Microbial quality evaluation and effective decontamination of nutraceutically valued lotus seeds by electron beams and gamma irradiation

Lotus seeds are nutraceutically valued natural plant produce, which succumbs to microbial contamination, predominantly to toxigenic moulds. Results of the present study revealed seed coat portion to harbor higher proportion of microbial load, particularly fungi than cotyledon portion. Among the mycotoxins analyzed, aflatoxins (B₁, B₂, G₁ and G₂) were below detectable limits, while the seeds were devoid of Ochratoxin-A (OTA). Application of different doses of electron beam and gamma irradiation (0, 2.5, 5, 7.5, 10, 15 and 30 kGy) for decontamination purpose revealed significant dose-dependent decrease in the fungal contaminants (P<0.05). However, the contaminant yeasts could survive up to 10 kGy dose, which could be completely eliminated at 15 kGy. From the results obtained, a dose range between 10 and 15 kGy is recommended for complete decontamination, as these doses have also been shown earlier to have minimal effects on nutritional and functional properties of lotus seeds.     

Effect of gamma irradiation on Burkholderia thailandensis (Burkholderia pseudomallei surrogate) survival under combinations of pH and NaCl

This study evaluated the effect of gamma irradiation on Burkholderia thailandensis (Burkholderia pseudomallei surrogate; potential bioterrorism agent) survival under different levels of NaCl and pH. B. thailandensis in Luria Bertani broth supplemented with NaCl (0–3%), and pH-adjusted to 4–7 was treated with gamma irradiation (0–0.5 kGy). Surviving cell counts of bacteria were then enumerated on tryptic soy agar. Data for the cell counts were also used to calculate D₁₀ values (the dose required to reduce 1 log CFU/mL of B. thailandensis). Cell counts of B. thailandensis were decreased (P<0.05) as irradiation dose increased, and no differences (P≥0.05) in cell counts of the bacteria were observed among different levels of NaCl and pH. D₁₀ values ranged from 0.04 to 0.07 kGy, regardless of NaCl and pH level. These results indicate that low doses of gamma irradiation should be a useful treatment in decreasing the potential bioterrorism bacteria, which may possibly infect humans through foods.     

Exhaustive radiolysis of 11 mM aqueous benzene solutions: effect of added oxygen

The gamma radiolysis of aqueous benzene solutions was studied under various conditions (oxygenated, aerated and anoxic) to ascertain the role that oxygen plays in the destruction of benzene. For the oxygenated and aerated systems, phenol and biphenyl were the major quantified products. For the anoxic system, phenol was the sole quantified product. Benzene was initially consumed with approximately the same yield in each of the three systems; G(–benzene) was 0.49 μmol J^–1. Initial yields of phenol, G(phenol), were found to be 0.12, 0.060 and 0.030 μmol J^–1 for the oxygenated, aerated and anoxic systems, respectively. Biphenyl was initially formed with G=0.028 and 0.019 μmol J^–1 in the oxygenated and aerated systems, respectively. The percent conversion of benzene to CO₂ after an absorbed dose of 2500 kGy was 55.1%, 30.5% and 12.5%, respectively, for the oxygenated, aerated and anoxic systems. The last traces of benzene disappeared by a dose of ca. 60 kGy in all three systems. A mechanism was proposed for each system that depended upon the presence or absence of O₂. The total solution toxicity for each system was calculated by summing the individual toxicities of benzene and each quantified product. For the oxygenated and aerated systems, the total solution toxicity was found to go through a maximum at a dose of 22 kGy and then decrease to a value below that of the original solution. The total solution toxicity of the anoxic system was found to decrease from the onset of irradiation.     

