Versatile two-phase solvent system for alkaloid separation by high-speed counter-current chromatography

In order to find a versatile high speed counter-current chromatography solvent system that can be used as a general prefractionation system for most alkaloids, the crude extracts of five Chinese traditional medicinal herbs, Cortex phellodendri, Semen strychni, green tea, Sophora flavescens ait, and Datura mete L. were resolved. All separations were performed only with a two-phase system composed of CHCl3-CH3OH-water (4:3:2). The water had different acidities controlled by adding NaH2PO4 or HCl to each sample. The fractionated components were identified by thin-layer chromatography, which confirmed this solvent system was versatile and very useful for the separation of alkaloids.     

Comprehensive separation of a wide variety of compounds from olive leaves by counter-current chromatography with three-phase solvent system

The three-phase solvent system counter-current chromatography has been of great research interest, because it can separate compounds with a wide range of polarity. The solvent system of n-hexane/methyl tert-butyl ether/acetonitrile/water (5:5:7:5, v/v) was used for counter-current chromatographic comprehensive separation of olive leaves. The study adopted the normal elution mode. The middle phase and the lower phase (at a volume ratio of 7:3) were pumped into the column simultaneously, followed by eluting with the upper, middle, and lower phases in sequence. The retention rate of the stationary phase measured by the experiment was 73.5%. The upper phase was used to elute the nonpolar compounds, then the mobile phase was switched to the middle phase to elute the moderately hydrophobic compounds, finally, the polar compounds were eluted by the lower phase remaining in the chromatographic column. This method successfully separated eight compounds in one step within 270 min and five compounds were identified. The logP values of these five compounds were 7.44, 7.86, 4.16, −0.11, and 0.96, respectively, covering a wide range of polarities. The present study demonstrated that the three-phase solvent has a strong extraction capacity for ingredients from extremely hydrophilic compounds to extremely hydrophobic compounds.     

Isolation of all-trans lycopene by high-speed counter-current chromatography using a temperature-controlled solvent system

The effect of solvent system, partition coefficient, retention of stationary phase, column, revolution speed, and flow rate of mobile phase are well known parameters to effect HSCCC (high-speed counter-current chromatography) separations. Temperature effects on chromatographic techniques like HPLC and GC are well studied, but the influence of temperature on CCC solvent systems is hardly investigated. This paper presents the influence of temperature on several key parameters (partition coefficient, settling time, volume ratios) in the hydrophobic HSCCC solvent system hexane:dichloromethane:acetonitrile (30:11:18, v/v/v) used for the isolation of lycopene from tomato paste at 10, 15, 20 and 25 degrees C.     

Three-phase solvent systems for comprehensive separation of a wide variety of compounds by high-speed counter-current chromatography

Three-phase solvent systems were efficiently utilized for high-speed counter-current chromatography (HSCCC) to separate multiple components with a wide range of hydrophobicity. The compositions of three-phase systems were optimized according to their physical parameters such as volume ratio, viscosity and specific gravity of upper (UP), middle (MP) and lower (LP) phases. The three-phase systems composed of n-hexane-methyl acetate-acetonitrile-water (4:4:3:4, v/v/v/v) was selected for HSCCC separation of a mixture of 15 standard compounds with a wide range in hydrophobicity from beta-carotene to tryptophan. The separation was initiated by filling the column with a mixture of MP and LP both as a stationary phase followed by elution with UP to separate the hydrophobic compounds. Then the mobile phase was switched to MP to elute the moderately hydrophobic compounds, and finally the polar compounds still retained in the column were fractionated by eluting the column with LP. The system successfully resolved all 15 compounds in one-step operation in 70 min.     

Rapid separation of flavonoids by analytical high-speed counter-current chromatography

A commercial model of the analytical high-speed counter-current chromatography instrument was used for separation of flavonoids from a crude ethanol extract of dried fruits of sea buckthorn (Hippophae rhamnoides). Using a two-phase solvent system of chloroform-methanol-water (4:3:2), a five-fold increase in flow-rate of the mobile phase from 60 to 300 ml/h resulted in a rapid separation of five components in less than 15 min without significant loss in peak resolution. Major flavonoid component, isorhamnetin, was identified in its pure state by mass spectrometric analysis.     

