ProteinA亲合膜色谱柱的性能及从人血浆中纯化免疫球蛋白的研究

以木纤维为基质,与甲基丙烯酸环氧丙酯共聚接枝合成了复合膜介质,用复合膜介质制备了ｐｒｏｔｅｉｎＡ亲合膜色谱柱,考察了ｐｒｏｔｅｉｎＡ亲合膜色谱柱液相流动特性和吸附性能。实验证明：流速与亲合膜色谱柱柱压呈线性关系,当流速为３ｍＬ／ｍｉｎ时,柱压为１６０ｋＰａ。免疫球蛋白（ＩｇＧ）浓度和上样速度是影响ｐｒｏｔｅｉｎＡ键合容量的重要因素,对其进行了优化研究。用动态吸附法确定了对人ＩｇＧ动态最大吸附能力可达２１．７ｍｇ／ｇ（干介质）。     

疏水膜色谱法对生物大分子的快速纯化

首次采用自制的分别级合了辛基、丁基、苯基及聚乙二醇-4000的4种常用疏水基团的纤维素疏水膜色谱柱,以键合了辛基、苯基的SepharoseCL－4B凝胶柱为对照,考察了疏水膜色谱柱对牛血清白蛋白（BSA）的动态吸附容量及流速对吸附容量的影响。疏水膜色谱柱对蛋白及酶具有较好的疏水吸附及纯化作用,但吸附容量比相应的琼脂糖凝胶柱低得多。增大流速及降低蛋白溶液质量浓度对疏水膜色谱柱的吸附容量影响较小,这些性能使膜色谱柱非常适合于大体积低质量浓度蛋白溶液（如基团工程培养液）的分离纯化。     

使用限进介质色谱柱的柱切换高效液相色谱法直接进样测定大鼠血浆中舒必利

提出一种直接进样测定大鼠血浆中舒必利浓度的高效液相色谱方法,使用限进介质色谱柱作为预柱在线去除血浆蛋白后,将舒必利通过柱切换转移到分析柱中进行分析。限进介质色谱柱为CAPCELLPAKMFSCX阳离子交换柱（20×4．0mmi．d．,5μm）,分析柱为Kromasil C18柱（150×4．6mm i．d．,5μm）,限进介质柱预分离时流动相为PH=6．88的50mmol／L磷酸盐缓冲液乙腈（100：5,V／V）,切换后分析流动相为PH=6．83的50mmol／L磷酸盐缓冲液-乙腈（100：10,V／V）。流速均为1mL／min,检测波长为240nm。该方法检出限为17ng／mL,定量限为50ng／mL。舒必利在50～1400ng／mL之间线性良好（r=0．9997）,高中低浓度的日内、日间相对标准偏差分别为1．5％～4．2％及2．0％～5．2％,方法回收率为98．8％～104．1％．     

高效离子交换膜色谱介质制备及其对蛋白质的分离

制备了一种以纤维素膜为基质,以二乙胺为配基的高效液相离子交换膜色谱介质,并考察了不同柱长、不同洗脱梯度、不同流速下其对几何标准蛋白的分离情况。与高效液相柱色谱相比,这种高效液相膜色谱柱可以更快速的达到蛋白质的分离。即使在较高流速下,柱压仍较低。实验表明,这种高效液相膜分谱柱适合于蛋白质的快速分离。     

固载蛋白A交联聚甲基丙烯酸缩水甘油酯连续床亲合色谱柱的制备及性能考察

采用沉淀聚法“原位”（in-situ)聚合合成了交联聚甲基丙烯酸缩水甘油酯连续床色谱柱,对其进行化学改性后,分别得到含有11个碳原子间隔臂以及不含间隔臂键合了蛋白A的高效亲合色谱柱。考察了这两种色谱介质的性能,结果表明含有间隔臂的介质有一定的疏水性;对传统制备蛋白配基的亲合色谱介质的合成路线进行了改进;采用不含间隔臂的亲合柱测定了人血浆中人免疫球蛋白G（HIgG)的含量,所测得的定量标准曲线线性相关系数达到0．999;考察了流速对合成的连续床色谱柱柱压的影响,当流速高达9．0mL/min时,柱压也仅为6．5MPa;采用pH梯度对HIgG的不同亚基进行了分离。     