Enhanced formation of quercetin by combined use of gamma ray and H2O2 from cyanidin-3-O-xylosylrutinoside

Cyanidin-3-O-xylosylrutinoside (cya-3-O-xylrut), a major pigment in Schizandra chinensis Baillon, was effectively removed by gamma irradiation of greater than 2 kGy, whereas quercetin, the most abundant of the flavonoids and has anti-inflammatory and anti-allergic effects, could be generated by degradation of cya-3-O-xylrut. In the present study, we investigated the effect of combination treatment of gamma irradiation and hydrogen peroxide (H₂O₂) on the formation of quercetin through the degradation of cya-3-O-xylrut. Cya-3-O-xylrut was significantly degraded (～93%) by gamma irradiation at 2 kGy and it was completely removed by a combination treatment (0.2% H₂O₂ and 2 kGy gamma ray). The formation of quercetin was significantly appeared at 2 kGy of gamma ray, together with disappearance of cya-3-O-xylrut. The quercetin formation by gamma ray is 3.2 μg/ml and combination treatment is 7.7 μg/ml. Therefore, the combination treatment of H₂O₂ and gamma ray is more effective to convert cya-3-O-xylrut into quercetin than gamma irradiation only. In conclusion, gamma ray combined with H₂O₂ would be a promising tool for bio-conversion of organic compounds.     

Irradiation effect on α- and β-caseins of milk and Queso Blanco cheese determined by capillary electrophoresis

Milk and Queso Blanco cheese were exposed to irradiation with doses of 1, 2, 3, 5, and 10 kGy to investigate the irradiation effect on α- and β-casein using a capillary electrophoresis. α_S1-Casein to total protein ratio in raw milk was decreased from 19.63% to 8.64% by 10 kGy of gamma irradiation. The ratio of α_S1- to α_S0-casein was also decreased from 1.38 to 0.53, which showed α_S1-casein is more susceptible to gamma irradiation than α_S0-casein. Similarly, α_S1-casein to total protein ratio in Queso Blanco cheese was decreased from 17.48% to 7.82% and the ratio of α_S1- to α_S0-casein was decreased from 1.16 to 0.43 by 10 kGy of gamma irradiation. Dose-dependent reduction of β_A1-casein was also found. β_A1-Casein to total protein ratios in raw milk and Queso Blanco cheese were decreased from 22.00% to 14.16% and from 21.96% to 13.89% after 10 kGy, respectively. The ratios of β_A1- to β_A2-casein were from 1.10 to 0.64 and 0.93 to 0.57 in milk and Queso Blanco cheese, respectively. However, α_S0-, β_B-, and β_A3-casein increased by irradiation at 10 kGy. The results suggest that α_S1-casein and β_A1-casein were more susceptible to gamma irradiation, and may be related to the reduction of milk allergenicity caused by gamma irradiation.     

Electron beam irradiation of fluoropolymers containing polyethers

A highly fluorinated monomer, 1,3-bis(1,1,1,3,3,3-hexafluoro-2-pentafluorophenyl methoxy-2-propyl)benzene (12F-FBE) was polymerized with some diphenols by polycondensation and then was electron beam irradiated between 100 and 1000 kGy to determine degradation radiochemistry yield (G_s) by gel permeation chromatography (GPC). The samples were characterized after irradiation by DSC, FTIR, and nuclear magnetic resonance (NMR). The fluoropolymers show apparent degradation in mechanical properties at 300 kGy, except 12F-FBE polymerized with biphenol and bisphenol A, when they did not show any apparent physical change up to 300 kGy; and continue to be flexible and transparent, with a radiochemical yield scission (G_s) of 0.75, 0.53, 0.88, and 0.38 for 12F-FBE/SDL aliphatic, 12F-FBE/biphenol, 12F-FBE/bisphenol A, and 12F-FBE/bisphenol O, respectively. The number average molecular weights for three of the polymers decrease upon 1000 kGy irradiation to 10% of their original values; however, the polymer from bisphenol A is much more stable and its M_n decreases to only 24% of original.     

