Crystallization behavior of glasses in the system of Na2O-CaO-MgO-Fe2O3-Al2O3-SiO2 with high contents of nickel oxide

The structural behavior of nickel oxide in glassy and glass-ceramic materials, obtained in the system of Na₂O-CaO-MgO-Fe₂O₃-Al₂O₃-SiO₂, was investigated. The influence of the NiO content on the vitrification, crystallization, structure and exploitation properties of two model compositions, with different ratios [CaO]/[MgO] was analyzed. On the basis of DSC and XRD data, it is shown that NiO promoted the formation of bunsenite crystals, as nuclei for crystallization. On the other hand, NiO promoted formation of pyroxenes even for compositions with low MgO contents, which formed gehlenite without NiO admixtures. It is shown that in the composition with relatively high MgO contents, NiO could participate in the formation of two types of pyroxenes with the structure and chemical composition similar to (MgO_0.4NiO_0.6)(CaO_0.9NiO_0.1)Si₂O₆ and diopside-hedenbergite solid solutions. The optimal contents of NiO in both model compositions was about of 7 wt%, since higher contents reduced the exploitation properties. The glass-ceramics with optimal contents of NiO were also produced using Ni bearing galvanic slurry and coal ash; the resulting materials showed similar exploitation properties to those mentioned above.     

Density-structure correlations in Na2O-CaO-P2O5-SiO2 bioactive glasses

Relations for Na₂O-CaO-SiO₂ glasses have been developed to calculate the density of Na₂O-CaO-P₂O₅-SiO₂ bioactive glasses. The calculation makes use of NMR results of O’Donnell et al. indicating that P₂O₅ forms a separate phase, containing Na₃PO₄ and Ca₃(PO₄)₂, in the investigated glasses. The volume of the silicate units is the same as that found in Na₂O-CaO-SiO₂, Na₂O-SiO₂, and CaO-SiO₂ glasses. Similarly, the volume of PO₄ units is equivalent to that in Na₃PO₄ and Ca₃(PO₄)₂. Calculated densities are consistent with the experimental data.     

Vitrification and crystallization in the system of K2O-B2O3-TiO2

The vitrification and crystallization behavior of melts produced at 1400 °C in the ternary system of K₂O-B₂O₃-TiO₂ is investigated. It is shown that there are two fields of compositions (indicated in mol%) which allow obtaining the glass-ceramic materials with continuous glassy matrix after the cooling of molten compositions. In the first field [TiO₂] = 25-57, [K₂O] = 30-50 and [B₂O₃] = 0-25, the glass-ceramics consisted of the potassium-titanium-borate glassy phase and different crystalline potassium titanates (K₄Ti₃O₈, K₂Ti₂O₅, K₂Ti₄O₉, K₂Ti₆O₁₃). The ratio of TiO₂:K₂O in the obtained titanates increases with [TiO₂] and [B₂O₃]. In the second field, [TiO₂] = 7-37, [K₂O] = 0-25 and [B₂O₃] = 52-93, the obtained glass-ceramics consisted of a similar vitreous phase, as mentioned above, and TiO₂ crystals. During the cooling of the melts, short whiskers-like crystals of anatase formed in the compositions with relatively low [TiO₂] and relatively high [K₂O], whereas long fiber-shaped crystals of rutile appeared with the compositions characterized with relatively high [TiO₂] and relatively low [K₂O]. The possible application of the obtained glass-ceramic materials as a source of fibrous TiO₂, for composite reinforcement, and as solid lubricants is discussed.     

