同位素内标-液相色谱-串联质谱法同时测定粮食及其制品中的5种真菌毒素

建立了同位素内标-液相色谱-串联质谱快速测定粮食及其制品中玉米赤霉烯酮(ZON)、雪腐镰刀菌烯醇(NIV)、脱氧雪腐镰刀菌烯醇(DON)及其衍生物3-乙酰基脱氧雪腐镰刀菌烯醇(3-ACDON)和15-乙酰基脱氧雪腐镰刀菌烯醇(15-ACDON)5种真菌毒素的分析方法。以乙腈-水(84∶16,v/v)为提取液,采用多功能净化柱净化,同位素内标法定量。5种真菌毒素在各自的线性范围内线性关系良好,相关系数(r2)均大于0.99,检出限(LOD,S/N=3)为5~20μg/kg。大麦、小麦、燕麦、玉米等9种代表性粮食及其制品在3个不同添加水平下的加标回收率为84.2%~114.5%,相对标准偏差(RSD)为0.4%~9.9%(n=6)。该法操作简单,成本低,准确可靠,灵敏度高,可同时检测粮食及其制品中的5种真菌毒素。     

Simultaneous determination of aflatoxins, ochratoxin A and Fusarium toxins in maize by liquid chromatography/tandem mass spectrometry after multitoxin immunoaffinity cleanup

A liquid chromatography/tandem mass spectrometry method was developed for the simultaneous determination of aflatoxins (B(1), B(2), G(1), G(2)), ochratoxin A, fumonisins (B(1), B(2)), deoxynivalenol, zearalenone, T-2 and HT-2 toxins in maize. A double extraction approach, using a phosphate-buffered solution followed by methanol, was applied to achieve effective co-extraction of the 11 mycotoxins under investigation having quite different polarities and chemical structures. A new multitoxin immunoaffinity column containing antibodies for all these mycotoxins was used to clean up the extract. Detection and quantification of the 11 mycotoxins were performed by reversed-phase liquid chromatography coupled with electrospray ionization triple quadrupole mass spectrometry (LC/ESI-MS/MS) using, as chromatographic mobile phase, a linear gradient of methanol/water containing 0.5% acetic acid and 1 mM ammonium acetate. Method performances were quite satisfactory for all tested mycotoxins at contamination levels close to or below the relevant EU maximum permitted or recommended levels. Limits of detection in maize ranged from 0.3 to 4.2 microg/kg. Recoveries higher than 79% were obtained for all tested mycotoxins with relative standard deviations less than 13%.     

Determination of 16 Mycotoxins in Maize by Ultrahigh-Performance Liquid Chromatography–Tandem Mass Spectrometry

An ultrahigh-performance liquid chromatography–tandem mass spectrometry method was developed and validated for the simultaneous determination of sterigmatocystin, verruculogen, enniatin A, fusarenon-X, fumonisins B1, B2, B3, aflatoxins B1, B2, G1, G2, ochratoxin A, deoxynivalenol, 3-acetyldeoxynivalenol, 5-acetyldeoxynivalenol, and zearalenone. The mycotoxins were extracted and cleaned up using a multitoxin column, separated on a C18 column, and then detected on a triple-quadrupole mass spectrometer. The limits of detection and quantification ranged within 0.2–2?µg/kg and 1–10?µg/kg, respectively. The recoveries ranged from 70.8 to 118.4%, with relative standard deviations below 15%. The method was used to analyze 80 samples obtained from Shandong Province in China. Fifty-eight samples were contaminated with 10 mycotoxins at concentrations ranging from 1.4 to 6566.1?µg/kg. Some samples exceeded the maximum limits in China and in European regulations for mycotoxins in unprocessed maize.     

