Growth,intensity and probabilities of f-f transitions of Nd3+ ions in KNd(PO3)4 single crystals

From a study of the melting diagram KPO₃—KNdP₄O₁₂ optimum conditions are derived for the growth of KNd(PO₃)₄ single crystals by the flux method. The absorption spectrum of KNd(PO₃)₄ was measured between 320 and 1000 nm at room temperature. The three JUDD -OFELT parameters Ω_λ were determined by numcerical methods and compared to the data for NdP₅O₁₄. A correlation has been attempted between the Ω₂ parameter and the site symmetry of Nd³⁺ in Nd-containing laser crystals. The calculated fluorescence branching coefficients from the ⁴F_3/2 level are in good agreement with the epxerimental data.     

Flux growth and characterizations of NdPO4 single crystals

Neodymium phosphate single crystals, NdPO₄, have been grown by a flux growth method using Li₂CO₃-2MoO₃ as a flux. The as-grown crystals were characterized by X-ray powder diffraction(XRPD), differential thermal analysis (DTA) and thermogravimetric analysis (TG) techniques. The results show that the as-grown crystals were well crystallized. The crystal was stable over the temperature range from 26 to 1200 °C in N₂. The specific heat of NdPO₄ crystal at room temperature was 0.41 J/g °C. The absorption and the fluorescence spectra of NdPO₄ crystal were also measured at room temperature.     

Flux crystallization of trigonal GdFe<Subscript>3</Subscript>(BO<Subscript>3</Subscript>)<Subscript>4</Subscript> competing with the crystallization of α-Fe<Subscript>2</Subscript>O<Subscript>3</Subscript>

The formation of trigonal GdFe₃(BO₃)₄ crystals in the Bi₂Mo₃O₁₂-B₂O₃-Li₂MoO₄-Gd₂O₃-Fe₂O₃ system was studied. The flux compositions for which GdFe₃(BO₃)₄ is the high-temperature phase with a wide range of crystallization were determined. The features of nucleation of these crystals and their growth near the phase boundary with α-Fe₂O₃ were analyzed. The growth of GdFe₃(BO₃)₄ single crystals involving preliminary nonequilibrium crystallization of α-Fe₂O₃ is described.     

Reducing Inversion Twinning in Single Crystal Growth of GaPO4

Gallium orthophosphate (GaPO₄) single crystals were grown by the reverse temperature gradient method from phosphoric acid solutions under hydrothermal conditions. Twins after (110) were studied by etching faces having been cut perpendicular to one of the twofold axes. Based on the determination of the twin boundary position as well as on the knowledge of the growth rates of different crystallographic forms, a few faces have been chosen to be quite promising for growing high‐quality GaPO₄ single crystals if they are offered at the referring seed crystal. From the characterization of the grown crystals conditions have been found, which may lead to the reduction of the inversion twin number during the growth process.     

Real Structure of LiB3O5 (LBO) Crystals Grown in Li2O‐B2O3‐MoO3 System

The liquidus surface structure and field of LiB₃O₅ (LBO) primary crystallization have been revealed in Li₂O‐B₂O₃ ‐MoO₃ ternary system. The optimization of charge composition and growth conditions results in large volume optical quality LBO single crystals yielding. Crystallographic properties and real defect structure of grown LBO single crystals have been investigated by X‐ray powder diffraction method and X‐ray reflection topography. The volume of the crystals is partly free of any structural imperfections.     

On the Iso‐Diameter Growth of β ‐BaB2O4 (BBO) Crystals by Flux Pulling Method

The iso‐diameter growth of β ‐BaB₂O₄ (BBO) crystals by the flux pulling method have been studied based on the phase equilibrium diagram in the BaB₂O₄‐Na₂O pseudo‐binary system and from the interface stability. The mathematical expressions for the cooling rate in the growth of the crystals with constant diameter under stable growth conditions are derived, the experimental phenomena such as diameter contraction and difficulty to grow a lengthy crystal by the flux pulling method are explained, the prerequisite for iso‐diameter BBO crystal growth from the flux is suggested; a new continuous charging flux pulling method is introduced to grow large‐sized high quality crystals with a relative high growth rate.     

Hydrothermal Liquid Phase Epitaxy of Gallium Orthophosphate on Quartz Crystal Substrates

Gallium orthophosphate (GaPO₄) layers for surface acoustic wave (SAW) and sensor applications have been grown on quartz crystal substrates with sizes of about 30 x 30 mm² by hydrothermal liquid phase epitaxy (HLPE). The growth of epitaxial GaPO₄ layers is difficult because of a strong tendency for twinning. Besides, a retrograde solubility and an intense chemical aggressiveness of the solution has to be considered. Nevertheless, we found an effective crystal growth technique to deal with these problems using large and qualitatively good substrate crystals of quartz. The most important step of the epitaxy is the formation of an interlayer between the quartz substrate and the GaPO₄ deposit. Epitaxial layers with thickness up to 500 μm were obtained and characterised by means of X‐ray techniques.     

