The effects of ionizing irradiation on Salmonella inoculated on almonds and changes in sensory properties

The goal of this study was to test the efficacy of irradiation on destroying Salmonella on raw almonds and evaluating the resultant sensory changes in the almonds. Raw almonds inoculated with various strains of Salmonella were irradiated at 5 dose levels up to 3 kGy and the D value was determined. The strain SEPT30 was the most resistant strain with a D value of 1.25 kGy indicating that a 4 log CFU/g reduction would require a dose of 5.0 kGy. Irradiation at 2.98 and 5.25 kGy induced significant sensory changes in almond nuts as manifested by intensity of chemical/metallic/rancid flavor ranked by a trained panel. A consumer panel found that samples treated with 5.25 kGy irradiation rendered the almonds unacceptable. Thus, irradiation by itself is unlikely to be a feasible method to eliminate Salmonella from raw almonds.     

Radiation resistances and decontamination of common pathogenic bacteria contaminated in white scar oyster (Crassostrea belcheri) in Thailand

In Thailand, white scar oyster (Crassostrea belcheri) was ranked for premium quality, being most expensive and of high demand. This oyster is often eaten raw, hence it may pose health hazards to consumers when contaminated with food-borne pathogens. As limited alternative methods are available to sterilize the oyster while preserving the raw characteristic, irradiation may be considered as an effective method for decontamination. In this study, the radiation resistance of pathogenic bacteria commonly contaminating the oyster and the optimum irradiation doses for sterilization of the most radiation resistant bacteria were investigated. The radiation decimal reduction doses (D₁₀) of Salmonella Weltevreden DMST 33380, Vibrio parahaemolyticus ATCC 17802 and Vibrio vulnificus DMST 5852 were determined in broth culture and inoculated oyster homogenate. The D₁₀ values of S. Weltevreden, V. parahaemolyticus and V. vulnificus in broth culture were 0.154, 0.132 and 0.059 kGy, while those of inoculated oyster homogenate were 0.330, 0.159 and 0.140 kGy, respectively. It was found that among the pathogens tested, S. Weltevreden was proved to be the most resistant species. An irradiation dose of 1.5 kGy reduced the counts of 10⁵ CFU/g S. Weltevreden inoculated in oyster meat to an undetectable level. The present study indicated that a low-dose irradiation can improve the microbial quality of oyster and further reduce the risks from the food-borne pathogens without adversely affecting the sensory attributes.     

Application of gamma irradiation for inactivation of three pathogenic bacteria inoculated into meatballs

In this research, the effect of gamma irradiation on the inactivation of Escherichia coli O157:H7 (ATCC 33150), Staphylococcus aureus (ATCC 2392) and Salmonella typhimurium (NRRL 4463) inoculated into Tekirdag meatballs was investigated. The meatball samples were inoculated with pathogens and irradiated at the absorbed doses of 1, 2.2, 3.2, 4.5 and 5.2 kGy. E. coli O157:H7 count in 1 kGy irradiated meatballs stored in the refrigerator for 7 days was detected to be 4 log cfu/g lower than the count in nonirradiated samples (p<0.05). S. aureus counts were decreased to 4 log cfu/g after being exposed to irradiation at a dose of 1 kGy. Although it was ineffective on elimination of S. typhimurium, irradiation at a dose of 3.2 kGy reduced E. coli O157:H7 and S. aureus counts under detectable values in the meatballs. However, none of the test organisms were detected in the samples after irradiation with 4.5 kGy doses.     

