Fe-Zn-Zr/分子筛复合催化剂上CO2加氢合成异构烷烃Ⅰ.不同分子筛对催化剂性能的影响

 在Fe-Zn-Zr/分子筛复合催化剂上考察了不同类型的分子筛对CO2加氢反应性能的影响. 结果表明,不同分子筛对复合催化剂性能的影响不同,Fe-Zn-Zr/HY是合成异构烷烃有效的复合催化剂. 分子筛的酸性及酸强度对复合催化剂性能有较大的影响,中等强度和较高强度的酸性位有利于异构烃的生成.     

微孔/微介孔H-ZSM-5分子筛上甲苯甲醇的烷基化性能

以不同硅铝比的H-ZSM-5分子筛为研究对象,考察了Na OH碱处理、酒石酸处理及Na OH碱处理-酒石酸处理相结合的方法对其物化性能和催化性能的影响.处理前后分子筛的表征结果表明,酸处理和碱处理可通过调变催化剂的酸性和孔道结构影响其催化性能.酸处理对低硅铝比H-ZSM-5的酸性和催化性能影响较大,而碱处理则主要影响高硅铝比分子筛的酸性和催化性能.酸处理和碱处理相结合则能同时调变分子筛的酸性和孔道结构,进而提高其在甲苯甲醇制二甲苯反应中的催化活性.其中,碱处理的高硅铝比H-ZSM-5分子筛表现出最优异的催化活性.     

含锆ZSM-5分子筛上丙烯齐聚反应的研究

以正丁胺(NBA)为模板剂，通过水热法直接合成了Zr/ZSM-5分子筛。XRD分析表明Zr/ZSM-5分子筛结晶度良好，但衍射峰的强度稍有差别。SEM显示样品分子筛表面规整，为3 μm～5 μm的棒状晶体。采用NH3-TPD法对分子筛进行了酸性测试，结果表明，在锆质量分数0.2%～1.2%，分子筛的中强酸和强酸量随锆质量分数的增加而增大，并向高温方向偏移。丙烯齐聚催化反应的活性评价结果显示，中强酸和强酸的量对Zr/HZSM-5催化性能有显著影响，在反应过程中对链的增长起促进作用。     

沸石分子筛催化苯甲醚与苯甲酰氯的苯甲酰化反应

分别采用五种H型沸石在无溶剂条件下催化了苯甲醚与苯甲酰氯的苯甲酰化合成4-甲氧基二苯甲酮.各种沸石的酸中心分布和孔道结构各不相同,使其表现出不同的催化效果.Hβ沸石的三维孔道和集中的中强酸中心为反应提供了适宜的条件,使苯甲酰氯的转化率和4-甲氧基二苯甲酮的选择性分别可达99.5%和91.2%.Pyrid ine-FT-IR结果表明B酸中心为H型沸石主要酸中心,H+为催化活性点;NH3-TPD谱图表明中强酸中心是苯甲酰化反应的合适酸中心,据此提出了H型沸石催化苯甲醚苯甲酰基化的反应机理.     

Alkylation of Ethylbenzene with Methanol on HY,HM and HZSM-5 Zeolite

The alkylation of ethylbenzene with methanol on various zeolites has been studied at atmospheric pressure, 300–500 °C and with ethylbenzene/methanol = 3 mol/mol in a fixed-bed, integral-flow reactor. The catalytic activity decreased in the order HZSM-5 > HY > HM. The optimum conditions for the formation of ethyltoluene were HY zeolite, 400 °C and W/F = 4.1 g-cat h/g-feed. The catalyst decay rate increased in the order HZSM-5 << HY < HM; coking of the zeolite increased the fraction of para-isomer in the ethyltoluenes. On HZSM-5 modified with alkaline earth metal, the conversion of ethylbenzene decreased with concomitantly increased selectivity of para-ethyltoluene especially evident in cases of magnesium and calcium (> 93% para-selectivity). These results are interpreted in terms of diminution of both the strong acid sites and the pore size of zeolites. For the reaction on HY at 400 °C, the reaction paths were determined; the ethylbenzene reacted via alkylation, disproportionation and dealkylation with initial selectivities 84.7%, 13.1% and 2.2%, respectively.     