Effect of gamma radiation on the mechanical and barrier properties of HEMA grafted chitosan-based films

Chitosan films were prepared by dissolving 1% (w/v) chitosan powder in 2% (w/v) aqueous acetic acid solution. Chitosan films were prepared by solution casting. The values of puncture strength (PS), viscoelasticity coefficient and water vapor permeability (WVP) of the films were found to be 565 N/mm, 35%, and 3.30 g mm/m² day kPa, respectively. Chitosan solution was exposed to gamma irradiation (0.1–5 kGy) and it was revealed that PS values were reduced significantly (p≤0.05) after 1 kGy dose and it was not possible to form films after 5 kGy. Monomer, 2-hydroxyethyl methacrylate (HEMA) solution (0.1–1%, w/v) was incorporated into the chitosan solution and the formulation was exposed to gamma irradiation (0.3 kGy). A 0.1% (w/v) HEMA concentration at 0.3 kGy dose was found optimal-based on PS values for chitosan grafting. Then radiation dose (0.1–5 kGy) was optimized for HEMA grafting. The highest PS values (672 N/mm) were found at 0.7 kGy. The WVP of the grafted films improved significantly (p≤0.05) with the rise of radiation dose.     

Determination of aflatoxins in cereal flours by solid-phase microextraction coupled with liquid chromatography and post-column photochemical derivatization-fluorescence detection

A new method for the determination of aflatoxins B₁, B₂, G₁, and G₂ (AFB₁, AFB₂, AFG₁, AFG₂) in cereal flours based on solid-phase microextraction (SPME) coupled with high performance liquid chromatography with post-column photochemical derivatization and fluorescence detection (SPME–HPLC–PD–FD) has been developed. Aflatoxins were extracted from cereal flour samples by a methanol:phosphate buffer (pH 5.8, I = 0.1) (80:20, v/v) solution, followed by a SPME step. Different SPME and HPLC–PD–FD parameters (fiber polarity, temperature, pH, ionic strength, adsorption and desorption time, mobile phase) have been investigated and optimized. This method, which was assessed for the analysis of different cereal flours, showed interesting results in terms of LOD (from 0.035 to 0.2 ng g⁻¹), LOQ (from 0.1 to 0.63 ng g⁻¹, respectively), within and inter-day repeatability (2.27% and 5.38%, respectively) linear ranges (up to 20 ng g⁻¹ for AFB₁ and AFG₁ and 6 ng g⁻¹ for AFB₂ and AFG₂), and total raw extraction efficiency (in the range 55–59% at concentrations in the range 0.3–1 ng g⁻¹ and 49–52% at concentrations in the range 1–10 ng g⁻¹). The results were also compared with the purification step carried out by conventional immunoaffinity columns.     

Quality of fresh-cut Iceberg lettuce and spinach irradiated at doses up to 4 kGy

Fresh-cut Iceberg lettuce packaged in modified atmosphere packages and spinach in perforated film bags were irradiated with gamma rays at doses of 0, 1, 2, 3, and 4 kGy. After irradiation, the samples were stored for 14 days at 4 °C. O₂ levels in the packages of fresh-cut Iceberg lettuce decreased and CO₂ levels increased with increasing radiation dose, suggesting that irradiation increased respiration rates of lettuce. Tissue browning of irradiated cut lettuce was less severe than that of non-irradiated, probably due to the lower O₂ levels in the packages. However, samples irradiated at 3 and 4 kGy had lower maximum force and more severe sogginess than the non-irradiated control. In addition, ascorbic acid content of irradiated lettuce was 22–40% lower than the non-irradiated samples after 14 days of storage. The visual appearance of spinach was not affected by irradiation even at a dose of 4 kGy. Consumer acceptance suggested that more people would dislike and would not buy spinach that was treated at 3 and 4 kGy as compared to the non-irradiated sample. Overall, irradiation at doses of 1 and 2 kGy may be employed to enhance microbial safety of fresh-cut Iceberg lettuce and spinach while maintaining quality.     

Effect of gamma radiation on the physico-chemical properties of alginate-based films and beads

Alginate solution (3%, w/v) was prepared using deionized water from its powder. Then the solution was exposed to gamma radiation (0.1?25 kGy). The alginate films were prepared by solution casting. It was found that gamma radiation has strong effect on alginate solution. At low doses, mechanical strength of the alginate films improved but after 5 kGy dose, the strength started to decrease. The mechanism of alginate radiolysis in aqueous solution is discussed. Film formation was not possible from alginate solution at doses >5 kGy. The mechanical properties such as puncture strength (PS), puncture deformation (PD), viscoelasticity (Y) coefficient of the un-irradiated films were investigated. The values of PS, PD and Y coefficient of the films were 333 N/mm, 3.20 mm and 27%, respectively. Alginate beads were prepared from 3% alginate solution (w/v) by ionotropic gelation method in 5% CaCl₂ solution. The rate of gel swelling improved in irradiated alginate-based beads at low doses (up to 0.5 kGy).     