Enhancement of microbial quality and inactivation of pathogenic bacteria by gamma irradiation of ready-to-cook Iranian barbecued chicken

Ready-to-cook Iranian barbecued chicken consists of cubed chicken breast, lemon juice, salt, red pepper, onion, saffron and vegetable oil with an overall pH value of about 5.5. This product is sometimes consumed under-cooked, hence it may pose health hazards to consumers when contaminated with food-borne pathogens. In this study, the effect of gamma irradiation (0, 1.5, 3 and 4.5 kGy) on the microbial quality of ready-to-cook (RTC) barbecued chicken samples stored at 4 °C for 15 days was investigated. Moreover, the effectiveness of irradiation for inactivating Listeria monocytogenes, Escherichia coli O157:H7 and Salmonella typhimurium inoculated into the samples was also studied. Irradiation of the samples resulted in dose dependent reduction in counts of aerobic mesophilic bacteria, yeasts and molds, Enterobacteriaceae and lactic acid bacteria. Among the microbial flora, yeasts and molds and Enterobacteriaceae were more sensitive to irradiation and got completely eliminated at dose of 3 kGy. D₁₀ values of L. monocytogenes, E. coli O157:H7 and S. typhimurium inoculated into the samples were 0.680, 0.397 and 0.601 kGy, respectively. An irradiation dose of 3 kGy reduced the counts of E. coli O157:H7 to an undetectable level in RTC barbecued chicken but was ineffective on elimination of L. monocytogenes and S. typhimurium. However, none of the food-borne pathogens were detected in the samples irradiated at 4.5 kGy. This study showed that irradiation had no undesirable effects on the initial sensory attributes of barbecued chicken. At the end of the storage period, irradiated samples were more acceptable compared to non-irradiated ones.     

Effects of gamma and electron beam irradiation on the survival of pathogens inoculated into sliced and pizza cheeses

The objective of this study was to identify the efficacy of gamma and electron beam irradiation of the food-borne pathogens (Listeria monocytogenes and Staphylococcus aureus) in sliced and pizza cheeses commercially available in the Korean market. Total aerobic bacteria and yeast/mold in the cheeses ranged from 10² to 10³ Log CFU/g. Irradiation of 1 kGy for sliced cheese and 3 kGy for pizza cheese were sufficient to lower the total aerobic bacteria to undetectable levels (10¹ CFU/g). Pathogen inoculation test revealed that gamma irradiation was more effective than electron beam irradiation at the same absorbed dose, and the ranges of the D₁₀ values were from 0.84 to 0.93 kGy for L. monocytogenes and from 0.60 to 0.63 kGy for S. aureus. Results suggest that a low dose irradiation can improve significantly the microbial quality and reduce the risk of contamination of sliced and pizza cheeses by the food-borne pathogens which can potentially occur during processing.     

Radiosensitivities of bacterial isolates on minced chicken and poached chicken meal and their elimination following irradiation and chilled storage

The radiosensitivities of Escherichia coli and Staphylococcus aureus on poached chicken meal (PCM) and minced chicken substrate (MCS) were determined. Effect of irradiation (0, 1, 2 kGy) on total viable cells (TVC) of PCM components was determined under chilled (3–5 °C) storage (0, 9, 14, 21 days) and challenge testing of the bacterial isolates with irradiation (0, 2, 3 kGy) was also conducted on PCM under chilled storage (0,7, 14, 21, 28 days). Additionally, sensory evaluation of the PCM components was assessed with irradiation (0, 2, 3 kGy) during chilled storage (0, 7, 14, 21 days). D₁₀ of E. coli on PCM and MCS were 0.18 and 0.25 kGy whiles those of S. aureus were 0.27 and 0.29 kGy, respectively. D₁₀ values for PCM<MCS and values for S. aureus>E. coli. 2 kGy controlled TVC and extended the shelf life of meals to ⩾14 days but 3 kGy was required to eliminate E. coli and S. aureus. Sensory qualities of the meal were not affected by an irradiation dose of 3 kGy.     

Effect of gamma irradiation on microbial decontamination,and chemical and sensory characteristic of lycium fruit