Preparative separation of isoflavone components in soybeans using high-speed counter-current chromatography

The analysis of ionic micro-contamination is of growing importance in the disc drive industry. Through the use of ion chromatography, cleanliness of drive components can be assessed. An objective to improve quantification of highly reactive inorganic ions that exist within the drive environment was implemented. This paper presents a new extraction technique used to determine low levels of ammonium, by microbore ion chromatography. Various chemical compounds within adhesive formulations can be a source of extractable ammonium. By combining this new extraction method with ion chromatography, the percentage of different chemical compounds within adhesive formulations was correlated to the level of extractable ammonium observed.     

Protein separation and enrichment by counter-current chromatography using reverse micelle solvent systems

A protein mixture consisting of myoglobin, cytochrome c, and lysozyme was separated by high-speed counter-current chromatography using a two-phase aqueous/reverse micelle-containing organic solvent system. About 50% stationary phase retention ratio was obtained in most chromatographic experiments. Separations were manipulated mainly by pH gradients that controlled the electrostatic interactions between the protein molecules and reverse micelles. Separations were further improved by incorporating an ionic strength gradient along with the pH gradient. Control of ionic strength in the aqueous solution helped fine-tune protein partitioning between the stationary and mobile phases. Although non-specific protein interactions affected baseline resolution, recovery of cytochrome c and lysozyme reached 90% and 82%. Furthermore, concentration or enrichment of these two proteins was achieved from a large-volume sample load. This technique can potentially be employed in the recovery and enrichment of proteins from large-volume aqueous solutions.     

Organic high ionic strength aqueous two-phase solvent system series for separation of ultra-polar compounds by spiral high-speed counter-current chromatography

Existing two-phase solvent systems for high-speed countercurrent chromatography cover the separation of hydrophobic to moderately polar compounds, but often fail to provide suitable partition coefficient values for highly polar compounds, such as sulfonic acids, catecholamines and zwitter ions. The present paper introduces a new solvent series which can be applied for the separation of these polar compounds. It is composed of 1-butanol, ethanol, saturated ammonium sulfate and water at various volume ratios and consists of a series of 10 steps which are arranged according to the polarity of the solvent system so that the two-phase solvent system with suitable K values for the target compound(s) can be found in a few steps. Each solvent system gives proper volume ratio and high density difference between the two phases to provide a satisfactory level of retention of the stationary phase in the spiral column assembly. The method is validated by partition coefficient measurement of four typical polar compounds including methyl green (basic dye), tartrazine (sulfonic acid), tyrosine (zwitter ion) and epinephrine (a catecholamine), all of which show low partition coefficient values in the polar 1-butanol-water system. The capability of the method is demonstrated by separation of three catecholamines.     

Rational development of a selection model for solvent gradients in single-step separation of ginsenosides from Panax ginseng using high-speed counter-current chromatography

A new model of solvent gradients selection was rationally developed for the preparative separation of target compounds. The solvent gradients were selected based on a three-stage screening process where stationary phase retention was ensured by introducing a new parameter termed as the phase ratio. The phase ratio was calculated after mixing the upper phase of a solvent system with the lower phase of a different solvent system (1:1, v/v). The developed model was applied to the one-step separation of eight ginsenosides from Panax ginseng. Three gradients were selected on the basis of new model and eight ginsenosides, Rb(1), Rb(2), Rc, Rd, Re, Rg(1), Rf, and Rh(1), were efficiently separated by high-speed counter-current chromatography coupled with evaporative light scattering detector. The structures of all compounds were characterized by electrospray-ionization mass spectrometry and nuclear magnetic resonance spectroscopy.     

Separation of polar antioxidants from Rhizoma Polygonatum Odorati by high-speed counter-current chromatography with a hydrophilic solvent system

Some highly polar compounds are quality control makers for medicinal herbs. However, investigation of them has been hampered because the existing fractionation steps are difficult and laborious to purify them. Similar situations happen to Rhizoma Polygonatum Odorati, a widely used food supplement and medicinal herb with strong antioxidant activity, and up to date, only ethyl acetate fraction of Rhizoma Polygonatum Odorati has been comprehensively investigated. Here, HSCCC using a hydrophilic solvent system composed of n-butanol–ethanol–2 M ammonium sulfate (1:1:2, v/v/v) was performed to isolate highly polar antioxidants in n–butanol fraction of Rhizoma Polygonatum Odorati, guided by DPPH–HPLC experiment. Afterward, Sephadex LH-20 column chromatography eluted by methanol was selected to eliminate ammonium sulfate and purify co-eluted compounds in HSCCC collected fractions. Finally, nine compounds, including four nucleosides, cytidine (1), uridine (4), guanosine (5), and adenosine (8); two nucleobases, guanine (3), and adenine (6); and three amino acids, tyrosine (2), phenylalanine (7), and tryptophan (9) with purities over 98% were achieved and identified by UV, MS, and ¹H NMR data. Notably, compounds 1–9 were first reported in genus Polygonatum. The results indicated that the proposed method was an efficient approach to isolate and purify highly polar compounds from complex extracts.     

