Complex study of the structural and optical homogeneity of lithium niobate crystals

Methods of Raman spectroscopy, laser conoscopy, optical microscopy, and electron spin resonance have been used to study the photorefractive properties and structural and optical homogeneity of the following lithium niobate (LiNbO₃) crystals: nominally pure crystals of congruent composition (LiNbO_3con); LiNbO₃:Cu[0.015 wt %] crystals grown from a melt of congruent composition and nominally pure crystals of stoichiometric composition grown from a melt with 58.6 mol % Li₂O (LiNbO_3st). A small deformation of optical indicatrix and regular microdomain structures of fractal type are revealed for the LiNbO₃:Cu[0.015 wt %]; the microdomain structures may be due to the nonuniform impurity incorporation into the structure. It is shown that oxygen octahedra in the LiNbO₃:Cu[0.015 wt %] crystal are deformed in comparison with the octahedra in LiNbO_3st and LiNbO_3con crystals and that the main and impurity cations are clusterized along the polar axis. It is established that the LiNbO₃:Cu[0.015 wt %] crystal exhibits photorefractive properties not only due to the presence of intrinsic defects with localized electrons, as in the case of LiNbO_3st, but also due to the charge exchange in copper cations (Cu²⁺ → Cu⁺) under illumination.     

Growth of near‐stoichiometric LiNbO3 crystals and Li2O contents determination

Two kinds of near‐stoichiometric LiNbO₃ crystals (SLN11 and SLN19) were grown by a flux pulling method from stoichiometric melt with addition of 11mol%K₂O and 19mol%K₂O, respectively. Compared with the congruent melting LiNbO₃, the ultraviolet absorption edges of two crystals shift towards shorter wavelengths, and the locations of the OH^‐ infrared absorption band have obvious change and the bandwidths become greatly narrower. From these experimental results, the Li₂O contents are determined indirectly to be about 49.6mol% for SLN11 and 49.9mol% for SLN19, respectively. The Li₂O content in SLN19 is very close to the ideal value of 50mol%. The coercive fields of two crystals were measured by the poling method at room temperature. A linear relationship between the Li₂O content and the coercive field was fitted. (© 2004 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Improved blue photorefractive properties of near‐stoichiometric LiNbO3:Mn:Fe:Zr crystal

Near‐stoichiometric LiNbO₃ single crystal tri‐doped with ZrO₂, MnO and Fe₂O₃ was grown from Li‐riched melt by Czochralski method. The defect structures and composition of these crystals were analyzed by means of ultraviolet‐visible and infrared transmittance spectra. The appearance of 3466 cm^‐1 peak in infrared spectra showed that the crystal grown from Li‐riched melt was near stoichiometric. The photorefractive properties at the wavelength of 488 nm and 633 nm were investigated with two‐beam coupling experiment, respectively. The experimental results showed that the response speed and sensitivity were enhanced significantly and the high diffraction efficiency was obtained at 488 nm wavelength. This manifested that near‐stoichiometric LiNbO₃:Mn:Fe:Zr crystal was an excellent candidate for holographic storage. (© 2010 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Near‐stoichiometric LiNbO3:ZrO2 single crystal growth by micro pulling down method

Crack‐free, rod‐shaped single crystals of undoped and 0.5, 0.7 and 1.0 mol% ZrO₂‐doped LiNbO₃ with a near‐stoichiometric composition were grown by the micro‐pulling down (μ‐PD) method. The structural properties of the grown crystals were examined by powder X‐ray diffraction (XRD). Electron probe micro analysis (EPMA) of the near‐stoichiometric LiNbO₃ single crystals revealed the homogeneous incorporation of Zr ions. The change in the refractive index and IR transmission spectra of the grown crystals were examined as a function of the Zr concentration. (© 2010 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Structure and optical properties of near stoichiometric Ce:LiNbO3 crystals

The near sotichiometric Ce:LiNbO₃ (Ce:SLN) crystals were grown by the top seeded solution growth (TSSG) method by adding K₂O flux to Li₂O‐Nb₂O₅ melt. Their UV‐vis absorption spectra and IR spectra were measured and discussed to investigate their defect structure. The results showed that the grown crystals were near stoichiometric and Ce ions in the crystals located the Li site. Photorefractive properties of Ce:SLN crystals were studied by two‐wave coupling experiment. The results of the two‐wave coupling experiments of the crystals showed that as the CeO₂ doping concentrations increased, the diffraction efficiency increased, photoconductivity decreased and the writing time and erasure time increased. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth of LiNbO<Subscript>3</Subscript>:Er Crystals and concentration dependences of their properties

