聚偕氨肟—硫脲络合物的组成对丙烯腈聚合的影响

在聚丙烯基聚偕氨肟(PPAO)—硫脲(TU)体系引发丙烯腈(AN)聚合过程中,将 c(TU)/c(PPAO)摩尔比调节在0.5以上,可以观察到 PPAO、硫脲和硝酸浓度的变化对聚合速度都不产生实质性的影响,但聚合诱导期则随 c(TU)/c(PPAO)摩尔比增大而延长。根据实验结果,得表观聚合速度R_p=2.07e~(-32.6KJ/RT)c~(2.0)(AN)碰撞频率因子极低和引发体系的零级反应是链自由基向初级自由基碰撞终止的特征。     

聚丙烯基聚肟偕氨合铜(Ⅱ)—亚硫酸钠体系引发甲基丙烯酸甲酯聚合动力学

研究了聚丙烯基聚肟偕氮合铜(Ⅱ)(PPAO—Cu)—亚硫酸钠体系引发甲基丙烯酸甲酯(MMA)水溶液聚合。表观聚合速度(Rp)是 Rp=9.7×10~(12)e~(88.8kJ/RT) c(MMA)~(0.88) c(Na_2SO_3)~(0.50) 聚合诱导期(τ)与亚硫酸钠浓度成反比,与PPAO—Cu用量和单体浓度无关。可表示为 1/τ=1.2×10~(12)e~(-55.3KJ/R) c(Na_2SO_3)=K_τ·R_ 聚合是由PPAO—Cu/Na_2SO_3氧化还原反应产生的初级自由基所引发。     

杨梅形聚肟偕亚氨二乙酸钒(Ⅳ)—硫脲体系引发丙烯腈聚合的研究

研究了杨梅形聚肟偕亚氨二乙酸树脂负载VO~(2+)(PV)与疏脲(TU)组合在硝酸溶液中引发丙烯腈(AN)的聚合反应。在实验条件下,表观聚全速度可表示为 R_p=1.91×10~5e~(-45.0/RT)c~(1.9)(AN)c~(1.0)(HNO_3)c~(0.60)(PV)c~(1.50)(TU) 聚合诱导期(τ)与反应物浓度和聚合温度关系是 1/τ=8.27×10~7e~(-38.3/RT)c~(1.9)(HNO_3)c~(0.60)(PV)C~(1.50)(TU)=K_τ;·R_i/R_p 在酸性介质中,氨羧基的协同作用促使键合的VO~(2+)氧化为VO_2~+,随后硫脲配位并通过氢桥缔合,后者分解生成初级自由基,引发丙烯腈的聚合反应。     

聚丙烯基聚肟偕亚氨二乙酸合铜(Ⅱ)—亚硫酸钠体系引发甲基丙烯酸甲酯的聚合动力学

研究了聚丙烯基聚肟偕亚氨二乙酸合铜(Ⅱ)(P-Cu)—亚硫酸钠体系引发水溶液中甲基丙烯酸甲酯的聚合反应。表观聚合速度(Rp)是 Rp=5.8×10~(12)e~(-84·2KJ/RT)[MMA]~(1·4)[P-Cu]~0[Na_2SO_3]~(0·50) 聚合的引发种被认为是通过“络合—氢转移”机理产生。     

笼形聚肟偕亚氨二乙酸钒(Ⅳ)-硫脲体系引发丙烯腈聚合的研究

 研究了笼形聚肟偕亚氨二乙酸钒(CPV)-硫脲(TU)体系在硝酸溶液中引发丙烯腈(AN)聚合反应.表观聚合速度(R_P)是 R_P=1.0×10⁸e(-10.500/RT)[AN]^1.0[CPV]^1.0[TU]^1.5[HNO₃]^3.0 聚合诱导期(τ)随反应温度和物料浓度发生变化,可表示为 1/τ=5.2×10⁹e^-12.800/RT[AN]^1.0[CPV]^1.0[TU]^1.5[HNO₃]^3.0实验结果表明,聚合反应以单基终止为特征,可能是和高分子载体较大的空间位阻有关.     

笼形聚肟偕亚氨二乙酸钒(Ⅳ)-硫脲体系引发丙烯腈聚合的研究

研究了笼形聚肟偕亚氨二乙酸钒(CPV)-硫脲(TU)体系在硝酸溶液中引发丙烯腈(AN)聚合反应.表观聚合速度(R_P)是 R_P=1.0×10~8e~(-10.500/RT)[AN]~(1.0)[CPV]~(1.0)[TU]~(1.5)[HNO_3]~(3.0) 聚合诱导期(τ)随反应温度和物料浓度发生变化,可表示为 1/τ=5.2×10~9e~(-12.800/RT)[AN]~1.0[CPV]~1.0[TU]~1.5[HNO_3]~3.0实验结果表明,聚合反应以单基终止为特征,可能是和高分子载体较大的空间位阻有关.     

