低硅铝比ZSM-5分子筛上C4烃的催化裂解反应

以低硅铝比(n(SiO2)/n(Al2O3)=20-45)的ZSM-5分子筛为催化剂, 研究了混合C4烃的催化裂解反应, 并对不同硅铝比的ZSM-5分子筛进行了酸性表征. 混合C4烃的催化裂解反应结果表明, 低硅铝比的ZSM-5分子筛具有较高的低温催化活性, 高硅铝比ZSM-5分子筛催化剂上乙烯和丙烯的收率高于低硅铝比ZSM-5分子筛催化剂, 低硅铝比ZSM-5分子筛上苯和甲苯的收率高于高硅铝比ZSM-5分子筛催化剂. 在反应温度为625 ℃时, 硅铝比为20的ZSM-5分子筛催化剂上乙烯、丙烯、苯和甲苯的总收率可达79.42%. 酸性表征结果表明, 硅铝比低的ZSM-5分子筛具有更多的Bronsted(B)酸酸量、Lewis(L)酸酸量及总酸酸量, 这是低硅铝比ZSM-5分子筛具有低温高活性及高的苯和甲苯收率的原因.     

Dealuminated ZSM-5 Zeolite Catalyst for Ethylene Oligomerization to Liquid Fuels

Ethylene oligomerization using ZSM-5 zeolite was investigated to study the role of Bronsted acid sites in the formation of higher hydrocarbons. The oligomerization of olefins, dependent on the acidity of ZSM-5 zeolite, is an important step in the conversion of natural gas to liquid fuels. The framework Si/Al ratio reflects the number of potential acid sites and the acid strength of the ZSM-5 catalyst. ZSM-5 with the mole ratio SiO2/Al2O3 equal to 30 was dealuminated for different periods of time according to the acidic ion-exchange method to produce ZSM-5 with various Si/Al ratios. The FT-IR analysis revealed that the integrated framework aluminum band, non-framework aluminum band, and silanol groups areas of the ZSM-5 zeolites decreased after being dealuminated. The performance of the dealuminated zeolite was tested for ethylene oligomerization. The results demonstrated that the dealumination of ZSM-5 led to higher ethylene conversion, but the gasoline selectivity was reduced compared to the performance     

CF-2沸石的表面酸性及催化性能

CF-2是一种新型的高硅沸石。1981年我们实验室首先在二乙醇胺-甘油-Na₂O-SiO₂-Al₂O₃-H₂O体系中制备成功^[1],以后才见到关于Theta-1^[2],ISI-1^[3],KZ-2^[4],NO-10^[5]和ZSM-22^[6]沸石的报道。     

超低硅铝比多级孔ZSM-5分子筛的无模板剂合成

以水玻璃为硅源、Al₂(SO₄)₃·18H₂O为铝源,投料硅铝比SAR=n(SiO₂)/n(Al₂O₃)=40,前躯体凝胶pH=11.2、Na₂O/SiO₂=0.18、 H₂O/SiO₂=43、m(晶种)/m(SiO₂)=0.16,不添加任何模板剂条件下合成了具有多级孔结构的超低硅铝比ZSM 5分子筛,其结构经²⁷Al NMR, SEM-EDS, Py-IR, NH₃-TPD, XRD和N₂-吸脱附表征。SEM结果表明ZSM-5分子筛晶体为侧面呈“维管束”状的长方体;EDS分析表明其表面硅铝分布具有显著不均一性：顶底表面SAR=20,侧面SAR=13。NH₃-TPD分析表明：该ZSM-5分子筛整体具备可观的弱酸总酸量(1.9 mmol·g^-1),且以Lewis酸为主。N₂吸脱附实验表明：ZSM-5分子筛存在明显的介孔结构,属同时含有微孔-介孔结构的多级孔、超低硅铝比ZSM-5分子筛。     

Solvate-supported proton transport in zeolites.

