Na—W—Mn／SiO2催化剂表面甲烷脉冲反应I.单组分Na／、W／、Mn／SiO2催化剂

制备了单组分Na/、W/、Mn/SiO2催化剂，在ITD（Ion Trap Detector）装置上进行了催化剂表面晶格氧脱附前后的甲烷恒温脉冲反应（CH4-CTPR），研究结果表明，N a/SiO2表面晶格氧具有一定的C2烃选择性，并能强烈抑制CO2的生成，W/SiO2表面晶格氧对C2烃的选择性较差，但对Cox具有高的选择性；Mn/SiO2表面的晶格氧对C2H4和CO具有高选择性，而较深部位的晶格氧则对C2H6和CO2具有高的选择性。     

On the Role of Vanadia Species for VOx／SiO2 in the Selective Oxidation of Methane

Various VOx/SiO2 catalysts were prepared by the methods of physical mixing, conventional wetness impregnation and ultrasonication-assistant impregnation. The catalysts were characterized by XRD, UV-Vis DRS, Raman, TPR, ESR and TPSR techniques and the nature of the vanadium species were correlated to their catalytic performance in the reaction of direct conversion of methane to formaldehyde. It is concluded that highly dispersed monomeric and low oligomeric vanadia species are formed on the sample prepared with both traditional wetness impregnation method and ultrasonication-assistant impregnation, whereas in the latter case, the amount of oligomeric vanadia species is much smaller. The V2O5 microcrystallines are the dominant species on the material prepared by physical mixing method. During the selective oxidation of methane, Vv species are reduced to V^IV paramagnetic species and both microcrystalline V205 species and oligomeric vanadia species are found to further disperse and transform into tetrahedral vanadia species. Based on the results of UV Raman spectroscopy and TPSR, C02 is suggested to be formed via two different routes, in which one is from the sequence reaction of CH4→ HCHO→ CO → CO2 over monomeric vanadia species, and the other is from the direct oxidation of methane to CO2 over oligomeric vanadia species. Oligomeric vanadia species is more active than monomeric vanadia species for methane activation.     

Oxidative Coupling of Methane over Lithium Doped （Mn＋W）/SiO2 Catalysts

Modification and performance of Li induced silica phase transition of (Mn W)/SiO2 catalyst, under reaction conditions of oxidative coupling of methane (OCM), have been investigated employing textural characterizations and redox studies. Stability and precrystalline form of fresh Li induced silica phase transition catalyst depend on the Li loading. A catalyst, with high lithium loading, destabilizes on OCM stream. This destabilization is not due to Li evaporation at OCM reaction conditions.α-cristobalite is proposed to be an intermediate in the crystallization of amorphous silica into quartz in the Li-induced silica phase transition process. However, the type of crystalline structure was found to be unimportant with regard to the formation of a selective catalyst. Metal-metal interactions of Li-Mn, Li-W and Mn-W, which are affected during silica phase crystallization, are found to be critical parameters of the trimetallic catalyst and were studied by TPR. Role of lithium in Li doped (Mn W)/SiO2 catalyst is described as a moderator of the Mn-W interaction by involving W in silica phase transition. These interactions help in the improvement of transition metal redox properties, especially that of Mn, in favor of OCM selectivity.     

Na-W-Mn/SiO2催化剂表面甲烷脉冲反应Ⅱ. 多组分Na、 W、 Mn/SiO2催化剂

制备了多组分Na,W,Mn/SiO2催化剂，在ITD（Ion Trap Detector)装置上进行了催化剂表面晶格氧脱附前后的甲烷恒温脉冲反应（CH4－CTPR）。研究结果表明，Na-W/SiO2催化剂表面晶格氧，具有较高的CH4转化率和C2烃选择性，并对C2H6的生成起着重要的作用，Na-Mn/SiO2催化剂表面晶格氧，也具有较高的CH4转化率和C2烃选择性，但对C2H6的形成有一定的诱导期；W－Mn/SiO2催化剂表面晶格氧，对CH4的转化和CO2的生成具有很高初活性，但对C2烃的选择性较低；Na-W-Mn/SiO2催化剂表面晶格氧，具有很高的CH4转化率和C2烃定向选择性，这是由于Na,W,Mn各组分协同作用的结果。     