The growth of β-LiA1SiO4 crystals from high-temperature solution in LiF-A1F3 mixtures

The growth of β-LiA1SiO₄ crystals from high-temperature solution is described. A mixture of LiF and A1F₃ is used as a solvent. The crystals are grown by a slow cooling technique in the temperature range 1100-1000°C. The solubility of LiA1SiO₄ in LiF with different A1F₃ admixtures is determined.     

Crystal growth and defects in Ga3PO7 crystals

Crystals with a non‐centrosymmetric structure are of great interest owing to their properties such as ferroelectricity, piezoelectricity, dielectric behavior and optical properties. In this letter, Ga₃PO₇ crystals are grown by the top‐seeded solution growth (TSSG) method from a Li₂O‐3MoO₃ flux. It crystallizes in a non‐centrosymmetric trigonal crystal system with space group R3m within point group 3m. The growth defects are investigated by means of chemical etching method. The results reveal hot concentrated phosphoric acid to be a good etchant for Ga₃PO₇. The main defects are cracks, inclusions, dislocations and twin. In the meantime, the effective measures for reducing the defects are proposed. (© 2010 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth and Properties of Trigonal Aluminium Gallium Orthophosphate Single Crystals Al1-xGaxPO4

The new piezoelectric solid solution aluminium gallium orthophosphate single crystals have been successfully developed for the first time in our laboratory by hydrothermal method. It has been demonstrated that these crystals are homogeneous, and isomorphous with AIPO₄ and GaPO₄. The solid solution crystals Al_1-xGa_xPO₄ are easy to grown and have better optical quality than those of AlPO₄ crystals under the same conditions. A phase transition temperature T_α-β is 587 ± 3 °C for x = 0.12. Cell parameters, and elastic, piezoelectric, and dielectric constants are given.     

Growth of LaBGeO5 crystal fibers by the micro‐pulling down technique

The LaBGeO₅ compound (LBGO) was prepared by solid state reaction at 1050°C and characterized by XRD and DTA analysis. The direct growth of LBGO fibers from the melt using micro‐pulling down technique was unsuccessful because of its high viscosity. The study of the LBGO‐LiF phase diagram showed that LiF could be considered as a convenient flux to reduce viscosity of the melt during the growth process. Several crystal fibers were then grown and characterized by Raman spectroscopy. To decrease the high volatility of LiF, B₂O₃ was added to the melt. A white cloudy fiber was obtained from LiF‐B₂O₃ flux and checked by Raman spectroscopy and scanning electron microscopy.     

熔体分层对BaBiBO4晶体生长的影响

研究在用助熔剂法生长BaBiBO4晶体的过程中,熔体分层对晶体生长的影响.以Li2Mo3O10作为助熔剂,采用自发成核和顶部籽晶两种方法来生长晶体.对于这两种方法得到的晶体,用X射线粉末衍射及拉曼光谱进行了表征,结果显示,在晶体生长过程中,由于熔体分层,导致通过自发成核和顶部籽晶分别得到BaMoO4多晶和LiBaB9O15单晶两种不同的物相.     

Crystal growth and spectral properties of Nd:Ca5(BO3)3F

A neodymium doped Ca₅(BO₃)₃F single crystal with size up to 51×48×8 mm³ has been grown by the top seeded solution growth (TSSG) technique with a Li₂O‐B₂O₃‐LiF flux. The spectra of absorption and fluorescence were measured at room temperature. According to Judd‐Ofelt (J‐O) theory, the spectroscopic parameters were calculated and the J‐O parameters Ω₂, Ω₄, Ω₆ were obtained as follows: Ω₂ = 1.41×10⁻²⁰cm², Ω₄ = 3.18×10⁻²⁰cm², Ω₆ = 2.11×10⁻²⁰cm². The room temperature fluorescence lifetime of NCBF was measured to be 51.8 μs. According to the J‐O paramenters, the emission probabilities of transitions, branching ratios, the radiative lifetime and the quantum efficiency from the Nd^{3+ 4}F_3/2 metastable state to lower lying J manifolds were also obtained. In comparasion with other Nd‐doped borate crystals, the calculated and experimental parameters show that NCBF is a promising SFD crystal.     

