Comparison of techniques for the extraction of the hypotensive drugs geniposidic acid and geniposide from Eucommia ulmoides

The extraction of geniposidic acid and geniposide from Eucommia ulmoides was carried out by Soxhlet extraction, enzyme-assisted aqueous extraction, semi-bionic extraction and supercritical fluid extraction techniques and the extracts were analyzed by high performance liquid chromatography. The results showed that the best methods for extraction of geniposidic acid and geniposide are enzyme-assisted aqueous extraction and semi-bionic extraction. Compared with various extraction methods, the semi-bionic extraction was more efficient, yielding the highest amount of geniposidic acid and geniposide. In semi-bionic extraction, no organic solvent was used. Semi-bionic extraction was performed at the same pH as that of the human body. The results indicated that semi-bionic extraction was the best method for large-scale efficient extraction of geniposidic acid and geniposide from plant materials. The supercritical fluid extraction process required more time than the other methods, and gave the lowest yields of geniposidic acid and geniposide.     

正交实验法在小麦粉中甲醛振荡提取条件的应用研究

小麦粉中甲醛的提取问题是一个比较复杂的多因素问题。采用正交实验法,选用L9(34)正交实验表,在提取试剂、提取温度、提取时间等多个因素和水平中优选小麦粉中甲醛振荡提取的最佳条件。实验中甲醛提取量采用Nash试剂柱前衍生高效液相色谱法测定。结果表明,提取温度是小麦粉中甲醛提取的最主要因素,最佳的提取条件为提取温度30℃、提取液为硫酸钠、提取时间为40min。     

微波辅助-旋转回流提取叶下珠中的没食子酸

A new kind of microwave-assisted circumrotation reflux extraction device was constructed and used to study the extraction technology of gallic acid from phyllanthus urmaria L.The extraction principle of the device was same as that of microwave-assisted solvent extraction but using circumrotation techniques as auxiliary stirrer to accelerate the process.Capillary electrophoresis was used to determinate gallic acid in phyllanthus urmaria L extracts in order to evaluate the extraction efficiency of the method.It was found that the most important factors influencing extraction gallic acid were solvent kind and microwave power.The optimum extraction conditions were as follows:water using as irradiate time 4 minute.Under the optimum extraction conditions,five experiments were carried out and the average extraction rate of gallic acid in phyllanthus urmaria L was 4.32 mg/g,relative standard deviations (R.S.D.) was 2.2%.Compared with other extraction methods e.g.reflux extraction and microwave-assisted extraction,better extraction efficiency was observed for the microwave-assisted circumrotation reflux extraction.     

Optimum extraction Process of polyphenols from the bark of Phyllanthus emblica L. based on the response surface methodology

Phyllanthus emblica L. is an economic plant used in Chinese medicine for the treatment of various diseases. The bark of P. emblica is rich in polyphenols and its extractions have shown strong antioxidative and radical scavenging activity. Response surface methodology (RSM) was used to assess the optimal extraction of polyphenols from P. emblica bark. Various extraction parameters including ethanol concentration, extraction time, temperature, solid–liquid ratio, and extraction times were chosen to identify their effects on polyphenols extraction. Among these parameters, extraction times and solvent concentration were found to have significant effect on polyphenols extraction. RSM was applied to obtain the optimal combination of solvent concentration, extraction time, temperature, and extraction time for maximum rate of extraction. The most suitable condition for the extraction of polyphenols was at ethanol concentration 75%, extraction time 25 min, extraction temperature 45°C, and extraction times 3. At these optimal extraction parameters, the maximum extraction of polyphenols obtained experimentally was found to be very close to its predicted value. The extraction rate of polyphenols was 19.78% at the optimum conditions. The mathematical model developed was found to fit with the experimental data of polyphenols extraction.     

超声微波酶解协同提取油茶壳中原花青素

建立了超声微波酶解协同提取油茶壳中原花青素的方法。通过单因素试验,探讨了超声微波协同提取油茶壳中原花青素过程中各主要因素对原花青素提取率的影响规律。实验中发现,往提取液中加入适量纤维素酶,可显著提高原花青素的提取率。在此基础上,通过正交试验,优化并获得了超声微波酶解协同提取原花青素的最适宜条件。最适宜提取条件为:超声波频率40 KHz、微波功率200 W、提取时间60 s、料液比1∶6、提取温度50℃、0.1%纤维素酶0.5 mL、提取次数2次。在最适宜条件下,原花青素的提取率为4.46%,分别是超声提取、微波提取和超声-微波协同提取的4.0、3.3和1.8倍。本文所建立的超声微波酶解协同提取油茶壳中原花青素的方法具有简便、快速、高效和节能等优势,有利于应用推广。     

Comparison of techniques for the extraction of the anti-cancer drug camptothecin from Nothapodytes foetida