Effects of gamma and electron beam irradiation on the survival of pathogens inoculated into sliced and pizza cheeses

The objective of this study was to identify the efficacy of gamma and electron beam irradiation of the food-borne pathogens (Listeria monocytogenes and Staphylococcus aureus) in sliced and pizza cheeses commercially available in the Korean market. Total aerobic bacteria and yeast/mold in the cheeses ranged from 10² to 10³ Log CFU/g. Irradiation of 1 kGy for sliced cheese and 3 kGy for pizza cheese were sufficient to lower the total aerobic bacteria to undetectable levels (10¹ CFU/g). Pathogen inoculation test revealed that gamma irradiation was more effective than electron beam irradiation at the same absorbed dose, and the ranges of the D₁₀ values were from 0.84 to 0.93 kGy for L. monocytogenes and from 0.60 to 0.63 kGy for S. aureus. Results suggest that a low dose irradiation can improve significantly the microbial quality and reduce the risk of contamination of sliced and pizza cheeses by the food-borne pathogens which can potentially occur during processing.     

Analysis of shellfish by thermoluminescence and X-ray diffraction methods: Knowledge of gamma-ray treatment and mineral characterization

To investigate the detection of irradiated shellfish, seven kinds of shellfish samples were gamma irradiated at 3 and 6 kGy. The first-glow curves for all the control and irradiated shellfish samples were recorded between temperatures of 50 and 400 °C at a heating rate of 5 °C/s. All the samples, the first glow curves (TL₁) of which have been recorded, were re-irradiated at 1 kGy for the normalization of results. Their second glow curves (TL₂) were obtained at the same conditions in order to achieve the thermoluminescence (TL) ratios (TL₁/TL₂). The TL method proactively identified the whole shellfish samples by using the calcite, aragonite and quartz minerals that are present in the shells. The X-ray diffraction spectroscopy has been used as an analytical tool for the characterization of minerals that are present in the shells as inorganic materials along with biomaterial.     

Gamma irradiation improves the antioxidant activity of Aloe vera (Aloe barbadensis miller) extracts

Aloe has been widely used in food products, pharmaceuticals, and cosmetics because of its aromatic and therapeutic properties. In the present study, the ethanolic extracts of aloe gel were gamma-irradiated from 10 to 100 kGy. After gamma irradiation, the color of the ethanolic extracts of aloe gel changed to red; this color persisted up to 40 kGy but disappeared above 50 kGy. Liquid chromatography/mass spectrometry analysis demonstrated the production of a new, unknown compound (m/z=132) after gamma irradiation of the ethanolic extracts of aloe gel. The amount of this unknown compound increased with increasing irradiation up to 80 kGy, and it was degraded at 100 kGy. Interestingly, it was found that gamma irradiation significantly increased the antioxidant activity, as measured by the 1,1-diphenyl-2-picrylhydrazyl-radical scavenging capacity. The antioxidant activity of aloe extract was dramatically increased from 53.9% in the non-irradiated sample to 92.8% in the sample irradiated at 40 kGy. This strong antioxidant activity was retained even at 100 kGy. These results indicate that gamma irradiation of aloe extract can enhance its antioxidant activity through the formation of a new compound. Based on these results, increased antioxidant activity of aloe extracts by gamma rays can be applied to various industries, especially cosmetics, foodstuffs, and pharmaceuticals.     

Effects of gamma irradiation on two heat resistant moulds: Aspergillus fumigatus and Paecilomyces variotii isolated from margarine

The present study was undertaken to evaluate the effect of gamma irradiation on two heat-resistant moulds, namely Aspergillus fumigatus and Paecilomyces variotii isolated from margarine samples. The irradiation process of these moulds was carried out in a ⁶⁰Co gamma (γ) irradiator at average absorbed doses of 1, 3, 5 and 7 kGy for exposure times of 52, 156, 260 and 364 min, respectively. The average D₁₀ value for A. fumigatus was 1.08±0.08 kGy while it was 0.59±0.10 kGy for P. variotii. Consequently, the sensitivity of P. variotii against γ irradiation was more than A. fumigatus.     

