fe₂O₃, which made the reduction of Fe₂O₃ easy. The synergistic effect between Au and Fe₂O₃ was probably responsible for the good catalytic performance of the Au/Fe₂O₃/Al₂O₃ catalyst at low temperature.     

Specific spectral properties of a photochromic ferromagnetic (C25H23N3O3Cl)CrMn(C2O4)3·H2O

A molecular magnetic (C₂₅H₂₃N₃O₃Cl)CrMn(C₂O₄)₃·H₂O whose spiropyran cation contains a quaternized pyridine fragment in the side aliphatic chain was synthesized for the first time. The compound possesses the properties of a ferromagnetic with T _c = 5.2 K and photochromic properties in the crystalline state. The photochemical properties of the hybrid compound were studied by electronic and IR spectroscopies. Photochromic transformations of the spiropyran cation are accompanied by the appearance of a broad absorption band in the region 400–600 nm in the electronic spectra and by reduction of intensity of the ν(C_spiro-O) IR band at 942 cm⁻¹. Published in Russian in Izvestiya Akademii Nauk. Seriya Khimicheskaya, No. 6, pp. 1055–1061, June, 2007.     

N2O and NO2 Formation in the Disproportionation of no over Ion Exchanged Cu-ZSM-5 at Lower Temperature

NO₃-type and NO₂-type adsorbed species are formed on Cu-ZSM-5 together with adsorbed O species at 523 K in the decomposition of NO accompanied by the evolution of N2, N₂O, and NO₂. This revised version was published online in June 2006 with corrections to the Cover Date.     

Pt LIII-edge XANES and EXAFS studies on γ-Al2O3 supported Pt catalysts

Pt L_III-edge XANES and EXAFS were employed to investigate the nature of Pt/γ-Al₂O₃, Pt−Sn/γ-Al₂O₃ and Pt−Fe/γ-Al₂O₃ catalysts. The results indicated that Pt species on these catalysts were all in the oxidized states before reduction, and in the metallic states after reduction. The dispersity of the Pt species on the catalysts was very high after reduction. The electronic properties of the highly dispersed Pt species were different from that of the bulk Pt in large crystallites. An interaction between Pt and the metal-oxide modified γ-Al₂O₃ support is proposed. The interaction improved the dispersity of the Pt species on the catalysts and is thought to be the reason for the enhanced activity and selectivity for dehydrogenation reactions over these catalysts.