Czochralski Growth of Potassium Lithium Niobate Single Crystals with Low Li Content and Their Characterization

Single crystalline and crack free potassium lithium niobate (KLN) single crystals with low Li content were grown by the Czochralski method. The crystal composition can be written as K_2.60Li_1.17Nb_5.44O₁₅ (=K_2.95Li_1.33Nb_6.17O₁₇) which contain relatively fewer Li ions than ferroelectric K₃Li₂Nb₅O₁₅ crystals. All experimental results show that the deficiency of the Li ions in the KLN crystals strongly influences their physical properties. Especially, the as‐grown crystals do not indicate any signature for a ferroelectric phase transition in contrast to the ferroelectric K₃Li₂Nb₅O₁₅ crystals. However, due to ionic conduction, the temperature dependence of the dielectric constant of such KLN‐2 crystals show a broad anomaly near 300°C. In addition, the existence of proton defects can be revealed by infrared absorption spectroscopy near 3500 cm^‐1 in as‐grown crystals.     

Laser heated pedestal growth of potassium lithium niobate for UV generation

Potassium lithium niobate (KLN) is a nonlinear optical material with a high nonlinearity. It has the potential to improve the performance and reduce the cost of blue and UV lasers. KLN crystals are not commercially viable because growth by traditional techniques is not possible. In an effort to develop commercially viable KLN, single crystals of the material were grown by the laser heated pedestal growth method (LHPG) with compositions of x=0.02, 0.06 and 0.2 following K₃Li_2?xNb_5+xO_15+2x. Noncritical phase matching at 20 °C for previously unreported compositions of x=0.02 and 0.06 was measured at 795 nm and 805 nm, respectively. Overall, the results suggest that single crystal KLN can be used for SHG into the UV region of the spectrum and can be developed into a commercially viable nonlinear optical material.     

Ternary system Li2O–K2O–Nb2O5: Re-examination of the 30 mol% K2O isopleth and growth of fully stoichiometric potassium lithium niobate single crystals by the micro-pulling down technique

Potassium lithium niobate (KLN) single crystals have attractive properties for non-linear optical applications based on frequency conversion of laser diodes in the blue range. Especially, fully stoichiometric K₃Li₂Nb₅O₁₅ crystals would be capable of doubling a laser light in the near UV range. Using powder X-ray diffraction and DSC experiments, we have re-investigated the 30 mol% K₂O isopleth of the ternary system Li₂O–K₂O–Nb₂O₅ in order to explore the possibility of a limited existence field for this phase. From our results, it was shown that the stoichiometric KLN phase exists between 970 and 1040 °C, temperature at which it undergoes a non-congruent melting. From this conclusion, compositionally homogeneous a-axis oriented single crystals fibers of stoichiometric K₃Li₂Nb₅O₁₅ were successfully grown by the micro-pulling down technique with pulling rates in the range 0.3–0.7 mm min⁻¹. The crystal length was between 10 and 120 mm for an apparent diameter near 500 μm. The fibers, characterized by optical microscopy, X-ray diffraction and Raman spectroscopy, appeared free of macro-defects and of good quality and their stoichiometric composition was also confirmed.     

The Growth and Properties of K1-yLiyTa1-xNbxO3 Crystal

Potassium lithium tantalate niobate (K_1-yLi_yTa_1-xNb_xO₃, KLTN) crystals with tetragonal phase at room temperature were grown by the flux pulling method. Two-wave coupling energy transfer has been realized in this crystal. The two-wave coupling gain coefficient measured is 0.46 cm⁻¹, and the sign of the dominant carrier is positive. As compared with potassium tantalate niobate (KTN), the dielectric properties of KLTN changed significantly.     

Study on the ferroelectric phase transition in potassium lithium niobate (KLN)

The ferroelectric phase of potassium lithium niobate K₃Li_2–xNb_5+xO_15+2x (KLN) in the range of 0.15 < x < 0.5 is a very promising material for the second harmonic generation (SHG) in the blue visible region (∼410 nm). The ferroelectric phase transition was shown to occur between 400 and 500°C depending on the composition of the KLN phase. In this study several analysis techniques were used to investigate the phase transition on ferroelectric (x = 0.3) KLN samples. The temperature‐dependent measurements of the relative dielectric constant ε₃₃ provided a phase transition temperature of about 470°C. In our DTA experiments, a small but reproducible thermal effect at the phase transition in KLN was indicated. The temperature‐dependent birefringence measurement technique, applied the first time on KLN, shows a second order behaviour at a temperature of 467 °C. However, this phase transition is accompanied by a small thermal effect. The DSC analysis for the other KLN composition (x = 0.5) provided a phase transition temperature of 514 °C. The appearance of a phase transition in the paraelectric KLN phase (Nb content higher than 55 mol%) was also studied. (© 2006 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Structure and crystallization behavior of mixed potassium-lithium niobiosilicate glasses