Solvate-supported proton transport in zeolite H-ZSM-5 was studied by means of complex impedance spectroscopy. The zeolite shows enhanced proton mobility in the presence of NH3 and H2O that depends on the concentration of the solvate molecule, temperature (298-773 K), and the SiO2/Al2O3 ratio of the zeolite (30-1000). In general, proton conductivity in H-ZSM-5 is most effectively supported in the presence of NH3 and H2O at high concentrations, low temperatures, and low SiO2/Al2O3 ratios (< or = 80). For the aluminum-rich samples desorption measurements reflect different transport mechanisms that depend on the respective temperature range. Up to about 393 K a Grotthus-like proton transport mechanism is assumed, whereas at higher temperatures (393-473 K) vehiclelike transport seems to dominate. The activation energies for NH4+ and H3O+ vehicle conductivity depend on the SiO2/Al2O3 ratio, and the values are in the range of 49-59 and 39-49 kJ mol-1, respectively, and thus significantly lower than those for "pure" proton conduction in solvate-free samples.     

载体组成对负载型PtSn/ZSM-5催化剂上丙烷脱氢反应性能的影响

用微型催化反应装置结合吡啶吸附的红外光谱、NH3-程序升温脱附、热重、H2化学吸附和程序升温还原等物理化学手段研究了载体组成对负载型PtSn/ZSM-5催化剂上丙烷脱氢反应性能的影响.结果表明,负载型PtSn/ZSM-5催化剂对丙烷脱氢的催化性能与载体组成密切相关.随着ZSM-5载体中SiO2/Al2O3比的增加,催化剂表面的酸中心总量和强酸中心量逐渐减少.当SiO2/Al2O3摩尔比从45增至108时,催化剂对丙烷脱氢反应的催化活性提高,并且催化剂的积炭量下降.当SiO2/Al2O3摩尔比增至304时,Sn组分与载体ZSM-5之间的相互作用减弱,经H2还原后催化剂中Sn0物种所占的比例增加,导致催化剂H2化学吸附量和丙烷脱氢反应活性下降.     

Dealuminated ZSM—5 Zeolite Catalyst for Ethylene Oligomerization to Liquid Fuels

Ethylene oligomerization using ZSM-5 zeolite was investigated to study the role of Broensted acid sites in the formation of higher hydrocarbons,The oligomeriztion of olefins,dependent on the acidity of ZSM-5 zeolite ,is an important step in the conversion of natural gas to liquied fuels,The framework Si/Al ratio reflects the number of potential acid sites and the acid strength of the ZSM-5 catalyst,ZSM-5 with the mole ratio SiO2/Al2O3 equal to 30 was dealuminated for different periods of time according to the acidic ion-exchange method to produce ZSM-5 with various Si/Al ratios,The FT-IR analysis revealed that the integrated framework aluminum band,non-framework aluminum band,and silanol groups areas of the ZSM-5 zeolites decreased after being dealuminated,The performanc of the dealuminated zeolite was tested for ethylene oligomerization.The results demonstrated that the dealumination of ZSM-5 led to higher ethylene conversion,but the gasoline selectivity was reduced compared to the performance of a ZSM-5 zeolite ,The characterization results revealed the amount of aluminum in the zeolitic framework,the crystallinity of the ZSM-5 zeolite,and the Si/Al ration affected the formation of Broensted acid sites,The number of the Broensted acid sites on the catalyst active sites is important in the olefin conversion to liquied hydrocarbons.     

Synthesis and Characterization of Ferrierite-Type Zeolite in the Presence of Nonionic Surfactants

Pure-phase ferrierite (FER) zeolite has been synthesized in the presence of small amounts of nonionic surfactants, Tween 20 and Tween 80. The input SiO(2)/Al(2)O(3) molar ratio has been varied over a range of 25 to 150. The results confirm that a small amount of pyrrolidine acts as a template and is necessary. The effects of varying concentration of surfactant on ferrierite crystallization and output SiO(2)/Al(2)O(3) molar ratio are reported. The results also show that in the absence of pyrrolidine, ZSM-5 cocrystallized with FER, whereas in the absence of a nonionic surfactant the yield and crystallization of FER are very poor. The XRF analysis shows the changes in SiO(2)/Al(2)O(3) output molar ratios as the surfactant concentration changes. The XRD data show that the samples are fully crystalline and pure. The TG/DTA of the sample shows its structural stability. The scanning electron microscopy results show changes in particle size with varying concentration of nonionic surfactant. Copyright 2001 Academic Press.     