Extraction methods using stirring extraction, Soxhlet extraction, ultrasonic extraction and microwave-assisted extraction (MAE) were evaluated for the percentage extraction of camptothecin (CPT) and 9-methoxycamptothecin (9-Me-CPT) from Nothapodytes foetida. The extracts were analyzed by high performance liquid chromatography (HPLC). Methanol (90%, v/v) extracted high percentage extraction of CPT and 9-Me-CPT compared to ethanol (90%, v/v). The results shows that the percentage extraction of CPT and 9-Me-CPT from N. foetida by MAE was more efficient in short time followed by Soxhlet extraction, ultrasonic and stirring extraction methods. Maximum percentage extraction of CPT (2.67%, w/w) was obtained by MAE technique. MAE has need of 3 min, whereas ultrasonic extraction, Soxhlet extraction and stirring extraction techniques require 30, 120 and 30 min, respectively to leach higher percentage extraction of CPT and 9-Me-CPT. The times taken by the microwave extraction process was 40 times less than the Soxhlet extraction for percentage extraction of alkaloids. The present results show that the extraction efficiency and considerable saving of time by MAE was more competent than the other extraction techniques.     

密闭微波辅助萃取当归粉中的阿魏酸

利用密闭微波样品制备系统(具有压力控制部件),对当归中的有效成分阿魏酸的萃取进行研究,比较了密闭微波萃取同超声波萃取和索氏萃取阿魏酸提取率的差异.结果表明:微波萃取与其他两种萃取方法相比,具有速度快和萃取率高的特点.并得到了阿魏酸提取的最佳条件:微波功率为400 W,萃取剂为90%的乙醇(体积分数),固-液比为1∶15,微波辐射为240 s,当归粒径为75μm.     

木蹄多糖提取工艺研究

通过对木蹄多糖提取得率有影响的子实体粉末颗粒大小、料水比、提取温度和提取时间进行的单因素研究,其中对料水比、提取温度和提取时间3个因素采用应用响应面法进行了优化,确定了木蹄子实体多糖的最佳提取工艺条件：子实体粉末颗粒60目,料水比1：42．92,提取温度88．92℃,提取时间3．92h,多糖得率达到5．68％。     

高压微波辅助提取法提取牛黄上清丸中的黄芩苷

采用高压微波辅助提取法提取牛黄上清丸中的黄芩苷, 利用蜜丸的粘性, 将蜜丸涂敷在自制毛玻璃片表面后, 置于高压微波提取装置中进行提取, 同时与直接将蜜丸切块置于微波装置进行了对比.     

野菊花中蒙花苷的提取及其含量的测定

以乙醇为溶剂,采用溶剂回流提取方法结合微波、超声波辅助提取野菊花中的蒙花苷,用HPLC法测定。采用正交试验法研究了野菊花中蒙花苷提取和HPLC实验条件,并比较了采用不同的微波和超声波辅助提取方式对蒙花苷提取结果的影响。结果表明,溶剂回流提取最佳条件为:提取温度80℃,回流时间2.0 h,溶剂用量40 mL。应用于安徽等产地野菊花中蒙花苷的提取分析,结果显示,广东和广西产地药材含量明显更高;在相同的实验条件下采用微波辅助提取可使蒙花苷达到较高的提取率,特别是采用微波辐射药材后再进行溶剂回流提取,提取时间可缩短一半。     

HPLC-ICP-MS for a comparative study on the extraction approaches for arsenic speciation in terrestrial plant, Ceratophyllum demersum

For the determination of arsenic compounds in terrestrial plant samples, a crucial step is the efficient extraction of arsenic from the solid plant matrix. However, the use of methanol-water extraction often resulted in low extraction efficiencies of less than 50%. In this study, eight solid-liquid extraction procedures (mainly based on mechanical mixing and sonication) were evaluated for the recovery of arsenic species from a submerged freshwater plant, coontail (Ceratophyllum demersum), collected in Moira River, Ontario, Canada. Speciation of As in the extracts was carried out with both anion-, and cation-exchange HPLC with sector-field inductively coupled plasma mass spectrometric (SF-ICP-MS) detection. The results obtained depended critically on the extraction solvents used in different extraction procedures. Extraction with methanol-water led only to 9%–44% recoveries of As. A high extraction yield (approximately 82%) was obtained by water extraction. Alkaline hydrolysis also resulted in high extraction efficiencies (86%–98%), but severe oxidation of As(III) to As(V) was observed. A protease enzymatic extraction led to a recovery of 48%. Approximately 0.5% of the total As in the plant sample was lipid-soluble. It was found that the extraction of inorganic arsenic species was suppressed by the presence of methanol in the extraction solvents, while high content of methanol in the extraction solvents was effective for the extraction of organic arsenic species. Therefore, it is recommended to perform the extraction both with water alone and with methanol-water (9+1, v/v), in order to obtain the complete As species profile in terrestrial plants.     