Potassium-lithium niobiosilicate (KLiNS) glasses with a composition of (27 ? x)K₂O · xLi₂O · 27Nb₂O₅ · 46SiO₂ (x = 0, 3, 12 and 20) have been synthesized by a melt-quenching method. The glass structure and devitrification behavior have been studied by Raman spectroscopy, DTA, and XRD. By increasing the lithium content, less distorted niobium octahedra increase, indicating a niobium clustering. This change strongly affects the crystallization behavior. In the glasses x = 0 and x = 3, just above T_g, only nanocrystals of an unidentified phase are formed, while for x = 12 and x = 20 potassium lithium niobate (KLN) solid solutions with tetragonal tungsten–bronze structure crystallize by bulk nucleation. In these glasses, LiNbO₃ crystallizes at higher temperature by surface nuclei. Ultimately, it is possible to produce nanostructured glasses based on KLN nanocrystals, by partial replacement of K by Li.     

Stoichiometry and point defects in lithium niobate crystals

Investigations of the OH⁻ ion incorporation into LiNbO₃ crystals and the comparison of calculated and measured densities show that undoped congruent lithium niobate crystals contain Li⁺ and O^{− −} ion vavancies O and Li⁺. If really present, stacking faults are of inferior importance. The good agreement of the absorption edges of stoichiometric and of 2.7 mol% MgO containing congruent lithium niobate crystals is explained by the occupance of all oxygen sites within these crystals.     

Structure and optical properties of near stoichiometric Ce:LiNbO3 crystals

The near sotichiometric Ce:LiNbO₃ (Ce:SLN) crystals were grown by the top seeded solution growth (TSSG) method by adding K₂O flux to Li₂O‐Nb₂O₅ melt. Their UV‐vis absorption spectra and IR spectra were measured and discussed to investigate their defect structure. The results showed that the grown crystals were near stoichiometric and Ce ions in the crystals located the Li site. Photorefractive properties of Ce:SLN crystals were studied by two‐wave coupling experiment. The results of the two‐wave coupling experiments of the crystals showed that as the CeO₂ doping concentrations increased, the diffraction efficiency increased, photoconductivity decreased and the writing time and erasure time increased. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth, structure, and properties of ferroelectric—ferroelastic— superionic K3Nb3B2O12 and K3−x NaxNb3B2O12 crystals

The potassium niobate-borate K₃Nb₃B₂O₁₂ (KNB) crystals and their solid solutions with partial substitution of potassium by sodium (KNB: Na) are grown from flux and their physical properties are studied. The specific feature of the crystals grown is a complicated polymorphism and the unique combination of ferroelectric and ferroelastic properties with superionic conductivity with respect to potassium ions.     

Optical characterization and crystal structure of the novel bronzetype CaxBa1‐xNb2O6 (x = 0.28; CBN‐28)

Calcium barium niobate (CBN), also like strontium barium niobate (SBN), belongs to the materials family of partially filled tetragonal tungsten bronzes, which show relaxor‐type ferroelectric phase transitions and large electro‐optic effects. For the first time, it was possible to grow large single crystals of Ca_0.25Ba_0.75Nb₂O₆ (CBN‐25) and CBN‐28 by using different growing techniques. The successful single crystal growth allowed to investigate several physical properties of the novel phase. Herein, we report on measurements of differential thermal analysis (DTA), wavelength dispersion of the refractive indices, temperature dependence of the birefringence and light absorption. Additionally, results of the single crystal X‐ray structure analysis are presented.     