Radiosensitivities of bacterial isolates on minced chicken and poached chicken meal and their elimination following irradiation and chilled storage

The radiosensitivities of Escherichia coli and Staphylococcus aureus on poached chicken meal (PCM) and minced chicken substrate (MCS) were determined. Effect of irradiation (0, 1, 2 kGy) on total viable cells (TVC) of PCM components was determined under chilled (3–5 °C) storage (0, 9, 14, 21 days) and challenge testing of the bacterial isolates with irradiation (0, 2, 3 kGy) was also conducted on PCM under chilled storage (0,7, 14, 21, 28 days). Additionally, sensory evaluation of the PCM components was assessed with irradiation (0, 2, 3 kGy) during chilled storage (0, 7, 14, 21 days). D₁₀ of E. coli on PCM and MCS were 0.18 and 0.25 kGy whiles those of S. aureus were 0.27 and 0.29 kGy, respectively. D₁₀ values for PCM<MCS and values for S. aureus>E. coli. 2 kGy controlled TVC and extended the shelf life of meals to ⩾14 days but 3 kGy was required to eliminate E. coli and S. aureus. Sensory qualities of the meal were not affected by an irradiation dose of 3 kGy.     

The effect of 60Co (γ-ray) irradiation on the electrical characteristics of Au/SnO2/n-Si (MIS) structures

The effect of ⁶⁰Co (γ-ray) irradiation on the electrical properties of Au/SnO₂/n-Si (MIS) structures has been investigated using the capacitance–voltage (C–V) and conductance–voltage (G/ω−V) measurements in the frequency range 1 kHz to 1 MHz at room temperature. The MIS structures were exposed to γ-rays at a dose rate of 2.12 kGy/h in water and the range of total dose was 0–500 kGy. It was found that the C–V and G/ω−V curves were strongly influenced with both frequency and the presence of the dominant radiation-induced defects, and the series resistance was increased with increasing dose. Also, the radiation-induced threshold voltage shift (ΔV_T) strongly depended on radiation dose and frequency, and the density of interface states N_ss by Hill–Coleman method decreases with increasing radiation dose.     

Physicochemical and functional characteristics of radiation-processed shrimp chitosan

The effects of gamma irradiation on chitosan samples were determined in terms of physicochemical and functional properties. Shrimp chitosan was extracted from shell using a chemical process involving demineralization, deproteinization, decolorization and deacetylation. Commercial snow chitosan was also used. Samples (in a solid state) were given irradiation dose of 25 kGy at a dose rate of 1.1013 kGy/h in air and 0 kGy samples were used as controls. Results showed that moisture contents were between 8.690% and 13.645%. There were no significant differences (P>0.05) in the degree of deacetylation of the chitosan samples. Significant differences (P<0.05) were observed in the viscosity and viscosity-average molecular weight of the chistosan samples. Viscosity and molecular weight decreased when the samples were given the irradiation dose of 25 kGy. Chitosan samples had low antioxidant activity compared with BHT. Water binding capacity ranged from 582.40% to 656.75% and fat binding capacity was between 431.00% and 560.55%. Irradiation had a major effect on the viscosity and the viscosity-average molecular weight of the chitosan samples.     

Effect of irradiation on kinetic behavior of Salmonella Typhimurium and Staphylococcus aureus in lettuce and damage of bacterial cell envelope