固定化铜离子亲和膜色谱柱吸附血红蛋白的研究

将纤维素滤纸进行碱处理及环氧活化、偶联亚氨基二乙酸、固定化铜离子等处理,并将其装入自制的色谱柱管,制得固定化铜离子亲和膜色谱柱。该柱可用于吸附血红蛋白(hemoglobin,Hb),吸附率可达到90%以上。考察了上样量、pH值、温度、上样速度等因素对固定化铜离子亲和膜吸附Hb的影响。实验结果表明,固定化铜离子亲和膜色谱柱吸附血红蛋白的最佳条件为：室温下实验,缓冲体系的pH值控制在6~8,上样速度0.5~1.0 mL/min,上样量为3.16~7.90 mg/g。     

单分散交联聚甲基丙烯酸环氧丙酯树脂的制备及亲合纯化伴刀豆球蛋白-A

采用一步种子溶胀聚合法制备了颗粒呈单分散的交联聚甲基丙烯酸环氧丙南树脂，对其环氧基的组成比进行了表征，并以氨基葡萄糖为配基，首次制备了纯化粗品伴刀豆球蛋白-A(Ⅲ）(Con-A，Ⅲ)的聚合物基质的高效亲合色谱柱。配基在树脂上的键合量为8．2mg／g，对纯化后的Con-A（Ⅲ）的吸附量为13．4mg／g。使用该亲合色谱介质成功地从粗品Con-A中快速纯化了Con-A，电泳分析显示为一个主要的谱带，纯度从15％提高到95％。     

壳聚糖涂层亲和层析介质合成的研究

研究了壳聚糖涂层亲和层析介质的制备工艺。采用合适的涂层条件，壳聚糖在玻璃珠上一次涂层量可达34mg／g介质。采用二氯化物交联剂可提高壳聚糖涂层介质的稳定性。当pH＞4．3时，交联壳聚糖涂层介质对Cu2＋的吸附容量达13．6mgCu2＋／g壳聚糖。在本介质的膨胀床中，最大液体流速可达1m／h。     

离子交换法纯化重组类人胶原蛋白Ⅱ的研究

用阳离子交换树脂CM-52分离纯化类人胶原蛋白Ⅱ（Human Collagen-like Bioprotein Ⅱ,HCBⅡ）。通过实验,分别确定了静态吸附和柱层析吸附的操作条件,即静态吸附：在pH4．0、NaCl0．15mol／L、进料浓度7g／L,处理量17．26ml／g树脂的条件下进行吸附,吸附时间为60min;柱层析：在pH4．0、NaCl0．15mol／L、进料浓度5g／L、流速5ml／min的条件下进行吸附。然后上柱,在pH4．0、NaCl0．30mol／L下进行脱附。实验表明,采用静态吸附的方式吸附HCBⅡ,然后上柱洗脱,HCBⅡ的吸附量可达到48、6mg／g树脂,回收率83．8％,操作时间短,分辨率高,最终纯化的HCBⅡ达电泳纯,分子量为97kD。     