A series of lithium niobate (LiNbO₃) crystals of congruent and stoichiometric compositions, doped with erbium, have been grown under non-steady-state thermal conditions. A series of LiNbO₃:Zn crystals, nominally pure LiNbO₃ crystals of congruent and stoichiometric compositions, and a LiNbO₃:B crystal have also been grown. Both growth conditions and concentration dependences of physicochemical, ferroelectric, and structural characteristics of LiNbO₃:Er crystals are investigated. The growth regular domain microstructures and periodic nanostructures in LiNbO₃:Er crystals are analyzed by optical microscopy and atomic force microscopy (AFM). A comparative study of the optical homogeneity and photorefractive properties of LiNbO₃:Er crystals of congruent and stoichiometric compositions and the Raman spectra of LiNbO₃ crystals of different compositions is performed.     

Growth and characterization of near stoichiometric LiNbO3 single crystal

A near stoichiometric LiNbO₃ single crystal has been grown by the Czochralski method from a 58.5% Li melt hold in a large platinum crucible. High resolution X‐ray rocking curves of 30 0 and 0006 reflections indicated that the near stoichiometric LiNbO₃ crystal possesses the high structural quality. Compared with the congruent LiNbO₃, the near stoichiometric LiNbO₃ possesses shorter ultraviolet absorption edge, thus higher Li concentration. The OH^– infrared absorption band analyses showed that the Li concentration in the near stoichiometric LiNbO₃ crystal is higher than that in the congruent LiNbO₃ crystal. This result is in good agreement with that of the ultraviolet absorption edge. The electro‐optic (EO) coefficient γ₂₂ of the near stoichiometric LiNbO₃ crystal was measured to be 6.75 pm/V higher than that of congruent LiNbO₃ crystal. It also proves the near stoichiometric LiNbO₃ electro‐optic Q‐switched requires a low driving voltage and it is advantageous for the device performance. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Inhomogeneity of composition in near‐stoichiometric LiNbO3 single crystal grown from Li rich melt

A near‐stoichiometric LiNbO₃ single crystal has been grown by the Czochralski technique from a melt of 58.5 mol% Li₂O. Its composition homogeneity was assessed by measuring the UV absorption edge. It was found that the maximum composition difference is about 0.03 mol% in the radial direction and 0.05 mol% in the axial direction. Differential scanning calorimetry (DSC) analysis was performed on the powder from the synthesized raw material and the frozen melt after crystal growth. The analytical results indicate that, during crystal growth, the magnitude of lithium volatilization from the melt surface is more than the degree of segregation from the crystal. The volatilized lithium diffuses into the crystal to compensate for the lithium segregation in the LiNbO₃ crystal. (© 2006 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Defect structure characteristics in near‐stoichiometric In:LiNbO3 single crystals grown by K2O‐flux method

With K₂O as flux, near‐stoichiometric In:LiNbO₃ (In:SLN) crystals with different indium contents were grown by the top seed solution growth (TSSG) method. Defect structure characteristics and the replacement principle of extrinsic ions were derived from X‐ray powder diffraction, differential thermal analysis (DTA), ultraviolet‐visible (UV) absorption and infrared (IR) spectrum measurement. Further analysis indicated that the threshold concentration of In₂O₃ in near‐stoichiometric LiNbO₃ crystals were about 1.1 mol%. (© 2009 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Photorefraction Dependent on Composition in LiNbO3 Crystals with and without MgO Doping

The photorefraction in LiNbO₃ single crystals dependent on the melt composition with and without MgO doping was investigated. It was found that 1 mol% MgO-doped crystal with nearly stoichiometric composition has a strong photorefraction resistance. compared with a congruent composition. In an undoped crystal, the photorefraction was shown to be pronounced as incrcasing Li content of a melt from 48.6 to 58 mol% Li₂O. These results were discussed from a viewpoint of the relationship between the photoconductivity and the concentration of cation-site vacancies or Nb on Li-site.     

Optical Properties of Er Doped Congruent and Stoichiometric LiNbO3 Single Crystals

Erbium doped LiNbO₃ (Er:LiNbO₃) single crystal fibers were grown free of cracks along c‐axis by the micro‐pulling down (μ‐PD) method. We have investigated the up‐conversion property with the change of doped Er₂O₃ concentration and the starting melt composition. An enhancement of green upconversion according host matrix is also observed the stoichiometric LiNbO₃. And, the dependence of the green emission according to Er³⁺ concentration is analyzed. The possible application of the Er³⁺ doped stoichiometric LiNbO₃ single crystal fiber for up‐conversion based optical devices is discussed.     