Magnesium-doped potassium lithium niobate crystal and its properties

High quality magnesium-doped potassium lithium niobate (designated as KLN:Mg) single crystal was grown for the first time. The tetragonal tungsten bronze structure of the Mg:KLN crystal was determined by X-ray powder diffraction, in which the lattice parameters were A=1.262nm and C=0.398nm. High temperature X-ray diffraction patterns showed that the expansion of the lattice with increasing temperature was less than that of the undoped crystal. The transmittance of the as-grown crystal was measured. It increased by 80% from the cutoff wavelength 380nm to 450nm. The transmittance for 404nm was 50%, which is larger than that of the undoped crystals. The frequency-doubling property of KLN crystal was analyzed. Preliminary frequency doubling experiments showed that the crystal could generate blue light of 404nm through noncritical phase matching (NCPM) second harmonic generation (SHG) using a 808nm diode laser at room temperature.     

Crystal growth of PZN‐PT single crystals and critical issues for higher piezoelectric coefficient

Single crystals of lead zinc niobate‐lead titanate (1‐x)Pb(Zn_1/3Nb_2/3)O₃–xPbTiO₃ for x = 8% and 9% have been grown by flux method using Lead Oxide (PbO) as flux. Low scan rate XRD has been carried out to investigate on the structural influence of the compositional variations in the grown crystals. Transmission spectra in the range of UV‐Vis‐Near IR and mid IR regions have been carried out to understand the distortions caused in the BO₆ octahedral lattice. Morphological aspects of as‐grown PZN‐PT crystals have also been investigated. Dielectric measurements clearly explained the dependence of T_c and diffusiveness with PT content. The values of P_r and E_cobtained from P‐E loops suggest the presence of ordered domain state in these PZN‐PT single crystals. (© 2012 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Compositional variation in 0.65 PbMg2/3Nb1/3O3 ‐0.35 PbTiO3 single crystals grown by high temperature solution growth technique

Single crystals of lead magnesium niobate titanate, 0.65 PbMg_2/3Nb_1/3O₃ (PMN) ‐0.35PbTiO₃ (PT) were grown using flux method near morphotropic phase boundary (MPB) composition. The crystals grown at the centre of the platinum crucible were found to PT deficient compared to those grown near the walls of the crucibles. A variation of ∼3.8 mol% in PT concentration was found in the crystals grown at the wall and at the centre of the crucible. The difference in the chemical composition of crystals grown at the centre and the near the wall of the crucible was observed by X‐ray diffraction, EDXRF, dielectric and thermal measurements. The presence of PT rich and deficient crystals is explained in terms of the segregation coefficient of PT in PMN. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Characterization of pure and doped potassium hydrogen tartrate single crystals grown in silica gel

Growth of pure‐, sodium‐ and lithium‐ doped potassium hydrogen tartrate single crystals by gel technique is reported. Growth conditions conducive for the growth of single crystals are worked out. The crystals are characterized by using powder XRD, SEM, FTIR, AES, EDAX, CH analysis and thermoanalytical techniques. The stoichiometric composition for the grown crystals are established as KHC₄H₄O₆.H₂O, (K)_0.98(Na)_0.02.H₂O and (K)_0.94(Li)_0.06HC₄H₄O₆.H₂O. Doping of sodium and lithium in the pure potassium hydrogen tartrate single crystals is found to influence the size, perfection, morphology, crystal structure and the thermal stability of crystals. (© 2009 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Domain structures and etching morphologies of lithium niobate crystals with different Li contents grown by TSSG and double crucible Czochralski method

Stoichiometric lithium niobate single crystals with different Li contents have been grown both by the top‐seeded solution growth (TSSG) method from potassium containing flux and by the double crucible Czochralski (DC Cz) method. Spectroscopic properties (e.g. the UV absorption edge, Raman linewidth) and the Curie temperature measurement have been used for the characterization of the crystal composition. The double crucible Czochralski method is found to be suitable for mass production of stoichiometric LiNbO₃ with Li content larger than 49.7 mol% and homogeneity of 0.03 mol%. The domain structures and etching morphologies on negative and positive c‐surface were also investigated by chemical etching method. A new domain structure of three‐fold symmetric sectors were observed in near‐stoichiometric LiNbO₃ grown by TSSG method. The straight line arrangement hillocks on negative c‐surface and the net‐like arrangement etch lines were observed and explained by stress etching mechanism. (© 2004 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth of lithium triborate (LiB3O5) single crystals in the Li2O-B2O3-MoO3 system

Solubility curves are plotted and optimal solvents for growing lithium triborate (LiB₃O₅) single crystals are determined. The crystallization range of this compound in the Li₂O-B₂O₃-MoO₃ system is refined. The molybdenum content in the crystals grown is analyzed.     