Electrical conductivity of NbN-SiO2 films obtained by ammonolysis of Nb2O5-SiO2 sol-gel derived coatings

The studies of electrical conductivity of NbN-SiO₂ films are reported. To obtain these films, sol-gel derived xNb₂O₅-(100 − x)SiO₂ (where x = 100, 90, 80, 70, 60, 50 mol%) coatings were nitrided at 1200 °C. The nitridation process leads to the formation of some disordered structures, with NbN metallic grains dispersed in insulating SiO₂ matrix. The structure of the samples was studied using X-ray diffraction (XRD) and atomic force microscopy (AFM). The electrical conductivity was measured with the conventional four-terminal method in the temperature range from 5 to 280 K. The superconducting transition was not observed even for the sample that does not contain silica. All the samples exhibit negative temperature coefficient of resistivity. The results of conductivity versus temperature may be described on the grounds of a model proposed for a weakly disordered system.     

Ac conductivity and dielectric relaxation in ionically conducting soda-lime-silicate glasses

The frequency dependent conductivity and dielectric relaxation of alkali ions in some soda-lime-silicate (Na₂O-CaO-SiO₂) glasses are investigated over a frequency range from 50 Hz to 1 MHz and in a temperature range from room temperature to 603 K by using alternating current impedance spectroscopy. The conductivity isotherms show a transition from frequency independent dc region to dispersive region where the conductivity continuously increases with increasing frequency. The electric modulus representation has been used to provide comparative analysis of the ion transport properties in these glasses. The scaling behavior of imaginary part of electric modulus indicates that all dynamical processes occurring at different frequencies give the same activation energy.     

Thermal and some physical properties of glasses in the La2O3−CaO−B2O3 ternary system

Glasses in the La₂O₃−CaO−B₂O₃ ternary system were studied. The glass forming range as determined by the appearance of the annealed cast was found to match previously published findings. Clear glasses were formed in the composition range of 5.7−19.1 mol% La₂O₃ with constant B₂O₃ content of 71.4 mol%, and in glasses of constant La₂O₃:CaO ratio of 1:4 with B₂O₃ content in the range of 71.4-55.0 mol%. The non-linear optical crystalline phase La₂Ca₂B₁₀O₁₉ was crystallized from the clear glasses after heat treatments, as determined by powder XRD. Two types of the LaBO₃ crystalline phases were detected in the partially and the fully crystallized glass compositions outside the glass forming range. Data are reported for the glass transition temperature (T_g), dilatometric softening point (T_d), linear coefficient of expansion (α), onset crystallization temperature (T_x), exothermal peak temperature (T_P), density (ρ) and index of refraction (n_D) in the clear glasses.     

Phase separation and crystallization in the system SiO2-Al2O3-P2O5-B2O3-Na2O glasses

The phase separation and crystallization behavior in the system (80 − X)SiO₂ · X(Al₂O₃ + P₂O₅) · 5B₂O₃ · 15Na₂O (mol%) glasses was investigated. Glasses with X = 20 and 30 phase separated into two phases, one of which is rich in Al₂O₃-P₂O₅-SiO₂ and forms a continuous phase. Glasses containing a larger amount of Al₂O₃-P₂O₅ (X = 40 and 50) readily crystallize and precipitates tridymite type AlPO₄ crystals. It is estimated that the phase separation occurs forming continuous Al₂O₃-P₂O₅-SiO₂ phase at first, and then tridymite type AlPO₄ crystals precipitate and grow in this phase. Highly transparent glass-ceramics comparable to glass can be successfully obtained by controlling heat treatment precisely. The crystal size and percent crystallinity of these transparent glass-ceramics are 20-30 nm and about 50%, respectively.     

The structure of SiO2-GeO2 glasses: A spectroscopic study

Four glasses of the SiO₂-GeO₂ binary system have been synthesized via a sol-gel route followed by a heat treatment and a quench. Glass structure has been determined by Ge K-edge X-ray absorption spectroscopy (XAS) at low temperature and Raman spectroscopy. These mixed glasses present a continuous random network of interconnected GeO₄ and SiO₄ tetrahedra, with GeO₄ tetrahedra similar to the GeO₄ units in GeO₂ glass and continuous compositional variations from GeO₂-rich regions to SiO₂-rich regions. Such a random mixture is consistent with physical properties of these binary glasses as well as with the chemical dependence of their polyamorphism at high pressure. This EXAFS-derived mean Ge-O-Si angles are close to the Ge-O-Ge mean angle in GeO₂ glass, 134° and 130°, respectively. This misfit with the Si-O-Si angles might explain the ease of formation of isolated and pair defects centers, which are suspected to be at the origin of photo-induced modifications of optical properties in Ge-bearing SiO₂ glasses.     

