Viscosity and IR investigations in the Li2O---B2O3 system

The high viscosity in melts of the Li₂O---B₂O₃ system makes it very difficult to grow large crystals of lithium triborate. The viscosity and IR characteristics of molten li₂O---B₂O₃ system are reported in this paper. When the temperature increases the viscosity of li₂O---B₂O₃ system decreases and follows an Arrhenius-type relationship. With an increasing 13203 ratio in Li₂O---B₂O₃ melts, the viscosity rises gradually to a maximum with a composition Li₂O: 3.513203 then it falls rapidly. In order to find active agents to reduce the viscosity, Na₂O, NaCl, LiF, P205, M003, W03 etc oxides were added to Li₂O---B₂O₃ samples respectively and investigated using the orthogonal method. The experimental results show that the addition of acidic oxides can significantly decrease the viscosity in the Li₂O---B₂O₃ system. For Li₂O: 4.513203, an ideal additive agent is 20wt% Li₂O:: 2MoO₃. Near the composition for crystal growth, the percentage reduction of viscosity is 62.2%. The IR spectra of Li₂O---B₂O₃ system revealed that the BO₄⁻/NO₃⁻ ratio is reduced in the melt using Li₂O: 2MoO₃ as an additive. It is proposed that the M003 reduced the concentration of bridging oxygen atoms of BO₄⁻. The change of structure explains the decline in the viscosity. In the crystal structures of lithium triborate, the matrix spaces are so small that larger other cations than Li+ are very difficult to enter the crystal matrix. So the use of additive agents to reduce the viscosity is a possible method if no new phase appears.     

Raman spectrum studies of the glasses in the system Na2O---Al2O3---P2O5

Raman spectra of ternary sodium aluminosphosphate glasses indicate that for glasses with Al₂O₃/P₂O₅<0.63, the glass network is mainly built up of (PO₃)_n^n- chains and rings or different kinds of phosphate groups and AlO₄ tetrahedra; for glasses with Al₂O₃/P₂O₅>0.63, the glass network is mainly built up of AlPO₄ groups.     

Molecular dynamics simulation of the mixed anion glasses Li4SiO4---Li3BO3

The structure and the mixed anion effect in the conductivity have been examined for the mixed anion glasses Li₄SiO₄---Li₃BO₃ by molecular dynamics (MD) simulation and X-ray diffraction (XRD) analysis. Structure factors derived from the MD simulation are in good agreement with those from derived from the XRD analysis of the actual glasses, showing that the MD simulation successfully reproduces the actual glass structure. Moreover, the enhancement of the diffusion coefficients of the Li⁺ ions in the middle of the composition range in the system Li₄SiO₄---Li₃BO₃ is simulated by the MD calculation. Structural analysis of the glasses derived from the MD simulation revealed that the increase in the halfwidth of the modified radial distribution function of the Li---O pairs due to the mixing of two ortho-oxoanions is one of the factors in the origin of the mixed anion effect in the conductivity.     

Cation site occupation by Ag/Na ion-exchange in R2O–Al2O3–SiO2 glasses

Ag⁺/Na⁺ ion-exchanged R₂O–Al₂O₃–SiO₂ glasses with uniform concentration profile of Ag⁺ and Na⁺ were prepared by heat treatment in molten silver salt followed by holding at the same temperature in an ambient atmosphere. Their glass transition temperature (T_g) and thermal expansion coefficient (TEC) were measured and structures were investigated using ²⁹Si-MAS NMR, ²⁷Al-MAS NMR, IR and Raman spectroscopies. Both T_g and TEC decreased with increase of the exchange ratio, but T_g was still above the ion-exchange temperature of 400°C even for the fully exchanged sample. The ²⁹Si- and ²⁷Al-MAS NMR spectra were mostly unchanged and no sign of the structural alteration of the glass network was observed. On the other hand, the vibrational spectra showed remarkable peak shifts depending on the exchange ratio. From these structural results, it was found that when the exchange ratio was low, the introduced Ag⁺ ions were stabilized at the non-bridging oxygen (NBO) site, and then Na⁺ ions in AlØ₄ site were exchanged by Ag⁺ ions after full replacement of NBO sites, where Ø represents the bridging oxygen.     