Electrochemical growth and properties of LaMn1−xCoxO3 (0 < x ≤ 1) single crystals

Single crystals of LaMn_1−xCo_xO₃ (0 < x < 1) with distorted perovskite structure have been obtained by the electrodeposition technique at anode from flux melt using Cs₂MoO₄‐MoO₃ binary system as solvent. An investigation of magnetic and electrical properties of the obtained crystals as well as its comparison with those for ceramic samples of the same composition were carried out. A much weaker interplay between magnetic and electrical properties and a smaller ∼8% magnetoresistance were found in the ternary oxide crystals slightly doped by Co on the verge of transition to ferromagnetic state in comparison to the data have been reported for LaMnO_3+δ single crystals. (© 2003 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth of filamentary KDP crystals from solution with the addition of Al(NO<Subscript>3</Subscript>)<Subscript>3</Subscript> · 9H<Subscript>2</Subscript>O

To elucidate the mechanism of nucleation and growth of filamentary crystals on the bipyramid faces of KH₂PO₄ (KDP) crystals from solution with the addition of Al(NO₃)₃ · 9H₂O, the growth rates and transverse dimensions of the crystals were measured at various supersaturations, temperatures, and impurity concentrations. The dependences obtained can be interpreted with due regard for the competition between the intrinsic and impurity particles in the presence of Cabrera-Vermilyea stoppers.     

Hydrothermal Synthesis of Zeolite Crystals Using Natural Scolecite

Natural scolecite is converted into analcime type zeolite by hydrothemal method at 180 °C at autogeneous pressure for 24 to 160 hours growth runs. Mordenite is detected in the final product. Cube and spheroid crystals of the products are illustrated and described. Crystals synthesized are characterized by X-ray diffraction, infrared spectroscopy EDAX and scanning electron microscopy. Particle size is estimated as 20–60 microns, induction period for nucleation as 12 hrs, and lattice parameter of cube crystals as 13.70 Å. Mechanism of growth, influence of anions and duration of growth etc. are discussed. It is established that the crystals grow in the system Na₂O Al₂O₃ SiO₂ H₂O.     

Investigations on the crystallisation of potassium molybdenum bronzes from flux melts

Results are presented to identify the fields of primary crystallisation of red and blue potassium molybdenum oxide bronzes K_0.30MoO₃ and K_0.33MoO₃ in the ternary system K₂MoO₄–MoO₃–MoO₂. Starting from crystal growth experiments for the preparation of bronze crystals by electrolytic reduction the binary marginal systems K₂MoO₄–MoO₃ as well as MoO₃–MoO₂ and further pseudo‐binary sections have been investigated by differential thermo‐analysis, hot‐stage microscopy, and by quenching experiments under inert gas. We succeeded in determining phase transition temperatures in the binary section Mo₄O₁₁–K₂Mo₂O₇. Temperature and composition ranges have been found in this section to crystallise red and blue potassium molybdenum oxide bronzes. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Structure and optical properties of near stoichiometric Ce:LiNbO3 crystals

The near sotichiometric Ce:LiNbO₃ (Ce:SLN) crystals were grown by the top seeded solution growth (TSSG) method by adding K₂O flux to Li₂O‐Nb₂O₅ melt. Their UV‐vis absorption spectra and IR spectra were measured and discussed to investigate their defect structure. The results showed that the grown crystals were near stoichiometric and Ce ions in the crystals located the Li site. Photorefractive properties of Ce:SLN crystals were studied by two‐wave coupling experiment. The results of the two‐wave coupling experiments of the crystals showed that as the CeO₂ doping concentrations increased, the diffraction efficiency increased, photoconductivity decreased and the writing time and erasure time increased. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

The effect of cooling rate on size,quality and morphology of KTiOPO4 (KTP) crystals grown by different nucleation techniques

KTP crystals have been grown by two nucleation techniques namely spontaneous nucleation in flux medium and nucleation on Pt rod using K₆P₄O₁₃ flux.10 °C/h, 7 °C/h, 0.8 °C/h, 0.4 °C/h and 0.2 °C/h cooling rates were applied for spontaneous nucleation and crystals up to 15 × 7 × 4 mm³ in size were grown. 1 °C/h and 0.8 °C/h cooling rates were also used for nucleation on Pt rod and crystals up to 8 × 6 × 3 mm³ in size were grown. The effect of cooling rate on size, morphology and optical quality of grown crystals by both techniques were studied. For nucleation on Pt rod upper and lower rotation rates limits and an optimum rotation rate were distinguished for each cooling rate. Quality of the grown crystals by both techniques was characterized by optical transmission analysis.