Lycium fruit, popular traditional Chinese medicine and food supplement generally is ingested uncooked, was exposed to several doses of gamma irradiation (0–14 kGy) to evaluate decontamination efficiency, changes in chemical composition, and changes in sensory characteristic. In this study, lycium fruit specimens contained microbial counts of 3.1×10³–1.7×10⁵ CFU/g and 14 kGy was sufficient for microbial decontamination. Before irradiation, the main microbe isolated from lycium fruit was identified as a strain of yeast, Cryptococcus laurentii. After 10 kGy of irradiation, a Gram-positive spore-forming bacterium, Bacillus cereus, was the only survivor. The first 90% reduction (LD₉₀) of C. laurentii and B. cereus was approximately 0.6 and 6.5 kGy, respectively, the D₁₀ doses of C. laurentii and B. cereus was approximately 0.6 and 1.7 kGy, respectively. After 14 kGy irradiation, except the vitamin C content, other chemical composition (e.g., crude protein, β-carotene, riboflavin, fructose, etc.) and the sensory characteristic of lycium fruit specimens did not have significant changes. In conclusion, 14 kGy is the optimal decontamination dose for lycium fruit for retention of its sensory quality and extension of shelf life.     

Effect of irradiation on kinetic behavior of Salmonella Typhimurium and Staphylococcus aureus in lettuce and damage of bacterial cell envelope

This study evaluated effect of gamma irradiation on survival of Salmonella Typhimurium and Staphylococcus aureus on lettuce and damage of cell envelope. S. Typhimurium and S. aureus were inoculated on red leaf lettuce, and they were irradiated at 0, 0.5, 1, 1.5, 2, 2.5, and 3 kGy, and the samples were then stored at 7 and 25 °C for 7 days. Survival of S. Typhimurium and S. aureus were enumerated on xylose lysine deoxycholate agar and Baird–Parker agar, respectively. D₁₀ value (dose required to reduce 1 log CFU/leaf) was calculated, and kinetic parameters (maximum specific growth rate; μ_max and lag phase duration; LPD) were calculated by the modified Gompertz model. In addition, cell envelope damage of the pathogens was observed by scanning electron microscope (SEM) and transmission electron microscope (TEM). D₁₀ values were 0.35 and 0.33 kGy for S. Typhimurium and S. aureus, respectively. During storage at 7 °C, S. Typhimurium and S. aureus had significant (P<0.05) growth only on non-irradiated samples up to about 2.5 and 4 log CFU/leaf at 0.42 and 1.28 log CFU/leaf/day of μ_max, respectively. At 25 °C, cell counts of S. Typhimurium and S. aureus on the samples irradiated at 0 and 0.5 kGy increased (P<0.05) up to 3–6 log CFU/leaf. The μ_max of both pathogens were higher in 0 kGy (1.08–2.27 log CFU/leaf/day) and 0.5 kGy (0.58–0.92 log CFU/leaf/day), and LPDs ranged from 1.53 to 3.14 day. SEM and TEM observations showed that cells irradiated at 1.5 and 3 kGy showed disrupted cell membrane. These results indicate that gamma irradiation could be a useful decontamination technology to improve food safety of lettuce by destroying cells of S. Typhimurium and S. aureus.     

Effect of gamma irradiation on Burkholderia thailandensis (Burkholderia pseudomallei surrogate) survival under combinations of pH and NaCl

This study evaluated the effect of gamma irradiation on Burkholderia thailandensis (Burkholderia pseudomallei surrogate; potential bioterrorism agent) survival under different levels of NaCl and pH. B. thailandensis in Luria Bertani broth supplemented with NaCl (0–3%), and pH-adjusted to 4–7 was treated with gamma irradiation (0–0.5 kGy). Surviving cell counts of bacteria were then enumerated on tryptic soy agar. Data for the cell counts were also used to calculate D₁₀ values (the dose required to reduce 1 log CFU/mL of B. thailandensis). Cell counts of B. thailandensis were decreased (P<0.05) as irradiation dose increased, and no differences (P≥0.05) in cell counts of the bacteria were observed among different levels of NaCl and pH. D₁₀ values ranged from 0.04 to 0.07 kGy, regardless of NaCl and pH level. These results indicate that low doses of gamma irradiation should be a useful treatment in decreasing the potential bioterrorism bacteria, which may possibly infect humans through foods.     