Na—W—Mn／SiO2催化剂体系中W和Mn对甲烷氧化偶联反应的作用

制备了一系列不同Ｗ,Ｍｎ含量的Ｎａ－Ｗ－Ｍｎ／ＳｉＯ２催化剂,并进行了其催化甲烷氧化偶联反应性能评价和ＸＰＳ,ＸＲＤ表征,研究结果表明,Ｗ和Ｍｎ的含量分别为２．２％≤Ｗ≤８．９％和０．５％≤Ｍｎ≤３％时,催化剂具有较好的甲烷氧化偶联反应性能。Ｍｎ的表面浓度与甲烷的转化率和乙烯的选择性有较好的对应关系,Ｗ的表面浓度与乙烷的选择性有一定有关系,据此提出Ｎａ－Ｏ－Ｍｎ和Ｎａ－Ｏ－Ｗ都是甲烷氧化偶联反应的     

Catalytic Performance of CeO2／ZnO Nanocatalysts on the Oxidative Coupling of Methane with Carbon Dioxide and their Fractal Features

CeO2/ZnO nanocatalysts were prepared from the coupling route of homogeneous precipitation with microemulsion and the impregnation method. The catalytic performance of these two kinds of catalysts on the oxidative coupling of methane with carbon dioxide was tested and compared; the fractal behavior of the nanocatalysts was analyzed using fractal theory. The CeO2/ZnO nanocatalysts had much higher activity than the catalysts prepared by impregnation method. There was no regular relationship between the average size of CeO2/ZnO nanocatalysts and their catalytic performance; however, the conversion of methane increased with the increase of the fractal dimension of CeO2/ZnO nanocatalysts.     

对甲烷氧化偶联W—Mn／SiO2催化剂Na2WO4的流失及其影响的考察

用ＸＲＤ，ＦＴ－ＩＲ，ＥＳＲ，Ｈ２－ＴＰＲ和ＴＯＰ等方法，对Ｎａ２ＷＯ４Ｍｎ２Ｏ３／ＳｉＯ２催化剂和其经水煮处理的一系列样品进行一表征。实验发现该催化剂中的结晶态ＮａＷＯ４易于流失，单层分布的Ｎａ２ＷＯ４在苛刻的处理条件下也有可能流失。     

CeO2-W-Mn/SiO2催化剂上甲烷氧化偶联反应性能的研究

报道了CeO_2-W-Mn/SiO_2催化剂常压和加压条件下的甲烷氧化偶联反应性能, 详细考察了反应条件对CeO_2-W-Mn/SiO_2催化剂反应性能的影响. 结果表明, CeO_2-W-Mn/SiO_2催化剂具有优异的催化活性, 常压下可得到29.7%的甲烷转化率和81.3%的C_2烃选择性, 低温活性高, 于710 ℃可得到甲烷转化率11.4%和C_2烃选择性86.7%的结果;该催化剂适宜于加压条件下的甲烷氧化偶联反应, 0.6 MPa下可获得37.2%的甲烷转化率和73.8%的C_2烃选择性. 催化剂表征结果显示CeO_2的加入增强了W-Mn/SiO_2催化剂的储氧能力.     

甲烷氧化偶联Na2WO4-Mn/SiO2催化剂热效应的研究

采用固定床微型反应装置,研究了甲烷氧化偶联反应过程中Na2WO4-Mn/S iO2催化剂床层的热效应和催化性能的关系,考察了反应炉温、CH4/O2比和反应气体空速对催化剂床层热点分布的影响.研究结果表明,甲烷氧化偶联催化剂床层的热效应强烈依赖于反应条件.反应炉温越高,CH4/O2比越低,反应气体空速越大,催化剂床层的热点温度越高.结合催化性能和热效应关系的研究,为优化甲烷氧化偶联的反应操作提供了实验依据.     