Solubility of glasses in the system P2O5-CaO-MgO-Na2O-TiO2: Experimental and modeling using artificial neural networks

Phosphate glasses in the system P₂O₅-CaO-MgO-Na₂O-TiO₂ for use as degradable implant materials were produced. In order to classify their solubility behavior, dissolution experiments were performed in deionized water for 60 min at 98 °C. Resulting solutions were analyzed using ICP-OES. In addition, pH measurements were carried out in physiological NaCl solution. With increasing phosphorus oxide content, the glasses showed a higher solubility and gave lower pH values in aqueous solution. This was caused by changes in the glass structure, as long phosphate chains are more susceptible to hydration than smaller phosphate groups. These changes in glass structure were followed by ³¹P MAS-NMR experiments. Increasing sodium oxide concentrations in exchange for calcium or magnesium oxide also increased the glass solubility by disrupting ionic cross links between chains. By contrast, addition of titania made the glasses more stable towards dissolution by cross linking smaller phosphate groups. The aim of this study was to find a relationship between glass composition and solubility behavior. As classical linear methods of data analysis were unsuitable due to the complexity of the relationship, preliminary artificial neural networks analyses were performed and were found to be an interesting tool for modeling the solubility behavior of phosphate glasses.     

Glasses and glass-ceramics in the oxyfluoride ternary system Pb(PO3)2-WO3-PbF2

Glasses were prepared by the melt-quenching method in the ternary system Pb(PO₃)₂-WO₃-PbF₂ and doped with Er³⁺ in order to prepare luminescent transparent glass-ceramics. This work focused on thermal and structural characterization of tungsten lead-phosphate glasses and crystallization study for preparing transparent glass-ceramics. Thermal properties such as thermal stability and crystallization behavior upon heating were investigated by DSC in function of PbF₂ content. For low PbF₂ concentrations, only one crystallization peak due to Pb₃(PO₄)₂ is observed whereas samples containing more than 15% of PbF₂ present another exothermic event at lower temperatures related with precipitation of PbF₂, Pb₂P₂O₇ and Pb₂OF₂. Structural investigations by Raman spectroscopy suggest that PbF₂ modifies the tungsten-phosphate network through the formation of P―F and P―O―Pb bonds but the average network connectivity remains almost constant. A crystallization study has been performed by DSC to investigate the dominant crystallization mechanisms in these glasses and it has been established that Pb₃(PO₄)₂ is nucleated on the surface whereas PbF₂, Pb₂P₂O₇ and Pb₂OF₂ crystallize dominantly from the glassy bulk. Transparent glass-ceramics containing nanosized PbF₂ crystallites were also prepared by suitable heat-treatment on the glass sample containing 20% of PbF₂ and Raman microscopy of these glass-ceramics supports the crystallization mechanisms determined by DSC.     

Sodium tracer diffusion in glasses of the type (CaO·Al2O3)x(2 SiO2)1−x

Tracer diffusion coefficients of the radioactive isotope Na-22 were measured in glasses of the type (CaO·Al₂O₃)_x(2 SiO₂)_1−x to study the diffusion of sodium as a function of glass composition, x, temperature and initial water content. The diffusion of Na-22 in glasses diffusion-annealed in dry air can always be well described by a single tracer diffusion coefficient, but sometimes not in samples annealed in common air. It was found that the sodium tracer diffusion coefficient decreases by about six orders of magnitude when the glass composition x changes from 0 to 0.75 at 800 °C. The temperature dependence of the diffusion of sodium seems to decrease as the silica content increases. Variations of the initial water content in some of the glasses investigated did not very significantly influence the rate of the tracer diffusion of sodium.     