Diffraction study of Li2O·SiO2 glass with computer simulation

The structure of Li₂O·SiO₂ glass has been determined by the pair-function analysis of the radial distribution function (RDF) obtained by X-ray and neutron diffraction measurements. The structure models were constructed by the molecular dynamics method (MD). The calculated RDFs, the summation of the pair-functions of the model, were compared with the observed RDFs while varying the MD parameters. Taking advantage of the negative scattering length of Li for neutron diffraction, the glass structure was investigated in detail, and it was found that the chains of SiO₄ tetrahedra bend at 20 °, which is a little less than for the crystal (23.48 °). It is known that the larger the size of the alkali ions (Na⁺ → K⁺ → Cs⁺), the smaller the bending angle of the chains. It was found that this rule also applies to Li⁺.     

Effect of Si3N4 on chemical durability of chalcogenide glass

Chemical durability of the Si₃N₄ doped (up to 0.5 wt%) chalconitride glasses was evaluated by weight losses of glass samples after immersion in deionized water, H₂SO₄, HCl and NaOH solutions. IR spectra and SEM were used as an aid to examine the surface structure of corroded glass samples. Weight loss measurements showed a poorer stability of non-oxide glasses in basic solution than in acid solution, and the Si₃N₄ doping was found to improve chemical durability. Comparison of IR spectra of samples exposed to the basic solution with their original ones suggested the higher content of OH⁻ in its reaction layers, indicating that the corrosion of the present non-oxide glasses in the basic solution may result from the breakdown of the bridging Se due to an attack launched by OH⁻. The SEM evidence confirmed that Si₃N₄ doping did hinder the OH⁻ attacks on Ge and/or As, which is most likely related to incorporation of the three-coordinated N into the glass network, as supported by a comparison of the IR transmitting spectrum between uncorroded chalconitride glass and undoped chalcogenide glass.     

Ab initio study of NMR spectra of Li2S–SiS2 glass system

We obtained the chemical shielding constants of ²⁹Si in Li₂S–SiS₂ glass system on the basis of molecular orbital calculations. The relative chemical shieldings calculated at the HF/6-31G* level is −16.1 and −23.8 ppm for E(1) and E(0), respectively. These calculations are in good agreement with the previous NMR study: σ(E(2))>σ(E(1))>σ(E(0)). It is found theoretically that incorporation of Li₂S into SiS₂ does not influence the ²⁹Si chemical shift, while incorporation of Li₂O into SiO₂ does to a significant extent. It is also found that the existence of oxygen in Li₂S–SiS₂ glasses increases the chemical shielding of ²⁹Si by about 25 ppm, which is in good agreement with the experimental result.     

Flux growth of BPO4 crystals

Single crystals of BPO₄ with sizes up to 15×10×12 mm³ were grown by top-seeded solution growth method using Li₂O–Li₄P₂O₇ as fluxes. The components volatilized from the melt were characterized by the method of X-ray powder diffraction. The defects of grown crystals have also been investigated. The measured ultraviolet cutoff edge of BPO₄ was about 130 nm. Its density was 2.82 g/cm³ determined using drainage method.     

B NMR investigations in xV2O5–B2O3 and xV2O5–B2O3–PbO glasses

11B (I=3/2) MAS NMR in the binary glass system xV₂O₅–B₂O₃ (x=0.053, 0.43) and the ternary glass system xV₂O₅–B₂O₃–PbO (0.1x1.5) has been investigated at room temperature. In the xV₂O₅–B₂O₃ glasses, one NMR line due to BO₃ unit was observed. Meanwhile in the xV₂O₅–B₂O₃–PbO, two NMR lines which arise from BO₃ and BO₄ units were detected, where the appearance of BO₄ units is produced by the presence of PbO. From the computer-simulation of the ¹¹B NMR central transition line (m=−1/2↔1/2), the quadrupole parameters (e²qQ/h and η) for BO₃ units in xV₂O₅–B₂O₃, and those for BO₃ and BO₄ units in xV₂O₅–B₂O₃–PbO were obtained as a function of x. As the V₂O₅ content increases in xV₂O₅–B₂O₃–PbO, the e²qQ/h and η values of the BO₃⁻ associated resonance are found to slightly decrease and increase, respectively. Meanwhile, the e²qQ/h and η values of BO₄⁻ associated resonance in xV₂O₅–B₂O₃–PbO are found to slightly increase and decrease, respectively. By comparing the intensities of the total transitions (m=−3/2↔−1/2,m=−1/2↔1/2, and 1/2↔3/2) for the ¹¹B NMR line of BO₃ and BO₄ units contained in xV₂O₅–B₂O₃–PbO with those of respective standard samples of 0.053V₂O₅–B₂O₃ and NaBH₄, the quantitative fractions of BO₃ and BO₄ in xV₂O₅–B₂O₃–PbO were obtained as a function of x.     