Thermospray high performance liquid chromatographic/mass spectrometric analysis of some fusarium mycotoxins

Thermospray high performance liquid chromatography/mass spectrometry (TSP HPLC/MS) was used to analyze five Fusarium mycotoxins in porcine plasma and urine. Four cytotoxic trichothecene mycotoxins, T-2 toxin, HT-2 toxin, diacetoxyscirpenol (DAS), deoxynivalenol (DON), T2 tetraol, and the fungal estrogen zearalenone (F-2 toxin) were analyzed. The thermospray mass spectrum contained molecular weight information with few, if any, fragment signals. Detection limits ranging from 1 to 10 ng of mycotoxin injected onto the HPLC column were obtained using selected ion monitoring (SIM) HPLC/MS. Neither the plasma nor the urine matrix interfered with TSP HPLC/MS analysis of these mycotoxins and no sample derivatization was necessary for the analysis. The TSP HPLC/MS technique appears to be ideal for very sensitive analysis of mycotoxins in biological samples.     

Fast determination of 14 mycotoxins in chestnut by dispersive solid‐phase extraction coupled with ultra high performance liquid chromatography‐tandem mass spectrometry

A dispersive solid‐phase extraction coupled with ultra high performance liquid chromatography with tandem mass spectrometry method was developed and validated for the simultaneous determination of T‐2 toxin, penicillic acid, fumonisins B₁, B₂, and B₃, aflatoxins B₁, B₂, G₁, and G₂, ochratoxin A, deoxynivalenol, 3‐acetyldeoxynivalenol, 15‐acetyldeoxynivalenol, and zearalenone in chestnut samples. The method was used to analyze 136 samples obtained from Shandong province in China. The mycotoxins were extracted using a dispersive solid‐phase extraction method and cleaned using an improved quick, easy, cheap, effective, rugged, and safe approach. The mycotoxins were then detected using a triple‐quadrupole mass spectrometer. The limits of detection and quantification ranged from 0.02 to 1 and 0.1 to 2 μg/kg, respectively. The recovery rates ranged from 74.2 to 109.5%, with relative standard deviations below 15%. A total of 71 samples were contaminated with seven mycotoxins at concentrations ranging from 1.2 to 105.5 μg/kg, with a number of samples exceeding the maximum limits set in the European regulations for mycotoxins in unprocessed chestnuts.     

Multiplex dipstick immunoassay for semi-quantitative determination of Fusarium mycotoxins in cereals

A multiplex dipstick immunoassay based method for the simultaneous determination of major Fusarium toxins, namely zearalenone, T-2 and HT-2 toxins, deoxynivalenol and fumonisins in wheat, oats and maize has been developed. The dipstick format was based on an indirect competitive approach. Four test lines (mycotoxin–BSA conjugates) and one control line were located on the strip membrane. Labelled antibodies were freeze-dried within the microwell. Two matrix-related sample preparation protocols have been developed for wheat/oats (not containing fumonisins) and maize (containing fumonisins) respectively. The use of a methanol/water mixture for sample preparation allowed recoveries in the range 73–109% for all mycotoxins in all tested cereals, with relative standard deviation less than 10%. The optimized immunoassay was able to detect target mycotoxins at cut off levels equal to 80% of EU maximum permitted levels, i.e. 280, 400, 1400 and 3200 μg kg⁻¹, respectively, for zearalenone, T-2/HT-2 toxins, deoxynivalenol and fumonisins in maize, and 80, 400 and 1400 μg kg⁻¹, respectively, for zearalenone, T-2/HT-2 toxins and deoxynivalenol in wheat and oats. Analysis of naturally contaminated samples resulted in a good agreement between multiplex dipstick and validated confirmatory LC–MS/MS. The percentage of false positive results was less than or equal to 13%, whereas no false negative results were obtained. Data on the presence/absence of 6 mycotoxins at levels close to EU regulatory levels were obtained within 30 min. The proposed immunoassay protocol is rapid, inexpensive, easy-to-use and fit for purpose of rapid screening of mycotoxins in cereals.     