黄芪中黄酮类化合物的超临界流体色谱分离方法研究

考察了超临界流体色谱（SFC）中的色谱柱、改性剂、添加剂、流速、柱温和背压等因素对9种黄酮类成分（包括芒柄花素、异鼠李素、毛蕊异黄酮、山奈酚、槲皮素、紫云英苷、芒柄花苷、异槲皮苷、毛蕊异黄酮葡萄糖苷）分离的影响,与高效液相色谱法（HPLC）进行了比较,并建立了黄芪饮片中5种主要黄酮类化合物的SFC分析方法。采用Agilent ZORBAX RX－SIL色谱柱（4.6 mm × 150 mm,5 μm）进行分离,CO2－0.1%磷酸甲醇溶液为流动相梯度洗脱,流速为3 mL/min;柱温为35 ℃;背压为10 MPa,9种黄酮类化合物可在10 min内实现基线分离。5种黄酮类化合物在一定质量浓度范围内均具有良好的线性关系（r2 ≥ 0.963 2）,检出限为10.69 ~ 16.21 μg/mL,日内相对标准偏差（RSD）为1.3% ~ 2.0%;日间RSD为1.6% ~ 2.2%。5种黄酮类化合物在48 h内具有良好的稳定性,重复性为3.6% ~ 6.0%,回收率为91.8% ~ 112%。与HPLC法相比,9种化合物的保留时间顺序基本相反,SFC法更快速、经济环保,且其保留及选择性受色谱柱、改性剂和添加剂的影响较大,添加剂对色谱峰形影响明显。     

Protein A tangential flow affinity membrane cartridge for extracorporeal immunoadsorption therapy.

Tangential flow affinity membrane cartridge (TFAMC) is a new model of immunoadsorption therapy for hemoperfusion. Recombinant Protein A was immobilized on the membrane cartridge through Schiff base formation for extracorporeal IgG and immune complex removal from blood. Flow characteristics, immunoadsorption capacity and biocompatibility of protein A TFAMC were studied. The results showed that the pressure drop increased with the increasing flow rate of water, plasma and blood, demonstrating reliable strength of membrane at high flow rate. The adsorption capacities of protein A TFAMC for IgG from human plasma and blood were measured. The cartridge with 139 mg protein A immobilized on the matrix (6 mg protein A/g dry matrix) adsorbed 553 mg IgG (23.8 mg IgG/g dry matrix) from human plasma and 499.4 mg IgG (21.5 mg IgG/g dry matrix) from human blood, respectively. The circulation time had a major influence on IgG adsorption capacity, but the flow rate had little influence. Experiments in vitro and in vivo confirmed that protein A TFAMC mainly adsorbed IgG and little of other plasma proteins, and that blood cell damage was negligible. The extracorporeal circulation system is safe and reliable.     

Macroporous poly(glycidyl methacrylate-triallyl isocyanurate-divinylbenzene) matrix as an anion-exchange resin for protein adsorption.

A novel macroporous poly(glycidyl methacrylate-triallyl isocyanurate-divinylbenzene) matrix was prepared by a radical suspension copolymerization. The matrix contained epoxy groups, so diethylaminohydroxypropyl groups were coupled to the matrix, leading to an anion-exchange resin. We studied the components, surface and pore structures of the anion-exchange resin by Fourier transform infared spectroscopy and scanning electron microscopy (SEM). SEM observations showed that the resin abounded in macropores as large as 3 to 8 microns both in the surface and the interior. The back-pressure of the column packed with the resin was modest even at a high flow-rate (60.2 cm/min). Then, bovine serum albumin (BSA) was used as a model protein to examine the adsorption properties of the anion-exchange resin. The results showed that under optimum conditions the resin had a capacity as high as 22.8 mg BSA/g wet resin, or 68.7 mg/g dry resin. The adsorbed protein could be desorbed by increasing the liquid phase ionic strength. Most importantly, the matrix had little nonspecific adsorption for BSA before introducing the ion-exchange groups.     

Oriented immobilized anti‐hIgG via Fc fragment‐imprinted PHEMA cryogel for IgG purification

