Growth and characterization of 2,6‐dibenzylidenecyclohexanone single crystal

Following the temperature reduction method, growth of single crystals of organic 2,6‐dibenzylidenecyclohexanone (DBCH) material from ethanol solution is reported in the present work. Solubility and metastable zone width measurements were carried out under stirring and nonstirring conditions of solution. Cell dimensions were obtained from single crystal X‐ray diffraction study. From FT‐IR spectral analysis, various functional groups of this crystal were identified. UV‐Visible spectral analysis was made. Mechanical strength of the grown crystal was estimated on the prominent (110) face using a Vickers microhardness tester. (© 2005 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth of benzophenone single crystals from solution: A novel approach with 100% solute ‐ crystal conversion efficiency

An unidirectional 60mm diameter benzophenone single crystal was successfully grown by utilizing a novel crystal growth method at room temperature. <110> oriented single crystal ingots were grown out of xylene as solvent and by fixing a seed at the bottom of the ampoule. The obtained benzophenone ingots with the sizes of 10mm, 25mm and 60mm diameter evident that ease in increasing the diameter of the ingot. The orientation of the ingot and the crystalline quality were justified by X‐ray studies. TG and DTA evaluated the thermal properties of the grown crystal. The optical transmission study and the powder SHG measurement show the suitability of the ingot for nonlinear optical applications. The achieved solute‐crystal conversion efficiency of hundred percent shows vital advantage of this technique for cost effectiveness. The microbial growth as in the case of amino acid based growth solutions can be more effectively controlled in the present method since the freshly prepared growth solution can be constantly made available to the growing crystal. © 2006 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim     

Studies on large uniaxially grown benzophenone single crystals

〈110〉, 〈010〉 and 〈100〉 oriented uniaxial benzophenone crystals were grown by uniaxially solution‐crystallization method of Sankaranarayanan ‐ Ramasamy (SR). The experimental parameters involved in the present study were investigated in detail and a constant growth rate was achieved by compensating the loss of growth units in the solution. A transparent uniaxial benzophenone crystal having dimension of 500 mm length and 55 mm diameter was grown at room temperature for the first time in the literature. In contrast to the conventional solution growth method, the growth rate along each direction was measured at ease during the respective growth experiment by monitoring the elevation of the solid‐liquid interface and found to be 2, 4 and 6 mm/day along the 〈110〉, 〈010〉 and 〈100〉 directions respectively for a chosen supersaturation. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Crystal growth,morphology, spectrographic characterization and thermal properties of 4,5‐bis(benzoylthio)‐1,3‐dithiole‐2‐thione

Single crystals of 4,5‐bis(benzoylthio)‐1,3‐dithiole‐2‐thione (BBDT), were grown from methylene chloride and the growth morphology was deduced by the Bravais–Friedel Donnay–Harker (BFDH) model. The grown crystals were characterized by optical absorption, infrared, Raman and X‐ray powder diffraction spectroscopy. The thermal behavior of BBDT has been investigated by means of thermogravimetric analysis and differential thermal analysis measurements in air. (© 2008 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth and characterization of 4‐Aminopyridinium‐4‐nitro phenolate single crystals

Organic optical material 4‐Aminopyridinium‐4‐nitro phenolate (4AP4NP) has been synthesized, and single crystals of size 20 x 14 x 6 mm³ have been grown from acetone solvent at room temperature by solvent evaporation technique. The grown crystals have been characterized by X‐ray diffraction to determine the cell parameters, and by FT‐IR technique to confirm the formation of the expected compound. The crystal belongs to monoclinic crystal system with space group P2₁/a.The structural perfection of the grown crystals has been analyzed by high‐resolution X‐ray diffraction (HRXRD) rocking curve measurements. The thermal stability of the compound has been determined by TG‐DTA curves. The transmittance of 4AP4NP has been used to determine the refractive index n; the extinction coefficient K and both the real ε_r and imaginary ε_i components of the dielectric constant as functions of photon energy. The optical band gap of 4AP4NP is 2.4 eV. The dielectric and mechanical behavior of the specimen was also studied. (© 2009 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Synthesis and characterization of 4,4′‐dihydroxy‐α‐methylstilbene crystal

4,4′‐dihydroxy‐α‐methylstilbene (DHAMS) was synthesized by condensation reaction with chloroacetone and phenol in the presence of concentrated sulfuric acid, and has been successfully grown by solution growth technique. This is the first report in the literature on the crystallization of DHAMS and exhibited the birefringent melt (liquid crystal property) of the optical properties. FTIR and FTNMR studies are in accordance with the structure. Good quality crystals were grown by slow evaporation technique by acetone as solvent. A transmission spectrum of the crystal was obtained in the region of 285 nm. The structural and optical properties were studied. (© 2006 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth and characterization of magneto‐optical YFeO3 crystals