This study evaluated effect of gamma irradiation on survival of Salmonella Typhimurium and Staphylococcus aureus on lettuce and damage of cell envelope. S. Typhimurium and S. aureus were inoculated on red leaf lettuce, and they were irradiated at 0, 0.5, 1, 1.5, 2, 2.5, and 3 kGy, and the samples were then stored at 7 and 25 °C for 7 days. Survival of S. Typhimurium and S. aureus were enumerated on xylose lysine deoxycholate agar and Baird–Parker agar, respectively. D₁₀ value (dose required to reduce 1 log CFU/leaf) was calculated, and kinetic parameters (maximum specific growth rate; μ_max and lag phase duration; LPD) were calculated by the modified Gompertz model. In addition, cell envelope damage of the pathogens was observed by scanning electron microscope (SEM) and transmission electron microscope (TEM). D₁₀ values were 0.35 and 0.33 kGy for S. Typhimurium and S. aureus, respectively. During storage at 7 °C, S. Typhimurium and S. aureus had significant (P<0.05) growth only on non-irradiated samples up to about 2.5 and 4 log CFU/leaf at 0.42 and 1.28 log CFU/leaf/day of μ_max, respectively. At 25 °C, cell counts of S. Typhimurium and S. aureus on the samples irradiated at 0 and 0.5 kGy increased (P<0.05) up to 3–6 log CFU/leaf. The μ_max of both pathogens were higher in 0 kGy (1.08–2.27 log CFU/leaf/day) and 0.5 kGy (0.58–0.92 log CFU/leaf/day), and LPDs ranged from 1.53 to 3.14 day. SEM and TEM observations showed that cells irradiated at 1.5 and 3 kGy showed disrupted cell membrane. These results indicate that gamma irradiation could be a useful decontamination technology to improve food safety of lettuce by destroying cells of S. Typhimurium and S. aureus.     

Effect of gamma irradiation on microbial decontamination,and chemical and sensory characteristic of lycium fruit

Lycium fruit, popular traditional Chinese medicine and food supplement generally is ingested uncooked, was exposed to several doses of gamma irradiation (0–14 kGy) to evaluate decontamination efficiency, changes in chemical composition, and changes in sensory characteristic. In this study, lycium fruit specimens contained microbial counts of 3.1×10³–1.7×10⁵ CFU/g and 14 kGy was sufficient for microbial decontamination. Before irradiation, the main microbe isolated from lycium fruit was identified as a strain of yeast, Cryptococcus laurentii. After 10 kGy of irradiation, a Gram-positive spore-forming bacterium, Bacillus cereus, was the only survivor. The first 90% reduction (LD₉₀) of C. laurentii and B. cereus was approximately 0.6 and 6.5 kGy, respectively, the D₁₀ doses of C. laurentii and B. cereus was approximately 0.6 and 1.7 kGy, respectively. After 14 kGy irradiation, except the vitamin C content, other chemical composition (e.g., crude protein, β-carotene, riboflavin, fructose, etc.) and the sensory characteristic of lycium fruit specimens did not have significant changes. In conclusion, 14 kGy is the optimal decontamination dose for lycium fruit for retention of its sensory quality and extension of shelf life.     

Gamma rays as an effective tool for removing undesirable color without adverse changes in biological activities of red beet extracts

The ethanolic extracts of red beet (Beta vulgaris L.) hairy root were used to investigate the removal of color and improvement of biological activity for enhanced industrial applications. The extracts were exposed to gamma rays ranging from 2.5 to 30 kGy. The red beet hairy root is composed of two major red-colorants, betanin and isobetanin. Gamma ray radiation at 5 kGy remarkably reduced the levels of the major colorants by 94% and the reddish color was eliminated by doses greater than 10 kGy. Color removal was likely due to the gamma ray radiolysis of ethanol. Although details on the mechanism responsible for the decay of the chromophore have not been entirely determined, our results suggest that the free radicals that are produced during this process are capable of destroying the chromophore group in isobetanin, thus bleaching the substrate solution. In spite of the degradation of the major colorants, the biological activities of constituents of the extract such as DPPH radical scavenging and tyrosinase inhibition were negligibly affected by the gamma ray radiation up to 20 kGy. The antioxidant activity was 92.7% in control samples and 90.0–92.0% in irradiated samples (2.5–20 kGy), and a slight decrease to 87.5% was observed for gamma ray radiation at 30 kGy. In addition, tyrosinase inhibition activity has also the same pattern; the activity is slightly increased from 50.7% of control to 49.1–52.8% of irradiated samples (2.5–20 kGy) with a 46.8% at 30 kGy.