Antibodies are used in many applications, especially as diagnostic and therapeutic agents. Among the various techniques used for the purification of antibodies, immunoaffinity chromatography is by far the most common. For this purpose, oriented immobilization of antibodies is an important step for the efficiency of purification step. In this study, F_c fragment‐imprinted poly(hydroxyethyl methacrylate) cryogel (MIP) was prepared for the oriented immobilization of anti‐hIgG for IgG purification from human plasma. Non‐imprinted poly(hydroxyethyl methacrylate) cryogel (NIP) was also prepared for random immobilization of anti‐hIgG to compare the adsorption capacities of oriented (MIP/anti‐hIgG) and random (NIP/anti‐hIgG) cryogel columns. The amount of immobilized anti‐hIgG was 19.8 mg/g for the NIP column and 23.7 mg/g for the MIP column. Although the amount of immobilized anti‐hIgG was almost the same for the NIP and MIP columns, IgG adsorption capacity was found to be three times higher than the NIP/anti‐hIgG column (29.7 mg/g) for the MIP/anti‐hIgG column (86.9 mg/g). Higher IgG adsorption capacity was observed from human plasma (up to 106.4 mg/g) with the MIP/anti‐hIgG cryogel column. Adsorbed IgG was eluted using 1.0 m NaCl with a purity of 96.7%. The results obtained here are very encouraging and showed the usability of MIP/anti‐hIgG cryogel prepared via imprinting of Fc fragments as an alternative to conventional immunoaffinity techniques for IgG purification. Copyright © 2012 John Wiley & Sons, Ltd.     

Membrane affinity chromatography for analysis and purification of biopolymers

Summary Affinity columns suitable for HPLC were prepared by immobilization of various ligands of protein A, human IgG, human IgM and pectinase on GMA modified cellulose membrane. The adsorption capacity, affinity efficiency and activity recovery of various IgGs on these affinity columns were measured. It was observed that the length of the coupling arm plays a very important role in affinity efficiency, and the effect of eluent flow-rate on adsorption capacity was very small. The protein A column was exploited for the process monitoring of dog IgG in clinical experiments on immuno-adsorption therapy. A pectinase column was used for the determination of polygalacturonase inhibiting proteins first purified on a hydroxyapatite column. It took only about 2.5 min for analysis at a flow-rate of 1.0 mL min⁻¹. The high speed analysis of biopolymers could be performed at a flow rate of 6.0 mL min⁻¹ within 15 s. Membrane affinity chromatography gives good reproducibility, high efficiency, low column-pressure and is rapid. It can also be used for micro-scale purification of biopolymers.     

Dye attached poly(hydroxyethyl methacrylate) cryogel for albumin depletion from human serum

Cibacron Blue F3GA was immobilized on poly(hydroxyethyl methacrylate) cryogel and it was used for selective and efficient depletion of albumin from human serum. The poly(hydroxyethyl methacrylate) was selected as the basic component because of its inertness, mechanical strength, chemical and biological stability, and biocompatibility. Cibacron Blue F3GA was covalently attached to the poly(hydroxyethyl methacrylate) cryogel to produce poly(hydroxyethyl methacrylate)-Cibacron Blue F3GA cryogel affinity column. The poly(hydroxyethyl methacrylate)-Cibacron Blue F3GA cryogel was characterized with respect to gelation yield, swelling degree, total volume of macropores, Fourier Transform Infrared spectroscopy, and scanning electron microscopy. It was found that the maximum amount of adsorption (343 mg/g of dry cryogel) obtained from experimental results is very close to the calculated Langmuir adsorption capacity (345 mg/g of dry cryogel). The maximum adsorption capacity for poly(hydroxyethyl methacrylate)-Cibacron Blue F3GA cryogel column was obtained as 950 mg/g of dry cryogel for nondiluted serum. The adsorption capacity decreased with increasing dilution ratios while the depletion ratio of albumin remained as 77% in serum sample. Finally, the poly(hydroxyethyl methacrylate)-Cibacron Blue F3GA cryogel was optimized for using in the fast protein liquid chromatography system for rapid removal of the high abundant proteins from the human serum.     

