Dy(Fe0.8Al0.2)2单晶体的宏观量子效应

测量了Dy(Fe_0.8Al_0.2)₂单晶体在[100],[110]和[111]方向上的退磁曲线、内禀矫顽力和磁黏滞性系数随温度的变化.认为退磁曲线出现台阶和大跳跃、内禀矫顽力随温度变化存在峰值、磁黏滞性系数与温度无关等都是畴壁隧穿能垒的宏观量子效应的反映.实验上得出由经典热激活到量子隧穿的交界温度约为5.5K. 关键词：     

MAGNETIC VISCOSITY AND DEMAGNETIZATION BEHAVIOUR IN ISOTROPIC NANOCRYSTALLINE Pr12Fe82B6 RIBBONS

We present the experimental results of the magnetic viscosity, demagnetization curve and recoil loop for isotropic nanocrystalline Pr₁₂Fe₈₂B₆ ribbons prepared by melt-spinning. The thermal fluctuation field, activation volume and irreversible demagnetization are discussed. The coercivity mechanism is mainly determined by the inhomogeneous nucleation rather than a simple nucleation of reverse domain.     

Magnetic microstructures of a high coercivity Nd-Fe-B sintered magnet in remanent and incomplete thermal demagnetization states

Magnetic microstructures of a high coercivity Nd-Fe-B sintered magnet in remanent and incomplete thermal demagnetization states have been revealed by using magnetic force microscopy (MFM) with high coercivity tips. MFM results indicate that specimens in a remanent state are single domain and their magnetizations align with the direction of the magnetizing field. The evolution of the magnetic domains with annealing temperatures shows that the thermal demagnetization process consists of four stages. Nd-Fe-B should be heat-treated at about 120-170 °C to make its magnetic state stable before practical applications.     

Influence of Al and Ni on the magnetic properties of Finemet alloys

Crystallization behavior and soft magnetic properties of the FeSiBCuNbM (M=Al or Ni) Finemet alloys are investigated by X-ray diffraction, differential scanning calorimetry, hysteresis loop tracer, and vibrating sample magnetometry. The nanocrystalline alloys are prepared by annealing melt-spun amorphous ribbons at different temperatures. Results indicate that the partial substitution of Ni or Al for Nb results in the increase of saturation magnetic induction density (B_s) of the alloys. The alloys with Al or Ni show favorable combination of soft magnetic properties. The partial substitution of Ni for Nb enhances the B_s value, while Al decreases coercivity. The mechanism underlining the magnetic behavior is discussed.     

纳米复合永磁材料中软磁性相交换硬化的研究

本文就纳米复合永磁材料中软磁相被交换硬化问题,从一维模型和三维模拟计算进行了分析研究. 一维和三维各向异性样品研究表明,在相同微结构下,当硬磁相的各向异性降低时,除矫顽力降低外,在磁矩全部反转之前退磁曲线是一样的. 因此,硬磁相各向异性的降低不会导致最大磁能积(BH)_max增大和剩磁增加. 对于三维各向同性样品的模拟计算表明,降低硬磁相的各向异性会使剩磁和(BH)_max都明显降低. 因此,增强硬磁相的各向异性并增大硬磁相晶粒尺寸是提高 关键词： 纳米复合永磁 矫顽力 剩磁 磁能积     

Nb含量对烧结NbFeB永磁体磁性能及显微结构的影响

关键词：     

Simulation of magnetization behaviours of Sm（Co,Fe,Cu,Zr）z magnet with low Cu content

The effects of microstructure, cell orientation and temperature on magnetic properties and the coercivity mechanism in Sm(Co,Fe,Cu,Zr)z with low Cu content are studied by using the micromagnetic finite element method in this paper. The simulations of the demagnetization behaviours indicate that the pinning effect weakens gradually with the thickness of cell boundary decreasing and strengthens gradually with the cell size decreasing. Because of the intergrain exchange coupling, the coercivity mechanism is determined by the difference in magnetocrystalline anisotropy between the cell phase and the cell boundary phase. And the coercivity mechanism is related to not only the cells alignment but also temperature. With temperature increasing, a transformation of the demagnetization mechanism occurs from the domain pinning to the uniform magnetization reversal mode and the transformation temperature is about 650~K.     