Development and in-house validation of a robust and sensitive solid-phase extraction liquid chromatography/tandem mass spectrometry method for the quantitative determination of aflatoxins B1, B2, G1, G2, ochratoxin A, deoxynivalenol, zearalenone, T-2 and HT-2 toxins in cereal-based foods

A sensitive and robust liquid chromatography/tandem mass spectrometry (LC/MS/MS) method was developed for the simultaneous determination of aflatoxins (B(1), B(2), G(1), G(2)), ochratoxin A, deoxynivalenol, zearalenone, T-2 and HT-2 toxins in cereal-based foods. Samples were extracted with a mixture of acetonitrile/water (84:16, v/v) and cleaned up through a polymeric solid-phase extraction column. Detection and quantification of the nine mycotoxins were performed by reversed-phase liquid chromatography coupled with electrospray ionization triple quadrupole mass spectrometry (LC/ESI-MS/MS), using fully (13)C-isotope-labelled mycotoxins as internal standards. The method was validated in-house for five different cereal processed products, namely barley, oat and durum wheat flours, rye- and wheat-based crisp bread. Recoveries and repeatability of the whole analytical procedure were evaluated at contamination levels encompassing the EU maximum permitted levels for each tested mycotoxin. Recoveries ranged from 89 to 108% for deoxynivalenol, from 73 to 114% for aflatoxins, from 85 to 114% for T-2 and HT-2 toxins, from 64 to 97% for zearalenone, from 74 to 102% for ochratoxin A. Relative standard deviations were less than 16% for all tested mycotoxins and matrices. Limits of detection (signal-to-noise ratio 3:1) ranged from 0.1 to 59.2 μg/kg. The trueness of the results obtained by the proposed method was demonstrated by analysis of reference materials for aflatoxins, deoxynivalenol, zearalenone. The use of inexpensive clean-up cartridges and the increasing availability of less expensive LC/MS/MS instrumentation strengthen the potential of the proposed method for its effective application for reliable routine analysis to assess compliance of tested cereal products with current regulation.     

Development of a liquid chromatography/time-of-flight mass spectrometric method for the simultaneous determination of trichothecenes, zearalenone and aflatoxins in foodstuffs

A liquid chromatography/atmospheric pressure chemical ionization mass spectrometry (LC/APCI-MS) method based on time-of-flight MS (TOFMS) with a real-time reference mass correction technique was developed for the simultaneous determination of Fusarium mycotoxins (nivalenol, deoxynivalenol, fusarenon X, 3-acetyldeoxynivalenol, 15-acetyldeoxynivalenol, HT-2 toxin, T-2 toxin, diacetoxyscirpenol, zearalenone) and Aspergillus mycotoxins (aflatoxin B1, aflatoxin B2, aflatoxin G1, aflatoxin G2) in corn, wheat, cornflakes and biscuits. Samples were cleaned up with a MultiSep #226 column. Detection of the mycotoxins was carried out in exact mass chromatograms with a mass window of 0.03 Th. Calibration curves were linear from 2 to 200 ng x mL(-1) for trichothecenes and zearalenone, and 0.2 to 20 ng x mL(-1) for aflatoxins, by 20 microL injection. The limits of detection ranged from 0.1 to 6.1 ng x g(-1) in foodstuffs analyzed in this study. The LC/TOFMS method was found to be suitable for the screening of multiple mycotoxins in foodstuffs rapidly and with high sensitivity, and its performance was demonstrated for the confirmation for target mycotoxins.     

基于真菌毒素污染差异的液相色谱-串联质谱法鉴别板栗粉中掺假小麦粉

建立了分散固相萃取-超快速液相色谱-串联质谱法同时测定板栗粉和小麦粉中43种真菌毒素的方法,对48份板栗粉和80份小麦粉样品的污染状况进行调查,筛选出5种专属于小麦粉的标志性真菌毒素.样品采用84％(v/v)乙腈水溶液提取,提取液采用C18结合增强型脂质去除净化剂(EMR-Lipid)净化,采用响应曲面-中心组合设计优...     