Poly(HEMA-co-NBMI) Monolithic Cryogel Columns for IgG Adsorption

Supermacroporous poly(2-hydroxyethyl methacrylate-co-1,5-naphthalene bismaleimide) [poly(HEMA-co-NBMI)] monolithic cryogel column was prepared by free radical cryo-copolymerization of HEMA with NBMI as a hydrophobic functional comonomer and N,N′-methylene-bisacrylamide as cross-linker directly in a plastic syringe for adsorption of albumin. The monolithic cryogel contained a continuous polymeric matrix which has interconnected pores of 10–100 μm size. Poly(HEMA-co-NBMI) cryogel was characterized by swelling studies, FTIR and scanning electron microscopy. The equilibrium swelling degree of the poly(HEMA-co-NBMI) cryogel was 10.5 g of H₂O/g dry cryogel. Poly(HEMA-co-NBMI) cryogel was used in the adsorption/desorption of IgG from aqueous solutions. The maximum amount of IgG adsorption from aqueous solution in phosphate buffer was 98.20 mg/g polymer at pH 7.0. The nonspecific adsorption of IgG onto plain poly(HEMA) cryogel was very low (2.79 g/g polymer). It was observed that IgG could be repeatedly adsorbed and desorbed with the poly(HEMA-co-NBMI) cryogel without significant loss of adsorption capacity.     

Isolation of human serum immunoglobulins with a new salt-promoted adsorbent

In this work a highly acetylated-ethylenediamine-Novarose (HA-EDA-Novarose) gel was synthesized and used as a new agarose-based salt-promoted adsorption chromatography (SPAC) matrix to effectively isolate serum immunoglobulins without the need of denaturing conditions. Samples of human serum in 0.5 M Na2SO4, 10 mM 3-(N-morpholino)-propane-sulfonic acid (MOPS), pH 7.6 were applied to a chromatographic column packed with the SPAC gel. Immunoglobulins (Igs) with affinity for the HA-EDA ligands were specifically adsorbed to the matrix, non-bound serum proteins were readily removed by washing the column with the same feed solution buffer. Bound Igs were effectively and very gently eluted by simply removing the salt from the feed solution buffer. The elution buffer consisted thus of only 10 mM MOPS, at pH 7.6 and no salt. The salt-dependent adsorption capacity of this system was estimated to be 7.3 mg/ml with protein recovery of about 93%. Sodium dodecyl sulfate-polyacrylamide gel (SDS-PAGE) electrophoresis analysis, radial immunodiffusion and enzyme-linked immunosorbent assays showed that immunoglobulins G, M and A (IgG, IgM and IgA) were the main components present in the elution fraction. The new SPAC adsorbent was used to purify Igs from human serum and IgG and IgA from non-pure commercially available Igs preparations in a very gentle single step.     

Metal-Chelating Nanopolymers for Antibody Purification from Human Plasma

The purification of immunoglobulin G (IgG) from human plasma was performed by using a novel metal-chelated adsorbent with nano size. The non-porous nanoparticles were produced by surfactant free emulsion polymerization of ethylene glycol dimethacrylate (EDMA) and 2-methacryloylamidohistidine (MAH). Then, Cu(II) ions were chelated on the nanoparticles. The nano-poly(EDMA-MAH) nanoparticles were characterized by Fourier transform infrared, scanning electron microscope, atomic force microscope and elemental analysis. The non-porous nanoparticles were spherical form and have 100?C250?nm size distribution. The maximum IgG adsorption capacity of the Cu(II) chelated nanoparticles was found to be 463?mg/g polymer at pH 7.0 in HEPES buffer. Desorption of IgG was performed by 1.0?M NaCl and desorption rate was found to be 97?%. IgG was obtained from human plasma with purity of 94?% (up to 578?mg/g polymer). The non-porous nanoparticles allowed one-step purification of IgG from human plasma.     

On-line simultaneous removal of human serum albumin and enrichment of doxazosin using a weak cation-exchange monolithic column

A weak cation-exchange monolithic column was prepared by modifying the GMA-EDMA (glycidyl methacrylate-co-ethylene glycol dimethacrylate) monoliths with ethylenediamine and monochloracetic acid. The properties of the column were investigated; the column exhibited the ability of low backpressure and fast analysis. Using this monolithic column, trace doxazosin in human serum albumin (HSA) solution and plasma samples has been on-line tested, the extraction efficiency and the maximum loading capacity of the monolithic column were obtained. The results showed that the monolithic column could realize deproteinization and trace drug enrichment simultaneously in the HSA solution and human plasma, which provided a simple, cheap, effective and friendly to environment method for assaying drugs in the blood.