纳米晶永磁Pr2Fe14B微磁学有限元法的模拟计算研究

根据实验数据，构造了接近实际纳米晶永磁Pr2Fe14B的样品，用微磁学有限元法进行了模拟计算.计算结果表明，晶界处各向异性的下降会导致矫顽力减小、剩磁值增大，而晶界处交换作用常数的减小则会使剩磁值减小、矫顽力增大.通过对实验样品的模拟研究发现，晶界处各向异性和交换作用常数的共同减小能够同时拟合出真实的矫顽力和剩磁值.模拟计算与实验在退磁曲线形状上的差距则说明模拟还存在不足. 关键词： 纳米晶永磁 磁滞回线 矫顽力 剩磁     

烧结Nd-Fe-B永磁合金矫顽力机制的理论与实验研究

从理论和实验上研究了烧结Ｎｄ－Ｆｅ－Ｂ永磁合金的矫顽力随取向磁场的变化规律。指出磁体反磁化过程主要是晶粒边界软磁性区的反磁化成核以及反磁化核长大成畴并向晶粒内部不可逆畴壁位移的过程。比较了成核场与退钉扎场的大小及其随磁场方向的变化，并得出结论：退钉扎场是决定烧结Ｎｄ－Ｆｅ－Ｂ磁体矫顽力的主要机制。 关键词：     

快淬Nd3.6Pr5.4Fe83Co3B5薄带的反磁化行为和磁黏滞性

用电弧熔炼法制备了Nd_3.6Pr_5.4Fe₈₃Co₃B₅合金铸锭,然后利用熔旋快淬法在铜辊转速V=20m/s下制备了Nd_3.6Pr_5.4Fe₈₃Co₃B₅薄带.快淬带主要由软磁相α-Fe和Nd₂Fe₁₄B型的硬磁相组成.采用直流退磁剩磁曲线方法分析了样品在反磁化过程中的可逆与不可逆磁化部分,并研究了软磁相和硬磁相的反磁化行为,得到样品的不可逆磁化形核场H_no约为440kA/m.同时研究了样品的磁黏滞性,结果表明由于软磁相的存在使得热激活体积较大. 关键词：     

纳米晶复合永磁材料的交换耦合相互作用和磁性能

本文介绍了纳米磁性材料晶粒交换耦合相互作用的有关理论。采用不同模型讨论了晶粒交换耦合相互作用对纳米单相软磁材料、永磁材料及双相复合永磁材料磁性能的影响。简述了用δM(H)曲线和不可逆磁导率的变化研究晶粒交换耦合相互作用及反磁化过程的方法。讨论了合金成分配比、添加元素、制备及热处理工艺对磁体硬磁性能的影响。从理论和实验两方面分析、研究了纳米复合永磁材料的反磁化过程和矫顽力机制。     

纳米晶复合永磁材料的交换耦合相互作用和磁性能

本介绍了纳米磁性材料晶粒交换耦合相互作用的有关理论。采用不同模型讨论了晶粒交换耦合相互作用对纳米单相软磁材料、永磁材料及双相复合永磁材料磁性能的影响。简述了用δM（H）曲线和不可逆磁导率的变化研究晶粒交换耦合相互作用及反磁化过程的方法。讨论了合金分配比、添加元素、制备及热处理工艺对磁体硬磁性能的影响。从理论和实验两方面分析、研究了纳米复合永磁材料的反磁化过程和矫顽力机制。     

Dauermagnetwerkstoffe mit bindern

If one knows the diagram of demagnetization of the magnet in plastic binder and knows the packing density, the curve of demagnetization of the used magnetic powder can be plotted. This procedure may also be inverted. Using anisotropic magnets with binders, a technical sufficient orientation must be required for calculating the curve of demagnetization. By comparing calculated and measured values, defects of the base materials, grindet powder, granulate, molding process, or magnetic orientation may be become known and removed.     

Studies on the magnetic properties for single-phase nanocrystalline FePt magnets with different orientation degrees

The single-phase nanocrystalline FePt magnets composed of 343 irregular-shaped grains are built. The demagnetization curves are simulated by micromagnetic finite element method. The remanence, coercivity and maximum energy product of the magnets decrease with deteriorating grain alignment. The characteristics of variation of magnetic properties with the degree of orientation are closely related to the average grain size of nanocrystalline magnets. The contribution of intergrain exchange coupling (IGEC) to remanence enhancement is associated to the degree of orientation, and decreases with improved grain alignment. With decreasing grain size, coercivity increases for anisotropic nanocrystalline magnets, which is completely different from that of isotropic nanocrystalline magnets.     