不同晶粒尺寸H-ZSM-5催化剂上甲醇芳构化反应性能

芳烃是一类重要的有机化工基础原料,通常采用传统的石油路线生产芳烃,包括催化裂化和催化重整等工艺.由于石油资源的紧缺,以可再生资源为原料生产芳烃工艺的发展具有十分重要的意义.甲醇作为一种重要的基础原料,可来源于煤、天然气和生物质等,因此,甲醇制芳烃工艺(MTA)的研究受到日益关注.ZSM-5分子筛具有较大的比表面积、可调节的酸性、优良的择形选择性和很高的水热稳定性,因而在甲醇芳构化中展现出良好的催化性能.研究发现,甲醇转化率和产物分布与ZSM-5分子筛的酸性和多孔性等密切相关.本文通过调控模板剂与水的比例和晶化时间,采用水热法制备了一系列不同晶粒度H-ZSM-5分子筛催化剂,通过X射线衍射(XRD)、扫描电镜(SEM)、N2物理吸附脱附(BET)和X射线荧光光谱等技术对所得分子筛的理化性质、骨架结构和形貌进行了表征;采用吡啶红外光谱和NH3程序升温脱附技术对其酸性进行了分析,使用热重(TG)技术对反应后催化剂的积碳含量进行了分析,并将所制备的H-ZSM-5分子筛催化剂分别应用于MTA反应,系统性地探究分子筛晶粒度对其理化性质和MTA催化性能的影响.XRD结果表明,所合成的五种样品均具有典型的ZSM-5分子筛特征衍射峰且无杂晶,且具有不同的晶粒度,分别为4.0±0.3,1.2±0.2 μm,614.1±31.9、391.9±32.4和99.1±7.0 nm.N2物理吸附脱附曲线可以发现,晶粒度为99.1±7.0 nm的ZSM-5分子筛展现出典型的Ⅰ型和Ⅳ型物理吸附曲线且在较高的相对压力(P/Po=0.8-1.0)处有一个明显的H4型迟滞环,表明此分子筛具有介孔和大孔结构;BJH吸附孔径分布图表明,这些介孔主要分布在2-7和20-50 nm范围内;同时各样品的比表面积和孔体积随着其晶粒度的减小而增大.结果还表明五种不同晶粒度的ZSM-5分子筛具有相似的SiO2/Al2O3摩尔比和酸性质.MTA反应结果表明,随着催化剂晶粒度的降低,甲醇的平均转化率,芳烃选择性和BTX选择性有所提高,在300 min时晶粒度较大的三个催化剂上,甲醇转化率迅速降至90％,而晶粒度较小的两个催化剂上,甲醇转化率始终维持在95％以上,其中晶粒度为99.1±7.0 nm的样品上芳烃选择性最高(平均42％以上),BTX选择性达37％.对失活催化剂积碳含量分析,随着催化剂晶粒度的降低,积碳量降低.晶粒度较低的纳米分子筛催化剂具有更短的孔道,更高效的扩散性能,更高的比表面积和独特的梯级孔结构,因而在甲醇芳构化反应中展现出更长的寿命,更高的活性和更低的积碳量,在甲醇制芳烃工业化生产中具有巨大潜力.     

Characterization and Activity of Cr, Cu and Ga Modified ZSM—5 for Direct Conversion of Methane to Liquid Hydrocarbons

Direct conversion of methane using a metal-loaded ZSM-5 zeolite prepared via acidic ion exchange was investigated to elucidate the roles of metal and acidity in the formation of liquid hydrocarbons. ZSM-5 (SiO2/A12O3=30) was loaded with different metals (Cr, Cu and Ga) according to the acidic ion-exchange method to produce metal-loaded ZSM-5 zeolite catalysts. XRD, NMR, FT-IR and N2 adsorption analyses indicated that Cr and Ga species managed to occupy the alllmlnum positions in the ZSM-5 framework. In addition, Cr species were deposited in the pores of the structure. However, Cu oxides were deposited on the surface and in the mesopores of the ZSM-5 zeolite. An acidity study using TPD-NH3, FT-IR, and IR-pyridine analyses revealed that the total number of acid sites and the strengths of the BrSusted and Lewis acid sites were significantly different after the acidic ion exchange treatment.Cu loaded HZSM-5 is a potential catalyst for direct conversion of methane to liquid hydrocarbons. The successful production of gasoline via the direct conversion of methane depends on the amount of aluminum in the zeolite framework and the strength of the BrSnsted acid sites.     