Effective electro‐optic coefficient of (1–x)Pb(Zn1/3Nb2/3)O3–xPbTiO3 single crystals

Refractive indices and effective electro‐optic coefficient γ_c of (1–x)Pb(Zn_1/3Nb_2/3)O₃–xPbTiO₃ (PZN‐xPT, x = 0.05, 0.09 and 0.12) single crystals were measured at 532 nm wavelength. Orientation and temperature dependences of the electro‐optic coefficient were investigated. Large electro‐optic coefficient (γ_c = 470 pm/V) was observed in [001]‐poled PZN‐0.09PT crystal. More importantly, γ_c of tetragonal PZN‐0.12PT is almost unchanged in a temperature range −20 ∼ 80 °C. The γ_c of PZN‐xPT single crystals are much higher than that of widely used electro‐optic crystal LiNbO₃ (γ_c = 20 pm/V). These results show that PZN‐xPT single crystals are very promising materials for electro‐optic modulators in optical communications.     

Electrical properties of SrBi2(Nb0.7V0.3)2O9−δ in the SrO–Bi2O3–0.7Nb2O5–0.3V2O5–Li2B4O7 glass system

Glasses in the system (100 − x)Li₂B₄O₇–x(SrO–Bi₂O₃–0.7Nb₂O₅–0.3V₂O₅) (where x = 10, 30 and 50, in molar ratio) were fabricated via melt quenching technique. The compositional dependence of the glass transition (T_g) and crystallization (T_cr) temperatures was determined by differential thermal analysis. The as-quenched glasses on heat-treatment at 783 K for 6 h yielded monophasic crystalline strontium bismuth niobate doped with vanadium (SrBi₂(Nb_0.7V_0.3)₂O_9−δ (SBVN)) in lithium borate (Li₂B₄O₇ (LBO)) glass matrix. The formation of nanocrystalline layered perovskite SBVN phase was preceded by the fluorite phase as established by both the X-ray powder diffraction (XRD) and transmission electron microscopy (TEM). The dielectric constants for both the as-quenched glass and glass–nanocrystal composite increased with increasing temperature in the 300–873 K range, exhibiting a maximum in the vicinity of the crystallization temperature of the host glass matrix. The electrical behavior of the glasses and glass–nanocrystal composites was characterized using impedance spectroscopy.     

Growth and thermal studies on pure ADP,KDP and mixed K1‐x(NH4)xH2PO4 crystals

The investigations on the formation of mixed crystals of ammonium dihydrogen orthophosphate (ADP) and potassium dihydrogen orthophosphate (KDP) i.e. potassium ammonium dihydrogen phosphate, K_1‐x(NH₄)_xH₂PO₄ have been presented in this paper. Pure and mixed crystals of ADP and KDP have been grown by slow evaporation technique from the supersaturated solution at an ambient temperature 26±1 °C for ammonium concentration x in the range 0.0 ≤ x ≤ 1.0 in the case of mixed crystals. Crystal compositions were determined by flame atomic absorption spectroscopy and chemical analysis. The results of the X‐ray analysis of the grown crystals are also reported. Thermogravimetric analysis (TGA) and differential thermal analysis (DTA) were used to study the kinetic process of dehydration and the high temperature phase behaviour. DTA showed the distinct thermal events attributed to dehydration of ADP, KDP and K_1‐x(NH₄)_xH₂PO₄. The results of thermal analysis and chemical analysis are consistent with each other. (© 2010 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Temperature dependence of lattice parameters of SBN single crystals in the vicinity of their structural phase transitions

Changes of lattice parameters of Sr_xBa_1‒xNb₂O₆ (0.35 < x < 0.72) solid solution single crystals were measured as a function of temperature. The X‐ray Bond’ method was used to carry out very precise measurements of the lattice parameters. Fine correlations between values of the lattice parameter and the Sr concentration in the solid solution of Sr_xBa_1‒xNb₂O₆ single crystals are found. A conventional analysis of lattice parameter data in terms of spontaneous strain and strain/order parameter coupling shows that a normal structural phase transition does occur. While the ferroelectric system (SBN26) displays a nearly tricritical behavior, β ≈ 0.20, the relaxor one (SBN61) complies with the two‐dimensional Ising‐model‐like criticality, β ≈ 0.17.