Effects of operating parameters on oxidative coupling of methane over Na-W-Mn/SiO2 catalyst at elevated pressures

The effects of operating parameters on oxidative coupling of methane (OCM) over Na-W-Mn/SiO2 catalyst have been studied at elevated pressures of 0.2, 0.3 and 0.4 MPa under low gaseous hourly space velocity (GHSV) and low temperature conditions. Experimental results show that when the operating pressure is increased, C2+ yield slightly decreases, while the maximum ratio of ethylene to ethane remains unchanged. Moreover, it has been found empirically that increase of pressure does not affect the catalyst behavior permanently, the catalyst recovers its original low pressure performance without hysteresis behavior by reducing the pressure. Under the investigated conditions, when oxygen is completely consumed, the increase of GHSV leads to improvement in C2 selectivity, while C3+ and COx selectivities decrease slightly. The C2+ selectivity increases by increase of nitrogen diluent in the feed, but the C3+ hydrocarbons selectivities decrease with increase of nitrogen since it is possible that further dilution at high pressure may reduce the probability of collision between CH3 and C2+ hydrocarbons. During the stability test at high pressure, the catalyst performance remains unchanged throughout the 20 h running. The fresh and used catalysts were characterized using XRD, SEM and N2 adsorption-desorption methods. It was found that the phase transformation of the support from α-cristobalite to tridymite and quartz does not have obvious effect on catalyst performance at high pressure.     

W－Mn／SiO_2催化剂甲烷氧化偶联制乙烯流化床工艺条件考察

本文报导了浸渍法制备的Ｗ－Ｍｎ／ＳｉＯ_２催化剂分别在Φ２８和Φ３８毫米反吹式流化床上进行的条件试验和３００ｈ稳定性试验结果。并用ＸＲＤ、ＦＴ－ＩＲ、ＢＥＴ等方法对催化剂进行了表征。结果表明，该催化剂可适用于流化床，并具有较好的ＣＨ４氧化偶联制Ｃ２烃的催化活性和稳定性。催化剂的结构研究表明，经３００ｈ反应后，该催化剂中结晶形式的Ｎａ_２ＷＯ_４和Ｍｎ_２Ｏ_３均已消失；α－方石英结构已完全转变为α－磷石英和α－ＳｉＯ_２石英，但催化剂的这种结构变化尚未对生成Ｃ２烃的收率和选择性产生明显影响。     

Scale up and stability test for oxidative coupling of methane over Na2WO4-Mn/SiO2 catalyst in a 200 ml fixed-bed reactor

The study of scale up for the oxidative coupling of methane （OCM） has been carried out in a 200 ml stainless steel fixed-bed reactor over a 5wt% Na2WO4-1.9wt% Mn/SiO2 （W-Mn/SiO2） catalyst. The effects of reaction conditions were investigated in detail. The results showed that, with increasing reaction temperature, the gas-phase reaction was enhanced and a significant amount of methane was converted into COx; with the CH4/O2 molar ratio of 5, the highest C2 （ethylene and ethane） yield of 25% was achieved; the presence of steam （as diluent） had a positive effect on the C2 selectivity and yield. Under lower methane gaseous hourly space velocity （GHSV）, higher selectivity and yield of C2 were obtained as the result of the decrease of released heat energy. In 100 h reaction time, the C2 selectivity of 66%-61% and C2 yield of 24.2%-25.4% were achieved by a single pass without any significant loss in catalytic performance.     