Synthesis of adamantane on zeolite catalysts

The synthesis of adamantane from tetrahydrodicyclopentadiene on zeolites with different framework structures was studied. The adamantane yield on HY zeolites is higher than on HM and HZSM-5 zeolites. Among various types of dealuminated HY zeolites the HEY and HUSY zeolites give higher adamantane yields than conventional HY zeolite. The changes in activity and selectivity of the main and side reactions are correlated with the acidity and the pore structure of the zeolites. To ion-exchange the HY and HUSY zeolites with Ni2+ and La3+ cations may further improve the activity and selectivity of the zeolite catalysts.     

ZnCl2/NaY催化邻苯二酚与甲醇醚化反应

ZnCl2/NaY催化邻苯二酚与甲醇醚化反应;固体酸催化剂;愈创木酚     

C2-C2直链烯烃在HY 和H-ZSM-5分子筛上的吸附

采用ONIOM(B3LYP/6-311++G(d,p):UFF)分层计算方法, 研究了C₂-C₅直链烯烃在HY 和H-ZSM-5 分 子筛上的吸附性质. 理论计算结果表明: 烯烃与分子筛的Br?nsted 酸性位相互作用形成π配位超分子复合物; 随着碳链的增长, 烯烃的吸附能增加, 增加量近似为一个常数(HY 分子筛: 约12 kJ·mol^-1; H-ZSM-5 分子筛: 约 25 kJ·mol^-1), 与烷烃在分子筛上的吸附具有相同的规律. 双键位置对烯烃的吸附能影响很大, 2位烯烃的吸附能 要远大于1 位烯烃的吸附能. 不同类型分子筛对烯烃的吸附性能也有很大差别, 由于局域效应的影响, 小孔径 H-ZSM-5分子筛上的吸附能大于大孔径的HY分子筛,而且碳链越长,这种差别越大.从微观结构上看,吸附的烯 烃与H-ZSM-5分子筛酸性位的距离要远大于它们与HY分子筛酸性位的距离, 这是由于不同类型分子筛的微孔 结构产生的范德华作用是不同的,这种作用随着孔径的减小而增强.前线轨道分析表明, 对于小分子烯烃,大孔径 HY分子筛对其催化活性相近,而小孔径H-ZSM-5分子筛随着烯烃碳原子数的增加催化活性有减弱的趋势.     

不同分子筛上1-己烯骨架异构化反应性能的研究

以HZSM-35、HZSM-5、HM和Hβ四种分子筛为1-己烯骨架异构化催化剂,比较研究了四种催化剂的异构化性能,对其构效关系进行了关联。结果表明,相比于HZSM-5和Hβ分子筛,HZSM-35和HM具有适宜的酸量,有效孔径为0.4-0.6 nm,而且无晶穴、无交叉孔道,具有良好的择形催化效应,在转化率高达95%的同时,C_5-和C₇₊等副产物的收率在20%左右,异己烯收率可达40%-50%。进一步对四种分子筛进行酸碱改性处理,结果显示,虽然酸性质略有改变,但是一维孔结构的HZSM-35和HM分子筛的异构化性能仍明显优于多维孔结构的HZSM-5和Hβ分子筛,说明在酸性质一定的前提下,孔结构对异构化反应起关键作用。     

复合分子筛催化微晶纤维素水解

采用水热晶化法制备了HY/ZSM-5复合分子筛。通过XRD、SEM、N2-吸附脱附、NH3-TPD及吡啶吸附红外光谱等手段表征催化剂的结构和性质。结果表明,HY与HZSM-5复合后HY型分子筛完全被HZSM-5紧密包裹,形成致密的核壳结构。与机械混合物相比,复合分子筛微孔比表面积及孔体积均有所减少,总酸量略高,弱酸量小,而强酸量大,Br9nsted酸量与之相似,而Lewis酸量有所减少。将所制备的HY/ZSM-5复合分子筛催化剂应用于以离子液体氯化1-乙基-3-甲基咪唑鎓([Emim]Cl)为溶剂的纤维素水解反应中,与HY催化的纤维素水解相比,HY/ZSM-5催化纤维素水解反应获得的最佳葡萄糖收率由28.04%提高到38.78%,葡萄糖选择性由28.91%提高至48.29%。     

Optimization for catalytic performances of Hβ zeolite in the acylation of 2-methylfuran by surface modification and solvents effect