Preparative isolation and purification of alkannin/shikonin derivatives from natural products by high-speed counter-current chromatography

Alkannin and shikonin (A/S) and their derivatives have been found in the roots of several Boraginaceous species and are also produced through plant tissue cultures. The chiral compounds A/S are potent pharmaceutical substances with a wide spectrum of biological and pharmacological activities like wound healing, antimicrobial, anti-inflammatory, anticancer and antioxidant activity. High-speed counter-current chromatography (HSCCC) was applied for the first time to the separation, preparative isolation and purification of A/S and their esters from extracts of Alkanna tinctoria roots, as well as commercial samples. The constituents of HSCCC fractions and their purity were determined by high-performance liquid chromatography-diode array detection-mass spectrometry (HPLC-DAD-MS), since DAD cannot detect oligomeric A/S derivatives that are present in most of the samples containing the respective monomeric derivatives. The purity of HSCCC fractions was compared with the one of fractions isolated by column chromatography (CC) using as stationary phases silica gel and Sephadex LH-20. As shown, the purity of monomeric alkannin/shikonin was greater by HSCCC than CC separation of commercial A/S samples.     

Liquid-liquid/solid three-phase high-speed counter-current chromatography, a new technique for separation of polyphenols from Geranium wilfordii Maxim

High-speed counter-current chromatography using a new liquid-liquid/solid three-phase system was used for the separation of the polyphenols corilagin and geraniin from a crude extract of Geranium wilfordii Maxim in one step. The optimized three-phase system was composed of n-hexane/ethyl acetate/methanol/acetic acid/water and to which was added 10-μm average diameter microspheres of cross-linked 12% agarose at the ratio of 0.2:10:2:1:5 and 0.1 g/mL, respectively. The purities of geraniin and corilagin were 82 and 90%, which were determined by HPLC at 280 nm. A 14.5 and 7 mg of geraniin and corilagin were purified from 160 mg crude extract with the yields of 70 and 78%, respectively.     

Analytical separation of tea catechins and food-related polyphenols by high-speed counter-current chromatography

High-speed counter-current chromatography (HSCCC) using the type-J coil planet centrifuge was applied to compositional analysis of tea catechins and separation of other food-related polyphenols. The HSCCC separation of nine different standard compounds and those from extracts of commercial tea leaves was performed with a two-phase solvent system composed of tert-butyl methyl ether-acetonitrile-0.1% aqueous trifluoroacetic acid (TFA) (2:2:3, v/v/v) by eluting the upper organic phase at a flow rate of 2 ml/min. The main compounds in the extract of non-fermented green tea were found to be monomeric catechins, their galloylated esters and caffeine. In addition to these compounds, oxidized pigments, such as hydrophobic theaflavins (TFs) and polar thearubigins (TRs) were also separated and detected from the extracts of semi-fermented oolong tea and fermented black tea. Furthermore, several food-related polyphenols, such as condensed catechin oligomers (procyanidins), phenolic acids and flavonol glycosides were clearly separated under the same HSCCC condition. These separation profiles of HSCCC provide useful information about the hydrophobic diversity of these bioactive polyphenols present in various types of teas and food products.     

高速逆流色谱分离制备椭圆叶花锚中的2种口山酮苷元

椭圆叶花锚的主要活性成分为口山酮类化合物,这类化合物具有利胆、抗炎、抗菌及抗病毒活性。应用高速逆流色谱法建立了2种高纯度口山酮苷元的分离制备方法。对椭圆叶花锚氯仿萃取部位运用高速逆流色谱分离纯化,以正己烷-乙酸乙酯-甲醇-水(5:5:7:5, v/v/v/v)为两相溶剂系统,上相为固定相,下相为流动相。在主机转速800 r/min,流动相流速1.5 mL/min,检测波长254 nm条件下进行分离制备。所得产物经高效液相色谱分析检测,其化学结构由核磁共振氢谱(1H NMR)和核磁共振碳谱(13C NMR)鉴定。在此条件下,从100 mg粗样品中一步分离得到18 mg 1-羟基-2,3,5-三甲氧基口山酮,14 mg 1-羟基-2,3,4,5-四甲氧基口山酮。经高效液相色谱分析,其纯度均达98%以上。该方法简便、快速,所得产物纯度高,适合于椭圆叶花锚口山酮苷元的制备分离。     

