草酸对丙烯酸酯-胺体系稳定作用研究

研究了草酸对TEGMA-DMT,TEGA-DMT,HPMA-DMT体系的氧化和聚合的影响。表明微量草酸对丙烯酸酯-胺体系的稳定作用非常突出,比对苯二酚大得多,是此体系有效的稳定剂。认为草酸的稳定作用首先是它抑制丙烯酸酯-胺体系氧化,使体系中不能生成过氧化合物,从而使体系稳定不聚合。     

芳香叔胺引发烯类单体聚合研究——单体结构与聚合的关系

不同烯类单体在芳香叔胺存在下的聚合机构不一样。甲基丙烯酸甲酯等有α-甲基的烯类单体在不照光的条件下即可被芳香叔胺引发聚合,其聚合机构认为是首先α—甲基被胺-氧复合物氧化,生成单体过氧化物。再与胺形成氧化还原体系,分解产生自由基。 丙烯酸酯,丙烯腈等没有α-甲基的单体,只有光照时才被芳香叔胺氧化聚合,不光照时完全不聚合。这是因为这些单体不被胺-氧复合物氧化。光照下聚合的机构认为是因光的激发,这些单体与芳香叔胺形成电子转移激发络合物,再分解产生自由基。 研究了单体结构,胺结构对光聚合速度的影响。不同单体的活性次序是: AN>MA>VA>St 不同芳香叔胺的活性次序是: DMT>DMA>DMB>DNA 表明单体双键电子云密度越小,芳香叔胺氮原子上电子云密度越大,越容易形成激发态电子转移络合物,从而越容易聚合。     

含胺基功能性单体的聚合研究 Ⅴ.4-N,N-二甲胺基苯乙烯的合成及其作为氧化还原引发体系组分的研究

<正> 前文我们报告了含有芳香叔胺基的丙烯酸酯、甲基丙烯酸-4-N,N-二甲氨基苄酯(DMABMA)在过氧化二月桂酰(LPO)引发下的聚合动力学。从所得的聚合速度方程式及低的聚合活化能,认为DMABMA与LPO形成氧化还原体系而使DMABMA聚合,在本文第Ⅳ报中报道了DMABMA不仅能引发甲基丙烯酸甲酯的聚合,还参与聚甲基丙烯酸甲酯的链中,因此称这种既能参与引发聚合反应,又参与聚合物链中的引发“引发剂单体(initiatomer)”。这种含有可聚合胺引发体系的优点是,用于丙烯酸酯类医用     

胺存在下自由基聚合与活性自由基聚合

综述了胺存在下自由基聚合,包括含胺的过氧化二酰与芳叔胺氧化还原体系、有机过氧化氢物与芳叔胺或脂肪叔胺氧化还原体系、过硫酸盐与脂肪胺氧化还啄体系和极性单体的胺光诱导电荷转移引发自由基聚合,以及活性／控制自由基聚合,主要为原子转移自由基研究的成果。     

丙烯酸酯在苯肼存在下的氧化和聚合研究

苯肼存在下丙烯酸酯的吸氧和氧化速度迅速增加,苯肼浓度约0.1—1.0％范围时,并发生聚合。 不同结构丙烯酸酯在苯肼存在下的吸氧与聚合的次序为:甲基丙烯酸 2-甲氧基乙酯>甲基丙烯酸羟基丙酯>甲基丙烯酸甲酯。我们认为苯肼存在下丙烯酸酯的氧化机构可能是苯肼结合丙烯酸酯醚键或双键α位碳原子上的氢,形成负碳离子或疏松离子对,从而在氧作用下生成过氧化合物。     

己内醯胺的聚合——Ⅱ.己内醯胺聚合反應的引發

己內醯胺聚合的最初階段為加成聚合。作者研究若干種化合物,試驗它們對己內醯胺聚合的引發作用。結果,自由基型的引發劑如過氧化苯甲醯,過氧化氫和它們的氧化還原體系,均不能引發己內醯胺的聚合。羧酸在無水存在時其引發作用甚弱。胺類則缺乏引發效應。但羧酸与胺同時存在時能迅速的引起己內醯胺的聚合。氨基酸不論何種類型均有迅速的引發作用。苯甲醯胺基己酸的引發作用遠較苯甲酸為差。碘化三甲基苯基銨(季銨鹽)不能引發己內醯胺的聚合,而N-甲基己內醯胺也不能用這些引發劑引起聚合。根據以上結果,己內醯胺聚合顯非自由基型的聚合,亦非引發劑与單體的逐步加成。作者建議引發劑的正負兩種離子都有影響。引發機構是由於氫原子的轉移,使己內醯胺發生雙離子式的極化,因而發生聚合。     