Comparison of extraction techniques for the isolation of explosives and their degradation products from soil

A comparison of four extraction techniques used for the isolation of 14 explosive compounds (Method 8330-Explosives) from spiked soil samples is described. Soxhlet warm extraction (SWE), pressurized solvent extraction (PSE), microwave assisted extraction (MAE) and supercritical fluid extraction (SFE) were included. The effects of basic extraction conditions – i.e. type of extraction solvent, temperature, pressure, and extraction time – were investigated. The best extraction recovery of the monitored compounds from spiked soil was obtained using pressurized solvent extraction. Recoveries of explosives using the PSE technique were in the range from 65 to 112%. Extraction recoveries by Soxhlet warm extraction and supercritical fluid extraction reached 65–99% and 52–75%, respectively. The lowest extraction recoveries (28–65%) were obtained using microwave assisted extraction. A very low extraction recovery for tetryl was observed in all cases but the best results were achieved by pressurized solvent extraction (58%).     

超临界CO_2萃取桑叶总黄酮工艺的研究

采用超临界CO2萃取桑叶总黄酮,以得率为指标,对萃取压力、萃取温度、夹带剂乙醇的浓度和流量等影响因素进行正交试验。结果表明最佳工艺条件为:萃取压力35 MPa,温度55℃,乙醇质量分数90%,乙醇流量0.01 mL/min。此条件下桑叶总黄酮得率2.28%。该方法简便、可靠、选择性高,适于工业化生产。     

超声波提取含羞草种子中总黄酮工艺条件优化研究

采用超声提取法对含羞草种子中黄酮类物质进行提取,对提取工艺条件如溶剂、配料比、浸泡时间、提取温度、提取时间进行了优化。在单试验的基础上进行正交试验,得出黄酮类物质的最佳提取工艺条件:乙醇体积分数为60%,含羞草种子与60%乙醇配料比(g∶m L)为1∶8,超声温度范围40~44℃,超声时间为50 min。该方法操作简单,提取时间短,提取效率较高。     

Dynamic Microwave-assisted Extraction of Flavonoids from Radix Scutellariae

IntroductionRadix Scutellariaeis the root ofScutellaria bai-calensis Georgi(Labiatae), which is widely cultivatedand used as traditional Chinese medicine. It has beendemonstrated to be anti-inflammatory, anti-metamor-phic, antiviral, anti-hot, and live pr…     

微波辅助流动萃取槐花中的黄酮类成分

槐花为豆科落叶乔木槐树(Sophora japonica L.)的花蕾,槐花能降低血管的通透性,所含芸香甙(芦丁)对心脏传导系统有抑制作用,能增强收缩力及输出量,降低血压;所含槲皮素可以扩张冠状动脉,降低心肌耗氧量,并能降低血脂。     

Enhancing extraction rate in solid-phase microextraction by using nano-structured polyaniline coating

The decrement of equilibrium extraction time without losing extraction efficiency in solid-phase microextraction (SPME) was achieved using nano-structured coating. Polyaniline (PANI) was used as an extraction phase for the comparison of extraction capacity and equilibrium extraction time of nano- and micro-structured coatings. Polychlorinated biphenyls (PCBs) were used as model compounds to examine the extraction properties of nano- and micro-structured coatings. The results revealed that nano-structured PANI coating showed higher extraction rate and shorter desorption time than micro-structured coating, because of the larger surface area. In order to evaluate the extraction capability of prepared nano-structured PANI coating, headspace-SPME method was used for the determination of PCBs in sediment samples by GC-electron capture detector. The proposed method was validated using the certified reference material.     

Ultrasound-assisted extraction of soy isoflavones

Efficiency in extracting four isoflavone derivatives (daidzin, glycitin, genistin and malonyl genistin) from freeze-dried ground soybeans was compared for mix-stirring extraction and ultrasound-assisted extraction, using different solvents and extraction temperatures with both. The efficiency of the extraction of soy isoflavones was improved by ultrasound but was dependent on the solvent employed. Optimization of the ratios of sample quantity to solvent volume and length of extraction time was also performed. Isoflavones can be quantitatively extracted from soybeans with 50% ethanol at 60 degrees C using ultrasound-assisted extraction in 20 min.     

Determination of Bisphenol A in Water Using a Packed Needle Extraction Device

A fiber-packed needle extraction device was used as a novel method for the extraction of bisphenol A from water samples. A bundle of filaments having a coating of polydimethylsiloxane was packed longitudinally into the needle. Good extraction efficiency was obtained even for an extraction time of 10 min, when the water sample was pumped through the needle with a syringe pump. The needle could be used repeatedly. The preparation procedure, included a derivatization process. Under optimum conditions, use of the fiber-packed needle showed a higher extraction efficiency than conventional sample preparation methods such as liquid–liquid extraction and solid-phase extraction.     

Multiple headspace single-drop micro-extraction for quantitative determination of lactide in thermally-oxidized polylactide

Single-drop micro-extraction (SDME), an emerging micro-extraction technique, was combined with multiple headspace (MHS) extraction to allow quantitative determination of lactide in thermally-oxidized polylactide. Different solvents, drop sizes and extraction times were tested to obtain best extraction efficiency and the method was further developed to obtain a linear regression plot for the multiple extractions. The combination of SDME and MHS extraction offered several advantages over traditional liquid-solid and headspace extraction techniques. No concentration step was needed and loss of volatiles was prevented as the ageing and extraction were performed in a closed system. Matrix effects, that disturb the quantitation of analytes in solid samples, were removed by the multiple headspace extraction.