The liquid phase acylation of 2-methylfuran with acetic anhydride over modified Hβ zeolite was first conducted in a continuous flow reactor. The deactivation of Hβ zeolites was attributed to strong adsorption of reactants or products and was verified by GC–MS and ¹³C MAS NMR. Deactivated zeolites can be regenerated to their original state by calcination. The acidic properties was adjusted by surface modification on Hβ, the maximum yield of 89.5 mol% and selectivity of 100 % were obtained over tartaric acid modified by Hβ. The deposition of tetraethoxysilane to silica on Hβ contributed to enhancing the catalytic stability. Combined with the results of NH₃-TPD and Py-FTIR, the amount of Broensted acids played a major role on catalytic activity. A close relationship between the catalytic stability and the ratio of the amount of strong to weak acids at 1:1 was highlighted here. The solvents' effect on the catalytic performances was examined, and 1,2-dichloroethane with moderate polarity exerted a positive effect on catalytic stability.     

Pd/Hβ-zeolite catalysts for catalytic combustion of toluene: Effect of SiO2/Al2O3 ratio

The effect of pure and high silica Hβ zeolites on the catalytic performance of toluene combustion over Pd/H/3 catalyst was evaluated.Pure and high silica β zeolites were prepared by direct synthesis procedures,then 0.1 wt% of palladium was impregnated on different Hβ zeolites via incipient wetness technique using palladium nitrate as the Pd source.The Pd/Hβ catalysts were characterized by XRD,N2 adsorption/desorption,H2O adsorption,NH3-TPD,H2-TPR and XPS techniques.With increasing the SIO2/Al2O3 ratio of β zeolite,the activity of the Pd/Hβ catalysts for toluene combustion increased clearly and the pure silica β zeolite supported Pd catalyst showed the best catalytic activity.The superior catalytic performance of Pd/β catalyst prepared from pure silica β zeolite was attributed to its high hydrophobicity and the preserving ability for PdO active species.     

掺杂Fe作为第二种金属组分的V-HMS催化剂的苯羟基化反应

采用浸渍法在V-HMS中引入第二种金属组分(Fe、Al、Cu、Ni、Co、Mo、Cr)以提高催化剂在H2O2为氧化剂的苯羟基化反应中的催化性能.筛选发现,Fe在所研究的金属组分中最为有效.进一步采用共合成法制备了一系列FexVy-HMS催化剂.采用粉末X射线衍射、N2物理吸附、透射电子显微镜、NH3程序升温脱附、H2程序升温还原等手段对催化剂的结构和性质进行表征,结果表明,HMS仍保持介孔结构,Fe的加入在催化剂中产生了新的酸性位和更强的氧化还原性.在苯羟基化反应中,钒物种是反应活性物种,铁物种起助剂作用,其中Fe0.04V0.06-HMS具有最高的催化活性,苯酚收率由不含Fe的Fe0.00V0.06-HMS的13.1%提高到18.1%.提出了Fe、V参与反应过程的可能机理.     

笼状烃金刚烷的新合成方法

笼状烃金刚烷的新合成方法米镇涛郭建维邱立勤（天津大学化工学院天津３０００７２）关键词金刚烷，沸石，催化异构金刚烷（三环［３．３．１．１［３，７］癸烷）是一种周正对称、非常稳定的笼状烃，是由１０个碳原子和１６个氢原子构成的环状四面体碳氢化合物，基本骨...     

四氢呋喃聚合介孔催化剂Zr-PHTS合成、表征及反应性能

在水-有机溶剂复合体系中,以P123为结构导向剂水热直接合成了锆掺杂介孔固体酸催化剂(Zr-PHTS),运用XRD、TEM、N2吸附-脱附以及NH3-TPD、Py-FTIR等手段对催化剂进行了表征.结果表明,在硅锆摩尔比20-100考察范围内,所得Zr-PHTS样品均显示有序二维六方晶相结构,具有以L酸为主的中等强度的酸性中心;随着锆引入量的变化Zr-PHTS的比表面积仅显示少量的变化,孔径维持在9.8 nm;在四氢呋喃聚合反应中Zr-PHTS显示出较好的催化活性,硅锆摩尔比30的样品表现出最佳的催化性能,聚合物收率达到40.4%,数均分子量2 135,推测催化剂表面酸性和孔结构决定了催化剂对四氢呋喃的聚合性能.     