笼形聚羧酸钒(Ⅳ)—硫脲体系引发丙烯腈聚合动力学

研究了笼形聚羧酸钒(PV)-硫脲(TU)体系在硝酸溶液中引发丙烯腈(AN)聚合动力学。表观聚合速度(R_p)是 R_p=9.7×10~5e~(-10500)/RT[AN]~1.0[PV]~0.50[TU]~0.76[HNO_3]~1.5聚合诱导期(τ)随反应条件而变化,聚合温度越高,引发种浓度越大,聚合诱导期越短,但与单体浓度的变化无关。 1/τ=4.6×10~(12)e~(-13500)/RT[AN]~0[PV][TU]~(-3/2)[HNO_3]~3=K_τ·R_i聚合物分子量随单体浓度增大而提高,但随聚合温度及引发种浓度增大而下降,即 笼形聚羧酸钒—硫脲体系引发丙烯腈聚合的动力学参数和引发机理与杨梅型聚羧酸钒—硫脲体系在相同的条件下引发聚合的行为有明显的区别,认为是和两种树脂大分子链的空间结构所引起的传质阻力有关。     

杨梅型聚丙烯基亚氨二乙酸钒(Ⅳ)—硫脲体系引发丙烯腈聚合的研究

研究了杨梅型聚丙烯基亚氨二乙酸钒(PIDA/VO)—硫脲(TU)体系在硫酸溶液中引发丙烯腈聚合动力学。表观聚合速度(Rp)和聚合物分子量(Mn)可分别表示为: Rp=2.2×10~5e~(-0860)/RT[AN]~1.0[PV]~0.50[TU]~1.5[H_2SO_4]~2.0 Mn=K·1/T·[AN]/[PV]~0.50[TU]~1.5[H_2SO_4]~2.0其中([PV]~0.05[TU]~1.5[H_2SO_4]~2.0)~2是正比于引发种浓度。由此可见,链自由基是以双基反应终止,伯基终止及链转移终止的可能性较少。和聚羧酸钒(Ⅳ)—硫脲体系引发丙烯腈聚合的机理相同,杨梅型聚丙烯基亚氨二乙酸钒(Ⅳ)也表现出强烈的羧基间协同作用和大分子场效应。     

钒(V)—硫脲氧化还原体系引发丙烯腈聚合的研究 Ⅰ.聚合动力学

研究了钒(V)—硫脲氧化还原体系在硝酸溶液中引发丙烯腈的聚合反应.表观聚合速度是:R_p=2.80×10~5e~(-14000/RJ)[AN]~(2.2)[HNO_3]~(0102)[V~(5+)~(0～1/3)[TU]~(0～4/3),实验结果表明钒(V)和硫脲产生引发种是一个相当复杂的过程。     

纤维素基磁性聚偕氨肟树脂吸附Mn（Ⅶ）

用酸处理的纤维素基磁性聚偕氨肟树脂（AMAO）在溶液中吸附KMnO4，发生氧化还原反应的几率在2％以下；用碱处理的树脂（BMAO）作吸附剂，KMnO4还原为Mn（OH）4的比例剧增，达到或超过10％，并且与溶液的pH有关。但是，Mn（Ⅶ）被还原为Mn（Ⅳ）的量基本上不受KMnO4起始浓度、吸附剂添加量和吸附时间变化的影响。BMAO树脂吸附KMnO4的量是树脂偕氨肟基含量的5倍以上。超当量吸附现象反映了物理吸附的本质。     

MECHANISM FOR THE INITIATION OF ACRYLONITRILE POLYMERIZATION BY POLYPROPYLENE-BASED POLYAMIDOXIME-THIOUREA COMBINATION

Polymerization of acrylonitrile (AN) in aqueous nitric acid initiated by polypropylene-based polyamidoxime (PPAO)-thiourea (TU) combination has been investigated. The overall rate of polymerization (R_p) under the conditions of [TU]/[PPAO]<0.5 molar ratio isThe molecular weights of the polymers were found to be inversely proportional to 3/2-power of nitric acid concentration and 1-power of thiourea concentration. In addition, it is independent with the concentrations of monomer and PPAO, and decreases with increasing temperature.On the basis of these experimental results, a coordination-proton transfer mechanism for the initiation was proposed and discussed.     

DEPENDENCE OF ACRYLONITRILE POLYMERIZATION KINETICS ON THE COMPOSITION OF POLYAMIDOXIME-THIOUREA SYSTEM

The polymerization of acrylonitrile (AN) initiated by polypropylene based-polyamidoxime (PPAO)-thiourea (TU) system was investigated at [TU]/[PPAO]>0.5 molar ratio. It shows that the variation of the concentrations of PPAO, thiourea and nitric acid does not exert an observable influence on the reaction rate. The overall rate of polymerization (R_p) isR_p = 2.07e~(-7,800/RT)[ AN]~(2.0)The zero order dependence on PPAO and thiourea concentrations and the lowest value of the collision frequence factor were considered to be a feature of the primary radical termination.     