The floating zone growth of magneto‐optical crystal YFeO₃ has been investigated. The polycrystalline feed rod was prepared by a pressure of 250MPa and sintering at about 1500°C. A crack‐ free YFeO₃ single crystal has been successfully grown. The crystal preferred to crystallize along <100> direction with about 10° deviation. The X‐ray rocking curve of the crystal has a FWHM of 24 arcsec, confirming the high crystal quality of the sample. The (100) plane was etched by hot phosphoric acid and the dislocation density was about 10⁴/cm². A thin outer layer with Y₂O₃‐rich composition was found at the periphery of as‐grown crystals, which was attributed to the Fe₂O₃ evaporation during growth. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth and characterization of pure and Co2+‐doped Li2B4O7 single crystals

Pure and Co‐doped Li₂B₄O₇ (LBO) single crystals were grown by the Czochralski method. Starting concentrations of Co₂O₃ in the melt were: 0.5, 0.85 and 1 mol% relative to Li₂CO₃. Technological factors affecting the quality of both crystals were discussed. Optical absorption and EPR spectra were analyzed to define the oxidation states and lattice sites of cobalt ions. It was shown that Co²⁺ ions enter LBO crystal at octahedral Li⁺ site positions. Low‐temperature EPR measurements revealed that two types of Co²⁺ complexes can be distinguished in the Li₂B₄O₇:Co crystals. Additional absorption calculated for γ‐irradiated crystals showed V_k type defects suggesting the creation of cation vacancies during growth. The concentration of the defects decreases with an increase of intentional Co concentration. Introduction of cobalt ions to LBO crystal is limited probably by the formation of cobalt ion pairs or by the entrance of cobalt as Co⁺. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Synthesis,bulk growth,polarizability and nonlinear optical properties of γ‐glycine single crystals

The role of sodium acetate, sodium nitrate, sodium hydroxide and malonic acid as additives in assisting the nucleation of γ‐polymorph from solution has been investigated. For the first time large dimensional bulk single crystals of γ‐glycine have been grown at the optimized concentration of the additives by the top seeded slow cooling technique. The bulk growth of single crystals elucidates well the unidirectional growth characteristics and the existence of merohedral twinning in γ‐ glycine. Polarizability, plasmon energy and Fermi energy has been evaluated for the first time for γ‐glycine single crystals based on an analytical approach. Structural affirmation of the nucleated polymorph has been carried out by Powder x‐ray diffraction and the thermal characteristics of the nucleated polymorph are well revealed by Differential Scanning Calorimetry. The non linear optical characteristics of γ‐glycine studied by Kurtz and Perry technique revealed increased SHG efficiency with the highest of about 2.2 in the presence of malonic acid compared to the standard Potassium dihydrogen orthophosphate (KDP).     

Structural,thermal, mechanical and z‐scan studies on 4‐nitrophenol single crystals

4‐nitrophenol (4‐NP) single crystals have been grown by using slow evaporation and slow cooling techniques. A single crystal with size in the range of 7x3.4x1.8cm³ has been obtained by slow cooling method. The grown crystals have been subjected to various characterization studies. The powder XRD spectrum of 4‐NP reveals the good crystalline nature of the grown crystal. Single crystal XRD studies show that the crystal belongs to monoclinic system with cell parameters of a=6.09 Å, b=8.79 Å, c=11.61 Å, α=γ=90°, β=103.15°. The resultant FTIR spectrum confirms the various functional groups present in 4‐NP. Thermal analysis has been performed on the material to study the thermal stability of 4‐NP. The grown crystals belong to the category of soft materials as confirmed by Vickers Hardness tests. The optical transmiitance of 4‐NP single crystals has been measured from Vis‐IR spectroscopy study. The nonlinear optical properties have been analyzed by z‐scan technique and 4‐NP is found to be self defocusing because of its negative nonlinear refractive index. (© 2012 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth and characterization of superconductive Nd2‐xCexCuO4‐y single crystals