甲烷在W-Mn体系催化剂上氧化偶联制乙烯

本文报导了w-Mn体系催化剂的甲烷氧化偶联反应性能,详细考察了反应条件对1.9wt％Mn—5wt％Na_2WO_4/SiO_2(W—34)催化剂反应性能的影响,并用XRD、BET、EPR、UV-DRS等方法对该催化剂进行了表征。结果表明,该催化剂具有较好的甲烷氧化偶联反应性能,在T=800C,甲烷空速=36,000ml·g~(-1)·h~(-1),CH_4:O_2:N_2=3:1:2.6的最佳实验条件下,其甲烷转化率为36.8％,C_2烃收率达到23.9％;研究还表明,C_2H_6,CO_2是CH_1氧化的一次产物,C_2H_4主要由C_2H_6脱氢而来,而CO则可能主要来源于C_2烃的表面深度氧化,催化剂的结构研究表明,在该催化剂中,w是以Na_2WO_4形式存在,Mn则以Mn_2O_3形式存在,而SiO_2已由无定型结构转变成u-方石英;W、Mn、Si之间没有形成新的化合物。     

等离子体条件Cu/SiO2对甲烷偶联的催化作用

It has been reported that methane coupling by plasma techniques with catalysts, such as direct current corona discharge with a Sr/La2O3 catalyst[1], dielectric-barrier discharge with zeolites[2] and pulsed corona discharge with metal oxide catalysts[3], give C2 hydrocarbons under atmospheric pressure. But acetylene predominates over other C2 hydrocarbons in the products. Our recent work reported that good results can be obtained for methane coupling under a pulsed corona plasma in the presence of hydrogen[4]. The addition of hydrogen improves the conversion of methane and the yield of C2 hydrocarbons. A methane conversion of 57.1% and a yield of C2 hydrocarbons of 43.4% were obtained at lower power, but acetylene was inevitably the main product. With the introduction of a Ni/γ-Al2O3 catalyst prepared by a cold plasma into the plasma reaction, the distribution of C2 hydrocarbons changed, and the content of C2H4 was 66.1%[5].     

硫酸钠对Mn/SiO2催化剂结构及其甲烷氧化偶联反应性能的影响

 采用等体积浸渍法制备了Na2SO4改性的Mn/SiO2催化剂,考察了Mn-Na2SO4/SiO2催化剂中各组分对甲烷氧化偶联合成C2产物(C2H4+C2H6)的影响,并采用X射线衍射、 X射线光电子能谱、 Raman光谱和程序升温还原等手段表征了催化剂中的物相结构、表面组分价态与含量以及氧化还原性能. 结果表明,在Mn/SiO2催化剂中添加Na2SO4可使载体SiO2由无定形转变为α-方石英相,使催化剂表面的Mn物种由Mn3O4转变为Mn2O3, 从而大大提高了甲烷转化率和目标产物C2的选择性. 因此,推测Mn2O3物种在反应条件下构成了甲烷氧化偶联反应的活性中心.     

氧化镧催化剂上的低温甲烷氧化偶联反应

 采用沉淀法制备了氧化镧催化剂,并考察其催化低温甲烷氧化偶联反应的性能. 催化剂性能测试结果表明,在723 K, CH4/O2摩尔比=3和GHSV=7500 ml/(g·h)的条件下,甲烷的转化率和C2的选择性分别达26.6%和40.8%, 比商品化氧化镧催化剂的启动温度低100 K. 催化剂的表征结果表明,沉淀法制备的氧化镧催化剂与商品化的氧化镧催化剂都为六方晶相的氧化镧,但前者具有较大的比表面积,并且在598 K处出现一个明显的O2脱附峰.     

Na-W-Mn/SiO2催化剂中的金属-载体作用

研究了Na-W-Mn/SiO₂催化剂中不同活性组份对载体结构的影响.结果表明,Na的诱导作用使无定型氧化硅在焙烧过程中相变为α-方石英结构,同时伴有比表面积的大幅度下降;单独担载Na时,硅小球经焙烧后基本无微孔存在,担载W则能使硅小球焙烧后形成较为均一的微米孔道.SiO₂载体在Na和W作用下发生的结构变化对催化剂的选择性起重要作用.