乙炔、丙烯在多种分子筛上的吸附和脱附性质

在80℃下研究了ZSM5、13X、Y、MOR、5A、SAPO34等多种分子筛和常见载体上乙炔和丙烯的吸附和脱附性能。结果表明,乙炔和丙烯在SiO2、γ-Al2O3上不吸附,而与分子筛存在较强的相互作用。对于同类型的分子筛,两者的饱和吸附量均随分子筛硅铝比的增大而减小。在同一种分子筛上,以摩尔计的丙烯吸附量均明显高于乙炔。在80℃改性β分子筛上乙炔和丙烯饱和吸附量可分别达到0.11mmol/g和4.89mmol/g,该结果明显高于文献报道的结果。     

苯甲醚在复合催化剂上的催化酰化

复合催化剂首次用于催化苯甲醚与酰化剂乙酰氯的酰化反应.发现不同沸石的单独使用仅给出很低产率的对-甲氧基苯乙酮.但是由HY沸石(硅铝比=40)或USY(超稳Y沸石)和SnO组成的复合催化剂的催化活性比单独使用沸石时高得多.增加由USY沸石和不同量的SnO组成的复合催化剂中的SnO的量,导致对-甲氧基苯乙酮产率的提高.由H型沸石(HY和H-ZSM-5沸石)和SnO组成的复合催化剂在苯甲醚与乙酰氯的酰化反应中的催化活性主要取决于所用沸石的硅铝比.     

Optimization of hydrothermal synthesis of H-ZSM-5 zeolite for dehydration of methanol to dimethyl ether using full factorial design

H-ZSM-5 zeolite was synthesized by hydrothermal method.The effects of different synthesis parameters,such as hydrothermal crystallization temperature(170-190 C) and Si/Al molar ratio(100-150),on the catalytic performance of the dehydration of methanol to dimethyl ether(DME) over the synthesized H-ZSM-5 zeolite were studied.The catalysts were characterized by N 2 adsorption-desorption,XRD,NH 3-TPD,TGA/DTA,and SEM techniques.The full factorial design of experiments was applied to the synthesis of H-ZSM-5 zeolite and the effects of synthesis conditions and their interaction on the yield of DME as the response variable were determined.Analysis of variance showed that two variables and their interaction significantly affected the response.According to the experimental results,the optimized catalyst prepared at 170 C with the Si/Al molar ratio of 100 showed the best catalytic performance among the tested H-ZSM-5 zeolite.     

纯固体配料体系中不同碱金属卤化物对ZSM－48沸石合成及性质的影响 Ⅱ．不同卤化钾的影响

纯固体配料体系中引入碱金属钾的不同卤化物ＫＸ（Ｘ＝Ｆ~－，Ｃｌ~－，Ｂｒ~－，Ｉ~－）对ＺＳＭ－４８沸石的晶化和性质有着显著的影响。ＸＲＤ测试结果表明：引入不同的卤化钾对合成沸石的结构基本没有影响，但均大大降低了沸石的晶化速率。通过等离子光谱和ＸＰＳ测试发现沸石的体相硅铝比基本相同，但沸石表面的硅铝比显著不同。合成体系中引入一定量的ＫＩ很难合成ＺＳＭ－４８沸石，或者需要很长时间才能合成，引入ＫＦ和ＫＢｒ不利于生成稳定的产物。ＴＧ／ＤＴＡ表明引入不同的卤化钾强烈影响着产物的热性质。ＳＥＭ测试表明产物的晶体形貌和晶粒大小与卤化钾的类型有关。     

分子筛硅／铝比对Cu-ZnO-Al2O3／HMCM-22催化合成二甲醚反应性能的影响

以六亚甲基亚胺为模板剂,采用动态水热晶化法合成了不同硅/铝比的HMCM-22分子筛,并以其为甲醇脱水活性组分与铜基甲醇合成活性组分(Cu-ZnO-Al2O3)组成双功能催化剂,在连续流动加压固定床微型反应器上考察了其对合成气直接制二甲醚反应的催化性能. 结果表明,随着HMCM-22分子筛硅/铝比的增大, CO转化率变化不大,但CO2和烃类副产物的生成量逐渐减少,从而导致目的产物二甲醚的选择性和收率均逐渐升高. 氨程序升温脱附和吡啶吸附红外光谱表征结果表明,随着分子筛硅/铝比的增大, HMCM-22分子筛的酸中心的数量逐渐减少.     