Defect structure and light‐induced scattering of Zr‐doped near‐stoichiometric Mn:Fe:LiNbO3 crystals grown by TSSG method

Near‐stoichiometric Mn:Fe:LiNbO₃ crystals doped with various concentration of ZrO₂ were grown by top seed solution growth (TSSG) method in the air atmosphere. The Zr concentration in the crystal was determined by inductively coupled plasma optical emission spectrometer. The defect structures were analyzed by means of ultraviolet‐visible and infrared transmittance spectra. The appearance of vibration peak at 3466 cm^‐1 in infrared spectra manifested that Li/Nb ratio in crystals approached to stoichiometric proportion. The fundamental absorption edge represented continuous red‐shift which was discrepancy with congruent doped LiNbO₃ crystals showed that doping ions possessed different location mechanism. The light‐induced scattering of the doped stoichiometric LiNbO₃crystals were quantitatively scaled via incident exposure energy. The results demonstrated that Zr(2 mol%):Mn:Fe:LiNbO₃ crystal had the weakest light‐induced scattering and the mechanism related to their defect structures was discussed. (© 2012 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Defect structure and optical damage resistance of In:Fe:Cu:LiNbO3 crystals with various [Li]/[Nb] ratios

In:Fe:Cu:LiNbO₃ crystals were grown in air by the Czochralski technique with various [Li]/[Nb] ratios of 0.946, 1.050, 1.200, and 1.380 in melt. Based on the ICP‐AES (inductively coupled plasma atomic emission spectrometry) analyzed results, the chemical formula of the triple‐doped In:Fe:Cu:LiNbO₃ crystals were obtained. It can be seen that the near‐stoichiometric ratio value is between 1.050 and 1.200 for our samples. The optical damage resistance of In:Fe:Cu:LiNbO₃ crystals was characterized by changes in light‐induced birefringence and it increases with the increasing of [Li]/[Nb] ratios. The dependence of the optical damage resistance on the defect structure of In:Fe:Cu:LiNbO₃ crystals is discussed in detail based on the obtained chemical formulas. (© 2011 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Bulk crystal growth of congruent MgO-doped LiNbO3 crystal with stoichiometric structure and its second-harmonic-generation properties

A new LiNbO₃ bulk crystal has been grown by doping with MgO (cs-MgO:LN; Li₂O:Nb₂O₅:MgO=45.30:50.00:4.70, (Li_0.906Mg_0.047V^Li_0.047)NbO₃), which successfully has the congruent point coinciding with the stoichiometric point. Its second-harmonic-generation (SHG) properties were evaluated. It was found that cs-MgO:LN has a much more homogeneous composition leading to uniform in-plane distribution of the non-critical phase-matching wavelength than the conventional LiNbO₃ crystals such as congruent LiNbO₃ (c-LN), stoichiometric LiNbO₃ (s-LN), and MgO-doped congruent LiNbO₃ (5MgO:LN). This homogeneity arose from the observation that none of the solute components including ionic species were segregated at the interface during growth. The SHG conversion efficiency of cs-MgO:LN is comparable to those of s-LN and 5MgO:LN.     

Effects of the Li-evaporation on the Czochralski growth of γ-LiAlO2

Two-inch-diameter γ-LiAlO₂ single crystals were grown from the melt by Czochralski method. The crystals were examined by optical methods, high-resolution X-ray diffraction and transmission electron microscopy (TEM). Inductively coupled plasma optical emission spectrometry (ICP-OES) was used to determine the Li/Al ratio in the residual melts. The Li-evaporation from both melt and grown crystal is the main problem in the γ-LiAlO₂ growth and has to be controlled by acting on the vertical temperature gradient. Shallow gradients increase the Li-evaporation from the crystal surface resulting in boules with a milky rim. On the other hand, steep gradients may induce cracks in the boule and enhance the Li₂O escape from melt with consequent variation of the composition. ICP-OES investigations reveal that melt compositions can vary in the range from 46.5 to 50 mol% Li₂O to obtain transparent LiAlO₂ crystals. Beyond this value, the formation of inclusions inside the crystals is probable. We have established an optimized growth assembly, which allows remaining the melt composition stoichiometric. The as-grown crystals exhibit defects like subgrains, twins and a core of voids and fine-grained inclusions. The latter could be characterized by TEM as submicron LiAl₅O₈ crystallites.     