The effect of 60Co (γ-ray) irradiation on the electrical characteristics of Au/SnO2/n-Si (MIS) structures

The effect of ⁶⁰Co (γ-ray) irradiation on the electrical properties of Au/SnO₂/n-Si (MIS) structures has been investigated using the capacitance–voltage (C–V) and conductance–voltage (G/ω−V) measurements in the frequency range 1 kHz to 1 MHz at room temperature. The MIS structures were exposed to γ-rays at a dose rate of 2.12 kGy/h in water and the range of total dose was 0–500 kGy. It was found that the C–V and G/ω−V curves were strongly influenced with both frequency and the presence of the dominant radiation-induced defects, and the series resistance was increased with increasing dose. Also, the radiation-induced threshold voltage shift (ΔV_T) strongly depended on radiation dose and frequency, and the density of interface states N_ss by Hill–Coleman method decreases with increasing radiation dose.     

Radiation sensitivity of bacteria and virus in porcine xenoskin for dressing agent

In this study, gamma irradiation sensitivities of bacteria and viruses in porcine skin were evaluated to establish the optimum sterilization condition for the dressing material and a xenoskin graft. Escherichia coli and Bacillus subtilis were used as model pathogens and inoculated at 10⁶–10⁷ log CFU/g. As model viruses, porcine parvovirus (PPV), bovine viral diarrhea virus (BVDV), and poliovirus were used and inoculated at 10⁵–10⁶ TCID₅₀/g into porcine skin. The D₁₀ value of E. coli was found to be 0.25±0.1 kGy. B. subtilis endospores produced under stressful environmental conditions showed lower radiation sensitivity as D₁₀ was 3.88±0.3 kGy in porcine skin. The D₁₀ values of PPV, BVDV, and poliovirus were found to be 1.73±0.2, 3.81±0.2, and 6.88±0.3 kGy, respectively. These results can offer the basic information required for inactivating pathogens by gamma irradiation and achieving dressing material and porcine skin grafts.     

Radiation sensitivity of Salmonella isolates relative to resistance to ampicillin,chloramphenicol or gentamicin

Antibiotic resistance of inoculated bacteria is a commonly used selective marker. Bacteria resistant to the antibiotic nalidixic acid have been shown to have an increased sensitivity to irradiation. The purpose of this research was to screen a collection of Salmonella isolates for antibiotic resistance and determine the association, if any, of antibiotic resistance with radiation sensitivity. Twenty-four clinical isolates of Salmonella were screened for native resistance to multiple concentrations of ampicillin (Amp), chloramphenicol (Chl), or gentamicin (Gm). Test concentrations were chosen based on established clinical minimum inhibitory concentration (MIC) levels, and isolates were classified as either sensitive or resistant based on their ability to grow at or above the MIC. Salmonella cultures were grown overnight at (37 °C) in antibiotic-amended tryptic soy broth (TSB). Native resistance to Gm was observed with each of the 24 isolates (100%). Eight isolates (33%) were shown to be resistant to Amp, while seven isolates (29%) were shown to be resistant to Chl. In separate experiments, Salmonella cultures were grown overnight (37 °C) in TSB, centrifuged, and the cell pellets were re-suspended in phosphate buffer. The samples were then gamma irradiated at doses up to 1.0 kGy. The D₁₀ values (the ionizing radiation dose required to reduce the viable number of microorganisms by 90%) were determined for the 24 isolates and they ranged from 0.181 to 0.359 kGy. No correlation was found between the D₁₀ value of the isolate and its sensitivity or resistance to each of the three antibiotics. Resistance to Amp or Chl is suggested as appropriate resistance marker for Salmonella test strains to be used in studies of irradiation.     

Gamma-ray response of a clear,crosslinked PMMA dosimeter,Radix W

Radix W, a clear poly(methyl-methacrylate) (PMMA) dosimeter was developed with improved properties compared to the conventional clear PMMA dosimeter, Radix RN15. PMMA with a glass transition temperature (T_g) higher than 120 °C was selected making it possible to measure doses in a wide range of 1 to 150 kGy. Dose rates of 2.5–10 kGy/h were tested and did not affect significantly the dose response. The influence of irradiation temperature was reduced compared with Radix RN15.     