红外光谱法研究不同硅铝比的ZSM-5及ZSM-11分子筛的骨架振动

红外光谱法研究分子筛的骨架振动得出了在X、Y等沸石分子筛骨架上振动频率与四面体中铝含量的线性关系^[1]。但未见到有关ZSM-5型的报道.本文用红外光谱法系壳探讨了硅铝比和ZSM-5及ZSM-11的骨架振动频率之间的线性关系,并将由IR得到的SiO₂/Al₂O₃比与化学分析值进行了比较。     

Synthesis of high-silica EU-1 zeolite in the presence of hexamethonium ions: a seeded approach for inhibiting ZSM-48

A seeded approach was developed to synthesize high-silica EU-1 zeolite via inhibiting the co-crystallization of ZSM-48 in the presence of hexamethonium (HM) ions. A systematic study was carried out to determine factors such as seed content and SiO(2)/Al(2)O(3) ratio, which influenced the crystallization of high-silica EU-1 and transformation of EU-1 into ZSM-48. Using EU-1 seeds, not only well-crystallized pure EU-1 zeolites with SiO(2)/Al(2)O(3) ratios more than 500 were synthesized, but also the co-crystalline of ZSM-48/EU-1 or pure ZSM-48 was obtained in control from silica-rich mixture gels. Furthermore, the kinetic features of the seeded synthesis of EU-1 zeolites with SiO(2)/Al(2)O(3) ratios of 55, 190, and 500 were examined. It was found that seeds played crucial roles in the decrease of apparent activation energy of EU-1 nucleation and inhibiting the transformation of EU-1 into ZSM-48. The HM and Al species performed synergistic roles to inhibit the formation ZSM-48 during high-silica EU-1 nucleation and crystal growth.     

用新方法催化合成6-乙酰基-1-甲基环己烯

室温下用HY沸石取代传统催化剂通过1-甲基环己烯与乙酐的酰基化反应合成了6-乙酰基-1-甲基环己烯，考察了HY沸石的SiO2／Al2O2摩尔比、用量和活化时间以及反应时间对该酰化反应的影响．当1-甲基环己烯／乙酐／HY沸石(SiO2／Al2O3摩尔比=29)=1mmol／10mmol／0．200g、反应温度25℃、反应时间3h时，所得酰化产品的产率为60％，HY沸石能够回收和重新使用，显示出与新鲜催化剂几乎相同的催化活性．     

分子筛硅铝比及晶粒粒径对 Cu-ZnO-Al2O3/HZSM-5催化剂直接合成二甲醚反应性能的影响

采用水热晶化法合成了硅铝比(SiO₂/Al₂O₃)为60、120、200和晶粒粒径分别为1.00和0.25 μm的HZSM-5分子筛,并以其为甲醇脱水活性组分与铜基甲醇合成活性组分(Cu-ZnO-Al₂O₃)组成双功能催化剂(Cu-ZnO-Al₂O₃/HZSM-5),在连续流动加压固定床反应器上考察了Cu-ZnO-Al₂O₃/HZSM-5对合成气直接制二甲醚反应的催化性能。结果表明,随着分子筛硅铝比的提高,二氧化碳副产物的生成量逐渐减少,从而使目的产物二甲醚的选择性逐渐增大。与常规分子筛相比,小晶粒分子筛的反应活性接近,但二氧化碳和烃类副产物的选择性较低。     

MFI沸石上对二甲苯的热脱附

MFI沸石（ZS－5型）的骨架结构内含十氧元环的二维孔道［‘］，孔容积0．18cm‘·g－‘，硅沸石（Silicallte－1）是骨架中不合铝的ZSM－5．’‘StMASNMR话可揭示沸石的结构对称性、硅铝比和局部缺陷［习．Nagy等人间提出St－OH缺陷在含铅量高时形成．Woolery等门则认为出OH完全是由于骨架内包藏的桂的存在而产生，并随铝合量降低而增大．ZSM－5、硅沸石的结构特征和对二甲苯（Px）的性质决定了Px在ZSM－5上的吸附特性·本文用’‘StMASNLDEL表征硅沸石及不同含铅量的H、Na型ZSM－5的结构，并用＊W＊＊G巾TA分析吸附于…