硅双极器件及电路电离总剂量辐照损伤研究

针对硅双极器件及其构成的双极集成电路有着如低剂量率辐照损伤增强效应等不同于其他类型电路的特殊的辐照响应问题, 分析了空间辐射电离总剂量环境及铝屏蔽作用, 双极晶体管及电路总剂量辐照损伤机理, 低剂量率辐照损伤增强效应、规律和电参数变化。通过选取几种典型的双极晶体管和电路进行地面辐照模拟试验和测试, 证明了双极器件及电路的关键参数受辐照影响较大, 特别是对低剂量率辐照损伤增强效应敏感, 低剂量率辐照损伤增强因子基本都大于1.5, 不同双极器件和电路的低剂量率辐照损伤增强效应有着明显的不同, 与器件类型、加工工艺(如氧化层厚度)等密切相关。     

硅双极器件及电路电离总剂量辐照损伤研究

针对硅双极器件及其构成的双极集成电路有着如低剂量率辐照损伤增强效应等不同于其他类型电路的特殊的辐照响应问题, 分析了空间辐射电离总剂量环境及铝屏蔽作用, 双极晶体管及电路总剂量辐照损伤机理, 低剂量率辐照损伤增强效应、规律和电参数变化。通过选取几种典型的双极晶体管和电路进行地面辐照模拟试验和测试, 证明了双极器件及电路的关键参数受辐照影响较大, 特别是对低剂量率辐照损伤增强效应敏感, 低剂量率辐照损伤增强因子基本都大于1.5, 不同双极器件和电路的低剂量率辐照损伤增强效应有着明显的不同, 与器件类型、加工工艺(如氧化层厚度)等密切相关。     

典型模拟电路低剂量率辐照损伤增强效应的研究与评估

采用变剂量率和变温两种辐照方法,对4款典型模拟电路的低剂量率辐照损伤特性及变化规律进行了研究与评估,分析了两种辐照方法下其辐照敏感参数的变化,比较了不同辐照方式下器件的退化程度,讨论了这两种实验室加速评估低剂量率辐照损伤方法的机理.结果显示,变剂量率辐照可以较快地预测实际低剂量率下的辐照损伤趋势,且在较低的总剂量下能够给出不太保守的估计,但其预测的总剂量受到器件退化速度的影响;变温辐照加速评估方法能够保守地估计其低剂量率下的辐照损伤,其评估范围不仅可达1000 Gy(Si),且可将评估时间缩短为12 h左右.研究结果表明,双极电路的低剂量率辐照损伤增强效应与感生的界面态密度和氢化的氧空位缺陷有关,辐照时剂量率和温度的改变会促进界面态的生长,抑制界面态的钝化作用,从而激发器件的辐照损伤潜能.     

不同剂量率下锗硅异质结双极晶体管电离损伤效应研究

对于相同制作工艺的NPN锗硅异质结双极晶体管(SiGe HBT), 在不同辐照剂量率下进行⁶⁰Co γ射线的辐照效应与退火特性的研究. 测量结果表明, 两种辐照剂量率下, 随着辐照总剂量增加, 晶体管基极电流增大, 共发射极电流放大倍数降低, 且器件的辐照损伤、性能退化与辐照剂量率相关, 低剂量率下辐照损伤较高剂量率严重. 在经过与低剂量率辐照等时的退火后, 高剂量率下的辐照损伤仍较低剂量率下的损伤低, 即待测SiGeHBT具有明显的低剂量率损伤增强效应(ELDRS). 本文对相关的物理机理进行了探讨分析. 关键词： 锗硅异质结双极晶体管 低剂量率辐照损伤增强 辐照效应     