Imaging surface plasmon resonance for multiplex microassay sensing of mycotoxins

A prototype imaging surface plasmon resonance-based multiplex microimmunoassay for mycotoxins is described. A microarray of mycotoxin–protein conjugates was fabricated using a continuous flow microspotter device. A competitive inhibition immunoassay format was developed for the simultaneous detection of deoxynivalenol (DON) and zearalenone (ZEN), using a single sensor chip. Initial in-house validation showed limits of detection of 21 and 17 ng/mL for DON and 16 and 10 ng/mL for ZEN in extracts, which corresponds to 84 and 68 μg/kg for DON and 64 and 40 μg/kg for ZEN in maize and wheat samples, respectively. Finally, the results were critically compared with data obtained from liquid chromatography-mass spectrometry confirmatory analysis method and found to be in good agreement. The described multiplex immunoassay for the rapid screening of several mycotoxins meets European Union regulatory limits and represents a robust platform for mycotoxin analysis in food and feed samples.     

Determination of trichothecenes in cereals by gas chromatography with ion trap detection

Summary A method for determination of the trichothecene toxins, deoxynivalenol, 3α-acetyl-deoxynivalenol, nivalenol, T-2 toxin, HT-2 toxin and diacetoxyscirpenol in cereals (wheat, barley, oats, corn) is described. Extraction was performed according to Tanaka et al. (J. Chromatogr.328, 271 (1985)) [33], derivatization by trifluoroacylation with trifluoroacetic acid anhydride. For quantitation and confirmation a capillary gas chromatograph combined with a selective mass detector (ion trap) working in CI-mode with methanol as reagent gas was used. The quantitation limit for the complete method is 1–5 μg/kg, depending on the chemical characteristics of each toxin and cleanness of the extracts. Recoverics from spiked cereals were 78–89%.     

Development and validation of a liquid chromatography/tandem mass spectrometric method for the determination of 39 mycotoxins in wheat and maize

This paper describes the first validated method for the determination of 39 mycotoxins in wheat and maize using a single extraction step followed by liquid chromatography with electrospray ionization triple quadrupole mass spectrometry (LC/ESI-MS/MS) without the need for any clean-up. The 39 analytes included A- and B-trichothecenes (including deoxynivalenol-3-glucoside), zearalenone and related derivatives, fumonisins, enniatins, ergot alkaloids, ochratoxins, aflatoxins and moniliformin. The large number and the chemical diversity of the analytes required the application of the positive as well as the negative ion ESI mode in two consecutive chromatographic runs of 21 min each. The solvent mixture acetonitrile/water/acetic acid 79 + 20 + 1 (v/v/v) has been determined as the best compromise for the extraction of the analytes from wheat and maize. Raw extracts were diluted 1 + 1 and were injected without any clean-up. Ion-suppression effects due to co-eluting matrix components were negligible in the case of wheat, whereas significant signal suppression for 12 analytes was observed in maize, causing purely proportional systematic errors. Method performance characteristics were determined after spiking blank samples on multiple levels in triplicate. Coefficients of variation of the overall process of <5.1% and <3.0% were obtained for wheat and maize, respectively, from linear calibration data. Limits of detection ranged from 0.03 to 220 microg/kg. Apparent recoveries (including both the recoveries of the extraction step and matrix effects) were within the range of 100 +/- 10% for approximately half of the analytes. In extreme cases the apparent recoveries dropped to about 20%, but this could be compensated for to a large extent by the application of matrix-matched standards to correct for matrix-induced signal suppression, as only a few analytes such as nivalenol and the fumonisins exhibited incomplete extraction. For deoxynivalenol and zearalenone, the trueness of the method was confirmed through the analysis of certified reference materials.     

进出口食品中常见霉菌毒素的污染及其检测技术探讨

阐述了进出口食品中常见霉菌毒素的种类,包括黄曲霉毒素、赭曲霉毒素、脱氧雪腐镰刀菌烯醇、玉米赤霉烯酮、伏马毒素、T-2毒素以及蛇形毒素等;分析了它们在进出口食品中污染的产生、来源和危害性;同时对霉菌毒素的检测技术及其研究进展进行了简要介绍。     

Simultaneous determination of trichothecene micotoxins, ochratoxin A, and zearalenone in grain and products of its processing, feed premixes, and meat by gas chromatography

A rapid and simple method is developed for the simultaneous determination of ochratoxin A, toxin T-2, deoxynivalenol, and zearalenone by gas chromatography with electron capture detection; the method is applicable to grain, products of its processing, feed premixes, and meat in concentration ranges 0.05–5 mg/kg (0.01–2 mg/kg for ochratoxin A and 0.03–3 mg/kg for T-2). The micotoxins were extracted from samples with acetonitrile; the extracts were purified by the QuEChERS method; and derivatives of target analytes were obtained with trifluoroacetic anhydride. The overall duration of analysis was 1–1.5 h; the relative standard deviation of the results did not exceed 8%.     