STUDY ON THE POLYMERIZATION OF ACRYLONITRILE INITIATED BY POLYPROPYLENE-BASED VANADYL POLYIMIDODIACETATE——THIOUREA REDOX SYSTEM

The present paper deals with the kinetics of polymerization of acrylonitrile (AN) initialed by the redox system of polypropylene-based vanadyi polyimidodiacetate (PV)-thiourea (TU)in aqueous sulfuric acid in the temperature range from 25 to 40℃. The polymerization rate was measured by varying the concentrations of monomer, vanadyl polyimidodiacetate, thiourea and sulfuric acid. The overall rate of polymerization was summarized asRp=2.2×10~5e~(-6.560/RT) [AN]~(1.0)[PV]~(0.50)[TU]~(1.5)[H_2SO_4]~(2.0)The molecular weight of polyacrylonitrile based on the experimental data was:(?)=k 1/T [pv]~(0.50)[TU]~(1.5)[H_2SO_4]~(2.0)These results indicated that the chain radicals are terminated by combination and/or disproportionation rather than chain transfer. The cooperation effect of carboxylic groups and the macromolecular field effect of polymer supporter are the characters of vanadyl polyimidodiacetate such as the case reported in early paper.     

芳香叔胺引发丙烯腈光聚合的引发机理

芳香叔胺引发丙烯腈(AN)光聚合是通过形成激基复合物(exciPlex)进行的。紫外光谱和荧光光谱表明,芳香叔胺在基态可以和AN形成电荷转移复合物(CTC),而在激发态可和AN形成exciplc(称定域激发)。CTC经光照亦可激发(称CTC激发)。 定域激发引起光聚合速率为CH_3C_6H_4N(CH_3)_2>C_6H_5N(CH_3)_2>HOCH_2·C_6H_4N(CH_3)_2>CH_3C_6H_4N(CH_2CH_2OH)_2,与芳胺荧光被AN淬灭的Stern-Vo-lmer常数顺序一致。CTC激发引起的光聚合顺序为:CH_3C_6H_4N(CH_3)_2>CH_3C_6H_4N(CH_2CH_2OH)_2>HOCH_2C_6H_4N(CH_3)_2>C_6H_5N(CH_3)_2,与芳胺上取代基推电子能力一致。端基分析表明聚合物有芳胺端基。     

三聚甲醛的等离子体引发固相开环聚合

１前言聚甲醛的内聚能密度高，聚集紧密，结晶度较高。它的突出优点是刚性高，硬度大，耐蠕变性和耐疲劳性优异。另外，它的强度和冲击性能好，因此，具有广泛的应用价值［１］。有人利用γ－射线［２－５］，α－射线［６］和Ｘ－射线［７］照射三苯甲醛使其在固态下开环...     

丙烯腈在金属镁引发下的聚合动力学

研究了金属镁在硝酸溶液中引发丙烯腈的聚合反应。实验结果表明,聚合速度与金属镁的用量无关,并且当[HNO_3]>[AN]时服从下列关系式: R_p=1.91×10~5e~(-15000/RT)[Mg]~0[AN]~(2.2)[HNO_3]~(0.45) 丙烯腈-丙烯酸甲酯的共聚试验证明,聚合反应是按自由基机理进行。     

"CAGE" VANADYL POLYCARBOXYLATE-THIOUREA COMPLEX FOR THE POLYMERIZATION OF ACRYLONITRILE

The polymerization of acrylonitrile (AN) in aqueous nitric acid initiated by " cage " vanadyl polycarboxylate (P=VO)-thiourea (TU) complex was investigated. The overall rate ofpolymerization isThe relationship between the induction period (τ) and the temperature of polymerization as well as the concentrations of reactants can be expressed as follows :The molecular weight of polyacrylonitrile increases with increasing monomer concentration and decreases with increasing temperature of polymerization and concentrations of vanadyl polycarboxylate and thioureaThe polymerization mechanism was proposed and discussed.     

亚硝酸钠引发丙烯腈聚合的研究

研究了亚硝酸钠引发硝酸溶液中丙烯腈的聚合反应。测得表现聚合速度 Rp=Ae~(-10,800/RT)[AN]~2.2[NaNO_2]~(0.17-1.0)[HNO_3]~(1.0-0.67 丙烯腈-丙烯酸甲酯共聚合反应中竞聚率分别是γ_An=0.96,γ_MA=1.17,表明聚合反应是按自由基机理进行。 根据聚合动力学和红外光谱分析,认为以亚硝酸钠引发硝酸溶液中丙烯腈的聚合反应与电解或金属溶蚀过程中的次级引发相同。