The effect of composition on UV-vis-NIR spectra of iron doped glasses in the systems Na2O/MgO/SiO2 and Na2O/MgO/Al2O3/SiO2

Glasses with the compositions xNa₂O · 10MgO · (90 − x)SiO₂, 10Na₂O · xMgO · (90 − x)SiO₂, 5Na₂O · 15MgO · xAl₂O₃ · (80 − x)SiO₂, xNa₂O · 10MgO · 10Al₂O₃ · (80 − x)SiO₂, 10Na₂O · 10MgO · xAl₂O₃ · (80 − x)SiO₂, 10Na₂O · 5MgO · 10Al₂O₃ · (80 − x)SiO₂ were melted and studied using UV-vis-NIR spectroscopy in the wavenumber range from 5000 to 30 000 cm⁻¹. At [Al₂O₃] > [Na₂O], the UV-cut off is strongly shifted to smaller wavenumbers and the NIR peak at around 10 000 cm⁻¹ attributed to Fe²⁺ in sixfold coordination gets narrower. Furthermore, the intensity of the NIR peak at 5500 cm⁻¹ increases. This is explained by the incorporation of iron in the respective glass structures.     

Effect of ZnO and Bi2O3 addition on linear and non-linear optical properties of tellurite glasses

Glasses in the system TeO₂-Bi₂O₃-ZnO were studied with respect to their linear refractive indices and optical absorption in the UV-vis range. The third order non-linear refractive indices were measured using degenerated four wave mixing (DFWM). The optical Kerr susceptibilities calculated hereof were in the range from 5.49 to 6.58 × 10⁻¹³ esu and hence 34-41 times larger than that of fused SiO₂. They are roughly proportional to values theoretically calculated by the theory of Lines.     

The structure and optical properties of GeO2-GeS2 glasses

Oxy-chalcogenide glasses with compositions of xGeO₂-(100 − x)GeS₂, where 0 ? x ? 100 mol%, have been prepared and studied in terms of their structures and optical properties. X-ray fluorescence spectroscopy shows that Ge:S ratio can deviate from GeS₂ by ∼10 at.%, depending critically upon the preparation conditions. Raman scattering spectroscopy suggests that stoichiometric GeO₂-GeS₂ glasses have a heterogeneous structure in the scale of 1-100 nm. The optical gaps are nearly constant at 3.0-3.5 eV for glasses with 0 ? x ? 80 mol% and abruptly increase to ∼6 eV in GeO₂. This dependence suggests that the optical gap is governed by GeS₂ clusters, which are isolated and/or percolated. Composition-deviated glasses appear as orange and brown, and these glasses seem to have more inhomogeneous structures.     

Remark on the optical gap in ZnO-Bi2O3-TeO2 glasses

Four ZnO-Bi₂O₃-TeO₂ glasses were prepared from high purity (4N5) oxides. From measurements of the optical transmission on very thin bulk samples the optical gap was determined at around 3.55 eV for the glasses studied. The temperature dependence of the optical gap was also determined from the room temperature close up to 500 K. Preliminary Raman scattering measurements indicate that with a decrease in TeO₂ content, TeO₄ trigonal bipyramid transformation proceeds into TeO₃ trigonal pyramids.     

Synthesis and characterization of calcium phosphate based bioactive quaternary P2O5-CaO-Na2O-K2O glasses

Calcium phosphate based bioactive quaternary glass systems P₂O₅-CaO-Na₂O-K₂O were prepared by melt growth technique. Glasses were prepared in five different compositions by fixing P₂O₅ at 47 mol% and CaO at 30.5 mol% and by varying the K₂O and Na₂O concentrations. The structural properties of the glasses are analyzed using X-ray diffraction (XRD) studies and scanning electron microscopy (SEM) studies; and the composition of the glasses are studied using energy dispersive X-ray spectrum (EDS). The microhardness of the glass systems are studied by Vickers hardness measurements and the bioactivity of the glasses are studied using in vitro study. The thermal properties have been examined by means of thermogravimetric analysis (TGA) and differential thermal analysis (DTA). The ultrasonic velocity measurements show that the addition of K₂O contents produces non-bridging oxygen ion and hence weaken of the glass structure. The weakening of the glass structure reduces the ultrasonic velocity and hence an increase in attenuation.     