Minimization of carryover for high‐throughput liquid chromatography with tandem mass spectrometry analysis of 14 mycotoxins in corn grits

A method for the simultaneous analysis of 14 mycotoxins with the minimization of carryover was developed. Our verification experiments suggested that the carryover occurred due to the chelation of fumonisins with the metal. To wash the fumonisins from the metal, the inner surface of the injection needle was rinsed with 10 mM trisodium citrate and 1% formic acid in water/methanol/acetonitrile/isopropanol after each injection, and the analysis was performed on a metal‐free Mastro C18 column. This approach remarkably minimized the carryover of fumonisins. Fourteen mycotoxins in samples were extracted with 2% acetic acid in water/acetonitrile and a quick, easy, cheap, effective, rugged, and safe extraction kit, purified on a MultiSep 229 Ochra, and then quantified by liquid chromatography with tandem mass spectrometry. Determinations performed using this method produced a linearity greater than 0.99 and recoveries ranging from 72.6 to 117.4%, with good intraday precision from 4.0 to 12.4%, and interday precision from 6.5 to 17.0%. The limits of detection ranged from 0.01 to 0.71 μg/kg, demonstrating that a highly sensitive method for the simultaneous analysis of mycotoxins over a wide range of concentrations was achieved with minimal carryover. When 12 samples of commercially available corn grits were analyzed with this method, deoxynivalenol, fumonisin B1, fumonisin B2, fumonisin B3, and zearalenone were present most frequently.     

Analysis of T-2 and HT-2 toxins in cereal grains by immunoaffinity clean-up and liquid chromatography with fluorescence detection

A sensitive, precise and accurate method has been developed for the simultaneous determination of T-2 and HT-2 toxins in cereal grains at ppb levels using high-performance liquid chromatography (HPLC) with fluorescence detection and 1-antroylnitrile (1-AN) as labeling reagent after immunoaffinity clean-up. Cereal samples were extracted with methanol/water (90:10, v/v), and the extracts were cleaned-up through commercially available immunoaffinity columns containing monoclonal anti-T-2 antibodies (T-2 test HPLC, Vicam). T-2 and HT-2 toxins were quantified by reversed-phase HPLC with fluorometric detection (excitation wavelength 381 nm, emission wavelength 470 nm) after derivatization with 1-AN. The monoclonal antibody showed 100% cross-reactivity with both T-2 and HT-2 toxin, and the immunoaffinity column clean-up was effective up to 1.4 microg of both toxins. The method was successfully applied to the analysis of T-2 and HT-2 toxins in wheat, maize and barley. Recoveries from spiked samples with toxin levels from 25 to 500 microg/kg ranged from 70% to 100%, with relative standard deviation generally lower than 8%. The limit of detection of the method was 5 microg/kg for T-2 toxin and 3 microg/kg for HT-2 toxin, based on a signal-to-noise ratio 3:1. HT-2 toxin was detected in ten naturally contaminated wheat samples out of 14 samples analyzed, with toxin levels ranging from 10 to 71 microg/kg; three of them contained also T-2 toxin up to 12 microg/kg.     