Variations in the radiation sensitivity of foodborne pathogens associated with complex ready-to-eat food products

Foodborne illness outbreaks and product recalls are occasionally associated with ready-to-eat (RTE) sandwiches and other “heat and eat” multi-component RTE products. Ionizing radiation can inactivate foodborne pathogens on meat and poultry, fruits and vegetables, seafood, and RTE meat products. However, less data are available on the ability of low-dose ionizing radiation, doses under 5 kGy typically used for pasteurization purposes, to inactivate pathogenic bacteria on complex multi-component food products. In this study, the efficacy of ionizing radiation to inactivate Salmonella spp., Listeria monocytogenes, Staphylococcus aureus, Escherichia coli O157:H7, and Yersinia enterocolitica on RTE foods including a “frankfurter on a roll”, a “beef cheeseburger on a bun” and a “vegetarian cheeseburger on a bun” was investigated. The average D-10 values, the radiation dose needed to inactivate 1 log₁₀ of pathogen, by bacterium species, were 0.61, 0.54, 0.47, 0.36 and 0.15 kGy for Salmonella spp., S. aureus, L. monocytogenes, E. coli O157:H7, and Y. enterocolitica, respectively when inoculated onto the three product types. These results indicate that irradiation may be an effective means for inactivating common foodborne pathogens including Salmonella spp, S. aureus, L. monocytogenes, E. coli O157:H7 and Y. enterocolitica in complex RTE food products such as ‘heat and eat” sandwich products.     

Effect of high-dose irradiation and autoclave treatment on microbial safety and quality of ready-to-eat Bulgogi sauce

In Korea, commercialized sauce for ready-to-eat (RTE) Bulgogi is usually manufactured using heat treatment to ensure that it has a long shelf-life. However, heat treatment may adversely affect the taste and flavor of the sauce, thus, the development of suitable sterilizing methods for RTE sauces is necessary to preserve the quality of the sauce during long storage periods. In this study, total bacterial growth, the viscosity, and the sensory properties of Bulgogi sauce were compared between sterilization with gamma irradiation (0–40 kGy) and autoclave treatment during storage at 35 °C for 90 days. No bacterial growth was observed following irradiation at more than 10 kGy or after autoclave treatment. However, the viscosity and sensory properties of samples gamma-irradiated at above 10 kGy or autoclave-treated were significantly changed, even though autoclave treatment induced a burnt taste and flavor. Therefore, a gamma irradiation of 10 kGy was effective to prepare ready-to-eat Bulgogi sauce with microbial safety and original sensory qualities.     

Influence of electron beam irradiation on growth of Phytophthora cinnamomi and its control in substrates

Very extensive production procedure, especially in plants growing under covering, require methods, which would allow quick elimination or substantial reduction of populations of specific pathogens without affecting the growth and development of the cultivated plants. Among soil-borne pathogens, the Phytophthora species are especially dangerous for horticultural plants. In this study, irradiation with electron beam was applied to control Phytophthora cinnamomi. The influence of irradiation dose on the reduction of in vitro growth and the population density of the pathogen in treated peat and its mixture with composted pine bark (1:1), as well as the health of Chamaecyparis lawsoniana and Lavandula angustifolia plants were evaluated. Application of irradiation at a dose of 1.5 kGy completely inhibited the in vitro development of P. cinnamomi. This irradiation effect was connected with the disintegration of the hyphae and spores of the species. Irradiation of peat and its mixture with composted pine bark with 10 kGy resulted in the inhibition of stem base rot development in Ch. lawsoniana. Symptoms of the disease were not observed when the substrates were treated with 15 kGy. In the case of L. angustifolia, stem root rot was not observed on cuttings transplanted to infected peat irradiated at a dose of 10 kGy. Irradiation of the horticultural substrates did not affect plant growth.     