取向烧结Nd-Fe-B永磁合金反磁化过程及矫顽力机理研究

本文对取向烧结Nd-Fe-B合金沿取向易轴饱和磁化后的反磁化过程分四个阶段进行了理论研究。结果表明,主相晶粒表面软磁性区成核及从表面向晶粒内部不可逆畴壁位移对Nd-Fe-B合金的矫顽力起决定性作用。矫顽力随温度升高而急速下降主要是由于热运动破坏了主相四方结构的完整性,从而使软磁性过渡区变厚所致。 关键词：     

High-coercivity nanocomposite permanent magnet based on Nd–Fe–B–Ti–C with Cr addition for high-temperature applications

We have investigated influences of various elements (Ti, Nb, Mo, Ta, Hf, W, V, Cr) on magnetic properties of Fe–B/Nd₂Fe₁₄B-based Nd–Fe–B–Ti–C nanocomposite magnets in order to obtain larger coercivity required for high-temperature applications. As a result, addition of Cr was found to be most effective among additive elements investigated to enhance coercivity. Thermal flux losses of high-coercivity (H_cJ=1609 kA/m) Nd–Fe–B–Ti–C–Cr nanocomposite magnet at 200 °C are less than 2%.     

Mössbauer study of intergranular phase in Nd 8 Fe86 − x Nb x B6(x = 0, 1, 2, 3) nanocomposite magnet

Nd₈Fe_86???x Nb _x B₆ (x = 0, 1, 2, 3) nanocomposite magnet has been studied by Mössbauer spectroscopy and nanostructure observation. It was found that intergranular phase formed between α-Fe and Nd₂Fe₁₄B phase in NdFeNbB alloys plays a significant role on the magnetic properties. By the addition of Nb into Nd₈Fe₈₆B₆ composition, coercivity was found to increase by 25% due to the grain refinement of both the soft and hard magnetic phases which was decreased from 50 nm of virgin Nd₈Fe₈₆B₆ to 25 nm in Nd₈Fe₈₅Nb₁B₆ alloys. The role of Nb addition was confirmed to stabilize the Nd₂Fe₁₄B lattice preventing from thermal vibration of the corresponding sites at where Fe atoms are substituted by Nb in the Nd₂Fe₁₄B lattice. The enhanced coercivity was originated from the exchange hardening of soft and amorphous phases surrounding the hard magnetic Nd₂Fe₁₄B crystal.     

应力对铁磁薄膜磁滞损耗和矫顽力的影响

改进了JA-SW混合模型, 使之能处理具有两种单轴各向异性的磁体. 数值研究了面内应力对铁磁薄膜磁滞损耗和矫顽力的影响. 结果表明, 磁滞损耗和矫顽力与应力强度和应力施加方向以及外场取向有关. 磁滞损耗或矫顽力随应力强度变化的关系曲线并不完全是单调增加的, 比如当外场与易轴方向平行时会出现弯曲. 另外, 应力会造成矫顽力随外场取向角关系曲线的峰值偏移. 结果与文献资料进行了广泛对比并对其差异进行了解释. 关键词： JA-SW混合模型 磁滞损耗 矫顽力 应力     

Influence of the demagnetizing factor on the magnetization of an ensemble of Stoner-Wohlfarth particles

The influence of the demagnetizing factor on the coercivity of a sample of oriented uniaxial Stoner-Wohlfarth particles is investigated in the approximation of a relaxation model with a self-consistent determination of the demagnetization field. The demagnetizing field is shown to change the particle magnetization reversal conditions and to reduce the blocking temperature and coercivity, for which, despite allowance for the demagnetizing field, the Neel-Brown relation holds. It is also shown that under the demagnetizing field, the internal magnetic field in which the particles are located is not stationary but varies with time concordantly with the time sweep of the temperature during magnetization in a constant external field after zero-field cooling (ZFC). Nonstationarity of the internal field in the ZFC regime causes the interval of transition temperatures of the ensemble particles from a blocked state to a state with equilibrium magnetization to increase.     

Sm(Co,Cu,Fe,Zr)z反磁化过程的微磁学分析

通过微磁学有限元方法研究了微结构对各向异性的Sm(Co,Cu,Fe,Zr)z磁性能的影响， 并 对不同温度下的退磁曲线进行了计算.计算结果表明，矫顽力随着2∶17相晶粒尺寸的增大 而增大，随1∶5晶界相厚度的增大而减小；通过减小晶界相厚度或增大晶粒尺寸可以有效提 高 磁能积.反磁化的物理机制主要为形核机制，主要表现为首先在晶界相形成反磁化核，随 着 磁场的增大反磁化核不断长大，最后导致整个磁体的磁化反转；而当温度升高时，晶界相逐 渐变成非磁性相，使得反磁化核难以形成，因此出现了反常的矫顽力温度依赖关系. 关键词： 微磁学 有限元 微结构 磁性能