Glass formation in the PbBr2–PbCl2–PbF2–PbO–P2O5 system

New glasses in the PbBr₂–PbCl₂–PbF₂–PbO–P₂O₅ system have been prepared and characterized. The glass-forming regions have been explored and the stability of the glasses against crystallization studied. Results show that the PbBr₂–PbCl₂–P₂O₅ ternary system has a broad glass-forming region which extends to 30 mol% P₂O₅. Most of the glasses in this system show strong stability against crystallization and some have glass transition temperatures as low as 146°C. When 5% PbO or 5% PbF₂ is introduced into the PbBr₂–PbCl₂–P₂O₅ system, the glass-forming region becomes smaller and the glass transition temperatures increase. However, the introduction of 2.5% PbF₂ and 2.5% PbO into the ternary system increases the glass transition temperature and broadens the glass-forming region. The introduction of PbF₂ alone improves the glass-forming ability of the system while the introduction of PbO alone lowers the glass-forming ability.     

Raman spectra of rapidly quenched glasses and melts containing large amounts of Li2O

Raman spectra were measured of rapidly quenched glasses and the corresponding liquids in binary and ternary (pseudobinary) systems composed of Li₂O and several glass-forming oxides such as B₂O₃, P₂O₅, and/or SiO₂. The fractions of the various structural units present were determined from the deconvoluted Raman peaks. Glasses with large amounts of Li₂O were composed of discrete structural units such as ortho-oxoanions and pyro-oxoanions. Based on these data the structural units in the glasses and the corresponding liquids were identical, although in some cases those in the corresponding crystals were different. In the pseudobinary systems combining pyro-oxosalts of lithium borate, phosphate and silicate, non-bridging oxygens were preferentially formed at the phosphate structural units rather than at the borate or silicate structural units. This order of preference was consistent with that of the acidity of the glass-forming oxides in the liquids.     

Optical absorption and elastic properties of Li2O---(LiCl)2---B2O3---Al2O3 glasses

Ultraviolet transmission, densities, and supersonic velocities of the Li₂O---(LiCl)₂---B₂O₃---Al₂O₃ glasses were measured. Adiabatic compressibilities of all these glasses were calculated. The results were interpreted from the viewpoint of the glass structure.     

Determination of diffusion coefficient of titanium ion in TiO2---SiO2 wet gel prepared from metal alkoxides during leaching

It was found that the radial gradient refractive index (r-GRIN) glass rod could be produced by the leaching of wet gel prepared by a sol-gel method from metal alkoxides and heat-treatment of the gel. The concentration gradient of the doped component resulting from its diffusion in the wet gel was studied. In order to estimate the exact diffusion coefficient of the titanium ion in the binary TiO₂---SiO₂ wet gel, its value was measured by using two methods. The observed diffusion coefficient by colorimetric analysis was about 1.1 × 10⁻⁶ cm²/s, while the value obtained from analysis of EPMA was about 1.2 × 10⁻⁶ cm²/s, and both values were nearly equal to each other. The activation energy of titanium ion diffusion in the wet gel was estimated to be about 11 kcal/mol.     

Migration of Cu ions in Cu2O---Al2O3---SiO2 glasses on heating in air

The behavior of copper ions in the Cu₂O·Al₂O₃·4SiO₂ (in moles) glass on heating in air at temperatures up to 500°C was studied. When the glass, in which about 90% of Cu was present as Cu⁺ ions, was heated in air above 300°C, a CuO layer was formed on the surface. The amount of CuO was increased with heating temperature and time, corresponding to the decrease in weight of the glass. Furthermore, the fraction of Cu²⁺ ions in the glass increased. These observations suggest that oxygens do not diffuse into the glass, but Cu⁺ ions migrate to the surface from the interior to balance the surplus positive charge produced by the oxidation of Cu⁺ to Cu²⁺ ions inside the glass. The following reaction scheme for the formation of the CuO layer was proposed; 2Cu⁺(interior) + ₂¹O₂(surface) → Cu²⁺(interior) + CuO(surface).     