Determination of the changes of antifungal properties of Satureja hortensis,Thymus vulgaris and Thymbra spicata exposed to gamma irradiation

In this research, changes in the antifungal activity of the extract of Satureja hortensis, Thymus vulgaris and Thymbra spicata exposed to gamma irradiation against two aflatoxigenic moulds Aspergillus parasiticus NRRL 2999 and 465 were investigated. The samples of dry plant leaf powder were irradiated with doses of 1.2, 3.0, 5.1 kGy. While the antifungal activity of S. hortensis with 0 and 1.2 kGy dose irradiation against A. parasiticus NRRL 2999 was found to be similar, it decreased with 3.0 and 5.1 kGy irradiation doses (P<0.05). On the contrary, antifungal activity of T. spicata increased until 3.0 kGy and then it decreased with 5.1 kGy irradiation dose (P<0.05). For T. vulgaris, an increase of irradiation dose resulted in a decrease of antifungal activity against aflatoxigenic moulds. This research shows that antifungal properties of some spices can be changed by gamma irradiation.     

Effects of gamma irradiation on two heat resistant moulds: Aspergillus fumigatus and Paecilomyces variotii isolated from margarine

The present study was undertaken to evaluate the effect of gamma irradiation on two heat-resistant moulds, namely Aspergillus fumigatus and Paecilomyces variotii isolated from margarine samples. The irradiation process of these moulds was carried out in a ⁶⁰Co gamma (γ) irradiator at average absorbed doses of 1, 3, 5 and 7 kGy for exposure times of 52, 156, 260 and 364 min, respectively. The average D₁₀ value for A. fumigatus was 1.08±0.08 kGy while it was 0.59±0.10 kGy for P. variotii. Consequently, the sensitivity of P. variotii against γ irradiation was more than A. fumigatus.     

The effect of gamma irradiation on glass transition temperature and thermal stability of Se96Sn4 chalcogenide glass

Se₉₆Sn₄ chalcogenide glass was prepared by melt quenching technique and exposed, at room temperature, to different doses of 4, 8, 12, 24 and 33 kGy of high-energy ⁶⁰Co gamma irradiation. Differential scanning calorimeter (DSC) was used under non-isothermal condition to determine the glass transition temperature T_g, onset T_c and peak T_p temperatures of crystallization, of un-irradiated and γ-irradiated samples, at four different heating rates. The variation of T_g with heating rates was utilized to calculate the glass transition activation energy E_t for un-irradiated and γ-irradiated glass, using the methods suggested by Kissinger and Moynihan. Based on the obtained values of the characteristic temperatures T_g, T_c and T_p, thermal stability was monitored through the calculation of the S parameter and the crystallization rate factor 〈K_p〉 for irradiated and un-irradiated glass. Results reveal that, as γ-dose increases T_g increases up to 12 kGy then decreases at higher doses but remains more than that of un-irradiated glass. Meanwhile, both E_t and 〈K_p〉 attain their minimum values at the same dose of 12 kGy and the glass is thermally stable at this particular dose.     

Enhanced formation of quercetin by combined use of gamma ray and H2O2 from cyanidin-3-O-xylosylrutinoside

Cyanidin-3-O-xylosylrutinoside (cya-3-O-xylrut), a major pigment in Schizandra chinensis Baillon, was effectively removed by gamma irradiation of greater than 2 kGy, whereas quercetin, the most abundant of the flavonoids and has anti-inflammatory and anti-allergic effects, could be generated by degradation of cya-3-O-xylrut. In the present study, we investigated the effect of combination treatment of gamma irradiation and hydrogen peroxide (H₂O₂) on the formation of quercetin through the degradation of cya-3-O-xylrut. Cya-3-O-xylrut was significantly degraded (～93%) by gamma irradiation at 2 kGy and it was completely removed by a combination treatment (0.2% H₂O₂ and 2 kGy gamma ray). The formation of quercetin was significantly appeared at 2 kGy of gamma ray, together with disappearance of cya-3-O-xylrut. The quercetin formation by gamma ray is 3.2 μg/ml and combination treatment is 7.7 μg/ml. Therefore, the combination treatment of H₂O₂ and gamma ray is more effective to convert cya-3-O-xylrut into quercetin than gamma irradiation only. In conclusion, gamma ray combined with H₂O₂ would be a promising tool for bio-conversion of organic compounds.