双极线性稳压器电离辐射剂量率效应及其损伤分析

为了对双极线性稳压器在电离辐射环境下损伤变化特征及其剂量率效应进行研究,选择一组器件进行⁶⁰Co γ高低剂量率的辐照和退火试验. 结果表明线性稳压器的输出电压、最大负载电流、线性调整率、压降电压等多个关键参数都有不同程度的蜕变. 且各器件在高低剂量率下的辐照响应略有不同,表现出不同的剂量率效应. 文中通过多种形式的测试结果分析,系统地讨论了各参数变化的原因及其内部各模块对稳压器功能的影响. 结合电离损伤退火特性,探讨了各剂量率效应形成的原因. 这不但对工程应用考核提供了参考,而且为设 关键词： 双极线性稳压器 总剂量效应 剂量率效应 辐射损伤     

双极集成电路低剂量率辐射损伤增强效应的高温辐照加速实验

选择了四种典型双极集成电路,在两种不同剂量率下,开展了不同温度的高温辐照加速实验,测量了典型双极集成电路的辐射敏感参数在不同高温辐照下的变化规律。实验结果表明:高温辐照能够给出空间低剂量率辐射损伤增强效应的保守估计,且存在最佳辐照温度,最佳辐照温度随总剂量的增加向低温区漂移,随剂量率的增大向高温区漂移,在相同剂量率和总剂量下,输入级为NPN晶体管的双极集成电路比输入级为PNP晶体管的最佳辐照温度低。     

双极集成电路低剂量率辐射损伤增强效应的高温辐照加速实验

选择了四种典型双极集成电路,在两种不同剂量率下,开展了不同温度的高温辐照加速实验,测量了典型双极集成电路的辐射敏感参数在不同高温辐照下的变化规律。实验结果表明：高温辐照能够给出空间低剂量率辐射损伤增强效应的保守估计,且存在最佳辐照温度,最佳辐照温度随总剂量的增加向低温区漂移,随剂量率的增大向高温区漂移,在相同剂量率和总剂量下,输入级为NPN晶体管的双极集成电路比输入级为PNP晶体管的最佳辐照温度低。     

双极电压比较器电离辐射损伤及剂量率效应分析

为了对双极电压比较器在电离辐射环境下的损伤变化特征及其剂量率效应进行研究,选择一组器件,在不同偏置条件下进行60Coγ高低剂量率的辐照和退火试验.结果表明:电压比较器的电源电流、偏置电流及失调电压等多个关键参数都有不同程度的蜕变;偏置条件对于电压比较器的辐射响应有很大影响;此外,不同公司生产的同种型号电路表现出不同的剂量率效应;通过对测试结果分析,系统地讨论了各参数变化的原因,并结合电离损伤退火特性,探讨了各剂量率效应形成的机理.研究结果对工程应用考核提供了参考,而且为设计抗辐射加固器件提供了依据.     

低剂量率60Coγ辐线辐照下SOIMOS器件的退化机理

本文通过实验分析了O．8μm工艺H形栅SOIMOS器件在低剂量率下的1射线总剂量效应．实验结果表明,总剂量相同时,低剂量率的辐照效应更严重,关态偏置条件下的阈值电压漂移大于开态,辐照引起NMOS器件发生kink效应时的漏极电压％升高．研究结果表明：界面态对PMOS器件亚阈值斜率和跨导退化的影响作用不同,主要原因是栅极偏置不同使起作用的界面态数量不同．     

超深亚微米互补金属氧化物半导体器件的剂量率效应

对0.18 μm互补金属氧化物半导体(CMOS)工艺的N型金属氧化物半导体场效应晶体管(NMOSFET)及静态随机存储器(SRAM)开展了不同剂量率下的电离总剂量辐照试验研究. 结果表明: 在相同累积剂量, SRAM的低剂量率辐照损伤要略大于高剂量率辐照的损伤, 并且低剂量率辐照损伤要远大于高剂量率辐照加与低剂量率辐照时间相同的室温退火后的损伤. 虽然NMOSFET 低剂量率辐照损伤略小于高剂量率辐照损伤, 但室温退火后, 高剂量率辐照损伤同样要远小于低剂量率辐照损伤. 研究结果表明0.18 μm CMOS工艺器件的辐射损伤不是时间相关效应. 利用数值模拟的方法提出了解释CMOS器件剂量率效应的理论模型.     