聚乙二醇型超支化聚酯胺的制备及表征

以M_n=250的聚乙二醇二丙烯酸酯为A_2单体(含有两个A基因的单体,其余类推),N-乙基乙二胺为B'B_2单体,利用丙烯酸酯基和胺基的迈克尔加成聚合反应,一锅法合成了表面含丙烯酸酯键、骨架含聚乙二醇(PEG)、内部含叔胺的具有三维椭球状结构的超支化聚酯胺,并研究了其聚合动力学。利用咪唑对超支化聚酯胺进行改性,并初步研究了咪唑改性的超支化聚酯胺的pH响应性和水溶性。利用核磁共振氢谱、红外光谱、凝胶渗透色谱、GPC-MALLS多角度激光散射系统表征了超支化聚酯胺的分子结构和化学组成。结果表明:聚乙二醇链段的引入能够赋予超支化聚酯胺水溶性;咪唑的引入有利于提高超支化聚酯胺的pH响应性。     

含叔胺基功能性单体的聚合研究——ⅩⅤⅠ.含吗啉基聚丙烯酸酯类及其水凝胶的温度敏感性

我们曾报道过含吗啉基丙烯酰类单体在过氧化物或芳酮存在下的热聚合及光聚合,以及做为氧化-还原引发体系组分引发烯类单体聚合的研究。利用这类单体与过硫酸盐所构成的引发体系可以获得分子量达千万的聚丙烯酰胺。实验中还发现某些含吗啉基的丙烯酸酯类聚合物的水溶液及其水凝胶具有温度敏感性。本文合成了以下四种含吗啉基丙烯酸酯类单体:     

过硫酸盐和脂肪胺引发体系的研究

本文研究了用过硫酸盐和各种水溶性脂肪胺组成的体系引发丙烯酰胺水溶液聚合的规律。发现伯胺、仲胺和叔胺都能有效地促进聚合。胺的促进活性随结构不同而异。发现了一种简便可靠的检测脂肪胺端基的新方法:CTC吸收光谱法。测定了聚合动力学并提出了引发反应机理。     

二苯酮-可聚合胺引发1,6-己二醇二丙烯酸酯的光聚合研究

以UV-Vis分光光度计法和Photo-DSC法分别研究了合成的3种可聚合胺类助引发剂DMPDA、EGDPM、EGMPM与二苯甲酮(BP)组成的引发体系的光化学初级过程及引发1,6-己二醇二丙烯酸酯(HDDA)的紫外光聚合动力学.考察了助引发剂胺的含量对BP的光化学初级过程和对引发HDDA光聚合动力学的影响,以及光强和温度对聚合动力学的影响.结果表明,随着胺含量的增加,BP的光化学初级反应速率增加,从而使体系的聚合反应速率增加.随着温度和光强的增加,单体最终转化率、最大反应速率增大,达到最大反应速率所需的时间减小.     

含胺引发体系烯类聚合的研究

研究了BPO-胺引发体系中,不同胺对MMA聚合速度与所得聚合物色泽稳定性的影响,以及单独使用胺时对MEMA聚合的影响。实验结果表明:在前者情况下,胺对聚合反应的活性顺序为DMT≈DHET>DMA;而对聚合物的色泽稳定性也有类似的结果。从聚合速度与对色泽的要求来说,BPO-DMT与BPO-DHET是较好的引发体系。在后者的情况下,胺的活性顺序为DMT DHET>DMA>MBDMA,从聚合动力学研究可得R_p=K[DMT]~(1/2)[MEMA]_(3/2),聚合表现活化能E_a=34.3千焦耳/克分子(8.2千卡/克分子)。     

STUDIES ON VINYL POLYMERIZATION WITH INITIATION SYSTEM CONTAINING AMINE DERIVATIVES

Two main types of amine-containing initiation systems were studied in this work. In the case of MMA polymerization initiated by BPO-amine (DMT, DHET, DMA) redox systems, it was found that the polymerization rate and colour stability of the polymer for different amine systems were in the following order: DMT≈DHET>DMA. Accordingly, BPO-DMT and BPO-DHET are effective initiators. In the case of MEMA polymerization by amine (DMT, DHET, DMA) alone, it was found that the polymerization rate and the percentage of conversion for these different amine systems were in the following order: DMT≥DHET>DMA. The polymerization rate and the percentage of conversion also increased with the increase of DMT concentration. From the kinetic investigation the rate equation of R_P=K [DMT]~(1/2) [MEMA]~(3/2) was obtained, and the overall activation energy of polymerization was calculated to be 34.3 KJ/mol (8.2 Kcal/mol). Moreover, the polymerization of MEMA in the presence of DMT was strongly inhibited by hydroquinone, indicating the polymerization being free radical in nature. From these results, the mechanism of MEMA polymerization initiated by amine was proposed.     