Nd_2‐xCe_xCuO_4‐y single crystals with different x values have been successfully grown by Traveling Solvent Floating Zone method (TSFZ). Electronic properties of Nd_2‐xCe_xCuO_4‐y single crystals with various x have been studied in detail. The results show that superconductivity can be found in crystals with x > 0.1 (0.13‐0.18) directly grown at oxygen‐reduced atmosphere without post‐annealed, while no superconductivity appears in crystals with x < 0.1 at the same atmosphere. It is also found that, the segregation coefficient of Ce is determined to be 0.946 and transition temperature Tc (onset) reaches maximum value of 23.5 K at nominal composition x = 0.165. With further increase of Ce concentration, transition temperature of single crystals declines due to the precipitation of secondary Phases. In addition, the variation of lattice constants of Nd_2‐xCe_xCuO_4‐y single crystals with different x is also given. (© 2004 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Synthesis,growth and characterization of single crystals of pure and thiourea doped L‐glutamic acid hydrochloride

L(+)Glutamic acid hydrochloride [HOOC (CH₂)₂CH(NH₂) COOH·HCl], a monoamino dicarboxylic acid salt of L‐Glutamic acid was synthesized and the synthesis was confirmed by FTIR analysis. Solubility of the material in water was determined. Pure and Thiourea doped L‐Glutamic acid hydrochloride crystals were grown by low temperature solution growth using solvent evaporation technique. XRD, UV‐Vis‐NIR analyses were carried out for both pure and thiourea doped crystals. The crystals were qualitatively analyzed by EDAX analysis and the presence of thiourea was confirmed. The cell parameters of L‐Glutamic acid hydrochloride have been determined as a = 5.151 Å, b = 11.79 Å, c = 13.35 Å by X‐ray diffraction analysis and it crystallizes in orthorhombic space group P2₁2₁2₁. UV‐Vis‐NIR spectra analysis showed good optical transmission in the entire visible region for both pure and doped crystals. Micro hardness of both pure and doped crystals has been determined using Vickers micro hardness tester. The SHG efficiencies of both pure and doped crystals were determined using Kurtz powder test and pure L‐Glutamic acid hydrochloride crystal was found to possess better efficiency than thiourea doped L‐Glutamic acid hydrochloride crystals. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth and characterization of KBi(WO4)2 single crystals

Potassium bismuth tungstate [KBi(WO₄)₂] single crystals with dimensions up to 20 mm × 15 mm × 15 mm have been successfully grown by using the top‐seeded solution growth technique and K₂W₂O₇ as solvent. Experiments show that this crystal is unstable in a strong acid or alkali environment and has a blue fluorescence emission. The density, hardness, melting point, absorption edge, transparency range, prominent Raman shift frequency are 7.57 g/cm³, 238 kg/mm², 800 °C, 380 nm, 400–5450 nm, 868 cm^–1 respectively. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth and characterization of large La1‐xPbxMnO3+δ (x=0.32–0.35) crystals

Large crystals of La_0.63Pb_0.37Mn O_3+δ with small La(Pb)‐ deficiency of about 0.005‐0.01 at.% were grown by high temperature solution growth method. The structure of the grown crystals was determined as rhombohedral with R‐3 space group by single‐crystal X‐ray diffractometry. The surface morphology of the crystals and the exact chemical composition was examined by scanning electron microscopy and energy dispersive X‐ray analysis methods, respectively. The IR‐transmission spectrum reveals the presence of Mn³⁺O₆‐ and Mn⁴⁺O₆‐ octahedra in the lattice of La_0.63Pb_0.37Mn O_3+δ crystals. (© 2009 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Capsule‐like α‐Fe2O3 nanoparticles: Synthesis,characterization, and growth mechanism

Uniform capsule‐like α‐Fe₂O₃ particles were synthesized via a simple hydrothermal method, employing FeCl₃ and CH₃COONa as the precursors and sodium dodecyl sulfate (SDS) as soft template. X‐ray powder diffraction (XRD), field emission scanning electron microscopy (FE‐SEM), transmission electron microscopy (TEM), and high‐resolution transmission electron microscopy were used to characterize the structure of synthesized products. Some factors influencing the formation of capsule‐like α‐Fe₂O₃ particles were systematically investigated, including different kinds of surfactants, the concentration of SDS, and reaction times. The investigation on the evolution formation reveals that SDS was critical to control the morphology of final products, and a possible five‐step growth mechanism was presented by tracking the structures of the products at different reaction stages.     