Micro‐Pulling Down Growth of Co‐doped Lithium Niobate Single Crystal Fibers According Er and Mg Contents and Photolumenescence Properties

The Er³⁺doped Mg:LiNbO₃single crystal fibers employed in our experiment were grown in air by a micro‐pulling down (μ‐PD) method from host materials of a congruent Li/Nb (0.945) ratio which were melt‐doped with a nominal molar concentration of 1, 3, 5% MgO and 0.6% Er₂O₃. The X‐ray diffraction analysis results indicated that the co‐doped crystals main tained the same structural characteristics as the undoped LiNbO₃, however the lattice parameters with Mg differed; c (Å) value decreased, and a (Å) increased than of pure LiNbO₃. The influence of dopants on the photoluminescence (PL) properties of the Er:Mg:LiNbO₃ single crystal fibers excited by laser lines of 514 nm was reported. Also, the PL properties according to temperature and the excitation power of Er:Mg:LiNbO₃ crystal fibers were analyzed.     

High photorefractive sensitivity and fast response time of near‐stoichiometric and MgO doped LiNbO3:Fe crystals

Congruent LiNbO₃:Fe and LiNbO₃:Mg,Fe crystals were grown by Czochralski method, and vapor transport equilibration technique was employed to improve the [Li]/[Nb] ratios of these crystals. The influence of stoichiometry and MgO dopant on the photorefractive sensitivity and response time of LiNbO₃:Fe crystals was investigated. Both stoichiometry and MgO dopant can effectively reduce the amount of intrinsic defects, but MgO can also decrease the concentration of Fe²⁺ ions in Li‐sites. Near‐stoichiometric and MgO doped LiNbO₃:Fe crystal has high photorefractive sensitivity and fast response time. (© 2006 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Investigation on photorefractive properties of doped lithium niobate

Cu:LiNbO₃ crystal and Fe:Cu:LiNbO₃ crystals were grown by the Czochralski method from congruent melt. The OH^‐ absorption spectrum of doped lithium niobate crystals was measured. The photorefractive properties of doped crystals were studied by the two‐wave coupling method. The results of the two‐wave coupling experiments showed that as the concentration of doping ions increased, the diffraction efficiency and the dynamic range enhanced, the holographic response time shortened. The recording time of Fe(0.10wt%): Cu(0.10wt%): LiNbO₃ crystal is only a tenth of that of Cu(0.05wt%): LiNbO₃ crystal. Among all samples, the dynamic range of the Fe(0.10wt%): Cu(0.10wt%): LiNbO₃ crystal was the most largest (up to 40.78). (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Temperature distribution in growing semi-transparent crystals (III). Conical liquid/solid interface

Temperature distribution in Al₂O₃ and YAG crystals grown by Czochralski method and in the melt layer adjacent to the liquid/solid interface of the conical shape was computed. The results were compared with the quality of the crystals. Using a highly absorbing material, temperature difference near the deeply submerged sharp interface decreases from the edge to the centre of a crystal and it is relatively great and unalterable in the case of a shallowly submerged blunt interface. Sharp interface show the crystals grown from the melt of the same composition (Al₂O₃ or accurately “stoichiometric” YAG), whereas the blunt one is typical of YAG grown from the melt of the “non-stoichiometric” composition, because its solidifying point is below the melting point of YAG phase.     

Reduction of grown-in dislocation density in Ge Czochralski-grown from the B2O3-partially-covered melt

Germanium (Ge) single crystals with an extremely low density of grown-in dislocations were grown by the Czochralski (CZ) technique with boron oxide (B₂O₃) liquid. Because attachment of particles floating on the melt surface to a growing Ge crystal leads to generation of dislocations during the growth, partial covering of the Ge melt surface with B₂O₃ liquid was attempted. Such attachment of particles was drastically suppressed or the particles were caught by the introduction of B₂O₃ liquid, and a particle-free Ge melt was realized in the central region of the melt surface. Ge single crystals were successfully grown from such melt, the grown-in dislocation density being 0–1×10³ cm⁻², which was remarkably lower than that in Ge crystals grown by a conventional CZ technique. The contaminations by B and O atoms of the grown crystal detected by SIMS analysis were very low. These Ge crystals have the potential for application to be applied as high-quality, dislocation-free substrates of GaAs solar cells for various usages including in space.