芳香叔胺引发丙烯腈光聚合研究

我们发现芳香叔胺是丙烯腈聚合极有效的光引发剂。芳香叔胺苯环上氢被正性基取代时,引发能力增加,被负性基取代时,引发能力下降。下列胺的活性次序是:N,N-二甲基对甲苯胺(DMT)>N,N-二羟乙基对甲苯胺(DHET)>N,N-二甲基苯胺(DMA)>N,N-二甲胺基苯甲醛(DMB)>N,N-二甲基对硝基苯胺(DNA)。芳香叔胺引发丙烯腈光聚合属自由基机构,聚合速度与叔胺浓度的0.66次方成正比。在叔胺浓度为10~(-2)—10~(-4)M范围内,聚合物平均聚合度的倒数与叔胺浓度的0.5次方成正比。初步认为在紫外光激发下,芳香叔胺与丙烯腈分子生成激发态电子转移络合物,再分解产生自由基,引发丙烯腈聚合。     

STUDIES ON THE INITIATION MECHANISM OF ORGANIC PEROXIDE AND N-METHACRYLOYLOXYETHYL-N-METHYL ANILINE IN METHYL METHACRYLATE POLYMERIZATION

The initiation mechanism of methyl methacrylate (MMA) polymerization by organic peroxide and polymerizable aromatic tertiary amine such as N-methacryloyloxyethyl-N-methyl aniline (MEMA) binary system has been studied. The kinetics of polymerization of MMA and the ESR spectra of organic peroxide/MEMA system were determined. Based on the ESR study and the end-group analysis by UV spectra of the polymer formed, the initiation mechanism is proposed.     

Amine activators for the “cool” peroxide initiated polymerization of acrylic monomers

Two tertiary amines with a chemical structure rather similar to dimethyl-4-toluidine have been prepared and tested as activators for the free radical polymerization of methyl methacrylate. 4-Dimethylaminobenzyl alcohol, DMOH, was synthesized by reduction of the corresponding benzaldehyde. 4-Dimethylaminobenzyl methacrylate, DMMO, was synthesized by condensation of methacryloyl chloride with DMOH in the presence of triethylamine as catalyst. Kinetic studies of the bulk polymerization of methyl methacrylate initiated by the redox system BPO–amine have been carried out by differential scanning calorimetry at different temperatures in the interval 30–40°C. An increase of the overall rate constant, k, with increasing temperature was observed for all redox systems. The system BPO/DMT gave the highest values of k. The polymerizations catalyzed by DMOH and DMMO respectively gave lower values of the overall Arrhenius activation than that obtained with DMT. DMMO may participate in the polymerization not only as activator but also as an acrylic derivative which can be incorporated into the polymeric growing chains during the propagation step of the free radical polymerization. © 1996 John Wiley & Sons, Inc.     

STUDY OF THE EFFECT OF TWO BPO/AMINE INITIATION SYSTEMS ON THE FREE-RADICAL POLYMERIZATION OF MMA USED IN DENTAL RESINS AND BONE CEMENTS

ABSTRACT

The kinetics of the free radical bulk polymerization of methyl methacrylate (MMA) was studied by DSC, using the benzoyl peroxide (BPO)/amine initiation system. N,N dimethyl-4-aminophenethyl alcohol (DMPOH), which is a newly synthesized and used amine in the preparation of acrylic dental resins and bone cements was examined, and the results compared to the most commonly used in these applications amine, the N,N dimethyl-p-toluidine (DMT). For both amines, the effect of the molar ratio of BPO/amine and of the reaction temperature, on the polymerization kinetics was investigated. The prepared polymers were characterized by determination of the average molecular weights (M¯ _n and M¯ _w ) and molecular weights distribution (M¯ _w /M¯ _n ) using Gel Permeation Chromatography. DMPOH was found to lead in slightly higher polymerization rates, lower gel times and lower molecular weights than DMT. The values of these parameters for both amines were influenced by the molar ratio of BPO to amine, when the product of the concentrations of these was kept constant. The highest polymerization rate occurred in the lowest gel time, resulting in polymers with the lowest molecular weight, and was observed when a molar ratio of about 1.5 BPO/amine was used. However, the final monomer conversion was found to be independent of the molar ratio and amine used. The activation energy of polymerization was found to be 51.8 kJ/mol K for BPO/DMPOH and 47.1 kJ/mol K for BPO/DMT.     

N-甲基-N-(2-甲基丙烯酰氧乙基)苯胺与其聚合物的荧光光谱

<正> 我们曾报道过甲基丙烯酸-4-N,N-二甲氨基苄酯(DMABMA)、N-(4-N′N′-二甲氨基苯基)代丙烯酰胺(DMAPMA)、8-丙烯酰氧喹啉(AQ)、N-丙烯酰-N′-苯基哌嗪(APP)等在同一分子中含有缺电子双键和给电子发色基团的单体及它们的聚合物在溶液中的荧光行为。在相同的链节克分子浓度下,这些单体的荧光强度比其聚合物的荧光强度低很多。我们将这种现象称为“结构自猝灭现象”。这种现象是由于共存在这类     

N-甲基-N-(2-甲基丙烯酰氧乙基)苯胺敏化的丙烯腈光聚合

The photopolymerization of acrylonitrile sensitized by N-methyl-N-(2-methacryloyloxye-thyl)aniline (MEMA) was studied kinetically. The photopolymerization rate of AN in DMF by using MEMA as sensitizer is proportional to 0.32 th power of MEMA concentration and 1.20 th power of AN concentration. The overall activation energy for the polymerization was found to be 4.82 Kcal/Mol. From the fluorescence analysis of obtained polyacrylonitrile sensitized by MEMA, it was confirmed that MEMA not only joined the inition but also entered into the polyacrylonitrile chains. The initiation mechanism was proposed tentatively.