Characterization of L‐ascorbic acid single crystals grown from solution with different solvents

Single crystals of L‐ascorbic acid, popularly known as vitamin‐C, were grown from solutions with different solvents and solvent combinations by low temperature solution growth methods. The suitability of different solvents and solvent combinations such as acetone, ethanol, methanol, isopropyl alcohol, water, water + acetone (1:1), water + ethanol (3:1), water + isopropyl alcohol (3:1) and isopropyl alcohol + methanol (1:1) for crystal growth of L‐ascorbic acid was found out by assessing the solubility and crystallization behaviours. Solubility of L‐ascorbic acid in selected solvents and solvent combinations in a range of temperatures was determined by gravimetric method. Solution prepared with water, water + acetone (1:1), water + ethanol (3:1) and water + isopropyl alcohol (3:1) were yielded crystals with tabular, columnar and prismatic habits and their morphologies were evaluated by goniometry. Grown single crystals were characterized with various instrumental techniques such as powder X‐ray diffraction, Fourier infrared spectroscopy, optical transmittance study, differential scanning calorimetry and second harmonic generation studies. (© 2010 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth and characterization of a novel organic NLO crystal: 4 – ethoxy benzaldehyde – n – methyl 4 – stilbazolium tosylate

The organic material 4‐Ethoxybenzaldehyde‐N‐methyl 4‐Stilbazolium Tosylate (EBST) is a new NLO material and new derivative in Stilbazolium Tosylate family. In this work we synthesized the EBST, the derivative of DAST. By slow evaporation method, we have grown the EBST crystal. Powder XRD confirms the crystalline property, the lattice parameters are calculated from single crystal XRD data and the molecular structure also revealed. The crystal system is found as monoclinic. The crystalline perfection is assessed by the high‐resolution X‐ray diffractometry. A single and reasonably sharp peak observed in the diffraction curve indicates that the quality of the crystal is quite good without having any internal structural grain boundaries. The FTIR and proton NMR study confirm the presence of functional groups. From the UV – Vis Far IR absorption spectra the good transparency is revealed. The Kurtz Perry SHG test confirms the NLO property of the EBST crystal grown and it is 11 times greater than urea. The melting point of the grown crystal is found to be 237°C from the DSC curve. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Structural,thermal and optical studies on 2‐naphthol crystals

Single crystals of 2‐naphthol was grown in slow evaporation solution growth technique. Grown crystals were characterized by various characterization techniques. Powder X‐ ray diffraction studies reveal that the grown crystal belongs to monoclinic system with noncentrosymmetric space group. Vibrational bands of the various functional groups and their significance were investigated by analyzing the vibrational spectra. Melting point and the decomposition temperature of the grown crystal was premeditated from the thermal analysis. From the UV‐VIS‐NIR spectrum the electronic excitation mechanism and the transmittance abilities of the crystal was studied. Theoretical value of first static hyperpolarizability was calculated and compared with urea. Second harmonic generation efficiency of the crystal is 0.6 times that of KDP. (© 2010 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Crystal structure of 2‐(2'‐hydroxyphenyl)‐6‐tributylstannyl‐4‐(3H )‐quinazolinone and 2‐(2'‐hydroxyphenyl)‐6‐iodo‐4‐(3H)‐quinazolinone

The structures of the title compounds C₂₆H₃₇N₂O₂Sn ( I ) and C₁₄H₉IN₂O₂ ( II ) were determined by single‐crystal X‐ray diffraction technique. Compound I crystallizes in the triclinic space group P1 with a = 9.560(3) Å, b = 16.899(6) Å, c = 17.872(5) Å, α = 65.957(7)°, β = 83.603(5)°, γ ( = 75.242(5)°, V = 2549.8(13) ų, Z = 4, and D =1.374 g/cm³. The compound consists of a quinazolinone ring with phenol and tributylstannyl moieties. Compound II crystallizes in the monoclinic space group P2₁/c with a = 7.6454(12) Å, b = 5.9270(9) Å, c = 27.975(4) Å; α = 90°, β = 95.081(3)°, γ = 90°, V = 1262.7(3) ų, Z = 4, and D = 1.915 g/cm³. The compound consists of a quinazolinone ring with phenol and iodine substituents. For both I and II , the short intramolecular O–H…N and two long intermolecular N–H…O hydrogen bonds are highly effective in holding the molecular system in a stable state. (© 2006 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth of Eu(OH)3 large single crystals by solid KOH assisted hydrothermal method and luminescent and magnetic properties

Large single crystals of lanthanide hydroxides [Ln(OH)₃ (Ln = La, Pr, Nd, Sm, Eu and Tb)] up to several millimeters have been grown by using solid KOH assisted hydrothermal method. Eu(OH)₃ samples, as a representative of the Ln(OH)₃ crystals, were characterized by X‐ray diffraction (XRD), 4‐circle single‐crystal diffraction, Fourier transform infrared (FTIR) spectroscopy and X‐ray photoelectron spectroscopy (XPS). FESEM image shows hexagonal prism morphology for the Eu(OH)₃ large crystals. Research on the photoluminescence and magnetic properties of Eu(OH)₃ species was conducted.