Preparation and certification of zearalenone mass concentration of two low-level maize reference materials

The contamination of maize by fungi, especially by Fusarium species, is a worldwide problem. One of the most prevalent Fusarium mycotoxins frequently found on European maize is zearalenone (ZON), which has been implicated in a range of human and animal diseases. It shows remarkable estrogenic properties and can cause severe infertility problems in farm animals. Currently, 9 countries have set maximum tolerable levels for ZON in food, ranging from 0 to 1000 microg/kg. This paper describes the preparation of 2 maize reference materials (BCR-716 very low level ZON and BCR-717 low level ZON) and the certification of their individual ZON contents (mass concentration and mass fraction). Uncertainties were calculated in compliance with the Guide to the Expression of Uncertainty in Measurement and include uncertainties that are due to possible inhomogeneity and instability. Finally, BCR-716 was certified at a level of <5 microg/kg and BCR-717 at a level of 83 microg/kg with an expanded uncertainty (k = 2) of 9 microg/kg.     

基于QuEChERS提取的快速液相色谱-串联质谱法测定婴幼儿谷基辅助食品中的9种真菌毒素

建立了婴幼儿谷基辅助食品中黄曲霉毒素B1、B2、G1、G2、赭曲霉毒素A、玉米赤霉烯酮、T-2毒素、脱氧雪腐镰刀菌烯醇、伏马毒素B1共9种真菌毒素的快速测定方法。试样用改良的QuEChERS方法进行提取,无需进一步净化,直接用液相色谱-串联质谱仪进行测定,基质外标法定量。在较宽的线性范围内,9种毒素的线性相关系数(r²)均不小于0.98,检出限为0.1~15.8 μg/kg,在3个不同添加水平下的加标回收率为77.6%~105.7%,RSD为2.5%~13.7%。采用建立的方法对市面上销售的41批次婴幼儿谷基辅助食品中的9种真菌毒素进行了筛查,数批产品检出不同含量的毒素。该方法准确、灵敏,可适用于婴幼儿谷基辅助食品中多种真菌毒素的快速分析。     

Simultaneous determination of aflatoxins, ochratoxin A, and zearalenone in grains by new immunoaffinity column/liquid chromatography

The simultaneous determination of mycotoxins was performed in 3 steps: extraction, cleanup, and detection. For extraction, a mixture of acetonitrile-water (60 + 40, v/v) was proved appropriate. For cleanup, a new Afla-Ochra-Zea immunoaffinity column was used. After derivatization with trifluoroacetic acid, the mycotoxins aflatoxins, ochratoxin A (OTA), and zearalenone (ZEA) were determined simultaneously by liquid chromatography with fluorescence detection. The detection limits in different matrixes after cleanup with the new immunoaffinity column were very low: aflatoxins, 0.002-0.7 microg/kg; OTA, 0.07-0.25 microg/kg; ZEA, 1-3 microg/kg. The limits of determination were: aflatoxins, 0.25 microg/kg; OTA, 0.5 microg/kg; ZEA, 5 microg/kg. The recovery rates for aflatoxins, OTA, and ZEA for rye and rice were between 86 and 93% when a 0.5 g sample matter per immunoaffinity column was used.     

Analytical method for the determination of mycotoxins in indoor/outdoor airborne particulate matter by HPLC-MS-MS

An effective analytical method for the screening of mycotoxins, in indoor/outdoor airborne particulate matter, was developed and method performance data are presented. Mycotoxins are natural compounds produced, in particular conditions, as secondary metabolites by filamentous fungi and moulds, and, after their production, they can be transported far from their source. To simulate real samples, an urban dust (reference material 1649a) free from mycotoxins was used as matrix and spiked by the most common mycotoxins, chosen on the basis of studies carried out previously in other real matrices: deoxynivalenol, aflatoxin B1, ochratoxin A, T-2 toxin, zearalenone and sterigmatocystin. The analytical method was optimised and structured in four successive steps: (1) accelerated solvent extraction of the (spiked) analytes from matrix, (2) solid-phase purification (SPE) of the previous extract, (3) pre-concentration of the eluates from SPE and (4) analysis of the concentrated eluates by high performance liquid chromatography tandem mass spectrometry in multiple reaction monitoring mode. After a proper sampling campaign, the method was applied to real indoor and outdoor particulate matter samples, where the clean-up step showed to be very effective and fundamental to avoid misleading analytical results.