酸化膨润土催化合成乙基叔丁基醚的研究

以不同浓度的H2SO4对膨润土进行改性,得到酸化膨润土催化剂x%H2SO4-BN(x=20,25,30,35,40),通过XRD,BET,FT-IR,Py-IR和NH3-TPD对膨润土的结构和性质进行表征,证明膨润土经酸化后,骨架结构基本没有变化,但是其比表面和孔容有很大的提高,且弱酸位增多.将其用于催化乙醇(EtOH)和叔丁醇(TBA)合成乙基叔丁基醚(ETBE)的醚化反应.结果表明,30%H2SO4-BN催化活性最好,最佳实验条件:催化剂用量为3.5%(催化剂与叔丁醇的质量百分比),反应温度130℃,原料摩尔比(EtOH:TBA)为2∶1.     

Production of dimethylether(DME) as a clean fuel using sonochemically prepared CuO and /or ZnO- modified γ- alumina catalysts

The catalytic conversion of methanol to dimethylether(DME)was studied over CuO/Al2O3,ZnO/Al2O3and ZnOCuO/Al2O3nanocatalysts prepared in presence or absence of ultrasonic irradiation.The catalysts were characterized by X-ray diffraction(XRD),surface characterization method(BET),scanning electron microscope(SEM),H2-temperature programmed reduction(H2-TPR)and temperature programmed desorption of ammonia(NH3-TPD).The experimental results show that during catalytic dehydration of methanol to dimethylether,the activities of the CuO/Al2O3,ZnO/Al2O3and ZnO-CuO/Al2O3catalysts prepared using ultrasonic treatment are much higher than those prepared in absence of ultrasonication.SEM shows that the use of ultrasonication results in much smaller nanoparticles.BET and XRD show that the ultrasonication increases the surface area and pore volume of the catalysts.H2-TPR profiles indicated that reducibility of the sonicated nanocatalysts is carried out at lower temperatures.NH3-TPD shows that ultrasound irradiation has enhanced the acidity of the nanocatalyst and hence enhanced catalytic performance for DME formation.     

ZSM-5酸改性对甲醇芳构化性能的影响

利用硝酸、草酸和酒石酸溶液对ZSM-5分子筛进行改性,并采用XRD、SEM、NH₃-TPD、XRF、²⁷Al MAS NMR、吡啶吸附红外光谱和N₂吸附-脱附对ZSM-5分子筛结构、酸量、比表面积及孔体积等物化性质进行表征分析。在反应温度为422℃,甲醇质量空速为4.74 h^-1的条件下,考察了ZSM-5分子筛的催化活性。结果表明,采用不同酸改性ZSM-5分子筛,影响了分子筛的比表面积、酸性及孔体积,从而改变了催化剂的催化性能。在甲醇芳构化（MTA）反应中,酸改性后的分子筛表现出良好的催化活性,且草酸改性后的催化剂表现出较高的催化活性及选择性,反应8 h时,芳烃及BTX收率分别达到57.40%和39.40%。     

Y沸石的酸性

用^29Si MAS NMR(MAS为Magie Angle Spinning), 统计计算,NH3-TPD 等方法对(NH4)2·SiF6去铝补硅得到的高硅Y型沸石的酸位分布情况进行了研究, 并与典型酸催化反应数据相关联, 证实了Y型沸石的酸位强度取决于A1原子的周围环境, 即与次邻位A1原子数目n-NNN(NNN为Next Nearst Neighbor)有关, 沸石的强酸性来自次邻位无A1原子的AIO^-4四面体。 NH3-TPD法测量的沸石酸量和酸强度数据与^29Si MAS NMR 实验结果和统计计算得到的不同n-NNN A1位的分布是一致的。 随着A1含量减少, Y型沸石表面的总酸量是单调下降的。但强酸量却是先增加后下降, 在A1/(A1+Si)为0.15左右出现极大值。不同硅铝比的Y型沸石对典型的强酸性和弱酸性催化反应的活性变化规律亦与酸性相吻合。     

含氮FAU分子筛的制备、表征及碱催化反应性能

利用脱水氮化法制备了含氮HY分子筛,氮化后分子筛的结晶度和比表面积均得到较好保持.由于氮原子的电负性低于氧原子,氮原子取代氧原子进入HY分子筛的骨架,使其Lewis碱性得到增强.利用氨气吸附红外光谱、二氧化碳吸附红外光谱与二氧化碳程序升温脱附方法对氮化前后的分子筛进行表征.结果表明氮化后HY分子筛的L酸中心数量有所降低,B酸中心数量有所增加,同时生成新的碱性中心.由于新碱性中心的引入,含氮HY分子筛在Knoevenagel缩合碱性探针反应中表现出优异的活性.