Chemical durability of Na2OCaOSiO2 glasses in acid solutions

The resistance of Na₂OCaOSiO₂ glasses to acid solutions has been studied. The compositions studied were Na₂O · 4SiO₂, Na₂O · x CaO · (4?x) SiO₂ and a common electrode glass containing 22.63Na₂O and 5.58 CaO, mol%. The reaction was made at 40°C for about 3 h in 1N solutions of HCl, HNO₃ and H₂SO₄. Powdered glass samples were used and the reaction was followed by analyzing the solution for soda, lime and silica.The extraction rates of each constituent were measured. The effect of acid concentration was also studied for each glass using 10^?3–10N solutions of the three acids for a fixed time. The quantity of calcium extracted increased slowly at first with increasing calcium content in the glass, but rapidly when the lime content exceeded ≈10 mol%. Above this concentration, both calcium and sodium appears to pass into solution in the same proportion in which they are present in the glass. The extraction rate was found to depend on the type and concentration of the acid used, being least in H₂SO₄ and much higher and almost equal in both HCl and HNO₃.An attempt was made to correlate the results of decomposition of the soda-lime-silica glasses to their membrane potentials in acidic solutions.     

Effects of Li replacement on the nucleation, crystallization and microstructure of Li2O-Al2O3-SiO2 glass

The Li replacement including the Li₂O replaced by other oxides and the expensive Li₂CO₃ replaced by low-cost spodumene mineral was studied to lower the product cost of (Li₂O-Al₂O₃-SiO₂, LAS) glass ceramic, and the effects of Li replacement on the nucleation, crystallization and microstructure of LAS glass were investigated by the differential thermal analysis (DTA), X-ray diffraction (XRD) and scanning electron microscopy (SEM). The results show that Li₂O replacement increases the crystallization activation energy, lowers the crystal growth, and increases the nucleation and crystallization temperature by restraining the formation of crystalline phases. The Li₂CO₃ replacement decreases the crystallization activation energy, promotes the crystal growth, without affecting the nucleation, and lowers the crystallization temperature by adding some beneficial compositions with mixed alkali effect.     

Magnetic properties of partially crystallized Na2OFe2O3SiO2 glass

The magnetic properties of partially crystallized glasses of the Na₂OFe₂O₃SiO₂ system which had undergone thermal treatments of different durations and intensities leading to phase separation, have been measured in order to investigate the influence of magnetic grain growth. Magnetic moments were evaluated at liquid helium temperature in fields up to 76 kOe. The magnetic susceptibilities of some of the samples have been measured between 4.2 and 300 K. They were shown to depend strongly on the dimensions of the grains, i.e. on the thermal treatment of each sample. The anomalous values observed are discussed in terms of the apparent presence of superantiferromagnetism superimposed on the contribution of paramagnetic Fe³⁺ ions dispersed in the amorphous matrix.     

Structural analysis of Na2OGa2O3SiO2 glasses by the X-ray diffraction method

The structure of Na₂OGa₂O₃SiO₂ glasses of four different compositions containing up to 45 mol. % Ga₂O₃ has been determined by the X-ray diffraction method. The radial distribution function D(r) obtained indicates that Ga³⁺ ions are in fourfold coordination and GaO₄ tetrahedra are formed in these glasses. The reduced intensity function S·i(S) and radial distribution function D(r) which were calculated based on a structural model for A-25, 0.25(Ga₂O₃)·0.75(Na₂O·2SiO₂)/3 glass agreed well with the observed ones.