Preparative separation of minor saponins from Platycodi Radix by high-speed counter-current chromatography

Platycosides (PSs), the saponins found in the root of Platycodon grandiflorum (Jacq.) A. DC. (Platycodi Radix), are typically composed of oleanene backbones with two side chains; one is a 3-O-glucose linked by a glycosidic bond, and the other is a 28-O-arabinose-rhamnose-xylose-apiose linked by an ester bond. Minor saponins, acetylated isomers of the major saponin on either the 2' or 3' position of rhamnose, were isolated from Platycodi Radix using a multi-step process including high-speed counter-current chromatography (HSCCC) and preparative reversed-phase high-performance liquid chromatography (RP-HPLC). After the separation of the major components, the enriched minor saponin fraction was used for this study. A two-phase solvent system consisting of chloroform-methanol-isopropanol-water (3:2:2:3, v/v) was used for HSCCC. HSCCC separation of the enriched minor saponin fraction yielded 2'-O-acetylplatycodin D, 3'-O-acetylpolygalacin D, 2'-O-acetylpolygalacin and a mixture of 3'-O-acetylplatycodin D and polygalacin D. The mixture fraction from HSCCC separation was further purified by preparative RP-HPLC, giving 3'-O-acetylplatycodin D and polygalacin D at a purity of over 98.9%. The developed method provides the preparative and rapid separation of minor saponins in the crude extract of Platycodi Radix. To the best of our knowledge, this is the first on the separation of acetylated PSs by HSCCC.     

Preparative separation of flavonoid glycosides in leaves extract of Ampelopsis grossedentata using high-speed counter-current chromatography

Preparative separation of flavonoid glycosides in leaves extract of Ampelopsis grossedentata was conducted using high-speed counter-current chromatograph (HSCCC) with a solvent system composed of n-hexane-ethyl acetate-methanol-water (1:6:1.5:7.5, v/v). In a single operation, 28 mg of 5,7-dihydroxy-3',4'-trihydroxyflavone-3-O-6'-rhamnose and 18 mg of 5,7-dihydroxy-3',4'-dihydroxyflavone-3-O-6'-rhamnose was obtained from 150 mg of the extract. The chemical structure of the two compounds was elucidated by electrospray ionization (EIS) MS and NMR.     

Preparative separation of rhein from Chinese traditional herb by repeated high-speed counter-current chromatography

High-speed counter-current chromatography (HSCCC) was repeatedly used for isolation and purification of rhein from Rheum officinale Baill (Dahuang) with a two-phase solvent system composed of n-hexane-ethyl acetate-methanol-water (3:7:5:5, v/v), which had been selected by analytical (HSCCC). Using two preparative units of the HSCCC centrifuge, about a 500 mg amount of the crude extract was separated, yielding 6.7 mg of rhein at a high purity of over 97%.     

Isolation of secondary metabolites from Hortia oreadica (Rutaceae) leaves through high-speed counter-current chromatography

High-speed counter-current chromatography (HSCCC) with a two-phase solvent system (hexane–ethanol–acetonitrile–water 10:8:1:1, v/v) was applied to examine the leaves of Hortia oreadica, which afforded the known limonoid guyanin (1), the alkaloids rutaecarpin (2) and dictamnine (6), the dihydrocinnamic acid derivatives methyl 5,7-dimethoxy-2,2-dimethyl-2H-1-benzopyran-6-propanoate (3), 5,8-dimethoxy-2,2-dimethyl-2H-1-benzopyran-6-propanoic acid (4), together with the new E-3,4-dimethoxy-α(3-hydroxy-4-carbomethoxyphenyl)cinnamic acid (5). The recovery of compounds 1–6 was determined by comparison with LC-atmospheric pressure chemical ionization MS/MS data: 66.2%, 93.1%, 102.5%, 101.2%, 99.0% and 84.9%, respectively. Compound 3 showed IC₅₀ of 23.6 μM against Plasmodium falciparum and 15.6 μM against Trypanosoma brucei rhodesienses and was not toxic to KB cells (IC₅₀ > 100 μM).