Phase relations around langasite (La3Ga5SiO14) in the system La2O3–Ga2O3–SiO2 in air

Phase relations around langasite (LGS, La₃Ga₅SiO₁₄) were studied on the basis of phase assemblage observed during calcination and crystallization process of samples of various compositions in the ternary system La₂O₃–Ga₂O₃–SiO₂. A ternary compound of apatite structure, La₁₄Ga_xSi_9–xO_39–x/2 was found for the first time. Crystallization of this compound was observed in the cooling process of molten samples of stoichiometric LGS as well as LGS single crystal, demonstrating that LGS is an incongruent-melting compound. A phase diagram was established primarily based on the crystallization sequence in the cooling process.     

Some characteristics of glass in the Al2O3---B2O3---SiO2 system from the gel

The colorless and transparent glasses in the Al₂O₃---B₂O₃---SiO₃ system with high B₂O₃ and SiO₂ content were prepared from gels at low temperature. Their IR spectra not only revealed the evolution of the gel to glass conversion, but also showed that the formation of mixed bonds in the glasses obtained did not show any effect due to the B₂O₃ content. The accuracy of the glass composition is dependent upon the SiO₂/B₂O₃ molar ratio. The higher the ratio, the less the deviation of the analyzed compositions of the resulting glasses from their original calculated values. It is obvious that the higher the ratio, the lower the thermal expansion coefficient and the higher the transformation temperature of the glass, and the temperature at which the thermal contraction reaches an equilibrium is higher.     

H2SO4-H2O中硝酸铜对脱硫石膏晶须生长的影响

以处理后的脱硫石膏为原料,在H₂SO₄-H₂O体系中以Cu(NO₃)₂为晶形控制剂采用水热法制备脱硫石膏晶须,探讨了Cu(NO₃)₂对脱硫石膏晶须生长的影响机理。结果表明:Cu(NO₃)₂对脱硫石膏有明显促溶作用,其中Cu²⁺可减小溶液中各离子的活度系数,使溶液中的Ca²⁺浓度增大。NO^-₃通过静电作用在Ca²⁺周围聚集并对SO^2-₄产生屏蔽作用,导致脱硫石膏继续溶解并使Ca²⁺和SO^2-₄的浓度处于相对稳定状态,有利于半水脱硫石膏晶体的形核与生长。此外,Cu²⁺还可在晶须的生长过程中选择性吸附在晶须表面,生成CuSO₄,促进了脱硫石膏的结晶生长,最终在Cu(NO₃)₂用量为2.0%(质量分数)时制备的脱硫石膏晶须长径比约为73。     

Study of crystallisation of the Li2O---ZnO---Al2O3---SiO2 system glasses

This paper deals with the relationship between phase separation and crystal morphology in the Li₂O---ZnO---Al₂O₃---SiO₂ system glasses, and investigates the effect of the nucleating agent on the microstructure of glass-ceramics, and the effects of heat treatment temperature on the properties of the microstructure.     

Glass formation, properties and structure of glasses in the P2O5---WO3---K2O---Al2O3 system

Glass formation in the P₂O₅---WO₃---K₂O---Al₂O₃ system was investigated and the glass-forming regions are presented.

the properties of the glasses in the P₂O₅---WO₃---K₂O---Al₂O₃ system (Al₂O₃ 8 mol.%) are reported.

The colouration of glass was studied. It was found that W⁵⁺ ions make glass blue.

Infrared spectra were measured by means of making KBr pills. Results of the investigation suggest that P---O---P, P---O---W, and W---O---W bonds form a continuous network in the phosphate glasses. So we suggest that tungsten trioxide is a glass former.     

Preparation and physical properties of amorphous V2O5 containing TiO2, Na2O or Li2O

V₂O₅ gels containing up to 18 mol% of TiO₂ were obtained through the simultaneous hydrolysis of alkoxides in ethanol solution. V₂O₅ gels containing Na₂O or Li₂O were obtained through the ion exchange method. The crystallization temperature, T_cr, of the gels increased and the H₂O content of the gels decreased by the addition of TiO₂ or Na₂O. These additives seem to stabilize the amorphous state of the gels. On the other hand, T_cr and the H₂O-content slightly varied with the addition of Li₂O. No ionic polarization was observed in coating films of the gels dried at temperatures below T_cr. The dc conductivity of the films was anisotropic, and increased with the addition of Li₂O or Na₂O. However, it decreased with increasing TiO₂ content. The fiber-like structure of gels was observed by TEM. The gels obtained from alkoxides were thin and short in comparison with the gels obtained through the ion exchange method.