Total ionizing dose effects of domestic Si Ge HBTs under different dose rates

The total ionizing radiation(TID) response of commercial NPN silicon germanium hetero-junction bipolar transistors(Si Ge HBTs) produced domestically are investigated under dose rates of 800 m Gy(Si)/s and 1.3 m Gy(Si)/s with a Co-60 gamma irradiation source. The changes of transistor parameters such as Gummel characteristics, and excess base current before and after irradiation, are examined. The results of the experiments show that for the KT1151, the radiation damage is slightly different under the different dose rates after prolonged annealing, and shows a time dependent effect(TDE). For the KT9041, however, the degradations of low dose rate irradiation is higher than for the high dose rate, demonstrating that there is a potential enhanced low dose rate sensitivity(ELDRS) effect for the KT9041. The possible underlying physical mechanisms of the different dose rates responses induced by the gamma rays are discussed.     

Effect of ionizing radiation on dual 8-bit analog-to-digital converters （AD9058） with various dose rates and bias conditions

The radiation effects on several properties （reference voltage, digital output logic voltage, and supply current） of dual 8-bit analog-to-digital （A/D） converters （AD9058） under various biased conditions are investigated in this paper. Gamma ray and 10-MeV proton irradiation are selected for a detailed evaluation and comparison. Based on the measurement results induced by the gamma ray with various dose rates, the devices exhibit enhanced low dose rate sensitivity （ELDRS） under zero and working bias conditions. Meanwhile, it is obvious that the ELDRS is more severe under the working bias condition than under the zero bias condition. The degradation of AD9058 does not display obvious ELDRS during 10-MeV proton irradiation with the selected flux.     

Effects of orientation of substrate on the enhanced low-dose-rate sensitivity （ELDRS） in NPN transistors

The radiation effects and annealing characteristics of two types of domestic NPN bipolar junction transistors, fabricated with different orientations, were investigated under different dose-rate irradiation. The experimental results show that both types of the NPN transistors exhibit remarkable Enhanced Low-Dose-Rate Sensitivity (ELDRS). After irradiation at high or low dose rate, the excess base current of NPN transistors obviously increased, and the current gain would degrade rapidly. Moreover, the decrease of collector current was also observed. The NPN transistor with <111> orientation was more sensitive to ionizing radiation than that with <100> orientation. The underlying mechanisms of various experimental phenomena are discussed in detail in this paper.     

Using temperature-switching approach to evaluate the ELDRS of bipolar devices

Enhanced low-dose rate sensitivity (ELDRS) exhibited at low-dose rates (LDRs) by most bipolar devices is considered as one of the main concerns for spacecraft reliability. In this work, a time-saving and conservative approach – temperature-switching approach (TSA) – to simulate the ELDRS of bipolar devices is presented. Good agreement is observed between the predictive curve obtained with the TSA and the LDR data, and TSA provides us with a new insight into the test technique for ELDRS. Additionally, the mechanisms of TSA are analyzed in this paper.     

Effects of orientation of substrate on the enhanced low-dose-rate sensitivity (ELDRS) in NPN transistors

The radiation effects and annealing characteristics of two types of domestic NPN bipolar junction transistors, fabricated with different orientations, were investigated under different dose-rate irradiation. The experimental results show that both types of the NPN transistors exhibit remarkable Enhanced Low-Dose-Rate Sensitivity (ELDRS). After irradiation at high or low dose rate, the excess base current of NPN transistors obviously increased, and the current gain would degrade rapidly. Moreover, the decrease of collector current was also observed. The NPN transistor with (111) orientation was more sensitive to ionizing radiation than that with (100) orientation. The underlying mechanisms of various experimental phenomena are discussed in detail in this paper.